PowerMaxx SB 12 Set - Drill METABO - Free user manual and instructions

Product type	Cordless drill/driver
Brand	Metabo
Model	PowerMaxx SB 12 Set
Battery voltage	12 V
Battery type	Li-Ion
Battery capacity	2.0 Ah (typical)
Chuck type	Keyless self-tightening chuck
Chuck capacity	1 - 10 mm
No-load speed (1st gear)	0 - 400 rpm
No-load speed (2nd gear)	0 - 1500 rpm
Max torque (soft/hard)	14 / 30 Nm
Number of gears	2
Max steel drilling	10 mm
Max wood drilling	25 mm
Weight (with battery)	1.1 kg
Dimensions (L x W x H)	190 x 190 x 60 mm
Power supply	Li-Ion 12 V battery
Charger included	Yes (ASC 55 charger or similar)
Variable speed trigger	Yes, by trigger
Rotation direction	Left/Right
LED light	Yes
Motor brake	Yes
Spindle lock	Yes
Sound level (LpA)	70 dB(A)
Vibration (metal drilling)	2.5 m/s²
Protection class	III (extra-low voltage)
Maintenance and cleaning	Clean with a dry cloth, do not use solvents
Spare parts and repairability	Contact Metabo customer service or www.metabo.com
General information	Supplied in a case with charger and 2 batteries

Frequently Asked Questions - PowerMaxx SB 12 Set METABO

Which batteries are compatible with the Metabo PowerMaxx SB 12 Set drill?

The drill uses Metabo Li-Ion 12 V batteries from the CAS (Cordless Alliance System). Compatible batteries include models from 1.3 to 10 Ah. Use only original Metabo batteries.

How to charge the battery of the PowerMaxx SB 12?

Insert the battery into the supplied charger until it stops. The control indicator flashes during charging and stays on when charging is complete. The charger automatically switches to maintenance mode.

What is the charging time for a 2.0 Ah battery?

With the ASC 55 charger, a 2.0 Ah battery recharges in about 30 minutes. Times may vary depending on temperature and battery condition.

Can I use the drill while the battery is charging?

No, the battery must be removed from the tool for charging. You cannot use the tool while charging.

What should I do if the charger warning light flashes?

Flashing indicates a defective or incorrectly inserted battery. Remove the battery immediately and check its condition. If the problem persists, contact Metabo customer service.

How to change the rotation direction on the PowerMaxx SB 12?

Use the rotation direction switch located above the trigger. Push it to the left for right rotation (screwing) and to the right for left rotation (unscrewing). Never switch while the motor is running.

What is the maximum torque this drill can provide?

The maximum torque is 14 Nm in soft mode (screwing) and 30 Nm in hard mode (drilling). You can adjust the torque to 21 positions via the setting ring.

How to clean and maintain the drill?

Clean the housing with a dry, soft cloth. Do not use aggressive detergents or solvents. Keep the ventilation slots clear. Have the tool inspected by a professional in case of malfunction.

Where can I find spare parts for the PowerMaxx SB 12 Set?

Spare parts are available from Metabo after-sales service or at www.metabo.com. Use only original parts.

Is this drill suitable for drilling concrete?

No, the PowerMaxx SB 12 is a standard drill/driver without hammer action. It is not designed for drilling concrete. Use it for wood, metal, plastic, and screwdriving.

USER MANUAL PowerMaxx SB 12 Set METABO

Chief Technology Officer Koki Holdings Co., Ltd.

*4) Metabowerke GmbH - Metabo-Allee 1 - 72622 Nuertingen, Germany

DEUTSCHde

Original instructions

1. Declaration of Conformity

We, being solely responsible: Hereby declare that these chargers, identified by type and serial number 1), meet the requirements of all relevant directives 2) and standards 3). Technical documents for 4) - see page 3.

For UK only:

UK We as manufacturer and authorized person to compile the technical file, see *4) on page 3, hereby declare under sole responsibility that these chargers, identified by type and serial number *1) on page 3, fulfill all relevant provisions of following UK Regulations S.I. 2016/1091, S.I. 2016/1101, S.I. 2012/3032 and Designated Standards see *3) on page 3.

