LCDXR-65A80L - TV SONY - Free user manual and instructions

USER MANUAL LCDXR-65A80L SONY

Installation Information for Using Sony Wall-Mount Bracket (SU-WL850) Supported models*: * In the actual model names, the “x”/“xx” indicates numbers and/or characters specific to each model. XR-77A8xL / 77A8xEL / 65A8xL / 65A8xEL / 55A8xL / 55A8xEL To Customers For product protection and safety reasons, Sony strongly recommends that installation of your TV be performed by Sony dealers or licensed contractors. Do not attempt to install it yourself. To Sony Dealers and Contractors Provide full attention to safety during the installation, periodic maintenance and examination of this product.

Sufficient expertise is required for installing this product, especially to determine the strength of the wall for withstanding the TV’s weight. Be sure to entrust the attachment of this product to the wall to Sony dealers or licensed contractors and pay adequate attention to safety during the installation. Sony is not liable for any damage or injury caused by mishandling or improper installation. For Safety and proper installation, follow the Wall-Mount Bracket Operation Instructions, TV Setup Guide and the directions in this manual.

Wall-Mount Bracket On Safety Thank you for purchasing this product.

To Customers WARNING If the following precautions are not observed, serious injury or death through fire, electric shock, or the product dropping can result.

Installing the TV to the Wall

WARNING PROFESSIONAL INSTALLATION REQUIRED This product should only be installed by a professional installer who is trained to determine the strength of the wall for withstanding the TV’s weight. If it is not properly secured during installation, the TV may fall and cause serious injury. Sony is not liable for any damage or injury caused by mishandling or improper installation, or installing any other than the specified product. Your Statutory Rights (if any) are not affected.

To Sony Dealers Sufficient expertise is required for installing this product. Be sure to read this instruction manual thoroughly to do the installation work safely. Sony is not liable for any damages or injury caused by mishandling or improper installation. Please give this manual to the customer after installation. This instruction manual shows the correct handling of the product and important precautions necessary to prevent accidents. It is your responsibility to read, thoroughly understand, and follow all instructions in this instruction manual. Failure to do so may result in serious personal injury or property damage, and may void the warranty. Keep this manual available for future reference. Products by Sony are designed with safety in mind. If the products are used incorrectly, however, it may result in a serious injury through fire, electric shock, the product toppling over, or the product dropping. Be sure to observe the precautions for safety to prevent such accidents.

CAUTION Specified products This Wall-Mount Bracket is designed for use with the products specified TVs. For TVs, refer to their Reference Guide to verify that the Wall-Mount Bracket can be used.

Be sure to subcontract the installation to licensed contractors and keep small children away during the installation. If the Wall-Mount Bracket or the TV is not installed correctly, the following accidents may occur. Be sure licensed contractors carry out installation.  The TV may fall and cause a serious injury such as a bruise or a fracture.  If the wall on which the Wall-Mount Bracket is installed is unstable, uneven, or not perpendicular to the floor, the unit may fall and cause injury or property damage. The wall should be capable of supporting a weight of at least six times the TV weight. (Refer to your TV’s Reference Guide for its weight.)  If the installation of the Wall-Mount Bracket on the wall is not sufficiently sturdy, the unit may fall and cause injury or property damage.

Be sure to subcontract moving or dismounting of the TV to licensed contractors.

Do not apply any load other than the TV on the Wall-Mount Bracket. Do not shake the TV left/ right, up/down. If you do so, the TV may fall and cause injury or property damage.

Do not lean on or hang from the TV. Do not lean on or hang from the TV as it may fall on you and cause serious injury.

CAUTION If the following precautions are not observed, injury or property damage may occur.  Be careful to not pinch your fingers while handling the Wall-Mount Bracket or swiveling the TV set.  While swiveling the TV set, handle it with caution and take care not to hit any people nearby.  Be sure to store the unused parts in a safe place for future use. Keep them away from children.

Do not handle the product with excessive force during cleaning or maintenance. Do not apply excessive force on the topside of the TV. If you do so, the TV may fall and cause injury or property damage.

If persons other than licensed contractors transport or dismount the TV, it may fall and cause injury or property damage. Two or more persons (three or more persons for 189.3 cm (75 inches) and above TV) are needed to transport a large TV set (except Egypt). Two or more persons (three or more persons for 75 inches (189.3 cm) and above TV) are needed to transport a large TV set (Egypt only).

Do not place this product close to medical devices.

Do not remove screws, etc., after mounting the TV.

Keep out of the reach of children or the supervised individuals.

If you do so, the TV may fall and cause injury or property damage.

