P 3300 G - Water pump METABO - Free user manual and instructions

USER MANUAL P 3300 G METABO

Original Instructions

1. Declaration of Conformity

We hereby declare that these pumps/domestic water works/domestic water automatic systems, identified by type and serial number 1 ), meet all relevant requirements of directives 2 and standards 3 . Technical documents for 4 - see page 3.

For UK only:

UK We as manufacturer and authorized person to compile the technical file, see *4) on page 3, hereby declare under sole responsibility that these pumps/domestic water works/domestic water automatic systems, identified by type and serial number *1) on page 3, fulfill all relevant provisions of following UK Regulations S.l.2016/ 1091,S.l.2016/1101,S.l.2001/1701,S.l.2012/ 3032 and Designated Standards EN 60335-1,EN 60335-2-41,EN IEC 63000:2018.

2. Specified Use

This device is used for conveying clean water in the house and garden area, for sprinkling and watering, as a well pump, rain pump and domestic water pump, for pumping empty of garden ponds and water tanks.

The pump is not intended for:

• continuous operation

• industrial or commercial use

The pump is not suitable for transportation of:

• drinking water

-food

• salt water

• explosive, flammable, aggressive, or hazardous materials (e.g. chemicals)

• liquids over 35^

• water containing sand and liquids with an abrasive effect

• liquids containing chlorine (e.g. pool water)

The pump is not suitable for increasing pressure: if the pump is connected to a line that is already pressurised then a suitable pressure regulator should be installed upstream of this. The maximal pressure of the system must not exceed the stated maximum pressure of the pump under any circumstances. It should also be borne in mind that

the inlet pressure is added to the cut-off pressure of the pump!

This device is not designed for the use of persons (including children) with limited physical, sensory or mental aptitude or lack of experience and/or knowledge.

Unauthorised modifications to the device and the use of parts that are not tested and approved by the manufacturer are prohibited.

All improper use of the device is regarded as non-specified use; this can result in unpredictable damage! The user bears sole responsibility for any damage caused by inappropriate use.

Generally accepted accident prevention regulations and the enclosed safety information must be observed.

3. General Safety Instructions

Pay attention to all parts of the text that are marked with this symbol for your own protection and for the protection of your device!

WARNING - Reading the operating instructions will reduce the risk of injury.

WARNING Read all safety warnings and instructions. Failure to follow all safety ings and instructions may result in electric k, fire and/or serious injury.

Keep all safety instructions and information for future reference.

Pass on your pump only together with these documents.

Information in these operating instructions is designated as shown below:

Danger! Risk of personal injury or environmental damage.

Risk of electric shock! Risk of personal injury from electric shock.

Caution! Risk of material damage.

4. Special Safety Instructions

Children, adolescents and persons who are not familiar with the operating instructions must not use the device.

Children should be supervised to ensure that they do not play with the device.

When the pump is being used in garden ponds and in the protected areas around them, the provisions of DIN VDE 0100 -702, -738.

The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).

The device must not be used if there are persons in the water.

The statutory water and waste water specifications and the provisions of DIN 1988 must be observed when used for the domestic water supply.

The following residual risks essentially remain when operating pumps and pressure vessels (equipment-specific) - they cannot be fully eliminated even if safety measures have been introduced.

4.1 Danger from the environment!

Do not expose the device to rain. Do not operate the device in a damp or wet environment.

Do not use the pump in potentially explosive locations or near flammable liquids or gases!

4.2 Danger from hot water!

Danger! Install a check valve at the suction connection (8) to prevent water from flowing back into the suction line. This can reduce the following danger:

Hot water can cause damage and leaks on the device and the connection lines, allowing hot water to escape. Danger of scalding!

Devices with the designation HWW...: if the shut-off pressure of the pressure switch cannot be reached due to poor pressure conditions or a defective pressure switch, the water can heat up within the device as a result of internal circulation.

Devices with the designation P.... do not operate the device against a closed discharge line for longer than 5 minutes. Water that circulates inside the device is heated up.

In the event of a fault, unplug the device from the power supply system and allow it to cool. A specialist must check the system to make sure it is in perfect working order before it can be used again.

4.3 Risk of electric shock!

Never direct the water jet directly at the device or other electrical components! Risk of fatal electric shock!

Always disconnect the device from the power supply system prior to installation and maintenance tasks.

Do not touch the plug with wet hands! Always pull on the plug and not the power cable to disconnect it.

Do not buckle, squeeze, drag or drive over the power cable or extension cables; protect them from sharp edges, oil and heat.

4.4 Danger due to deficiencies or faults on the device!

Check the device for possible damage - especially the mains cable, mains plug and electrical components before each use. Risk of fatal electric shock!

A damaged device must only be reused after it has been correctly repaired.

Do not attempt to repair the device yourself! Only specialists are permitted to repair pumps and pressure vessels (equipment-specific).

Caution! To prevent water damage, such as flooded rooms, caused by deficiencies or faults on the device:

• Provide appropriate safety measures, e.g. alarm device or collection tank with monitoring The manufacturer is not liable for any damage caused by:

• Improper use of the pump.

• Overloading of the pump through continuous operation.

• Failure to operate and store the pump in a frost-free environment.

• Unauthorised modification of the pump. Repairs to electrical equipment may only be carried out by qualified electricians!

• Use of spare parts which have not been tested and approved by the manufacturer.
• Use of unsuitable installation materials (fittings, connection lines etc.).

Suitable installation materials:
- pressure-resistant (min. 10 bar)
- heat-resistant (min. 100^ ). When using universal swivel couplings (bayonet couplings), only use versions with an additional securing ring to ensure safe sealing.

5. Overview

See page 2. The illustrations are regarded as exemplary for all devices.

1 On/Off switch
2 P u m p
3 Pressure vessel ("vessel") *
4 Air valve for pilot pressure
5 Water drain screw
6 Pressure switch
7 Pressure gauge (water pressure) *
8 Suction connection
9 Water filling screw
0 Pressure connection
1 Pressure switch - adjustment of the cut-in and cut-out pressure
2 Pressure switch - adjustment of the differential pressure
equipment-specific

6. Commissioning

6.1 Installation

The unit must be set up horizontally at a dry (humidity max. 80% ), well-ventilated site that is free of atmospheric influences. Ensure that the unit is positioned on a secure, level and firm base when full of water. The air vents must not be covered or suck in dirt. There should be a clearance of at least 5 cm from walls and other objects. Protecting against frost - see section 8.2.

The device should not be bolted on but rather positioned on a resilient base to avoid vibrations.

The device must be installed in a flood-proof location and secured against falling in for operation in garden ponds. Additional statutory requirements must be taken into consideration.

6.2 Connecting the suction line

Caution! The suction line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.
Caution! Use an intake filter to protect the pump against sand and contamination.
Caution! The check valve is absolutely essential to prevent the water from draining when the pump is switched off. We recommend the installation of check valves at the intake opening of the suction hose and at the suction connection (8) of the pump. A check valve may already be integrated depending on the model (see section 13. Technical Specifications).
Seal all fittings with thread seal tape (approx. 10-15 windings in the thread direction). Leaks result in the intake of air and reduce or prevent the intake of water.
The suction line should have an internal diameter of at least 1^ (25 mm); it must be kink- and vacuum-resistant.

The suction line should be as short as possible because the longer the line length, the lower the conveying capacity.
The suction line should rise uniformly towards the pump to prevent air pockets.
An adequate supply of water must be guaranteed and the end of the suction line should always be under water. Ensure that the suction line is not on the ground so that no sand or dirt is sucked in. It is possible, for example, to use a floating intake as an accessory.

6.3 Connecting the discharge line

In order to reduce friction losses, the discharge line should have an interior diameter of at least 1" (25 mm). If using smaller diameters, such as 1/2 then application problems may arise due to inadequate ventilation.

Caution! The discharge line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.

Seal all fittings with thread seal tape to prevent water leakage (approx. 10-15 windings in the thread direction).

All discharge line components must be pressure-resistant and installed correctly.

Danger! The discharge line can burst during operation if non-pressure-resistant components are installed or they are assembled incorrectly. Injuries are possible if highly pressurised fluids are ejected!

6.4 Connection to a pipe network

The device should be connected to the pipe network with flexible hose lines to reduce vibration and noises.

In the case of fixed pipes, it is recommended that these are laid only rising in the first 2 metres to ensure optimal ventilation.

6.5 Power supply connection

Risk of electric shock! Never operate the device in a wet environment and only under the following conditions:

• Connect it only to an earthed outlet that is properly installed, earthed and tested.
• The mains voltage, mains frequency and fuse protection must correspond to those stated in the "Technical Specifications".
• The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).
• The electrical connections must not be under water and must be located in a flood-proof area. The connections must be splashproof for outdoor use.
• Extension cables must have sufficient conductor cross sections. Cable reels must be fully unrolled.
• National installation specifications must be observed.

6.6 Setting the pilot pressure (only HWW...)

Set the pilot pressure before the initial operation. See section 9.4.

6.7 Filling the pump and suction

Caution! The pump must be filled with water with every new connection and in the case of water loss or air intake. Operating the pump without filling it with water will destroy it! In order to ensure trouble-free operation, we recommend sufficient removal of water so that the system is fully ventilated before initial use.
- Unscrew the water filling screw (9) with gasket.

• Slowly pour in clean water until the pump is filled.
• Screw in the water filling screw (9) with gasket again.
• Open the discharge line (open the water tap or spray nozzle) so that air can escape during suction.
• Switch on the device (see section 7).
• The device is ready for operation when water emerges evenly.
  Note: the suction line does not need to be filled because the pump is self-priming. However, it may take some time until pressure is built up depending on the length and diameter of the line. To shorten the suction time: install a check valve at the intake opening of the suction hose and fill the suction line too.

7. Operation

Caution! The pump and suction line must be connected and filled (see section 6.).
Caution! The pump must not be allowed to run dry. There must always be sufficient conveying medium (water) available.

A protective circuit shuts down the motor if the pump is blocked by foreign bodies or the motor is overheated.

7.1 Using the device

Garden pump

(Device designation P...)

Principle of operation: the device runs when it is switched on.

Danger! Run the pump for a maximum of 5 minutes if the discharge line is closed because otherwise overheating of the water in the pump can cause damage.

1. Insert the mains plug.
2. Fill the pump if necessary - see section 6.7
3. Switch on the device:
   Turn on the device at the switch (1).
4. Open the discharge line (open the water tap or spray nozzle).
5. Check that water emerges!
6. Switch off the device when work is complete. Turn off the device at the switch (1).

Domestic water works (Device designation HWW...)

Principle of operation: the device switches on when the removal of water causes the water pressure to fall below the switch-on pressure; it switches off again when switch-off pressure is reached. The pressure vessel contains rubber bellows that are under air pressure ("pilot pressure") when delivered; this permits the removal of small volumes of water without the pump starting up.

1. Insert the mains plug.
2. Fill the pump if necessary - see section 6.7
3. Switch on the device:
   Turn on the device at the switch (1).
4. Open the discharge line (open the water tap or spray nozzle).
5. Check that water emerges! The device is not ready for operation.
6. The device switches on and off as required.

8. Maintenance

Danger! Prior to all work on the device:

• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.
  Repair and maintenance work other than that described in this section should only be carried out by qualified specialists.

8.1 Regular maintenance

• Check device and accessories for damage, in particular electrical and pressurised components, and repair if necessary.
• Check suction and discharge lines for leaks.
• Clean the intake filter and filter element (if installed) and replace if necessary if the conveying capacity decreases.
• Check the pilot pressure of the pressure vessel (3) (equipment-specific) and increase it if necessary (see section 9.4 Increasing the pilot pressure).

ENGLISHen

8.2 If there is a risk of frost

Caution! Frost (< 4 °C) destroys the pump and accessories as both always contain water!

• Disassemble the pump and accessories and store them in frost-free conditions (see the following section) if there is a risk of frost.

8.3 Disassembling and storing the device

• Switch off the device. Disconnect the mains plug.
• Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
• Completely drain the pump (2) and vessel (3) as follows:
• unscrew the water drain screw (5).
• remove the suction and discharge lines from the device.
• store the device in a frost-free room (min. 5^ ).

8.4 Set pressure switch (HWW 3500/25 G only. Contact the Metabo service team for setting all other HWW models.)

Danger! Risk of electric shock at the terminals on the pressure switch! Only trained electricians should open the pressure switch and carry out changes.

The pressure switch is pre-set on site for the most common application areas and can be adjusted as follows if required:

Note: Adjustment of the main pressure spring (11) results in almost proportional changes in the cut-in/ cut-out pressure, the difference in pressure remains unchanged. An adjustment of the difference in pressure (12) only changes the cutout pressure, the cut-in pressure remains unchanged.