2. Specified Conditions of Use

Chargers are only suitable for charging original Metabo and CAS (Cordless Alliance System) battery packs.

This device is not designed for use by persons (including children) with physical, sensory or mental disabilities, or with insufficient experience and/or knowledge, unless they are supervised by a person responsible for their safety, or have received instructions on how to use the device by this person.

ASC 290 is suitable for charging Li-iron battery packs (12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells). The device is suitable for charging electronic devices with a USB-C interface (like smartphones, MP3 players, tablets, etc.) - no data exchange

ASC 145 is suitable for charging Li-lon battery packs (12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells).

ASC 55 is suitable for charging Li-ion battery packs (12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells).

ASC 55 is suitable for charging NiCd battery packs (12 V, 1.7 Ah, 10 cells).

SC 36, SC 30 is suitable for charging Li-Ion battery packs (12 V - 18 V, 1.3 Ah - 10 Ah, 3-10 cells).

Never attempt to charge batteries that are not rechargeable. Danger of explosion!

The user bears sole responsibility for any damage caused by inappropriate use.

Generally accepted accident-prevention regulations and accompanying safety instructions should be observed.

3. General Safety Information

WARNING - Read the operating instructions to reduce the risk of injury.

WARNING Read all safety warnings and instructions.

Failure to follow all safety warnings and instructions may result in electric shock, fire and/or serious injury.

Keep all safety instructions and information for future reference.

Before using the charger, carefully read through and familiarise yourself with all

the enclosed safety information and the Operating Instructions.

Keep all enclosed documentation for future reference, and pass on your charger only together with this documentation.

4. Special Safety Instructions

For your own protection and for the protection of your power tool, pay attention to its text of the text that are marked in this symbol!

Danger - electrical voltage!

A slightly acidic, flammable fluid may leak from defective Li-ion battery packs!

If battery fluid leaks out and comes into contact with your skin, rinse immediately with plenty of water. If battery fluid leaks out and comes into contact with your eyes, wash them with clean water and seek medical attention immediately! Do not recharge a fully charged battery pack!

Only for use in indoor rooms.

ENGLISHen

Protect the charger from moisture.

Never allow children to use the device.

Children should be supervised to ensure that they do not play with the tool.

Keep children away from the battery charger and the working area!

Keep your battery charger out of reach of children!

Pull out the mains plug immediately if the battery charger starts to smoke or flames emerge!

Do not insert objects into the ventilation slots on the battery charger – there is a danger of electric shocks and short circuits!

Do not use faulty battery packs.

In areas with high metal dust exposure do not charge any battery packs with AIR COOLED chargers.

ASC 290: Only use the original Metabo network connection line.

5. Overview

See page 2. The illustrations are regarded as exemplary for all devices.

1 Battery pack (not in scope of delivery)
2 Sliding seat
3 Operation display
4 Warning display
5 Charge status indicator
6 USB cover
7 USB-C port *
8 LED indicator (USB-C port supplied with voltage) *

• depending on the model

6. Initial Operation

Before commissioning, check that the rated mains voltage and mains frequency stated on the type plate match your power supply.

Devices like these that generate direct current can influence simple earth leakage protection devices.

Use a type F or better, with a release current of max. 30mA

Before commissioning the charger, ensure that the air slots are free. Minimum distance to other objects is 5cm

6.1 Self-test

Plug in.

The warning display (4) and the operating indicator (3) light up one after the other for approx. 1 second and the installed fan runs for approx. 5 seconds.

7. Use

7.1 Charging battery pack

Push the battery pack completely to the stop on the sliding seat (2).

The operating indicator (3) flashes.

Note: To have the charge level displayed on Li-ion battery packs, first take the battery pack out of the charger and then press the button on the battery pack.

7.2 Conservation charge

Once the charging process has finished, the battery charger automatically switches to conservation mode.

The battery pack can remain in the battery charger and is therefore always ready for use.