This product (including accessories) has magnet(s). Swallowing magnet(s) could cause serious harm, such as choking hazard or intestinal injuries. If magnets (or a magnet) were swallowed, consult a doctor immediately.

Do not make alterations to the parts of the WallMount Bracket. If you do so, the Wall-Mount Bracket may fall and cause injury or property damage.

Do not mount any equipment other than the specified product. This Wall-Mount Bracket is designed for use with the specified product only. If you mount equipment other than specified, it may fall or break, and cause injury or property damage.

This product (including accessories) has magnet(s) which may interfere with pacemakers, programmable shunt valves for hydrocephalus treatment, or other medical devices. Do not place this product close to persons who use such medical devices. Consult your doctor before using this product if you use any such medical device.

EN Precautions  If you use the TV installed on the Wall-Mount Bracket for a long time, the wall behind or above the TV may become discolored or the wallpaper may come unstuck, depending on the material of the wall.  If the Wall-Mount Bracket is removed after installing it on the wall, the screw holes are left.  Do not use the Wall-Mount Bracket in a place where it is subjected to mechanical vibrations.

Be sure to install the Wall-Mount Bracket securely to the wall following the instructions in this instruction manual. If any of the screws are loose or fall out, the Wall-Mount Bracket may fall and cause injury or property damage. Be sure to use the appropriate screws for the material of the wall and install the unit securely using four screws of 8 mm diameter (or equivalent).

WARNING Do not install the Wall-Mount Bracket on wall surfaces such as a pillar, where the corners or the sides of the TV protrude away from the wall surface. If a person or object happens to hit the protruded corner or side of the TV, it may cause injury or property damage.

Be sure to install the TV on a wall that is both perpendicular and flat. If you fail to do so, the TV may fall and cause injury.

If people or objects get tangled with cables, this may result in injury or damage to the TV.

Do not install the WallMount Bracket on wall surfaces where the corners or the sides of the TV protrude away from the wall surface.

If the TV is exposed to shock, it may fall or break apart. This may cause injury.

After proper installation of the TV, secure the cables properly.

Installing the WallMount Bracket

The following instructions are for Sony dealers only. Be sure to read safety precautions described above and pay special attention to safety during the installation, maintenance and checking of this product.

Be careful not to subject the TV to shock during installation.

Be sure to use the supplied screws and attachment parts properly following the instructions given in this instruction manual. If you use substitute items, the TV may fall and cause bodily injury to someone or damage to the TV. Be sure to assemble the bracket properly following the instructed procedure explained in this instruction manual. If any of the screws are loose or fall out, the TV may fall and cause bodily injury to someone or damage to the TV.

Do not install the TV over or under an airconditioner.

Be sure to tighten the screws securely in the designated position.

If the TV is exposed to water leaks or air current from an air conditioner for a long time, it may cause a fire, an electric shock or a malfunction of the TV.

If you fail to do so, the TV may fall and cause bodily injury to someone or damage to the TV.

Do not allow the AC power cord (mains lead) or the connecting cable to be pinched. If the AC power cord (mains lead) or the connecting cable is pinched between the unit and the wall or is bent or twisted by force, the internal conductors may become exposed and cause a short circuit or an electrical break. This may cause a fire or an electric shock.

The screws needed to secure the Wall-Mount Bracket to the wall are not supplied. Use the appropriate screws for the wall material and structure when mounting the Wall-Mount Bracket.

Before Getting Started  The TV illustrations shown in this manual are examples used to provide clear explanations of the operations. For this reason, the illustrations may appear different from your actual TV.

What Is Your Wall Made Of? Firstly, check the type of the wall to install the TV.

Solid concrete or concrete block

Precautions  Maximum dry wall thickness: 16 mm.  Ensure that the inner wood stud size is at least 51 mm × 102 mm for common or 38 mm × 89 mm for nominal.  Keep minimum 406 mm horizontal space between fasteners.

Precautions  Mount the Wall-Mount Bracket directly onto the solid concrete wall.  Ensure that the thickness of solid concrete wall is at least 203 mm.  Ensure that the size of each concrete block is at least 203 mm × 203 mm × 406 mm.

Checking the Parts Supplied with SU-WL850  Verify that all the parts are included. WM1 (×1)

Supplied with the TV Wall-Mount Attachment VS (×4)*

* Only for limited region/country/model.