1. Switch off the pump, turn off at the mains, and ensure that no voltage is carried.
2. Remove the cover from the pressure switch.
3. Changing cut-in pressure: adjust main pressure spring (11) (SW 9 mm; 1 rotation ca. 0.1 - 0.15 bar). This adjustment also changes the cut-out pressure to a practically proportional extent!
4. Changing cut-out pressure: adjust (12) pressure difference. The cut-in pressure remains unchanged.
5. Mount the cover on the pressure switch and check professional installation.
6. Operate pump, check desired target value (7) on the manometer.
7. Repeat steps 1-6 if necessary until the desired values are set.

Caution! The stated maximum pressure of the pump must not be exceeded. The cut-in pressure of the pressure switch must always be at least 0.2 bar over the precharge pressure of the chamber (1.5 bar, see Chapter 9.4). To prevent regular switching of the pump, the chosen pressure difference should be as high as possible (e.g. pre-set at ca. 1.8 bar).

9. Troubleshooting

Danger!

• Prior to all work on the device:
• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.

9.1 Pump does not run

• Noms voltage.

• Check the on/off switch, cables, plug, socket and mains fuse.

• Mains voltage too low.

• Use an extension cable with an adequate conductor diameter.

• Motor overheated; motor protection relay has tripped.

• After cooling the pump will switch ON again.

• Ensure that there is adequate ventilation, keep air slots free.

• Observe the maximum supply temperature.

• Motor hums, but does not start.

• If repairs are required, see Chapter 11.
• Pump clogged or defective.

• Disassemble and clean the pump. Clean the diffuser and replace if necessary. Clean the impeller and replace if necessary. See section 11.

• Line/inlet pressure greater than pump cut-in pressure.

• A pressure regulator should be installed upstream, see Chapter2.

9.2 Pump not drawing in correctly or running very loudly:

• Lack of water.
• Ensure that there is an adequate supply of water.
• Pump not sufficiently filled with water. - See section 6.7.
• Suction line leaking.
• Seal the suction line, tighten the screw couplings.
• Suction height too high.
• Observe the maximum suction height.
• Insert the check valve, fill the suction line with water.
• Intake filter (accessories) obstructed. - Clean and replace if necessary.
• Check valve (accessories) blocked.
• Clean and replace if necessary.
• Water discharge between motor and pump, shaft seal leaking. (Minor discharge of water (max. approx. 30 drops per day) is normal with the use of shaft seals).
• Replace the shaft seal. See section 11.
• Pump clogged or defective. - See section 9.1.

9.3 Pressure too low or pumps runs continuously (continuous switch-on/off):

• Suction line leaking or suction height too high. - See section 9.2.
• Pump clogged or defective. - See section 9.1.
• HWW...: pressure switch adjusted.
• Read off the switch-on and switch-off pressure on the pressure gauge (7) and check the values (see section 13 Technical Specifications). Please contact Metabo Customer Service if a modification is required. See section 11.
• HWW.... pump starts up even after a small volume of water is removed (approx. 0.5 l) - Check whether the pilot pressure in the pressure vessel is too low. Increase the pressure if necessary. See section 9.4.
• HWW....: water is running out of the air valve. - Rubber bellows in the pressure vessel are leaking, replace them. See section 11.

9.4 Increasing the pilot pressure (only HWW...)

If - in the course of time - the pump starts up even after the removal of a small volume of water (approx. 0.5 l), the pilot pressure in the vessel must be restored.

Note: the vessel pilot pressure (air pressure) cannot be read on the pressure gauge (water pressure) (7).

1. Disconnect the mains plug.
2. Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
3. Unscrew the plastic cap on the front face of the pressure vessel; the air valve is located behind it.
4. Mount the air pump or compressor hose with a "tyre valve" connection and pressure gauge on the air valve.
5. Pump up to the specified pilot pressure (1.5 bar; see section 13. Technical Specifications).
6. Connect the device again and check it works.

10. Accessories

Use only genuine Metabo accessories.

Use only accessories that fulfil the requirements and specifications listed in these operating instructions.

See www.metabo.com or the catalogue for a complete range of accessories.

11. Repairs

Danger! Repairs to this device must be carried out by qualified electricians only! Please contact your Metabo service centre if you have Metabo devices that require repairs. See www.metabo.com for addresses.

For shipment: drain the pump and vessel completely (see section 8.3).

You can download a list of spare parts from www.metabo.com.

12. Environmental Protection

Observe the national regulations on environmentally compatible disposal and on the recycling of disused tools, packaging and accessories.

Packaging materials must be disposed of according to their labelling in accordance with municipal guidelines. Further information can be found at www.metabo.com in the "Service" section.

Only for EU countries: never dispose of power tools in your household waste! Used power tools must be collected separately and handed in for environmentally compatible recycling in accordance with European Directive 2012/19/EU on waste electrical and electronic equipment and its implementation in national legal systems.

13. Technical Specifications

Explanatory notes on the specifications on page 3. Subject to change in accordance with technical progress.

The pump characteristic curve (diagram on page 3) shows the conveying capacity that can be reached depending on the conveying height (suction height 0.5m and 1^ suction hose).

E E l e c t r V =Check valve integrated on the suction connection (8) of the pump

K =Mains cable

U =Mains voltage

f =Frequency

P1 = Rated input power

P_Standby = Standby consumption

= Rated power

C =Operating condenser

n =Rated speed

F_V, = Max. conveying capacity

F_h, = Max. conveying height

Fp,max =Max. conveying pressure

p1 =Pressure switch switch-on pressure

p2 =Pressure switch switch-off pressure

S_h, = Max. suction height

S_temp = Max. supply temperature

Ttemp = Ambient temperature

S1 =Splash protection class

_2 =Protection class

S_3 =Insulation class

M =Pump housing material

G = Grey cast iron

M_R = P u m p shaft material

M_W = Pump impeller material

D_s =Suction connection female thread

D=Pressure connection female thread

TV =Vessel volume

Tp,max =Max.vessel pressure

Tp.1 =Vessel pilot pressure

A' = Dimensions:

length x width x height

m =Weight (with mains cable)

AC power

The technical specifications quoted are subject to tolerances (in compliance with the relevant valid standards).

A Emission values

These values make it possible to assess the emissions from the power tool and to compare different power tools. The actual load may be higher or lower depending on the operating conditions, the condition of the power tool or the accessories. Please allow for breaks and periods for assessment purposes when the load is lower. Arrange protective measures for the user, such as organisational measures based on the adjusted estimates.

Typical A-effective perceived sound levels:

LpA =Sound-pressure level

L_WA(G) =Guaranteed acoustic power level as per 2000/14/EC

Wear ear protectors!

Notice originale

Pomp verstopt of defect.

M =Materialipumpeakselen

Mw =Materiale i pumpens Iopehjul

D_s =Sugetilkobling, innvendige gjenger

Reservedelslicer kan downloads pa www.metabo.com.

12. Miljobeskytelse

S3 =Katnyopia movwtkou uikou

Tp,max =Mey. pieon λeβnta

Tp.1 =Piocn nponlnpomega s λeβnta

A = △iaστασεις

MnKoC x nAtoC x uOos

Hacoc He paccuHTaHa TaKaHe ycIOBnA:

• npoDOnJIHKeIbHaN 3KcNJaTaUa

• pPOMbIJIeHHOe IIN PpOeCCNoHaJIbHOe HcNIOJIb30BaHHe

Hacoc He noDxOoNT IJIa nepeKaUHbAHn TaKnx HJDKOCTeI:

-NTBeBaB B0da
-ПИЗЕВIELnpODYKTbl
- COJIeHaB BOda
B3pbIbOONaChBie, rOpUHne, arpeccnBHe iJIN onaChBe IJI 3DOpOBbMaTePnaJIbI (HanpIMep, XIMHKaTBI)
- HNIOCTn CTemnpaTpyoB BIIe 35 ^ C
- BODa C COepeKHaHnEm NecKa N a6pa3nBhbIe HNkOCTN
-xlopcoedepekauxx HnKocTei (B0da B6accseHax)

Hacoc He paccunTaH Ha nobIeHne daBHeHHa.
nPi OndKIOUeHN HACoCA K IINHn,
HaxOJaueCe NOd DaBHeHMe, HeoXoDMo
ncONoJb3OBaTb NOxOJaun peyKTOp.

MaKcHmAbHoe DaBHeHne B CnCTeMe He DoJIHHo npeBBbWAty KAs3AHHO MaKcHmAbHoe DaBHeHne HAcOca.CJeDyET YHTbIbTb,HTO BXOHe O daBHeHne CymMpyTeC dABHeHnEM BBkIOuHHeNHaCocA!

DaHbHn HAcoc He npEHa3HaueH dIa
NcNoJIb3OBAHn IiUAMn (BkIOuHg ATeT) C
OrpaHueHehBMn FmIeHeCKHM, CeHCOpHbIMn
NII NcHXHueCKHM CnOCoHObCTMn,
HeIOCTaTOUYbIM ONbITOM n/nu 3HaHNIM.

3anpeaaetcramoBolhoe BHeceHne
n3MeHEH N KOCTpyKuH NaCocA, a TaKHe
NCIOb3OBaHne DeTaeH, He npOeJHX
NCbTaHAn H Ne pa3peWeHHbIX K pPImeHHeH
n3ROBOTeJIEM.

JIIO6OE HcNOJb3OBAHHe HaocAc HapUeHHe mnpABINr ERO 3KcNlYatauCnCHTaETCR hCNoJIb3OBAHHe He No Ha3HaNeHIO; TaKoe hCNoJIb3OBAHne MOKeT NOBLeNb 3a CoBoI HepeDvHEnHb yuePb6! 3a yuePb6, Bo3HKnH B pe3yJbTate NcNoJIb3OBAHnE He No HA3HaYeHIO, OTBeTCTBeHHOCtB HeCeT TOnJIHO nONb3OBaTeB.

Heo6xOJHMO CbokDaT b o6eepnHtBte npaBnHa npeD0TbpAeeHHeCuaCTbX Cnyaeb, a TaHOg YKazAHN O TeXHnke 6e3oNaCHOCTn, npuBeEHhIe B daHHOM pyKOBOcTBe.

3. 06uhe yha3aHnno TeXnKe 6e3oNaCHOCTn

ДлгБашен co6cTbeHHHOb 6eONACHOCHIN 3aunbI yCTpoiC7Ba OT NOBpeKdENH COJIIOJaTe Yka3AHJN,OTMeYehHbIe DAHHIM

CIMMBOIOM!

PDEYNPEKHENE-BueJX CHINKENHINCKA TPABMI PNOHTHE DAHOHO pyKOBDCTO NO KCNLIyTAuHn.

PPEyIPEHDEHNE! PpOHTte Bce HNCTpyKuIN uKa3aHnNo TExHHe

6e3onachocn. HecobJeHne HNCTpyKmI N yka3aHN NO TexHnE 6e3oNaChocTMOKeT npBecTN K nopaKeHnIO 3JekTPnuCeKM TOHOM, BO3HNHOBEHnIO NOkapa N/nn K NOyHeHIO TReJeIbIX TpaBM.

CoXpaHnTe BceMHCTpyKunH yHa3aHHNo texHnke 6e3onachOCTn dIy nCnONb3OBaHHn B 6dyuem.

JaBHeu npepaay Baewo Hacoc aOcUyecTBnAeTObBO BMeCTe C3TmN DOKYMHTAMI.
HOpMaun O603NaueHa B DaHHOM pyKOBODCTBe NO 3KcNyaataun CneDyou o6pa3OM:

Onachoctb!PpeynpeKdEHeNc o6 onaCHoCTn TpaBMblnn O BpeDe IJH aHOooJIe cpebl.

Onachoctb noulyehn TpaBm OT ydapa 3JIeKTPuYeCKM TOHOM!

IpeDyIpEKeHEne 06 onaChOCTn TpaBMbl npi pa6oTe c 3JeKToo6OpoyoBaHNem.

BnmaHne!IpeDynpexKdeneo BO3MOXHOM MaTePnaJbHOM yuepe6.

4.Oco6bIe yHa3aHnI NO TEXHNKe 6e3onacHOCTn

He pa3pe7aeTcNcNoIb3OBAHne HacocA DeTbMn NIOpOCTKaMn, a TaKHe IuCaMn, He O3HaKOMNBUsIMNCr C pyKOBOdCTBOM IO KcNlyaTaCNI.

TeHdoJHHbI HaxOHTbcra NOD NOCTOARHHbIM Ha6JIIODeHNEM, YTO6bl OHn He NCNOJb3OBaJIH HAcOC B KaueCTBe nrgpuKn.

PnEKnIyatauB npydx
DolHbI coJIIOdaTbcra
noJKeHn DIN VDE 0100-702, - 738.

Питанne arperaTa DoJHKHO OCyUeCTBnTbCЯЧe3 yCTpoIcTBO 3aUHTHO OTHIOUChENy (Y3O) C yCTaHOBJIeHHbIM TOKOM yTeuKN MaKc.30 mA.