The operating display (3) lights up continuously.

7.3 ASC 290 only: Charge USB device

Only connect USB devices which are compatible with the USB standard. Using

incompatible devices can lead to malfunctions, damage or injuries.

Open the cover (6) and plug a USB device with a suitable cable into the USB-C port (7). The device is charged.

The USB-C port (7) is only supplied with voltage (LED indicator (8) illuminated) if no battery pack is charged.

If a battery pack and USB device are connected at the same time, the USB charging process will start automatically after the end of the battery pack charging process.

8. Faults

8.1 Warning display (4) lights up continuously

Battery pack is not charged. Excessive/insufficient temperature. When the temperature of the battery

pack is between 0^ and 50^ , the charging process begins automatically.

ASC 290: Warning display (4) lights up continuously and charge status indicator (5) flashes: Charger is hot, or battery pack is cold or hot, battery pack is charged with reduced charging capacity.

8.2 Warning display (4) flashes

• Battery pack is defective. Remove the battery pack immediately from the charger.
• The battery pack was not pushed correctly onto the sliding seat (2). See chapter 7.1.
• ASC 290: Warning display (4) lights up and charge status indicator (5) is off: battery pack is not charged. charger too hot.

9. Repairs

Repairs to the charger must only be carried out by qualified electricians.

If the mains connection cable of this device is damaged, it must be replaced by the manufacturer or the Customer Service department of the manufacturer or a similarly qualified person to prevent endangering personnel and property.

If you have Metabo charges that require repairs, please contact your Metabo service centre. See www.metabo.com for addresses.

10. Environmental Protection

Observe national regulations on environmentally compatible disposal and on the recycling of disused machines, packaging and accessories.

Packaging materials must be disposed of according to their labelling in accordance with municipal guidelines. Further information can be found at www.metabo.com in the "Service" section.

Only for EU countries: never dispose of power tools in your household waste!

According to European Directive 2012/19/EU

on Waste from Electric and Electronic Equipment and implementation in national law, used power tools must be collected separately and recycled in an environmentally-friendly manner.

11. Technical Specifications

See page 3.

U = voltage ranges of the battery packs

C = battery pack capacity

I_C =charging current

= charging time

USB = Voltage and max. charging current of the USB-C port

1) Example charging times for selected battery packs. Real charging times may deviate from the specifications depending on the residual capacity and the temperature of the battery pack.

Recommended ambient temperature when charging: 0^ to 40^ .

Subject to change in accordance with technical progress.

Device of protection class II

AC Power

Notice originale

Varning for livsfarlig elspanning!

Trasiga litiumjonbatterier kan lacka en nagot sur, brannbar vatska!

reducere risikoen for

personskader.

ADVARSEL Læs alle

C = Uwunlngh hqnnpnpnlin

Ic =1gfmunfumhfnnmuf

t=1hgtuunuufduunuufu

USB=USB-C npnih hgfudnpufupnupdp l unuulj uqnlf hnuuifp

1) Cunpudlq hnunulh3 dupunlingfip h1hgfuudnpuufi duwufuul: yu|nuw dnnunulh2 dupunlng pnuh jhuugnpuwhnuiuupmnpnGg h gpiuunuH6u, 1gufuupduhpuu duunuulh qupnL muppluL fucud uuduulh:

3apraTafbiu KypbInfbiHaH WbIFapbIn, COHaH COH aKKMyJIaTOpdaFBI TyMeHi 6acbIHbI3.

7.2 TypaKTbI KocbIMwa 3aprTay

3apraaKaTaNfah XaFdaIa, 3apraTafblu KpybIbI aBtOMaTTbI TypDe TpaKTBi KocbIMwa 3apraTay pexMIHe aybicaBl.

AkkymyIaTOp 3apraTafblkypbIbfi iHHe KaIbIn, epdaibm Kymbicka daibn6Ojybl MymkiH.

100%

Kymbic INHnKaTopbI (3) TypaKTbI TypeJe KaHbIN TypaDbI.

