StarLight - Cooker DOMETIC - Free user manual and instructions

Frequently Asked Questions - StarLight DOMETIC

USER MANUAL StarLight DOMETIC

Please read this manual carefully before starting up and store it in a safe place. If you pass on the device to another person, hand over this instruction manual along with it.

Contents

1 Explanation of symbols 8
2 General safety instructions 9
3 Scope of delivery 12
4 Accessories 12
5 Intended use 12
6 Technical description 13
7 Installing the device 14
8 Before initial use 16
9 Using the device 16
10 Troubleshooting 19
11 Maintaining the device 19
12 Cleaning the device 20
13 Warranty 20
14 Disposal 20
15 Technical data 21

1 Explanation of symbols

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or serious injury.

CAUTION!

Safety instruction: Failure to observe this instruction can lead to injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair the function of the product.

fig. 1 5, page 3: This refers to an element in an illustration. In this case, item 5 in figure 1 on page 3.

NOTE

Supplementary information for operating the product.

Action: This symbol indicates that action is required on your part. The required action is described step-by-step.
This symbol describes the result of an action.

2 General safety instructions

The manufacturer accepts no liability for damage in the following cases:

• Faulty assembly or connection
• Damage to the product resulting from mechanical influences and excess voltage
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in the operating manual

2.1 General safety

WARNING!

• Only use liquid gas (butane, propane) in the I_B / P, I_3+, I_3 categories. Do not use any other fuel sources.
• Keep a suitable fire extinguisher in the immediate vicinity. Ensure that the fire extinguisher is regularly checked by a specialist.

• This device may only be connected to the gas supply by a specialist in accordance with the applicable guidelines and standards (in particular EN 1949).

• This device is not connected to an exhaust extractor. It must be installed and connected according to the applicable installation conditions. Pay special attention to the ventilation requirements.

NOTICE!

• Only use the device as intended.

2.2 Safety precautions when handling liquid gas

WARNING!

• Keep combustible materials away from heating or cooking devices and other light or heat sources.
• Compare the pressure information on the type plate with the information on the pressure regulator.
• Never store liquid gas cylinders in unventilated areas or below ground level (cellar, funnel shaped holes in the ground).
• Keep liquid gas cylinders away from direct sunlight. The temperature may not exceed 50^ .

2.3 Operating the device safely

WARNING!

If you smell gas:

• Close the valve on the gas cylinder and keep it closed until the error is rectified.

• Never attempt to find a gas leak with a naked flame.

• The device may only be used in rooms with adequate ventilation according to the applicable regulations of the country.

• Using the gas cooker leads to a build-up of heat and moisture in the room it is used in. Ensure the room is well-ventilated by keeping natural air vents open or providing a mechanical ventilation device (such as an extractor hood).

Using the device intensively and for prolonged periods could make additional ventilation necessary, for example by opening a window or a more efficient ventilation system, such as using the mechanical ventilation device at a higher power level.

• People (including children) whose physical, sensory or mental capacities prevent them from using this device safely may not be allowed to operate it without the supervision of a responsible adult.
  Children must be supervised to ensure that they do not play with the device.
• Never leave the device unattended when in use for prolonged periods of time.
• Use long matches or a suitable lighter. Check the gas outlets when you ignite the burners. Do not ignite the burner if you cannot see it directly.

Remove your hand quickly as soon as the burner is lit.

• Wear suitable clothing when using the device.
  Do not wear loose hanging clothing which might catch fire.
• Leave the device to cool down properly before you touch it with bare hands.
• Never change the nozzles, injector or burners.
• Keep the area around the device free from fat, alcoholic substances, plastic and flammable materials (e.g. curtains, cloths or kitchen materials).
• Only use pots and pans with an even base and a diameter not larger than the grids on the hob (approx. 200^ ). The pots and pans should be large enough to cover the flame. If the flame is not covered, items of clothing could catch fire.

Pots and pans of the correct size also improve the efficiency of the hob.

• Ensure that pots and pans are stable when cooking.
• Never allow pot or pan handles to protrude over the edge of the hob. Turn the handles inwards, making sure that they are not positioned over other burners. This reduces the risk of spillage, the ignition of flammable materials and serious scolding.
• Proceed with caution when heating oil or fat, as they can ignite under excessive heat.
• Only use dry oven cloths to avoid steam build-up. Do not use towels as these can catch fire.
• Only operate the device when you or another person can attend to it. Pots which boil over can cause smoke and fires.