He pa3pewaeTcIcNoJIb3OBAHne Hacoca,ecIn B BOe HaxoJrTCa IIOu.

Pn3KcNpyTaunB DomaunHe
CNCTeMe BOOCha6KeHn
DOJIHHbI CO6JIOdaTbcra
3aKpeJIeHHbIe 3aKOHOM
PpeINHCAnHr OTHOCHTeJIbHO
BOOCha6KeHn
BOOOITBeHn, a TaKHe
NoIOKeHn DIN 1988.

При ЭКслуацин НасOCOBи Нанорньхpe3epByapOB(B ЗавсимоCTNOTKOMпгТаци) СуцесътOTСLEДУQUОО OCTaTOUHbIE ONaCHOCTN, KOTOpbIe HeIb3Я ПОЛHOCTbIO YCTpaHNTb, Даже ррИЯВ над�жаци Меры БeЗОпАССТСТИ.

4.1 Onachocb, cBraHHa c OkpykaIouei cpeo!

He octabnIte Hacoc noD
doXdEm. He nCnoJb3yIte Hacoc
BO BnaKhbIX N cbIpblx
POMeueHnX.

He nCnoJb3yIte Hacoc BO B3pbIOONaCHbIX NOMUeHnAX

HIN B6JIH3N TROPUQHX HNDKOCTeH INIra3OB!

4.2 Topya Boda npedctablaet c6ooh onachoctb!

OnacHOCTb!YcTaHOBnTe 6paTHbI KlaanH Ha BCaCbIBaIOUeM NaTpYbKe, (8) YTO6bI He DOnyCTHTb O6paTHoro OTToKa BObl BO BCaCbIBaIOUeJ LHNH.NTO N03BOJNTymHeHbWHTb CJeDyIOUne ONaCHOCTN:

Bpe3yIbTaTe BO3dEInCTBnI RopAeN BODbl MOrYT BO3HNKHyTb NOBpeXDeHnI HRepeMeTHuHOCTb HacOca I COeINHITbHbIX Tpy6oPBOOBo, B pe3yIbTaTe Yero rOpraa BOa MoKeT noCTyNaTb HapJHy. OnachocTb Oxora!

Pn6Opblc 6o03NaeHHeM HWW....ecn DaBLeHne BbIKIIOUeHn IHeBMaTHueCKOro BbIKIOUaTeJI He DOCTNfAeTcR BCJeDCTBHe HeKOppeKTHo BbINOJIeHHbIX HaCTpoEKNB BCJeDCTBHe DeΦeKTA camoro IHeBMaTHueCKOro BbIKIOUaTeJI, BOda n3-3a cnpKylAun BHyTpN yCTPOJCTBa MoKeT HarpeBaTbcra.

Pn60pbIc 6o03NaueHnem P...: yCTPOINCTBO He DOJIHKHO pa6OtaTb C 3aKpbITbIM HAnOpHbIM Tpy60npoBODm DoJIbSe 5 MNHyT. Boda, UnpkUnpyUoJiaB BHyTpN HAcoca, HaRpeBaeTcJ.

B clyuae HeNCnpaBHOCTN OTcoeHNHTe HAcOCOT 3JeKTPnueeCHOcTe N DaIte Emy OCTbITb. Ipeep NOBTOPbIM BBODOM B KcNpyaTuIO CNEUJIHCTbI DOJHKbI PPOBepNTb NCpnaBHOCTb FyhNKUHOHPOBaHnY UCTaHOBKn.

4.3 Onachoctb, 06ycnoBHeHHa NCIOJIb3OBAHnEm 3JIeKTPo06OpyDoBaHnI!

He HaprabJIe CTpyo BObl HeNocpeDCTBeHNO Ha HAcOC Nn Dpyrne 3JeKtpueckNe y3JIb! OnacHocTb dJa Jn3HN, oBcJIOBJIeHHa YdapOM 3JeKtpuecknM TOKOM!

He donyckaetc npoBeHne pa60 nO yCTaHOBKe H TexHNueCKOMy 06CnyJHKBaHIO HaocA, NOKJIOpEHNO K 3JIeKTpUeCKO CETn.

PYCCHNru

He 6epntecb 3a ceTeByIO BnIky BlaJhbIM pyKaMn! Bcerda TAHnte 3a ceTeByIO BnIKy, a He 3a Ka6eJIb.

He donyckaIte 3aJOMOB, 3aKIMaHnI Hn Hae3da Ha ceTeBOH uYdInHHTeJIbHbI Ka6JIb; 6peRHTe OT KOHTaKTa C OCTpbIM KpOMKaMn, MaCLOM N BbICOKOH TEMpePaTPOI.

4.4 OnacHOCTb BCJIeIcTBHe deΦeHTOB HnH HeNCnpaBHOCTeHacoca!

Пюверяпт haacoc,В OOC6eHHoCTn CeTeBOI Ka6elb, BnKHy n 3JIeKTpueCkne DeTaIIHa Ha HAIyHne NOBpeKdEHN IpePeKaKDbIM BHLIOUChEnEM. OnaCHocTb dIЯ JN3Hn, OBycNoBJIeHHa YdapOM 3JIeKTpueCkIM TOKOM! IOBTOphoe NcNoJIb3OBAHne NOBpeJDeHHOrO HaCOca DOnyCKaEtCra ToIbKO NocIe OCyUeCTBJIeHnpeMOHTa KBaJIuФицIpOBaHHbIMN CNeuJaNNCTamN.

He BbINOJIHnTe
camoCTOaTeIbHbIpeMOHT
Pnp6opa! PpOBedeHne pemOHTa
HaococB n HApOpHBIX
pe3epByapOB (B 3aBnCmOCTn OT
KOMnleKTAuN) pa3peuaeTcR
TOJbKO KBaINΦuNpOBaHHbIMN
CpeuJaNCTamN.

BHHMaHHe!ДЯTOrOyTO6bI n36eKaTb yUep6a OT BODbl, HAnpIMeP 3aToPJIeHnI NOMEuEHN, Bbl3BaHHORo DeΦeKTAMn IIN HeNCnPabHOCTaMn HaCOca:

-Претсмтпгпохдяшп Мерь 6e3ОнаСHOCТи,Нар.； yctpoiCTBO aBapnHoiN CINHaIIN3aUIN INI npHemHbI pe3epByap CФунКцeн KOHtpoJr
Pon3BODNTeH He HecET HnKaKoI OTBETCTBEHHOCTN 3a yuep6, KOtOpbIMoKeT 6bITb HaHeceH Bpe3yNbTaTe
- INCNoJIb3OBAHnY yCTpoIcTBA He NO Ha3HaueHIO;
- neperpuy3KN BCJeCDTBHeHnpepbIBHOpa0TbI;
-3KcNllyaTaunn Hnn XpaHEnn yCTpOiCTBa 6e3 3aunTbI OT MOp03a;
- CamocToTeIbHO BHeceHn H3MeHEnB KOHCTpyKUnIO yCTPOINCTBa;POn3BOiNTb peMOHT 3JIeHTpOpnp6OpOB

pa3pewaeTcra Tolbko CneuannCTam-3eKtpnKaM!

-NCNoB3OBAHn3aNaChbIX
YacTeN, He npOBepeHHbIX N He
YTBepKdEHHbIX
PpON3BOIDTeJIem;
- HcnoJb3OBAHnHa HeNoJxOJaIeRo MOHTaXHOr MaTePnaIa (apMaTypa, CoeHNHTeNbHbIe Tpy6OpOBoDbI N.T.I).

IopxOpaun MOHTaHHbIMatepnAn:

-ВыдерЖиBaET daBleHne (MnH. 106ap);
-TeNIOcToHKn (MnH.100°C)
Pn NcNoJIb3OBAHN
YHINBepCaJIbHbIX NOBOpOTHbIX
(6aJHOHeTHbIX) MyΦT B cIeJIax
HaDeXHOCTn rIaPON3OJIaCNI
DOJIHXbI NCIOJIb3OBAbTCr TOJIbKO
BapNaHTbI NCIOJIHHeHnC
DOnOJIHHTeJIbHbIM PpHHIMHbIM
KoJIbUcOM.

5.0630p

Cm. ctp. 2.ИЗбразжени могут И спльзоватсь в Качестve пимерда BCEx пиборов.
1 BbikIIOuateTeIb
2Hacoc
3 HanopHy pe3epByap ("KoTeJ")
4 Bo3dyHbI KJIanaH dIaBHeH NOpNTK
5 Pe3b6oBaI np06ka BODocnBHO O TBepCTna
6 MaHOMETPNueckn BbIKIOUaTeIb
7 MaHOMeTp (dAbJIeHne BOIbI)
8BcabsbAiouni naTpy60
9 Pe3b6oBa npo6Ka HAIINBHO O TBepCTnA
10 HanopHbI naTpy6oK
11 MaHOMeTpNueckn BbIKIOuateIb — peryIINPOBkDaJIeHn BbIKIOeHn I bIKIOeHn
12 MaHometprnueckn BbKIOUoateIb peryInpObKa nepenada daBLeHna
B 3aBnCIMoCTN OT KOMJIeKTAuIN

6. BbOaB 3Hcnpnyatauio

6.1 yctaHOBka

YcTpoCTBO CLeDeyET yCTaHaBnBaTb B CyXOM (MaKc. BlAxAHCOCTb BO3Dxa 80 %), xopoJIOpeBtPnBAeMOM, 3aunuHHeHOM OT HeNORoDbI MecTe, Ha TOpH3OHTaLBHOM OCHOBaHN. Heo6xOdimo ObceNeHTb NaedEHXOCb T yCToHINBOCTb TaKe Iprn MaKcImaLbHM HanoJIHeHIN BODoB. BeHTnIaHOnHbIe OTBepCTNr DOJIKNHb 6BtB OTKpBTb N 3aunuHBe bT ONnADaHn rpa3n. PacctOTHHe Do CTEN I dpyRn X pPeIMTOB He Mehee 5 cm. 3aunTa ot MopO3a — CM. rnaBy 8.2.

TObbln36EkaBbN6paaHm HAcON He DoJIHNHe 6bIb JKecKTO PnINBHUNeH, OHJIOKeY UCTAHABINBATcHnA 3NaCTaHNOJNDIoKNy.

Pn3KcNlyaTaunHa npydx HAcocdoJKeH6bItb yCTaHOBJeC yETOM BO3MOxHOro NObema yPOBnB OdbI N 3aUnuEh OT naDeHn. Heo6xoImo TaKe npHHMaTb BO BHmHaHe DOIOJIHNTeJbHbIe 3aKOHDoAteJbHbIe Tpe6ObaHn.

6.2 PoiKluoyeHne BCacbIbaIOueJINHH

BHMaHHe! BcacBiaKUaJIHHNIOJHnMoHTNPOBaTbTaHKMOBa3OM,QTObiOHa HE Oka3bIBaJIHnKHORO MExAHmEeCKoBO3DeICTBnI HAnPraJeHHa HaHAcOC.

BnHMaHHe!NcNoJb3yIte npneMHbI 1nBtp,HTo6bI 3aUHTNTb HAcO OTNecha N 3arp3AHEHn.

BHHMaHHe!YTo6bI B0a He BbITeKaHa N3 OTKIOUHO HAcOa,OB3aTeJIbHOHyKeoibaHKnAn. MblpeKOMeHdyem YcTaHObky oBaTHbIX KlanAho HA BXOJHMOTBepCTIN BCacbIbaIOero WlaHra N Ha BCacbIbaIOeM naTpy6ke (8) HacOca.B 3abNCmOCTOn MToeJe, oBaTHbIK KlanAHMOKeT 6bITb yHe yCTaHOBJen (cm. raby 13. TexHnueChne XapaKTepNCTHN).

Bcepe3b60bIe coeHNHeHn CneJeT
repeMtn3HOBaTb C nMOOuHb yNLOTHENTbHn
JIeHTb (Pnp61.10-15 oOpTOB B HapabLeHH
XoJa pe3b6bl).Yepe3 HepeMpTeuHbMeCTA
ponCXoHIT NOcOC Bo3dYxa, BpeyltaTe Yero
CHINKaETcR INI PpeKpaUaTeCBAcsIBaHHe
BOJb.

BcacbIbaOuaa IINHn DOJNHa IMeTb BHTpeHHn DnAmEtp He MeHee 1" (25 MM); OHa DOJNHa 6bITb YCTOuHbA K3aIOMAM H BaKyyMy. BcacbIbaOuaa IINHn DOJNHa 6bITb HAcTOJbKO KOPOTKo, HACOJIbKO 3TO BO3MOHHO, TAK KaC C yBeUHHeHm DInHbI LINHN YMeHbJaTeCt MoUHOCt b NpaHn.