7.3 TeK ASC 290: USB KypbIINfbicbiH 3apnTay

Tek USB cTaHdapTbImeH yInecimDi USB KypblfblnapbIH KocbiHbI3. YInecimDi emec KypblfblnapMeH 6ipre naJaHaHaH Jxafda, 6yI qyHKnra akaylapbl, 3aKbIMdap Hemece XapaKaT anyFa eKeNyi MymkIH.

KaKnaKTbI (6) aWbIn, USB KypblfbcH Tnicti Ka6eJIbMeH USB-C KocblmbHa (7) caJIbHb3. KypblFb3apraTalanaBl.

USB-C Kocblimbl (7) aKKyMyJrTop 3apraTajMaHaH XaFdaJaTeK KepeHMeH KyaTTaIaBb (XapbIKnOu INHnKaTOpbl (8) KaHaIbbl).

AkkymyJrTop MeH USB KypbIfbcBih 6ip yaKbITKaCKaH Ke3e,USB 3apraTay npoeci aKKymyJrTopDbH 3apraTay npoeci aKaTaIFaHHaH KeiH aBTOMaTTb Tpye 6actanaDbI.

8. AkayIbIK

8.2 Eckepty INdkaTop (4) XbInbIbIKTaIbI

• AkkymyIaTOp aKayIbI. AkkymyIaTOpdbI 6ipDeH 3apraTaftbIu KypblfDaH WbIfapbHbI3.
• AkkymyJrTop kblnKbImaJIbI TIpeKke (2) Dypbc KblNkbITbIMaHaH.7.16enimH kappaHbI3.
  ASC290: eckepTu INHnKaTOpbl (4) XbInbIbIKtan Typ XaHe 3apd DeHreinH

HINKaTOPbI (5) cEHdipyni: aKKMyJrTOp 3apraTaNMayda, 3apraTaFbIi KypbIJfbl KaTTbI Kbl3bIn KeTTi.

9. XeHney

3apraTafbiW KpybIJfblJa KeHney KymbIcTapbIH TEK KaHa 3neKtpwi MaMaH eTKi3yi Tnic!

OcbI KypblnfbHbH JeJIiIK KyaT Ka6eJI 3akbIMdaJFaH KaFdaJa, Kayinti XaFdaJnapdbI 6oJbIpMaY wH, ON eHdipyWl Hemece Kb13MeT Kepcety optaBfbiHa HeMece YKcac bIikTIiIKKe Ne Tynfa TapaBHaH aybIcTbPbJybl Tnic.

Metabo qinnnaIbHa XeHdeydi KaXeT eTeIH Metabo 3apraTaftbiu KypblfbcimEn 6ipre 6apbIb3. MeKeHkaJnapbl WwW.metabo.com caaTbIHda 6epinreH

10. Kopwafrn opTaHbI Kopray

PainanaHbInFaH acnantapdbI, opaybiTapdbI
XHe KepeK-kaPaKTapdbI KOpwaFAnOpTa yuH
Kayinc3 Typde KaDere XapaTy XHe KaTAt eHdey
BoBHwA YTTbIK epexeJIepdi YCTaHbIHbI3.

OpaybI MaTePnAJaapBt H TaH6aJamaHbI3
60bIHwa KOMMyHaJIbIK DInpeKTHBaJapFa CKeKc
KaJeE XapaTy KaKeT. KocbIMHa HyCKayJaapDbI
www.metabo.com Be6-caTbHaH《CepBnc》
aMafblHa KaPaHbI3.

TeKaHa EO eJepiHne: 3JIeKtpnIK KypaIbI TyPmbICTbIK KOkbicka TactMaHbI3! 3JIeKtpnIK XHe 3JIeKtpoHdbIK ecki

KpybIbInap KHe YTTbIK 3aHfA TypneHdipy
XeHiIderi 2012/19/EU eyponabIK DnpeKTnBacbiHa
Caikec, naJaIaNbIIFan 3JIeKTPNIK KypaIap
6oNEK XInHaBn, KopWafAn opta ywiH Kayinci3
KaIta eHdeyre xibepinyi Tnic.