• Set the control knob to the neutral setting (0) before removing the pot or pan.

• Do not use the device to heat the room.

• Hot parts should not be allowed to come into contact with oil, water or any other liquids.

3 Scope of delivery

No. in fig. 1, Quantity Description page 2
1	1 Oven with grill and hob
2	2 Pot holder
3	1 Gimbal
4	1	B	a	k	i
5	1	R	a	c	k
-	1 Instruction manual

4 Accessories

Available as accessories (not included in the scope of delivery):

Description Item number

Pan 9103303862

5 Intended use

Dometic StarLight is intended for installing on board vehicles or boats.

The device may only be used for cooking, baking and grilling. It may not be used for heating.

6 Technical description

Dometic StarLight (item no. 9103303820) is a gas-powered oven with a grill and hob with 2 burners.

The device is made of stainless steel. The chromed pot grids and holders are detachable.

The two cooking rings can be controlled separately from the grill and oven. Liquid gas in the categories I3B / P,I3 + ,I_3 (butane, propane) is used as fuel.

The grill and the oven cannot be used at the same time.

Control elements

No. in fig. 2, Description page 2

1 Control knob for the left cooking ring

2 Control knob for the right cooking ring

3 Knob for the grill and oven

4 Neutral position

5 Large flame setting

6 Small flame setting

7 GRILL setting

6.1 Gas pressure

Refer to the type plate for the permissible gas pressure.

Only use pressure regulators that have been specified and approved in your country.

WARNING! Beware of injury

The outlet pressure of the pressure regulator must always match the connection pressure (gas pressure) of the device (see additional sheet).

7 Installing the device

You can fit the device into an existing kitchen installation.

7.1 Selecting the installation location

When selecting the installation location, observe the following instructions:

• Select a well-ventilated location for the device.
• Check the dimensions of the device (fig. 4, page 3 and fig. 5, page 4).

• Ensure the following minimum clearances

• 200^ to the side walls

• 170^ mm to the back wall

• 500^ between the burner and horizontal surface above the hob

• Ensure that there are no draughts in the installation location.

• Do not operate the device in rooms that are potentially explosive.
• If gimbals are being used, make sure that the cooker is able to vibrate.
• Leave sufficient space for the vibration of the gimbal.

7.2 Installing the device

NOTICE! Beware of damage

Before drilling any holes, make sure that no electrical cables or other parts of the vehicle can be damaged by drilling, sawing and filing.

This is how to install the device (fig. 6, page 4 and fig. 7, page 5):

Fasten the side plates using the screws provided leaving a space of 134mm around the kitchen unit.
Mount the device so that the bolts of the mounting plate hook into the side plates (fig. 7, page 5).

7.3 Connecting the device to the gas supply

WARNING! Beware of injury

• This device may only be connected to the gas supply by a specialist in accordance with the applicable guidelines and standards (in particular EN 1949).
• Only use propane or butane gas cylinders with an approved pressure reducing valve and a suitable head. Compare the pressure information on the type plate with the pressure information on the propane or butane gas cylinder.

Observe the following instructions during connection:

• Use gas pipes made from steel 8 × 1 ~mm (welded, seamless or stainless steel), which are flush-mounted with a cutting ring screw assembly.
• Fasten the pipes on the side or rear wall of the surrounding furniture parts so that no loads are exerted on the actuators.
• The connection must only be able to be released using tools. Observe the technical regulations on DVGW worksheets G607 and G608.
  The entire pipe system must be free of stress.
• During operation, there must be air vents with a cross-section of at least 150~cm^2 in the installation space. These vents can be closed, but must be kept open when the device is in use.

Connect the device to the gas supply.

Attach a sign above the device with the following text:

"WARNING!

When cooking, provide additional ventilation e.g. by opening windows near the grill, hob or oven.

This device must not be used for heating the room."

Open the main shut-off valve.

WARNING! Beware of injury

Never check for leaks with a naked flame or near sources of ignition.

Check all connections with leak spray.

There are no leaks if no bubbles form.

8 Before initial use

Clean the rack and the baking tray with a standard cleaning agent.
Turn the oven on for 30 minutes while empty at the highest temperature.