Bcabsibaoua JINHJ DOLIKHa NocTOrHHO NOHNMaTbCnNo HAnpBaJIeHmIO KHaCCcy,ДЯTOrO TcObI He DOnyCTInb BO3NtKHOBeHnBO3DyUhBix KapMaHOB.

Heo6xOJHMO oecneuHT bocTaOtHyb noBOD BObla KOneU BCaBbIaOuJe IINHH DoJIHN BcERda HaxoNtCB R BOJE.CLeDn3 Ta TEM, YTOb6 bCacBbIaOuaJIaONH He HaxoDInAc hA DHe, YTOb6I NcOK nII rpr3b He nonaJIb BHyTpB. C 3ToI ueJIbIO MOKET sbITb NCNoJIb3OBAH PIIaBAouJMy BODo3aOp, BXoJaJMy B nepeYeHb PnHaIaeXHoCTe.

6.3 PoiKIOUeHHe HAnOpHOro Tpy6oPobOda

Tc06bl Chn3ntb nOtepr HAnopa Bpe3yIbTaTe TpeHNAHTyPHeHHN DnAmeTp HApOpHOro Tpy6OpnpOba DoJxHeh 6blt He MeHbWe 1" (25 MM). PpN NcNoJIb3OBAHHm MeHbUxN dAmetPOB, HApMep, 1/2" Moryr 6blTb np06JIeMbPi nKcNJIpyATAuIN, CB3aHHbIe C pioxHM YdaJIeHMe BO3dYxa.

BHHMaHHe! HanOpHbI Tpy6OpBoOd D0JIKeH MOHTHpOBaTcH TaHIM O6pa3OM, YTo6bI OH He OKa3BaIHa HIKaKOro MExaHcHEcHOrO BO3eYCTBnN HnHapRJeHnHa HaHoc.

Bce pe3b60bIe coeHHeHn CneDyET
RpeMTNIOBaTc NMOUcMbY yNtOHTeNbHOJ
JIeHTBI BO I36KeHAnHe NPOTeKaHn BoDi (npN6J.
10-15 6obopoT B HapnbLeHn XoJa pe3b6bl).

BceTeTaN HAnOpHOro Tpy60npOBoa DoJNHHb BbIePnHBaTb HApO, IX MOHTaK OcyuIeCTBIAETcK BaJIINHfUHpOBaHHbIMC CneUAAHNTAMi.

Onachocb!PnHaJIyHHe npOHyBx DeTaJNe HEnBaJIHpUPOBaHHOM MOHTAKe HAnOpHbTpyoOpnpOBoMOKet IONHyTB BO BPEM 3KcIpyatauN. BByIbIAOuAaCn PoD BILCOHM DabNeHem KINIOCTb MoKET TpaBMIpObaT Bac！

6.4 PoiKJIuOeHne H cetn Tpy6oNpOBooD OTObI CHN3NTb BNpaun N Wymbl, HAcOC DOJHKHe NIOHIOUaTbC K CcETn Tpy6oNpOBooD npn NOMOUs 3laCTNuHbIX CoeINHInTeBbIX WJNAHOB.

B clyuae ctaunohapbIx Tpyb pehomeHdyetcmoHTnpoBaTb nepBbIe 2 Metpa C npDbeMOM, yTO6bl oBeCneNeHbMaHCmMaJIbHbI BblNyCKB03dyxa.

6.5 PoiKluoyeHne H cTeH 3/NTaHn

OnacHOCTb,06ycIOBJIeHHaH NcNoJIb3OBAHHem

3eKtpo60pOyOBAHnI! He HcNoJIb3yIte HaOC B cbIpBX NOMeueHNx N BblOJIHnTe CNeDyUOuHe yCLOBnA:

-Hacoc pa3pewaeTcra NOKIOUaTb TOIbKO K PO3eTKaM C 3aHTbIM KOHTaKTOM, KOToPbIE HaJIeKaUIM

6pa3OM yCTaHOBLeHbI, 3a3emLeHbI npoBepeHbI.
- HanpЯЖeHne cETn, yacToTa n пpeДoxpaHNTeЛьdoJIHbI COOTBcTCTBOBaTb TEXHueCKHm XapaKTePcNtHkAm.
-Питаяне arperaTa Должно OcyшесТВЯТьСя Урета 3auntHOrO OTKIOUChENy (Y3O) c YCTAHOBJIeHHbIM TOKOM yTeuHm MaKc.30 mA.
-3JIeKtpnueckne coeINHeHnnaPpeaetcOnyCKaTbB BODY,ONHdoJHHbI HaxOHTbcR 3aUHHeHHoOT 3aTOpJIeHHaHE.1nKcNpyTaunn BHe NOMEuHn OHNdoJHHbI 6blTb 3aUHHeHbI OT 6pbI3r.
- YdHnHTeBbIe Ka6eHn DOJHHbI NMeTb DOCTaTOUHOe NOpeHuOceEeHne JHJI. Ka6eHn DOJHHbI 6bITb NOHOCTbIO pa3MOtaHbIC 6apa6aHa.
- Heo6xOaHMo c06JIouDaTb HaunOHaJIbHbIe IpeJncaHnI MoHTaKu N yCtAHOBKe.

6.6 YcTaHOBbKa DaBJeHnNoDnHTN (ToIbKO HWW...)

Ipeep BBODOM B3HcNJIyatauHIO HAcTpoTe daBHeHne NOpNTKn.CM. rnaBy 9.4.

6.7 3aNoJIHeHHe HAcOca N BCacbIbAHne

BHHMaHHeI Prn KaKdOM HOBOM NOJIIOHcEHNI NIN pYteHHe BObl HEO6XoHMo 3aONJHb HAcO BDOi.

3KcnIyataaHACo6a 6e3 3anIOJIHeHnB OBOO
pa3pyuAeT Hacoc! Ira rapaHTNI
6ecnepe60HnP aBoTo bPeKoMeHdyem npi
npEBOM BBODe B 3KcNlYATAuTHO ObceNeHTb
DOCTaTOHbI 3a6Op BODbI nIPOIHO
ydaJIeHOB Bo3Dyxa h3 CNCTEmbI.

• BbINHTIpe360byIO npO6ky HAJIIBHOOTBepCTN(9)BMcTe C yNJIOTHEHHeM.
• MeIeHNo 3aJIiBaIte NcIcTyIO BDOy, nOka HAcOC He HAnJIoNITc.
• ChoBa 3aBHTInTe pe36bOByIO npO6Ky HANHBOTO OTBepCTN (9) BmECTe C VJNOTHHEHM.
• OTkpoIte HAnOpHbI Tpy6OpPObOg (NoBepHnTe BOOnpOBoDHy bKpaH INI cNOII,TObSb Ipn BCaCbBAHN MOr BByXoDmTb BO3dVx.
  -BkIouHe Hacoc (CM.7.)
• Ecnl BOda BbIXoNt PabHOMepHO, HACOC TOBOTK 3KcNpIyatau.

Yka3aHHe: BCacbIbAioUIO LInHIO 3aNoJHrTb He Tpe6yETc, TAK KAK HAcOC cAmOBcBaIOuHm. B 3aBHCIMOCTN OT dINHb I NnAmEtPa IINH MoHET npOITN HEKTOPOE BpEM Do TEX NOP, nOKa 6ydtcO3aHO Heo6xOJHMoe DaBJIeHne. ECnn Bbl XOTNTe COKpATITb BpEM BCACbBAHn, yctAOHbTE O6pTaHb Klanao HA BxOJHOM OTBerCTN BCACbIbAOUero UJHaHRn tAokHe 3aONHInTe BCacbIbAOUIO LInHIO.

7.3Kcnnyataun

BHMaHMe! HAcoc NInHNA BCaCbBAHnA DOJKNbI 6bTbN POnKlIOHeHb I 3aONJIHeHb rnaBy 6.).

BHHMaHHe! He donyckaetcpa6oTa hacocae 6e3 zanJHHe. HeoXoDmO nOCToRHOe Hmne DOCTaTOHOrO KOJIYeCTBa EkaHbAeMoN CpeDb (BOdy).

Pn6boknoBHe Hacoca HOpOdbIM TeOM Nnnp npeperpe3eJKTPOBnRATeTNECTema 3aunbToTbKIOUaET 3eKTOPOBnRATeTb.

7.1 NcnoB3OBAHne Hacoca Caoobb HACOC

(0603NaueHne npn6opa P...)

PpHnnpa60tbl: np6op pa6oTaet, noka OH BKIOUeH.

Onachocb!pa6ota hacoca npn 3akpbitom HapopHOM Tpy6onpoBOe He DOnIKHa npoJokBa 6Ooe 5MHytB pOHTBHOM Cnyae N3-3a nepeRpeBa BObl B Hacoce MOrTy BO3NHKHTb NOBpeHDeHn.
1. BCTaBbTe BnIKy B pO3eTKy.
2. ПИн Heo6xOuMocTH 3aONHHTe HAcOC - CM. rIaBy 6.7
3. BkIIOUeHne npbOpa: BkIOHTe npbOp C NOMOuBIO BkIOUaTeJI (1).
4. OTHpoIte HAnOpHbI Tpy6OpBOd (NOBepHmTe BOOpOBoDHyb KpaH NnI conNo).
5. Y6eHNTecb, yTO BODa nowla!
6. Nocle OKOHuaHnpaObTBI OTKIOUHTHe HAcOC: OTHIOUHTe npIbOp c NOMoBb BbIKIOUaTeJIa (1).

Hacocha TAHU

(06o3HaueHne npn6opa HWW...)

PnHnIpa6Obl: np60bKbIOaTeTcA,ecINB pe3yIbTaate paXoDa daJIeHHe BOIb IpaDeT HNKe nOpora BkIOuHEnH, nCHObBaBbIOaTeTc PnpDocTHNeHH nOpora OTKIOHEnH. KOTe HmEeT pe3INHObyIO dHaΦpArMy, HaxOaJyOcR NOd DaJIeHHe BO3dyxa ("DaJIeHHe NOpNTKn); 3TO NO3BOJRAET OcyIeCTBJIbTb 3a6Op He6oJIbXH KOJIHcTB BOIb, He 3aNyCah HAcOC.

1. BCTaBbTe BnIKy B pO3eTKy.
2. Пин Нeo6xOДМоCTH 3aIOnHIne HAcOC - CM. rIaBy 6.7
3. BhLIOUeHne npIbopa: BkIOHHTe npIbOp c nOMOu bBO BkIOUaTeJIa (1).
4. OTHPOIte HAnOpHbI Tpy6OpBoD (NOBepHnTe BOOpOBoDHy KpaH NII conNo).
5. Y6eHITecb, yTO BOa nOuHa! PnI6Op rOtOB K pa6Ote.
6. Пиббор Вьлочаетсь и Вьнлочаетсь по Инобховимост().

8. TexHnuechoe 6cbnyHnBaHne

Onachoctb!pepe npoBeeHem IIO6bIX pa60t Ha np60pe:

• N3BNEKNTe BUNKy n3 pO3eTKN.
• Y6eIHTScB,чTO npHbOp nOIOHIOUHOe K Hemy OobpyOBOaHne He HaxOJaTcNOD DaJIbEHNEM.
  Bce onncahhble 3decb paobToI no ToxecbnykBaHnIO n peMOHTOdoJIHHbByBbIOJIHTbC TOJbHO CneMaJIHCTAMI.

8.1 PeryIaRhoe texHuecHoe 06CnyHbAHne

• PpOBepbTe npHbOp n OTHOcHueeC K HEmy oBOpyDobAHnE, OCObeHNO 3JIeKTPnueCkne I HaxoDAIpeCn IOJ DaBHeHem DeTaN, Ha OTCytCTBnE NOBpeKdHn, pNp HE0xOAnMOCTOn OTaaine B peMOHT.
• PIOBOpBte BCaCbIbAoumH HAnOpHbI Tpy6OpBoDbHa RepeMTeuHocTb.
  -При снжкени мошости подуп порочтente Илл замени TE BCaSbIBAOUIС ПИьт И СмEHнbl ФИльТуюши ЗLEMERT (при Нeo6xOДIMOCTN)
• PpOBepbTe DaBHeHne NoNtKn KOTla (3) (B 3aBnCHMOCr OT KOMJIeKTaun), pRn Heo6OxIMocTn yBeInyBe TaBHeHne (Cm. rNaBy 9.4YBeInMeHne DaBHeHne NoNtKn).

8.2 Pn onacnoctn 3amep3aHn

BHHMaHHe!Mopo3(<4°C) npNBoiNT K IOBpeKdEHNIO yCTpOciCTBaI

PnHAnIeXHoCTe,TaK KaK B HNX NOCTOARHO CODepKHTcB ODA!

• Pn OnaChOCTn 3aMeP3aHnHr Heo6xOdmo pa3o6paTb npHbOp nPnHaJdIeXHoCTn H xpaHTb B 3aUnIeEHHom OT MOp03a MeCTe (CM. cJeDyUoi p43de).