11. TexHnKaJIbIK depeKTeP

3-6etti kapaHbI3.

U=akKymyIaTOpDbIHKepeHeynana3OHBi

C = aKKMyJnTOpDbIH KyaTbIbIfbI

IC 3apraTay torbl

t=3aprnday yaKbITbl 1)

USB = USB KocbIbIMbIbIH KepeHyi MeH MaKcImaNdbI CbIbIMdbIbIK TORbl

1)Mbican petiHde TaHdaIaNfAH aKKMyJrTOpDbIH 3apTay yaKbITbl. AkMyJrTOpDbIH KaJFaH KyaTTbIbIfbl MeH TeMnepaTypaCbHa 6aIIaNbICTbl 5bHaBb 3apTay yaKbITbl CneuΦnKaunapDaH e3reJeNeHy MyMKIH.

3apay KeiHderi YcbHbIaTbIH KopWafaH opta TemnepaTypacb: 0^ XeHe 40^ apaIbIbHa.

TexHnKaJIbIK dAmyFa kappa e3repyi MymKiH.

II KOpFaHbIC KJIacbIHdAfbI KypbJIJFbI

AHybImaJIbl TOK

Пайдалануь сюнча hyckаманьн hyкypасы

IiD'EnHyBaTn JInIe npncTpoi USB, cymichi 3i CTaHdapToM USB. BnKOpncTaHHra 3

HecymichmnpnctpoMMOJepn3BecTN OHeCnpaBHOCTi,NOKODKeHHa6o TpaBM.

BiDkpntn KpnuKy (6) i niD'EnHaTn npncTpii USB 3a DOnOMOro BIDINOIBHoro Ka6eIIO Do po3'emy USB-C (7).Pnpctpi 3apdKaetbcra.

Hanpyra KINBJIeHHNoaetbCHa po3'em USB-C (7) (CBITIOIOHN iHnKaTOp (8) cBITNbC), TIlbKN KOJn aKMyJIaTOpHn 6LoK He 3apAHaetbCra.

KuO aKymyIaTOPHn 6LoK i USB-npncTpii niEHaHO OndHocHo,3apJxKaHHa USB- pNCTPOU PO3IOuHETbCra ABTomaTHNo UoH0 3aBepuHTbc3apJxKaHHaKymyIaTOPHO 6loka.

8. HecnpabHocti

8.1 PonepeJyBaJIbHn iHdIHaTOp (4) roptb noctiHo.

AkyMylrOpHn 6JIOK He 3apdHaeTbcra. Tempepatya 3aHaTO BvcoKa / 3aHaTo Hn3bKa. KoIy Tempepatya aKymyIrTopHO rOky ckaIae BiD 0^ Do 50^ , npocec 3apdHaHHnoHnHaetbcra ABTomATnHOr.

ASC 290: nonepedkyBaIbHn iHdNkatop (4) CBITbcra noCTiHNO, a iHdNkatop pIBHa 3apAdy (5) 6IImaε: 3apAHHn npncTpi rapAyn, aKymyTAOPHN 6LOK XOJODHn qn rapAyn, aKymyTAOPHN 6LOK 3apAJaE TbC8 3i 3HKeHO NOtYHKHcTIO.

8.2 PonepeJyBaJIbHn iHdHaTOp (4) 6JIIMaE

• AkymyJIaTOPHn6IOK NOUKOJKeHn. HeraHOBINMiTb aKymyJIaTOPHn 6Iok i3 3apJdHoro npNCtpoIO.
  AkymyJIaTOPHn6LOKHeNPaBnIbHO BCTaBHeHny rHi3do (2).DnB. po3di7.1.

ASC290:nonepedkyBaIbHni iHnKaTOp(4) 6IImaε, a iHnKaTOp pIBHa 3apAdy (5) He CBiHTbcr:akymyIaTOpHn 6Jok He 3apAJaCaETbcR, 3apAhn npncTpri 3aHaTO rapAyn.