9 Using the device

NOTE

While it is operating, you will be able to hear a slight noise caused by the gas flowing out. This is completely harmless.
- Smoke can occur when using it for the first time. This is caused by deposits of machine oil burning and stops after approx. 10 minutes.
- The stainless steel burners turn blue from the high temperature. This does not affect the operation or the quality of the material.

9.1 Igniting the burners

WARNING! Beware of injury

• Only use the device when you or another person can attend to it.
• Ignite the burner as soon as you have turned on the gas supply. Otherwise gas can accumulate in the burner area and could cause an explosion.
• The complete ignition process must be visible from above and must not be hidden by pots placed on the hob.

Open the main shut-off valve.
Turn the control knob of the burner anti-clockwise from the neutral setting (0) to the large flame setting.
Press the control knob in and hold it in this position.
Ignite the burner straight away with a match or suitable lighter. Remove your hand quickly as soon as the burner is lit.

Once the burner is lit, you can release the knob after approx. 10 seconds.

If the burner goes out after releasing the knob: wait at least 60^ seconds before you ignite it again.

Set the flame so that it does not exceed the base of the pot.

Turn the control knob to the required position: "Large flame" or "Small flame".

9.2 Igniting the grill

WARNING! Beware of injury

• Only use the device when you or another person can attend to it.
• Never use the grill without any food to grill.
• Ignite the burner as soon as you have turned on the gas supply. Otherwise gas can accumulate in the burner area and could cause an explosion.
• Keep an eye on the gas outlets while you are igniting the burner (fig. 8 1, page 5).

Pull the heat guard out fully (fig. 9 1, page 6).
Open the main shut-off valve.
Turn the control knob (fig. 2 3, page 2) from the neutral setting (0) to the GRILL setting.
Press the control knob in and hold it in this position.
Ignite the burner straight away at the gas outlet (fig. 8 1, page 5) using a long match or a suitable lighter. Remove your hand quickly as soon as the burner is lit.

Once the burner is lit, you can release the knob after approx. 10 seconds.

If the burner goes out after releasing the knob: wait at least 60^ seconds before you ignite it again.
After it is ignited, check that the flames are burning on both sides along the whole length of the burner pipe (fig. 8 2, page 5).

NOTE Place the pan (accessory) directly on top of the burner to gain the most heat.

9.3 Igniting the oven

WARNING! Beware of injury

Use long matches or a long lighter to ignite the burner.

Remove your hand quickly as soon as the burner is lit.

NOTE

The oven can only be ignited if the oven door is completely open.

Open the oven door completely.
Open the main shut-off valve.
Turn the control knob of the burner (fig. 2 3, page 2) anti-clockwise from the neutral setting (0) to the large flame setting.
Press the control knob in and hold it in this position.
Ignite the burner straight away at the gas outlet (fig. 10 1, page 6) using a long match or a suitable lighter. Remove your hand quickly as soon as the burner is lit.

Once the burner is lit, you can release the knob after approx. 10 seconds.

If the burner goes out after releasing the knob: wait at least 60 seconds before you ignite it again.
After it is ignited, check that the flames are burning on both sides along the whole length of the burner pipe.
Turn the control knob to the required position.

NOTE

If the oven has not cooled down from previous use, the burner may go out straight after lighting it. In this case, blow into the burner opening to get rid of the steam.

Ignite the oven again as previously described.

9.4 Using the rack and baking tray

Note the following information when using the rack and baking tray:

• You can select three heights for the rack and baking tray.
• Always insert the rack (fig. 11 1, page 7) and baking tray (fig. 11 2, page 7) into the oven as shown.
  Always slide the rack into the guide rails.

9.5 Switching off the hob, grill or oven

Turn the control knob to the neutral position.
The burner goes out.
If you are not planning to use the device for a long time, close the valve on the gas cylinder.

10 Troubleshooting

Repairs to the gas supply parts on the device may only be carried out by a qualified technician.

Shut off the gas supply immediately if a fault occurs.
Check again for any damage to the device.
Replace the damaged parts.
Only use the device again once all the faults have been rectified.

11 Maintaining the device

For safety reasons, the device must be inspected annually by a specialist for correct functionality and necessary repairs.

While checking the device every year, pay particular attention to the following:

• G a s l e a k s
• Burning and flame stability
• Fresh air supply
• Safety and regulating devices (burner taps)

Check that the installation location conforms to local regulations.