8.3 DEmoHTaHxpaHeHne np6opa

• BbIKIOHHTe npH6Op. N3BJIeKHTe BNkky n3 pO3eTKN.
• OTKPOHTe HAnOpHbI Tpy6oNpOBoD (NOBepHITe BOIDIOPOBHOHy KpaH NcIIOLO), POINHOCTbO CnYCTNTe BOyD.

-NonHOCTbO ONOPOXHHTe HAcOC (2) N KOTen (3),
- BbIKpyTHe pe3b6OByIO npo6Ky BOIOcINBHOOTBepCTnA (5).
-ДемоHTypyTe BCacbIbAUOuN HAnOpHbI TpyBonpoBObI arperata.
-XpaHntbarpetcneyETBHe3aMepe3aOouem NOMeueHHMnH.5℃).

8.4 PerynnpOBb MaHOMeTpuechoro

BbHIOUOATEIaTOJIbKO HWW 3500/25G. IaIpeRyINPOBKnOCTaJIbHbIX MoDEJIe HWW o6paTHTeCB CepBnCHyO cnJh6y Metabo)

Onachoctb! Onachoctb npaKeHHN 3JIeKTPnueCkHM TKOM pH NKTaKTe C KJIeMMaMn NOKnIOUeHHMaHOMeTpueCkOro BbIKHOATEJ! BCKpBIAbMaHOmeTpueCkHb BbIKIOuHaTeJ N BbIIOHNb HAcTPOHN IMeOT npaBO TlBKO KBaINHcHIpOBaHNbIe 3JIeTpKN. MaHOmeTpueckn BblKNOvateJb HAcTPOEH Ha 3aBOJe Ha Camble paNCpoCTpaHEHbIe cΦepbl PnIMHeHHAMn, pN Heo6XoHmOCTH MOKHO OTpeYlnPoBaT erO CLeDyOuMm O6pa3OM.

PnmeHne:nytempeyInpOBKnrIabHO
HaHMnO npynHbI (11) n3MeHReTcAdbHeNe
BkIOUeHNu BYkIOUeHNu NOHTn
PnpONpuOHaHLHo, nepepa DaJIbeHNo OCTaETc
HENMeHHbIM.PnppeyInpOBKe nepepa daJIbeHN (12) n3MeHReTcTOJbKO DaJIbeHNe
BbIKIOHeHN, daJIbeHNe BkIOUeHNo OCTaETc
HENMeHHbIM.

1. BbIKHOHTb HAcOC, BbIHyTB BnIKy H3 pOeTKN N O6ecneHTb 3aunTy OT BKIOUeyHNA.
   C. 2487KpIiIKy MaHOMEtpyeCKOrO BbIKIOUoyATEJI.
   3.ИЗМЕHENHЯДавLEнHЯВКЮЧENHЯ:peryInpOBKa rIaBHOHaKIMHON npYHKINHbI(11)(paMep KIOHua 9MM,1 NOBOPOT npN6JI0,1-0,156ap).PpN 3TOM dABLHeHNEBbIKLOUHENI N3MeHReTC NOHTNpONOpDIOHAJbHO！
   4.ИЗмЕнгпдАБлENHЯ ВьКЛЮЧЕНЯ:perулірOBна nepenada ДдБЕнгHA（12）ДдБЕнгБВКЛIOЧЕНЯ OCTaETCRHeN3MENHbIM.
   5.YCTaHOBtHaMeCToKpBiUKy MaHOMETPnueCkOBO BbIhIOuATeJI N npOBepTb nPaBnBbHOCTb MOHTaJa.
2. BBeCTH HACOC B 3KcNJIyATAuHIO, npOBePrtb COOTBcTCTBNE 3aAHHIM 3HaYeHnM C NOMOuIb MAHOMeTpA (7).
   7.Пи Heo6xOaMOCTH NOBtOpNbIaRn1-6do NONYeHIN XeJaembIX 3HaHeHIn.
   BHHMaHHe!Yka3aHHeMaKcMaJIbHo
   DaJIbeHHe HAcOcHe DoJIxHO 6blTb
   npeBbIeHO. DaJIbeHHe BHKIOUeHn
   MAHometrpueChEHO BbIKIOuHaTeNl DOJIxHO 6blTb
   BcERda 60bIe DAbJIeHn NOJINTHK KOITNa MHN.
   Ha 0,2 6ap (1,5 6ap, cm. rnaBy 9.4). Bo
   366KaHHe Yactoro BHKIOUeHn HAcOcA CLeyET
   ycTaHABINBaTb MaKcMaJIbHbN IpePaad
   DaJIbeHn (HanpIMep, npEdBaPteLbHaR
   HaCTpoJa pnp6I.1,8 6ap).

9. Ipo6JIeMbI HHeHcPnPaBHOCTN

Onachoctb!

-Перед пrobовенем Лобьх рабт на пибODE:
-ИЗБЛЕКИТЕВИДКИУИЗ pO3eTKN
- YbEInTeCb, YTO npBOp nOIOKlnOeHHe K HEmyOBOpDobAHe He HaxOaTcNoD DaBJeHnEM.

9.1 Hacoc he pa6oTaet

CetBoe HnpanJHHe OTCyTCTByET.
IpoBepbTe nepeKIOHATEb BH/BlIKl, Kaebb, ceteByIO BnKy, po3eTKu npeDOxpaHITeB.
Ceteboe HapnpeHne cHnKOM Hn3Koe.
- IcnoIb3yIte ydHInHtJIbHbI KAb6Ib C DOCTaTOHbIM NOpEpeHbIM CeEHnEM XINJ.
- Dnuratelnb neperpet, cpaobotana 3aueta Dnuratela.

IocLeOxJaKeHnHaHCoC BkJIIOHTcCHOBaABTomatHeCN.
-ДяобсесченяdoctatoCHHOB BENTJUINI DEPHNTE BENTJUINHOHHyO ueb CBO6OHN.
- Co6IIOJaTe MaKcHMaJIbHyO TeMnepaTpyo nOaDaI.

PYCCHNru

3NeKtpoDbBnraTeIb rHyNT,He 3ayncKaeTcA. Tpe6yETcpeMOHT,CM.rJaby11.
Hacoc 3acopnncnn HncnpaBeH.

Pa36epnte n npOHCTnTe 3JIeKTPoDBrInaTeIb. IpoHCTnTe nn 3aMeHNTe dHfOy3Op. IpOCHCTnTe nn 3aMeHNTe paOooey KONEo.Cm.rnaBy 11.

-Давлиец Влини / Ha BXOde Bblwe Давлиец BKIOUeyHЯ HAcoca.

• PoiHIOUHTb peDyKTOp, cm. rnaBy 2.

9.2 Hacoc BcacbBaet HenpaBnIbHO nn pa6oTaet OeyHrPOMHO:

• HexBaTka BoDbI.

• Y6eHntecb, yTo HMeetcA DoCTaTOHbI 3anac BObl.

Hacoc HeoctatoHOn3aONHeN BDOJ. -CM.rnaBy6.7.

HerepmetnHa BcacbBaHoaJARINHA.

-06cneybeTepreMetnHocbBCacbIaoueJINHH,3aTAHHTpe3b6oBbIE COEINHEHNA.

CINUKOM60lbwABarBbICOTaBCaCbIBAHNA

• C6bIpaTe OpaHnueHn NO BbICote BCaCbBaHn.

• YcTaHOBnTe 6opatHbIM KlaanH,3aONHInTE BCacbIBAOUO LINHIO BOJOn.

ΦnIbTp BCaCbIBaHOseJIINHH (DOnOJIHNTeJIbHOe OobOpyOBoAHne)3acOpNlscr.

• PpoHCTHe nIIN, npn Heo6xOaMocTN, 3aMeHHTe.

• O6paTHbI KlaanAH (DOnONHHTeNbHoe 06OpydoBaHne) 3aBIOKINPOBaH.

• PpOuNCTHe Hn, npH Heo6XoHMoCTn, 3aMeHHTe.

• YteKa BObi MeKdy 3JeKTePbDnRaTepaIeMn HAcOCOM,TOpcEBoe yNtOHeHHe HerepeMeTuHO. (He3aHuTeBHaYteKa BOB1 (MaHC.30 Kaenb B DeHb) oycLobHeHa KOHCTpyKnei TopcEBOrO yNtOHeHna.

• 3aMeHnTe TopeBoe yIIOThHeHne. Cm rIaby 11.

Hacoc3acopnIcnnHeNcnpaBeH.

• CM. rnaBy 9.1.

9.3 DabJIeHne CImHKoM Hn3Koe HnH Hacoc pa6Otaet HenpepbIBHO (NoCToRHHoe BKNIOHeB/BkIIOHeHne):

BcacbibaQuaJINHnHeRpeMHTuHaNnY BbICota BCacbibaHnCmUKOM 60JIa.

-CM.rnaBy9.2.

Hacoc3acopnncnnHecnpabeh. -CM.rnaBy9.1.

• HWW....: HeBepHo HacTpoEH MaHOMeTpueckn IpeKJIIOUaTeIb.

3aMepbTe DaBnHeNBEHIOUeHIN BbHIOUeHIN pIn NOMOUs MAHOMeTpA (7) INPOBepBe 3HAeHIN (CM. rIaby 13. TexHMueChne XapakTepuCTHN. B clyuae Heo6XODIMOCTH NaCTPOIKN o6paTITcB KJIHeHTCHyO CnyK6y KomNaHH Metabo.CM. rIaby 11.

HWW....: Hacoc cpa6aTaBbAeT yKe npn He3NaHTeJIbHOM (OK.0,5I) 3a6ope BObl.

• PpOBepeTe, He cHnUkOM Hn H3Koe dABLeHeNe NOPTNH B KOTne. Pn HEOxOdMocT yBEnuHbTe daBJeHne.Cm. rnaBy 9.4.

• HWW...BODa TeuETn3 Bo3duHoro KlananaHa.

• Pe3nHOBaI DnaΦparMa B KOTne HeRepeMTeuHa; 3aMeHnte. Cm. rIaby 11.

9.4 YBeJIuYeHne JaBHeHn NoDnHTKn (TOJbHO HWW...)

EcnHacoc-c TeueHem BpeMeHH 3anyChaeTc4 DaKe npH He3HaHTeBbHom 3a6ope B0bl (Ok.0.5n), Heo6XoIMMo BOCCTaHOBtB KOTIE DaBHeNE NOHNTHK.

YkaaHne: daJIbHeHne NOJNTKn KOTNa (daJIbHeNc BO3dya) He n3MePReTcMaHOMeTpom (daJIbHeNc BObIy) (7).

1. N3BNEKNTe BUNKy H3 pO3eTKN.
2. OThpOHTe HAnOpHbTyPbOpOBoD (noBepHnTe BOOpOBoHDbKpaHnnI conNo), NOHIOCTbO CNYCTne BOy.
3. OTBnHTHe nlaCTNKOByIO KpbIbHcy Ha TopceBOB CTOpOHE KOITJa; 3a HeN HaxoDNTCA BO3dyuHb BEHTnHb.
4. NODCOEHNHTE BO3DyWHbH HACOC INN WJAHKOMNPecCOPa C HAKOHeHHKOM IJI

HakyaBaHHaMHnMaHOMETpKBO3dyuHOMy BEHTNIIO.

1. HanaHbaiTe do DocTHHeHnepDyCMToPHeHOro DaBHeHnNoDnHTKn (1,56ap;cm. rIaby 13. TexHneckhe xapahtepncn).
2. Choba nokloute hacoc n npobepbte ero Функшонрованe.

10. PpHaJdJIeHHoCTn

NcnoB3yTe ToIbKO opnHaJIbHbIe npHaJNeXHoCTN KOMNaHH Metabo.

NcnoIb3yIe ToIbKO TaKHe npHaJaIeKHOCTH, KOTOBIE OTBeeAOT TpeBOBaHnM nnapaMeTpam, nepeHNCJIeHHBM B daHHOM pyKOBoDCTBe NO 3KnLJyatauIN.

PonHbI accOpTmEHT npHaJNeJHoCTeM CM. HacaiTe www.metabo.com JUN B KaTanoRe.

11. PemOHT

AnacOCTb! PnO3B0DnTb peMOHT daHHOro arperata paapeaTaTc TOLko cneuHaNCTam-3IeKTKpHAM!

Дяремота порунmetabo obpaаиТecь в ретюньhoeпгддагпьсвMetabo. Adepeca m. H caite www.metabo.com.

Ia nepecbiHK: noHocbHO onOpOHnTe Hacoc H KOTe (CM. rnaBy 8.3).

IpeuHn 3anaChbix yacteM MoKHO 3aRpy3ntb c caTt a www.metabo.com.