EN Preparing for Installation  Have the TV’s Reference Guide and Setup Guide at hand before installation.  Confirm the installing position of your TV.  Prepare four screws of 8 mm diameter and four proper washers (not supplied). Select screws suitable for the material of the wall.  Prepare the following tools: *1

*1 Only for dry wall with studs

*2 Only for solid concrete or concrete block *3 Depending on models *4 Be careful when selecting screws and washers Washer

 Attaching the Wall-Mount Bracket to the Dry Wall with Studs

to the wall and make four marks aligned with the studs. WM1

Installing the Wall-Mount Bracket to the Wall

Note  Use a level to check whether WM1 is level.

4 Drill upper pilot holes on the

1 Decide on the installation location.

Make sure that the wall has enough space for the TV and is capable of supporting a weight of at least six times that of the TV. • Refer ”Measurement for Wall-Mount Bracket installation on the wall“ on page 18. • Refer to your TV’s Reference Guide for the TV’s weight.

Make sure the location on the wall to drill the holes are strong enough to support a weight of at least six times that of the TV. ×2 5.5 mm

Note  When your TV is installed on the wall, the upper side of the TV slightly leans forward.  We recommend you to check the position of TV in the viewing environment.

Note  Pilot holes must be drilled to a depth of 75 mm, using a 5.5 mm diameter drill bit.

8 Pull out the arm of the bracket to

on the wall using suitable screws (not supplied) and washers (not supplied). WM1

Preparing for the Installation

of the TV Note  Use a level to check whether WM1 is level.

Precaution  Do not over-tighten wooden screw 8 mm × 60 mm. Improper tightening could reduce the holding power of wooden screw 8 mm × 60 mm.

 Be sure to store the removed screws and unused parts in a safe place, keeping them away from children.

6 Drill lower pilot holes on the marks. (Refer step 4 for the drill instruction.)

Installing the TV to the Wall from Carton* ×2

* Only for limited region/country/model.

1 Remove the screws from the rear of the TV.

7 Fit the suitable screws and washers to the holes.

Note  Use a level to check whether WM1 is level.

2 Attach the Wall-Mount

Installing the TV to the Wall from Table-Top Stand

Attachment VS (supplied with the TV) to the rear of the TV (to make it parallel with the wall).

1 Remove the terminal cover.

2 Remove the screws from the rear

 Be sure to fasten the Wall-Mount Attachment VS when attaching them to the TV. Use only a flat head screwdriver to install the Wall-Mount Attachment VS . Use of another tool might result in over torqueing the Wall-Mount Attachment VS and damaging the TV.

3 Attach the Wall-Mount Attachment VS (supplied with the TV) to the rear of the TV (to make it parallel with the wall).

VS Note  Be sure to fasten the Wall-Mount Attachment VS when attaching them to the TV. Use only a flat head screwdriver to install the Wall-Mount Attachment VS . Use of another tool might result in over torqueing the Wall-Mount Attachment VS and damaging the TV.

 Three or more people are required to detach the Table-Top Stand.  Be careful not to use excessive force while detaching the Table-Top Stand from the TV as it may cause the TV set to fall resulting in personal injury or physical damage to the TV.  Take care when handling the Table-Top Stand to prevent damage to the TV.  Be careful when lifting the TV as the Table-Top Stand is detached, the Table-Top Stand may topple over and cause personal injury.  Take care when removing the Table-Top Stand from the TV to prevent it from falling over and damaging the surface that the TV is sitting on.

Installing the TV on the Wall M6

5 Detach the Table-Top Stand from the TV.  Remove one side of the Table-Top Stand at a time. Firmly hold the Table-Top Stand securely with both hands while the other people lift up the TV.

 Repeat the previous step and remove the other side of the Table-Top Stand.

3 Screw the left and right side of the Wall-Mount Bracket using M6 and attach WM3 .

Note  Do not attach WM3 on the labels.

5 When moving the TV, hold it firmly from the bottom.

Note  The TV may not move near close to the wall depending on the type and number of cables attached. This is not a malfunction.

 Attaching the Wall-Mount Bracket to the Solid Concrete or Concrete Block

WARNING  Two or more persons (three or more persons for 189.3 cm (75 inches) and above TV) are needed to transport a large TV set (except Egypt). Two or more persons (three or more persons for 75 inches (189.3 cm) and above TV) are needed to transport a large TV set (Egypt only).

Installing the Wall-Mount Bracket to the Wall

1 Decide on the installation location.

Confirming the Completion of the Installation Check the following points.  The cord and the cable are not twisted or pinched.

Make sure that the wall has enough space for the TV and is capable of supporting a weight of at least six times that of the TV. • Refer ”Measurement for Wall-Mount Bracket installation on the wall“ on page 18. • Refer to your TV’s Reference Guide for the TV’s weight. Note

WARNING  Improper placement of the AC power cord (mains lead), etc. may cause fire or electric shock through a short circuit. Be sure to confirm the completion of the installation for safety.