9. PemoHT

Pemont 3apraHoro npncTpoIO NOBHeH 3diIChIOBaTnCRA TIlbKn PPOeCiINHMN eIeKtpnKaMn!

Y pa3i yuKoDxKeHHKa6eHIO KHBnEHH DaHOro npIaLy BuiJx 6e3neHn Heo6XiDHO 3a6e3neHTN Ioro 3amHy BnO6HNKOM, faxIBcEM cepBicHOI cny6bN a60 iHoo Oco6oH BiDnOBiDHOI KBaJIΦiKaUII.

Для ремонту заюнх пистоов Metabo 3вертайесь в PeriohalbHe пedingtabHNTBO Metabo. Адеси ДИВ. на сaiti www.metabo.com.

10. 3axnct doBknla

DToPmMyTeCeHaioHaJIbHnx npaBn 6e3neHoYtIi3aui i nepepo6Kn BHKOpncTaHINHCTpyMeHTIB, naKyBaJIbHnx MaTepiA1ib i npila.

NakybaJIbHI MaTepiAIn yTnIi3yUToBc BiIDNoBIdHO Do IXhboRO MapKyBaHHa 3rIINO 3 KOMyHaJIbHIMn npaBnAmn. IOnaTKOBy iHOpMaciIO MoKHa 3HaHTn Ha caTI www.metabo.com y po3diIi «Cepbic»

TilbKn dIa KpaIH EC: He yTuIi3yIte eNeKTpoIHCTpyMeHTn pa3OM 3 NObyTOBIMN BIDXoAMn! 3riDHO 3 DupeKTHBOHO EC 2012/

19/EC npo eJektpnHi Ta eJektpOnHi npncTpoi Ta BiIDNOBIDHMN HaioHaJIbHMN HopMaMn BiIDnpaCbObaHi eJektpoiHCTpyMeHTn NiIyraOTb po3dJIbHi yTNIi3aqi3 3 MeTOIO IX NpdaJIbWoI ekoloriyHo 6e3neuHOI nepepo6Kn.

11. Texhichi xapaKtepncnkn

ДиВ.стор. 3.
U = Hanpyra aKymyTOpHoro 6Ioky
C=emHicTb aKymyIaTOPHOro 6IoKy
IC =ctpyM3apAaHHA
t=Yac3apRkaHHA
USB = Hanpyra i makc. cnna cTpyMy po3'emy USB-C
1) TpnbaiicTb 3apJdKaHHN DJI Bn6paHnx
aKymyIaTOphNX 6loKIB K npNKlaI. 3aJeKHO BiD
3aIIuIKOBoI EMHOCTi Ta TEMpePaTyPi
aKymyIaTOphHO 6L0KA qAKTHUHa TpNbaiicTb
3apJdKaHHN MoKe He 36iraTncs 3i Bka3aHIMN
3HaueHHAMN.
PeKOMeHDoBaHa TempepaTypa HABKOJIuHbOro cepeIOBua nId yac 3apJxKaHHa: BiD 0^ do 40^
3aIIuHaEMO 3a cO6oIO npaBO Ha TexHiHHi 3MiHN.
PnIaAD KlaCy 3axNcTy II
3MiHHN CTrpyM

Bnpo6Hnk:Meta6oBepkeTm6X,

Metafo-Aler 1,72622 HoptinreH, HimeyuHa

YnoBHOBaKeHn npedCTaBHNK:

TOB "Metaabo YkpaHa", Byl. 3OpraHa,

6y.22,c.CBraToneTpibcBe,

Hnibcbka 06I., 08141, YkpaHa

1g jzall gswill 1eJg sIlc
aaii iia JdJn g jll
!ailjgSll sljdo aLg

1

auiuuiiuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuuiuui uuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuuu uu

A. i. 11

*USB-C 山 _ 山 Y * (auiuuiy iue USB-C ）LED

.6

a 30

15 5

PB CA

1

a 5 a a a a a a a a

7.

(2) aai jai xie lii ie aai iiaai yai jai jai

(3)