12.3aunTa OKpyHauouei cpebl

C6bnoaTHe HaunohalbHbe npabnla 3KoIorueckn 6eOnachOytnln3auu n nepepa60THN OTCnyHNBWH INHCTpyMeHTOB, ynaKoAKn n pinnHaedxHcOteN.

YnakoobHbIe MaTePnaJIby YTHIN3NpyUOTcB COOTBECTBmC INX MapKnPOBKO CORNACHO KOMMyHaJIbHM pAbvAmL. DOnOHNHTeJIbHyIO HHΦOpMaUNHO MOxHO HaNTHa caTne www.metabo.comBa pa3dene «CepBNC»

ToIbKO dIraCTpaH EC: He BbIbpaCbIbAte 3JIeKTPONHCTpyMeHTbI BMEcTe C bIbTOBbIMN OTxOaAMn! COIlaCHO EBPONEChOH
DnpeTnBE 2012/19EU no OTxOaAM 3JIeKTPnueCHORIO n3JIeKTPONHOrO o6OpYoBaHN H ee npImHeHIno B pAmkax HaunOHaJIbHOro 3aKHOaTeAeNbCTBa bIbUne B yOnTp6bJeHN 3JIeKTPOnHCTpyMeHTbI NOJNeKaT pa3dEhOMy C6Obp Cy cEJIbNo Ix NocLeNyUoWe EKoIOnuHecKn 6BeonachNo nepePabOToH.

13. TexHueckne xapakTepeNCTHH

PorrcheHnK daHHbIM, npBBeHeHbIM Ha cTp.3. OctaBnem 3a co6oI npAbo Ha TexHueckne n3MeHeHn.
「pαnuecka xapaKTepeNCTHaHacoca (DnAarpMaM, Ctp. 3) noKa3bIbaeT erO npOn3BOiNTeBbHOCTb B 3aBNCIMoCTn OT Hanopa (Bbcota BCacbIbAHn0,5 M N BCacbIbaIOuŋ m IJahr1"
E =3JeHTPOHnKa/3aunTaOT cyxOro xoJa V =6paTHbI KIanah HA BCacBIAoUeMaTpy6ke (8) Hacocca
K = cTeBOI KaBebIb
U HapnpeHne cTeN
T = yactota
P1 =HOMHaJIbHaRA MOUHOCTb
Pstandby=pacxOdBpeKHMoeOKHdAHNA
HOMINHaJIbHbI IN TOK
C = pa6o7n KOHdeHcaTOp
n =HOMHHaIbHaI CKOpOCTb BpaueHHA
Fv,max =MaRC.npoa3BOAnTeJIbHOCTb
h,max =MaRC.BbICota noDaun
Fp.max =MaKc. daBneHne noDaun
p1 =MAHOMETPNUCHKNEpeKELIOUATELeB: DABNEHE BKNIOUEHNIA
p2 =MAHOMETPNUChNpeKHeJouCeTb: DaBJIeNEOtKIOUHeN
Sh.max =MaKC.BbICOTa BCacbBaHnA
Stemp =MaKc.TeMnepaTpyaNoDaH
Itemp =TemnepaTypa OKpykaUoce npdebl
S1 =Knaacc3aunTbIOTOpbl3r
S2 =Klaacc3aunTbI
S3 =Klaccn3OJIaIIN
Mp =MaTePnAaN KOpnyca Hacocca G= cebpiuHyTyr

MR =mATEpnaBalaHacoca

Mw =MaTePnA1 pa6Oyero K0leca Hacocca

Ds =BHTypeHnRApe3b6aBCacBIAoUcero naTpy6Ka

Dp =BHTpeHnHpe3b6a noDKIIOHEn HANHOPHOHNH

TV =eMKoCTb KOTJia

Tp,max =MaKc.ДaBHeHne B KOTNe

Tp.1 =aBHeHne NOdNTHK KOtla

A =pa3Mepbl:

LpA =ypOBeHb 3ByKOBOrO DaBHeHn

LWA =ypoBeHb 3ByKOBOM MOUHOCTN

KpA, KwA=HO3ΦΦHnueHNT norpeuHocTN

L_WA(G) = rapaHTnIOBApAHbIy yOpeBHe b3yKOB0MouHocN corlacho 2000/14/EG

IcnoJb3yIte CpeICTBa 3aunTbI opraHOB cnyxa!

EAC

HΦopmaunn nnoynateJr:

CepTHΦHKaT COOTBETCTBIA:

Ne TC RU C-DE.5JI08.B.01787, cpoK DeIeCTBna c 10.10.2018 no 09.10.2023 r., ByidaH opraHOM no septHnФИнKaUm npOduKuN «IBAHOBO-

CEPTNΦHAT» OCO «IbAhoBcKn ΦoHd
CepTnΦHauaun»; Adepoc(1op. n φaHT.): 153032,
Pocchckaa Φepeaun, IBaHObCKaObl., r.
IbAHOBO, yu. CtaHNOCTpONTeJe, d. 1; ten.
[phone]; E-mail: [e-mail]; ATTcTeTa
aKHeNTaun Ne RA.RU.11BLO8 ot 24.03.16

CTpanaH3rOToBJeHn:KHTaI

Pon3BOnTeIb: "Metabowerke GmbH",

Metaboallee 1, D-72622 Nuertingen, RepmaHnA

HmnpTeB Pocn:

OOO "MeTa6o EBypa3n

Pocn,127273,MoKBa

yI. Bepe3oBa aIner, I 5 a, cTp 7, oΦnc 106

ten:[phone]

Data npOn3BODCTBa 3aunHpObaHa B 10-3NaHOM cepHnHOM HOpeme IHCTyMeHTA, yKa3aHHOM Ha ero IwnbIKe. 1 aIuPpa Oo3NaHaayr oT, HapnMep «4» o6o3NaHaayeT, YTO n3JeIne npOn3BeHeHO B 2 rN 3 uNpbl Oo3NaHApOT HOpem Mecaua B rOy npOn3BODCTBa, HapnMep «05» -MaJ

CpOK CnyK6bl N3dEInna CoCTaBnReT 7 ne.T.He peKOMEHdyetcK KcNlNyatauIN NO HCTeUeHN5 5 neXpaHEnrC DaTbI N3rTOBLeHnE 6e3 npedBaPntelbHnI npOBePK (Daty N3rTOBLeHnC M. Ha 3tNkETHe).

OprihaIbHa IIncTpyKciJ 3 ekCnLyataci

1.Дeнларuaи npo BiDIOBIDHicTh

3i BcIEO BiNObIaIbHicTIO 3aBIAEMO: IHaHacOH/ NObyTOBI HAcOHCI CTaHJIABTOMaTHHI HAcOH CI tAHUII 3 iJeHTnPHiKaIeIO 3a TNIOM I HOMePOM MoJeni *1) BiNObIaIOY BCIM IOHUM nIOJHOHNM IMpeHTHB *2) i Hopm *3).TexHiHy DOKyMeHtauIO dIra *4)-DIN. H CTOp.3.

2.BnKOpNCTaHHa npH3HaueHHaM

Lepnpctpi npn3HaueHm dIy nOaHn yHCToI BODn pnp 6OcLyOBvBAHNb HdyNHKB i caDobNX dIINHOK, dIy DOuSyBAHH a3pOvBAHH, JCK CBEPdIOBnHHn HACOC, HACOC dNPEPONMnyBAHH DooBHX I TexHiHNNX BO, dIy BiIDomNyBaHH BoN 3 baceHNB, CTABKIB i pe3epByapB.

Hacoc He po3paxoBAHn Ha TaKi yMOBn:

• Tpmbana ekcnnyataui

• npomnclobe afo npopeciHne BnKOpNCtAHH

Hacoc He npn3NaueHm IdaI nodaI TaKnx pIDH:

• NITHA BODA

-xapOBI npOdyKTn

• COLOHA BODA

• Bn6yXoHe6e3neHry, rOpUci, arpeCnBHi a60 He6e3neHHy dIa 3doPob'MaTePiaJN (HanpKnAd, XIMiKAtN)

-pidHH3 TempepatypoBnue 35°C

• BODa 3 BMICTOM nicky n a6pa3nBHi pIDHHI

• xIopBMiCiPi pDHHn (HaNP, BODa 3 baceHy)

Hacoc He npn3haeHn dIy nIbHueHO TnCHy: npnPiNIOUeHHi HACoCdo TpyboPObOy, 103hAXoOnTbCnPi TnCKOM, NOTpIbHn NOpEpeDhbO BKNIOHcpeDyKTOp. MAChCMaJIbHn TnCK B CNTeMI He NOBHeH nepeBnUyBaTH BkA3aHm MAChMaJIbHn TnCK HAcocA. CnIb BPaxOByBaTH, 10BxIDHn TnCK CyMyETbC3 TnCKOM BIMKHeHHa HacocA!

LcI npnlaH He NOBHe HBNOPNCOTByBaTncra OOCaMn (BKNIOUaOuN DItei),KHI He CNPOMOXH BNOPATNC3 HIM B CNY CBOIX 6MOMeHEHX fHINX, NCNXIHHX aO CEHCOPHX MOHJBOCTE, A TAKOH B CNY BIcCyTHOCTI 3HAH Ta/aOdocBiyD.

3abopohraTcba camobIbhe BHeceHHaMIBKOHCTpykuHacocca，aTAKOHBnOKPcTAHNDEtaJIe，IO He npoiWNBnpo6yBaHHi I HeIOZbOJBEHIO 3aCTOCyBaHHaBnPOOBHHOM.

Byb-He BHKOpNCTaHH HACoA 3 NopyWeHHAM
pAbnH OIO eKNYataJIi BBXaeTbcS
BHKOpNTAHmHE 3a NoPn3HaueHHM,Ke ME MOKE
pN3BeCTn DO HepepeD6aYeHNx 36ntkIB Ta
TPaBM! 3a NowKOdKHeHH, BKNlHkHi
eKcNYataJIeO He 3a np3HaueHHM,Hece
BiNDOBIAIbHIcTb BHKIOUHO KOpCtYBaH.

Heo6xioHO DoTpmyBaTncb 3aRaJIbHOnpHnHrTnx npabIN 3anaOirAHnHEuacNHm BInpaIqXAM, a TAKoN npabIN TehKIn 6e3neKn, pInBeDeHNX B ciin hctpyuui.

3. 3araIbHI npabHla TexHiN 6e3neHn

ДяBawoI BlaChoi 6e3neKи I 3axNCTy
ПИЛАДУ BID YUKOДСЕНБ
ДOTРМYntecB BkA3IBOK, LO BIDMCHENI
LIM CUMBOLO!

DNEPEDHHEHH-3JHIO 3NHKEHH 3NHYOPTMAHNAI TJIeCHNX yHKoKHeHb OHHTAte IIOHCTpyHIO3

ekcnnyataa.

NONEPEDHEHH - O3haomtec3 Ycima npabnam Ta Bha3iBkAm 3 TexHNI 6e3neH. HeotpMaHn npaBnTa BkA3iBOK 3 TexHNI 6e3NeK MoHe Pn3BecTu DO yApdyeEHTPNHm CTpyMOM, NoKeKi Ta/a60 TAKHX TiNECHX YsKOJHeHb.

36epiraIte npabnla Ta Bha3iBHN 3 TexHIHb 6e3neH ymaBHyTHbO R BHOpNCtAHN. IpepeabaiTe baw hacoc Tlbn pa3om 3 uMmDOKyHMeHTAMn.

Inphiopmaqno3haeHaBiiinCTpyK2i3 eKJIyatauHAcTynHM YINOM:

He6e3neHa! PonepeJxHnHn npo He6e3neKy TpAByMaHHa a60 uKoDn dIa DOBkIIJIa.

He6e3neka ypaKeHHN eIeKtpnHMM cTpyMOM! IhonepeJKeHH npo He6e3neKy mByaHH 360ky eIeKtpnH.

Ybara!PonepeHKeHH npo MOKJIbIMi MaTepiAlbHi 36nTkn.

4. CneuaJIbHi npabHla texhiKn 6e3neHH

He Do3BOJAEbCByNKOpNCTaHHaHocOaDiTbMnIPiDJIITkAmn,a TaKoXOCo6aMn,IO He O3HaNoMnJInc3 KepiBHNCTBOM 3 ekCnIyataui.

CniKnyTe 3a DiTbMn, 06 BOHn He BnKOpNCTOBvBaI npIlaD Ira irop.

PnBHKOpNCaHHi y CTaBKax Tpe6aDToTpmyBaTncnnoJIOKeHb CtaHapTy DIN VDE 0100-702, -738.

ПидкюаTe npILAДdo
eIeKTpOmepeKi uepe3 npncTpI
3axnCHoro BiKJIuOeHn（ПЗВ）3
MaKcIMaJIbHnM CtpymOM BHTOKy
30MA.

HeD03BOJRAETbCBNIKOPNCaHHHaocca,AKUoYBODI3HaxOJaTBcRJIIOH.