Check the following components for dirt and clean, if necessary:

Gas outlets on the burner
- Burner heads
- Thermal element

Check the correct distance between the burner head and thermal element (approx. 1-3 mm).

12 Cleaning the device

NOTICE!

Do not use any sharp or hard objects for cleaning since they may damage the device.

Only use standard cleaning agents.

Allow the device to cool down properly before cleaning it.
Remove the grids from the hob.
Clean the hob surface, the grill box and the oven. Pay special attention to removing sticky fat and oil residue.
Do not use a steam cleaner to clean the device under any circumstances.

13 Warranty

The statutory warranty period applies. If the product is defective, please contact the manufacturer's branch in your country (see the back of the instruction manual for the addresses) or your retailer.

For repair and guarantee processing, please include the following documents when you send in the device:

A copy of the receipt with purchasing date
A reason for the claim or description of the fault

14 Disposal

If possible, dispose of the packaging material in the appropriate recycling container.

15 Technical data

	Dometic StarLight
Item no.: 9103303820
Gas consumption: Burner: 291 g/h	Grill: 100 g/h Oven: 80 g/h
Device class: III
Gas category: I	3B/P l3+, l3 (butane/propane)
Number of cooking rings: 2
Nominal heat input: Burner: (2200°W + 1800°W Grill: 1300 W Oven: 1100 W
Dimensions:	see fig. 3, page 3
Weight: 23 kg
Inspection/certification:	CE

6 Description technique

3aKpoIe BeHTnIb ra3OBoro 6aJIHOHa n OCTaBBte erO 3aKpbITbIM Do yCTpaHeHna HeNCpPaBHOCTN.
- HNKoRda He nbItaTeCb HaHTn yTeUky C NOMOuH OTKpbITo- ro nnameHn.

Tepmetnucb oecneueha, cnn He 6pa3yOTcny3bipbkN.

Dometic Australia Pty. Ltd.

1 John Duncan Court

Varsity Lakes QLD 4227

[phone]

[phone]

Mail: [e-mail]

AUSTRIA

Dometic Austria GmbH

The Gateway 25 Canton Road,

Tsim Sha Tsui · Kowloon

Hong Kong

[phone]

[phone]

Mail: [e-mail]

ITALY

Domatic Italy S.r.l.

Via Virgilio, 3

I-47100 Forli

[phone]

[phone]

Mail: [e-mail]

NORWAY

Dometic Norway AS

Skolmar 24

N-3232 Sandefjord

[phone]

[phone]

Mail: [e-mail]

POLAND

Dometic Poland Sp. z o.o.

Ul. Puławska 435A

02-801 Warszawa

Poland

[phone]

[phone]

Mail: [e-mail]

RUSSIA

Domatic RUS LLC

Komsomolskaya square 6-1

107140 Moscow

Russia

[phone]

[phone]

Mail: [e-mail]

SLOVAKIA

Domatic Slovakia s.r.o.

Tehelna 8

SK-98601 Filakovo

[phone]

[phone]

Mail: [e-mail]

SPAIN

Dometic Spain S.L.

Avda. Sierra del Guadarrama, 16

E-28691 Villanueva de la Canada

Madrid

[phone]

[phone]

Mail: [e-mail]

SWEDEN

Dometic Scandinavia AB

Gustaf Melins gata 7

Dometic Switzerland AG

Riedackerstrasse 7a

CH-8153 Rümlang (Zürich)

[phone]

[phone]

Mail: [e-mail]

TAIWAN

WAECO Impex Ltd.

Taipei Office

2 FL-3 · No. 56 Tunhua South Rd, Sec 2

Taipei 106, Taiwan

[phone]

[phone]

Mail: [e-mail]

UNITED KINGDOM

Domatic UK Ltd.

Dometic House The Brewery

Blandford St. Mary

Dorset DT11 9LS

[phone]

[phone]

Mail: [e-mail]

UNITED ARAB STATES

Dometic AB

Regional Office Middle East

P O Box 74775

Dubai, United Arab Emirates

密 [phone]

[phone]

Mail: [e-mail]

UNITED STATES OF AMERICA

Dometic Marine Division

2000 N. Andrews Ave. Extension

Pompano Beach, FL 33069 USA

[phone]

[phone]

Mail: [e-mail]