Other Information When removing the TV, reverse the previous installation procedure. WARNING  Two or more persons (three or more persons for 189.3 cm (75 inches) and above TV) are needed to transport a large TV set (except Egypt). Two or more persons (three or more persons for 75 inches (189.3 cm) and above TV) are needed to transport a large TV set (Egypt only).

 When your TV is installed on the wall, the upper side of the TV slightly leans forward.  We recommend you to check the position of TV in the viewing environment.

to the wall and make

on the wall using suitable screws (not supplied) and washers (not supplied).

Note  Use a level to check whether WM1 is level.

3 Drill pilot holes on the marks. Make sure the location on the wall to drill the holes are strong enough to support a weight of at least six times that of the TV.

Note  Use a level to check whether WM1 is level.

Precaution  Do not over-tighten wooden screw 8 mm × 60 mm. Improper tightening could reduce the holding power of wooden screw 8 mm × 60 mm.

6 Pull out the arm of the bracket to the end.

Note  Pilot holes must be drilled to a depth of 75 mm, using a 10 mm diameter drill bit.

Preparing for the Installation of the TV Note  Be sure to store the removed screws and unused parts in a safe place, keeping them away from children.

EN Installing the TV to the Wall from Carton*

Installing the TV to the Wall from Table-Top Stand

* Only for limited region/country/model.

1 Remove the terminal cover.

1 Remove the screws from the rear of the TV.

2 Remove the screws from the rear of the TV.

2 Attach the Wall-Mount Attachment VS (supplied with the TV) to the rear of the TV (to make it parallel with the wall).

3 Attach the Wall-Mount 1.5 N·m {15 kgf·cm}

VS Attachment VS (supplied with the TV) to the rear of the TV (to make it parallel with the wall).

Note  Be sure to fasten the Wall-Mount Attachment VS when attaching them to the TV. Use only a flat head screwdriver to install the Wall-Mount Attachment VS . Use of another tool might result in over torqueing the Wall-Mount Attachment VS and damaging the TV.

 Be sure to fasten the Wall-Mount Attachment VS when attaching them to the TV. Use only a flat head screwdriver to install the Wall-Mount Attachment VS . Use of another tool might result in over torqueing the Wall-Mount Attachment VS and damaging the TV.

 Three or more people are required to detach the Table-Top Stand.  Be careful not to use excessive force while detaching the Table-Top Stand from the TV as it may cause the TV set to fall resulting in personal injury or physical damage to the TV.  Take care when handling the Table-Top Stand to prevent damage to the TV.  Be careful when lifting the TV as the Table-Top Stand is detached, the Table-Top Stand may topple over and cause personal injury.  Take care when removing the Table-Top Stand from the TV to prevent it from falling over and damaging the surface that the TV is sitting on.

Installing the TV on the Wall M6

5 Detach the Table-Top Stand from the TV.  Remove one side of the Table-Top Stand at a time. Firmly hold the Table-Top Stand securely with both hands while the other people lift up the TV.

 Repeat the previous step and remove the other side of the Table-Top Stand.

3 Screw the left and right side of the Wall-Mount Bracket using M6 and attach WM3 .

Note  Do not attach WM3 on the labels.

5 When moving the TV, hold it firmly from the bottom.

Note  The TV may not move near close to the wall depending on the type and number of cables attached. This is not a malfunction.

 Two or more persons (three or more persons for 189.3 cm (75 inches) and above TV) are needed to transport a large TV set (except Egypt). Two or more persons (three or more persons for 75 inches (189.3 cm) and above TV) are needed to transport a large TV set (Egypt only).

EN Dimensions: (Approx.) [mm] a : 354 b : 116 c : 77 d : 563 e : 533 f : 370 g : 368 h : 350 i : 11 Mass (base only): (Approx.) [kg] 3.0

Confirming the Completion of the Installation

Design and specifications are subject to change without notice.

Check the following points.  The cord and the cable are not twisted or pinched. WARNING  Improper placement of the AC power cord (mains lead), etc. may cause fire or electric shock through a short circuit. Be sure to confirm the completion of the installation for safety.

Other Information When removing the TV, reverse the previous installation procedure. WARNING  Two or more persons (three or more persons for 189.3 cm (75 inches) and above TV) are needed to transport a large TV set (except Egypt). Two or more persons (three or more persons for 75 inches (189.3 cm) and above TV) are needed to transport a large TV set (Egypt only).

References Measurement for Wall-Mount Bracket installation on the wall Figures in the table may differ slightly depending on the installation.