PnPiKluoyehHi Do NObyTOBoi
CNCTeMI BODOnocTaayHn
NOBHHI BNKOHyBaTnC
NIOJKeHHaKOHy BiHOcHO
BOOOnocTaayHn i
BOOIBBeDEHHa TaHOx
NIOJKeHHa DIN 1988.

PnEcknyatauiHacocib I HanipnHexpe3epByapib(3aJIeJHo BID KOMNLeKTAuii) icHyIOTb HAcTyHi 3aIIuKOBi He6e3neKn, RKi He MoKHa NOBHCtU yCyHyTN, HabiTb BKNBUn HaJIeKHi 3axOJn 6e3neKn.

4.1 He6e3neHa, NOB'3aHa 3 BnINBOM HABKOLHbOro cepedobuca!

He 3aIinwaIte Hacoc nID doouem. He BnKOpncTOByIte HACOC y BOIOrnx i CnpNx npMiuJeHHx.

He BnKOpncToBvIte Hacoc y Bn6yXoHBe6e3neuHx npimiueHHa6o n6n3y ropouhns pDInh Ta ra3iB!

4.2 He6e3neKa, NOB'3aHa 3 rapraOIO BOdoIO!

He6e3neka! BcTaHOBIb 3BOPOTHNI KJIaNaH Ha BCMOHTyBaJIbHOMy NaTpPy6Hy (8), 06 3aIO6IrTH 3BOPOTHOMy BiTOHY BOHN Y BCMOKTByBaJIbHi JIni. Ie Do3BOINr 3MeHUnTI NaCTynHI He6e3neK:

Tapya Boda MOHe Ipn3BecTn Do
NoWKoJKeHHa60
HerepMeTuHocTi Hacoca i
3'EDHyBaJIbHnx Tpy6OpBoDiB,
BHacIIOK YOro rapya Boda
MOHe NOCTyNaTH Ha3OBHi.
He6e3neKa onIKiB!

Hacocn 3 no3haueHHm HWW....
Rkso TnCK BiKJIIOUeHH
MaHOMEtpyHoro BVIMKaHa He
DOcRAeTbcB HAcIIOK
HEKOpeKTHnx HaJauSTyBaHb a6o
DeΦeKTy camOro
MaHOMEtpyHoro BVIMKaHa,
BOda B pe3yNbTaTI BHyTp1iHhBoi
CIPKylaui ycepeDnHi npncTpoIO
MOHe HarpiBaTnCra.

Hacocn 3 no3haueHHm P...: TpnbaiicTb eKcnnyaTauii Hacoc a npn 3akpnTomy HanipHomy Tpy6oPBODi He NOBnHa nepeBnuuYbaTu 5 XBnInn.Boa, uNPKUIOUa ycepeDnHi Hacoca, HarpiBaCTbcra.

Y pa3i HecnpaBHOCT BiE'EnHaHTe
Hacoc BiE eIeKtpnHoi MepeXi i
daIte Nomy oxoOnHyTN. Peep
NOBTOPHM BBeDEHHM B
EeCNyatauIO DopyuITb faxIBcM
peBipNTn CnpaBHiCTb
fynkuioHyBaHN npnaNy.

4.3 He6e3neHa, NOB'ra3aHa 3 eIeKtpnko!

He HanpaBnIe CtpymHb BOni 6e3nocepRedNo Ha Hacoc a6o Ha iHsi eJeKTPnHi KOMNOHEHTN! He6e3neKa DnJnTTT, NOB'ra3aHa 3 UpaKeHHm eJeKTPnHm Ctpymom!

He donyckaetbcnpoBedeHnro pObit 3 MOHTaKy i TexHiuHoro o6cIyROByBaHHra Hacoca, nIiKIOueHOro do eJeKtpnHoiMepeKi.

He 6epitbcra 3a MepeKeBy BnIky BOLOrHM pyKaMNI 3aBKnTgHiTb 3a WTeNCEJIbHy BnIKy,a He 3a Ka6eJIb.

He donyckaTe neperHaHHa3aTnCKaHHa,po3TayBaHHa60Ha3dy Ha Ka6eJIb JINBLeHHa I NOOBKaBbHn Ka6eJIb;6peKITb BiD KOHTaKTy 3ROCTpIMN KpOMKaMn, OJNBiI BUCOKHX TEMepaTyp.

4.4 He6e3neHa BnacIioK DeΦeKTIB a6o HecnpaBHOCTeHacoca!

IpeBipraHte Hacoc,OCO6nBO Kaebb JNWBHeHH, WTeKepi

YKPAIHcBAuk

eNeKTpNHi DeTani Ha HaaBHCtbyWKoJKeHb Neped KOxHnBMKnUoyehnM. He6e3neKa IJnHNTI, NOB'raHa 3 ypaKeHHaMeJeKTpNcHm cTpymOM!

IOBTOPHe BnKOpNCaHn HnOxKOJKeHOro HaocCaOnyCKaETbcTtIbKn NiCJIpeMOHTy KBaJIiΦIKOBaHmNfaxIBaMn.

HeHAMaraTecra camocTiHOBiDpeMOHTyBaTH HAcOC! PemOHTHacociB i HanipHnx pe3epByapib(3aJIeKHO BiKOMnJIeKTAciI)do3BOJRAETbCra TIIbKNKbaIΦIKOBaHmN φaxIBzAymN.

YBara!ДЯTORO，06
yHnKHyTN3bNTkIBBIDBOHN,
HaPnKlaJad3aTOnJIeHHra
IpMIiUeHb,BNKlnKaHORO
deΦeKTamna6o
HeCnpaBHOCTaMnHaCOca:

-3anlaHynteHaJIeKHi 3axOdi 6e3neHn, HApnKlaIa aBapiny CunHaI3aIIO a6o npnMaJIbHni pe3epByap 3ФyHKciEIO KOHTpOJIIO

Bnpo6Hn He Hece BiIDNoBIaIbHiCTb 3a 36HTN, BHKInKaHI HaCTyHHMn DiAMn:

-BNKOpNCtAHHHaHCoCa He 3a npn3HaueHHM;

• nepeBaHTaKeHHBHaCJIIOK 6e3nepepBHOIpo60Tu;

-ekcnnyataaia 6036epirahnHaHacocaa63axncty BiMop0sy;

-camocTInHe BHeceHHa 3MiH B KOHCTpyKciIO Hacoca.PeMOHT eKeTPOiHcTpymeHTy NOBHeH 3diCHIOBaTnCra TIIbKn KbaJIiΦIKOBaHmN φaxIBqMaMneKeTpknAmn!

-BNKOpNCtAHH3aNaCHHX qactnH,He nepeBipeHnx i He 3aTBePdKeHx BnPo6HkOM;

-BHKOpNCTaHHHeHnpuHaTHOROMHTaXHOrO MaTepiAly (apMaTpya,3'EdHyBaIbHi Tpy6oPBoDoToIo).

HaJIeKHi MaTepiAn IJn MOHTaKHnx pO6iT:

-BNITpmyIOTb TnCK (MiH.106ap)

Pn BnKOpNCaHHi
yHIBePCaJIbHNx NOBOPOTHX
(6aNoHETHNX) MyΦT dJa HAdiHoI
rIdpoIsOlauci II NobHHI
BnKOpNCTOByBaTnCra TlIbKn
BapiaHTN BnKOHaHHa3
IDoDaTKOBnM PrNTnCKHM
KJIbUcEM.

5.OrnA

Hb. cTOp. 2. MaJIOHN MOHyt b CnyHHTN pRHKaIOM DJI BCIX MoDEJIeI.

1 NepemKau YBIMK/BIMK

2Hacoc
3 HanipnpeepByap (peepByap)
4 NobitprnH Klaanah dny TnCKy nDxHnBHeHH

5 Pi3b60Ba npo6Ka BOO3INHBHO OTBOPy

6 MaHOMeTpNHH BmHKaay

7 MaHOMeTp (TnCK BODN)

8BCMOKtyBaIbHn naTpby60

9 Pi3b6Ba npo6Ka haJIINBHO O TbOpy

10 Hanipn nnatpy6o

11 MaHOMeTpNHyBmHKaaypeyIIOBaHH TnCKy VBIMKHeHHry BIMKHeHH
12 MaHOMeTpnuHHN BmHKaU -peyIIOBaHHn nepenady TnCKy

*3aJIeKHO BID KOMnJIeKToaJI

6. BBeDeHnB EeknIyatauio

6.1 BCTaHOBJEHH

Pnncpti cnid BCTaHOBIOBaTHrop3oHTaIbHo, B cyxomy (MaKc.BoIorictb nobITpr 80%),do6pe npOBtPOBAHOMy, aXnueHEOMy Bi dAtmocepHnx BnINbMicui. Heo6XiHO 3a6e3neuHTn HadiHCTb CTNIKCTb TAOH pNp MaKcIMaNBOMy HanOBHeHHPiNCPTPO BOIO. BeHTnJIaHI OTBOPN MAOTb BYKn BiDkpNTI N 3axuHi BID notpannnHn 6pyd. BiDctanb Do CTIH Ta iHUNX npedmetB-He Me nue 5 cm 3axnCT BiD MOpO3y -INB. po3dn 8.2.

LIO6 yHNUKHTy BIBpaui, HACOC He Ma6 6yTN JOKCTHO PNIRBHHENH, BIH NOBHeH BCTAOHIOBATCN Ha eJNACTNHY nIHKnAaNDKY.

PnEckpnyatau y cTaBkax npncTpiMae 6yTN BCTaHOBJIeHm 3ypaxyBaHHm MOJINBOrO NiIMy pIBH BOi i 3axNueHn BiD naIHn.

Heo6xIDHO TaKOH BpaxOByBaTN DoaTKOBI BmOri, No3HaueHb 3aKoHOdaBvNx aKTax.

6.2 PIIKHOUeHHB CMOKHTyBaIbHoiJIiHi

Ybarla!BCMOKHTyBaJIbHa NIIHIA M6 ByTN 3MOHTOBAHa TaK,IOB BOHA He YINHnla HIAKOI MEXAHIHOI DI abo Hanpyr Ha HAcoc.

Ybara! BnOOPMCTOByTe npHMaIbHnI 0iBtP,io63axHCTHTn Hacoc BiNicky i 3a6pyDHeHb.

Ybara！UoBBoaHeBntiKaana3 BIKJIOueHOHACOa，06OB'3KOB0
NotpiEben3BOPOTHNIKLANAH.MnpeKOMeHyEmo BCTAHOBJEHHN 3BOPOTHNXKLANAHIBHaBXIDHOMy OTBOPiBCMOKByBaIbHORO WlanHraI Ha BCMOKTYBaIbHOMy naTpy6Ky（8）Hacocca.
3aneKHOBIIdMoeJI，3BOPOTHNIKLANAHMOKe 6ByTNBKEBCTaHOBeHn（INB.p03d13. TexHHIxapAKTePNCHTKN）

Yci pi3b60bi 3'εdHaHH MaOToB 6yTn
repMeTH3oBAH3a DOnOMTOO YuJIiNbHOBAIbHo
ctPIuN (10-15 o6ePTAHb y HAnpMcyPi3b6).
Yepe3 HerepeMeTuHi Micu BIDoyBaETBCR
PiDCMOK TYBAHNA NOBITPRA, BHACIIOK YORO
3HNKcTBcA BOO pINNIHReTBCB CMOK TYBAHNA
BOIN.

BHytpiHmI qIaMeTp BcMOHTyBaIbHOI liHII NOBHEN ChIkaTn He MeuHne 1 (25 MM); BOHA Mae ByTN CTiHaK Do 3aJAMyBaHb I BaHYMy.

BCMOKryBaIbHaJIiHaMa6ByTHNaCTINbKn KOPOTKOHO, HAcIKJIbHnCe MOXJIbBO, OCKIIbHN 3I 36JIbUeHHN MOBKHNIJIH II 3MeHJWYETCBN NOTyHKHtB NOAHHN.

BCMOHTyBaIbHaJIHIO NobHHaNocTIIHO nIDHIMATNCu HANPmKHy DO HAcoca, 106 He OONYCTNTBHNKHeHNEHNOBITPNHX KMIeHb.

Heo6xioHO 3a6e3neHTn DoCTaThe NiBeDeHHA BOi, a KIEcB BCMOKTYBaIbHOJIiHII NOBIHEH 3aBHKn 3haxOJNTncy y Boi. CnIKkyTe 3a TmH, 0o6 BCMOKTYBaIbHa LiHlE He 3haxOJNAC Ha DHI, 0o6 nicok abo 6pyd He NotpanHn BCEpOHy. 3 ciHo MeTOIO MOKHa CHOPICTyBAHtnc PIAbaOHIM BOD3aBOPOM, 0o BXoDnTb Do npelniKy npnilaJa.

6.3ПИДКИLOЧЕНHAHINPHOROTpy6oNPOBODY

Uo6 3Hn3HTBpatTN TCKy B pezylbTaTI Teptra, BHyTpiuHi diametp HanipHOI NOBITPRAHOI JIniMae

6yTHHe MeHHe 1" (25 MM).PnBHKOpncTaHHI MeHuxDiAMetPi, HapnpNAd, 1/2"MOxHyb 6yTH np6bnm Pn eKcnPyatai, nob'3aHi 3 NoraHM BvdaeneHHM Nobitpi.

YBaRa! HanipHn Tpy6oBpOiMa 6yTu3MOHTOBaHn Ta, o6 Bi He uHHB HIAKoi MexaHIOI di a60 Hanpyu Ha HAcoc.

Yci pi3b60bi 3'edHaHH MaIOb 6yTu
reMpTeN3OBAHI 3aDonOMOIO yUJIbHIOBaIbHOi
ctPiHK, uo6 3anoBITn BNTOKy Bodn (10-15
0epeTaHb y HapamHy pi3b6u).

Yci Detani HanipHoro Tybo npoBdy nobHHI BnTPhyBaTH TCH; IX MOHTa 3dijCHOeTbcra KBaIIΦIOBAHmD faxIBzRM.

He6e3neKa! HerepeMeTuHi detani i HEKbaJIoiKOBaHm MOHTAK MOHYb np3BeCTn Do pO3pNBy HanipHO rTy6oPBOPOy NiD qac EChNlayatau..PiDiHa, 0U BnPbAebcR niD BnCOHM THcHOM, MoKe TpaBMyBaTH Bac!

6.4 PIIKIOUeHHoMepexi Tpy6oNpOBoDIB

Ioo3Hn3HTN Biopaui i Wymn, Hacoc Tpe6a niiHIOUATn DO MEpEXI TybompOBd 3a DONOMORO EAnactHHX 3'EDyBaIbHNx IuaHrib. CtaiohApHi tybu peKoMeOHyETcR moHTyBatn nepi2 MeTpi 3 NiJIOMOM, uoo3a6e3neuHTn MAHCIMAbHe BIDANeHn NOBITpr.

6.5ПинlueyHЯdoeIeKtpomepexi

He6e3neKa, NOB'3aHa 3 eIeKtpnKOIO! He BnKOpNCTOByTe HAcOC y BOJoromy cepedOBuNi O6OB'3KoBO BVKnOHyTe HaCTyNHi yMOBN:

-Hacocdo3BOJAEbCn iHIOUaTN TINbKN DO PO3eTOK i3 3axNCHM KOHTaKTOM, kHaJIeHHNm YINHom BCTaHOBJeHi, 3a3emJIeHI npeBipehi.

• Hanpyra MepeKi, Yactota i 3aNo6iKHNK NOBHHI BiNOBiDaTI TEXHcHIM XapaKTePNCtHKam HacOca.

-ПдкюаиTe npnilaДdo eIeKTpOmepeKi uepe3 npicTpii 3axnchoro BiKlHueHHa (P3B) 3 MaKcHMaJIbHIM CTpyMOM BHTOKy 30 mA.

• EneKtpnHi 3'EdHaHHa3abOpHHeTbc8O npyckatu yBOy, BOHn NOBHHi3haxoHTncBnue MoJInBOrOPiNOMpyIBHbOu. PidvacEcnnyataui no3aPnMIeEHnMn BOH MaOTb6TyN 3axnuehi BiD 6pnzOK.

Ipeep BBeEeHHB E KcNpyaTaio Tpe6a BCTAHOBHTN TNC iDxHNBHeHH. NIB. po3in 9.4.

6.7 3anOBHeHHHaHocOa I BCMOKTyBaHHa

Ybara!PnKoXHOMyHOBOMy nIHKUOeHHI a60 npn BHTOKY BOiN Heo6xJH0 3anOBHIbATn HAcOC BDOIO. EKcIyatauia Hacoca 6e3 3anOBHeHHBOdoO pyHyE hAcoc! Dra rapaHTI 6e3nepe6iHoi pOboTn

peKOMeHny6MO npn nepwOmy BBeDeEHI B EKnNyatauio 3a6e3neUHTN DocTAHI 3a6ip BOIN IJIOBHORO BHaJaleHnnoBtprj 3CNCTEMN.

Bunbnttbpi360by np6ky HaHnBHoro OTbopy (9)pa3OM 3yuiiIbHeHHaM.
-Повьно ЗаловiteЧмctу Body,поки На coc He HANOBHNTCB.
-3HOBy 3aBHTITb pi3b6Oby np06ky HaJIINBHOROTBOPY (9) pa3OM 3 yUINbHeHHM.
BIDKpnIte HanjinHnTYpOBoPiD (NoepHITb BOIOnpoBIDHn KpaH aBO coIIIO), 06 pRBCMOHTyBaHI BIXOAnIO NOIBTPI.
- YbIMKHiTb HAcOC (INB. po3di7.).
-HKUO BODA BNXOUNTB PIBHOMIPHO, HACOC ROTOBM DO EKCNyataJI.

Bka3iBa: BCMOKTyBaIbHy LiHiO 3aONBHObAHT He Tpe6a, OcIbHn HaocC 6 CamOBKOTyBaIbHnM. 3aJIeJHO BID IOBKnHn I diametpy LiHm MoKe npOnI DeKeHH QAC, NOKT NCK DOsRHe HEo6xHOrO pIBHa. RkIoO BN XOHTe CKOpOTn Hac BCMOK TYBaHH, BCTaHOBI TB OOPTHN KlanAH NaXIDHomY OTBopi BCMOKTyBaIbHoro WJaHaIg I TaKOH 3aONBHIT BCMOKTyBaIbHy LiHiO.

7. Eknnyatauia

6).

Ybara! He donyckaetbca po6ota hacoca 6e3 BODn. Hacoc 3abKmae 6ytu

OBHEHIM pIDHIOO (BODOIO) y DOCTaTHbOMy 131.

Pn6bOyBaHHi HAcOa YKxOpjDnHM TlOM a60 npnpeperPiBHa eJeKToPDBrHyHa CnCTema 3axNCTY BIDKnIOe eJeKToPDBrYNr.

7.1 BnKOpNCTaHHHaHacOca

CaoBn Hacoc

(No3naeHH npHnady P...)

PpHnnpo60Tn: Hacoc npaue,doKn BIn yBIMKHeHn.

He6e3neKa! npn 3aHrTOMy HanipHOMy TpybONpOBoDi Haoc He NoBHHen

npaobatn 61bIbue 5XbnHIn,HaKwpe3 neperpBaHHB OBN Haoc MoKe 6yTN nowkDkeHN.

1. BCTaBTe BnIky B po3eTky.
2. B pa3i noTpe6n 3aNoBHt b Hacoc -DIN. po3dIn 6.7.
3. YbIMKHeHH npHnaDy:
   yBIMKHiTb PnIa3a DOnOMoIO NepEMHKaHa (1).
4. Bɪdɪkɒpɪnɪte HɑnɪpHɪnɪ Tpɪyɒbɒpɒbɪd (NobepHɪt b Bɔdɒpɒbɪdʒn Kpʌn aʊc oʊ cɒnlo).
5. NpekeKaHTeC, 0o Boga niWla!
   6.ПИСЯЗАКIHHEHня рОБТУВIMKHIb HAcOC: BIMKHIb II pIINaD 3a DOnOMOROI NpeMnKaHa (1).

Hacocha ctaHua

(No3HaueHn npHnady HWW...

PpHnH npOToH: npHaad BMNkaeTbC8, RaKIO B pe3yIbTaTIaBOPy BOIN TNC NaJaE HNNue nopORY yBIMKHHeH, i3HOBY BMNkaeTbC8 pNp DOcRAHHI NOPY BIKHIOUChEH.

P3eepByapP3eepByap OCHaueHnI rMoBnM CnIbΦOHOM,IOCTABJIεTcB 3 aBoy3 BCTaHOJIeHMM NOIBITpRnHM TNCOM ("TNCK NiDIXNBLHeHH"); CE ΜOZBORe 3dIiCHIOBATn 3aBip HeBeINHX KIIbKoCTeB BoN, He 3aNyCKaOHy HAcOC.

1.BcTaBTe BnIky Bpo3eTky.
2. B pāzī nötpēb 3aŋoBhɪt b hacoc -dɪn. pɔzdi n 6.7.
3. YbIMKHeHH npHnaDy:
YBIMKHTIb pInJaI 3a DOnOMOIO NOpeMnKaHa(1).
4. BvdKnHte HanipnTpy6oPbID (noBepHtB BODOpOBiHN Kpan aOo coNIO).
5. NpeekohaiTeec, 0o Boda niuHa! PnnaI rtoBn do po6oTH.
6.Пилад BMнкаETbCЯ N BmMnKaETbCЯ,КOLIN ue notpi6Ho.

8. Texhiye 06cIyroByBaHHa

He6e3neHa!Ipeed6ydb-yaHmnpo6oTaMn 3 npnaam:

-BNTARHIbWTeNCeBHy BnIKy 3 pO3eTKN.
- PpehoHaTecra, 10 npnla i nkiKIOuehe npnaI3HaxOaTbcr He nID TNCOM.

• Otncahi dani p6oTo3 texHIOHO 06cIyROBaBHn i peMOHTy do3BOJAEtbcB BOKHYBaTH TlBKn faxiBAM.

8.1 Perylarphe texhichne 06clyroByaHHA

• Ipebeipte npnla i BIDNOBIDne npnla, OcObIbO eNEKTPNHI DeTani Ta KOMHOHTN Ni TCHKOM HA BiCyTHiBtBuHODHeHb, B pasi NOTpebn BiDaaTe B pemOH.
• NepeBipTe BCMOKTyBaIbHn i HanipHn
  Tpy60npoBOnHa repMeTHHicTh.
• Pn3HKeHHI npOyKTHBHOCTi HAcoc a npOHTb abo 3aMihTb nPiMaBHHi fJIbTp i fJIbTpVbaBHn EneMeHT (B pasi NTpe6n).
  IpepeipTe TnCK NIKBNEHn peepByapa (3) 1eNHO BID KOMNIIeKTAii),Y BnAHy Heo6xIHocTi 36IbUneT (DVB. po3i9 9.4 36IbUeHHN TnCKy NiJKNBHeHHa.

8.2 Pn He6e3neci 3aMeP3aHH

YbaralMop03(<4°C)pyHyeHacoci npIaIaI,OCKJIbKBOHOIOCTIHO MICTATb BOy!
- Pn He6e3nei 3amep3aHna Heo6xidno
pos3ipatn Hacc0i npnaadj 36epiratn B
3axnueHOMy BiM MOpO3y MiCi (DVB. Hactynnn
po3di).

8.3 DEMOHTaH i 36epirAHnCtahui

-BMHHItb IHCTpymeHT. BnTARHITb wTeNceIbHy BNKHY 3 pOeTKI.
-BidkpniTe HanipnH TpyoBpOIB (noBepHtB BOIOpOBiDn H kpaH aOo conIIO), NOBHCIO cnycITb BODy.
-ПовсгTO BnnpoKHTb Hacoc (2)ipesepeByap(3)，DЯцboro:
BUNBHITb pi3b6OBy npo6ky BOIO3JIINBHOOTBOPY (5).
- DEMOHyTe BCMOKTyBaIbHn I HanipHn
tpybonpoBoAn arperaTy.
-36epiratn arperat cr Nb He3aempe3aoOmy npimuHenni (He MeHne 5°C).

8.4 PeryIIOBaHH MaHOMeTpHoro BIMnHa（TIlbH HW 3500/25 G.DIpe rpyIIOBaHH iHmX MoJeH HW 3BepHtBC B cepBicHy Metabo)

He63eHa! He63eHa ypaHexHH eEKeTpuHMM CTpyMOM pN KOtAKTI 3 KJIeAMn NIKKIOeHHa MAHOmETpuHOro BIMNKaHa! PO6bHTNa HaaTyBaHHa MaOt b P8 TIIbKn KBaIipKObaHJI eEKeTPhK.

MaHOMeTpNHyBIMnHaHalaTobAHn Ha 3aBoDi Ha HainoINpeHIiCfepn 3actocyBaHH, y pa3i Heo6XiHocti MoKHa BIDperyIIObATn Ioro TAHM YIHOM.

BkasibKa: npn peryIIOBaHHI rOBoHOH HATNCHHOI pyKHHN (11) 3MHIoETbCn Ttck YBMIXEHHe N BIMKHEHHA MJIe NpONOpuHIO, npeNaT TtCKy 3aIIWaeTbCn He3MIHHN. Pn peryIIOBaHHI nepenady TtCKY (12) 3MlHOEtbc TaIbKn TtCK BIMKHeHH, Ttck YBMIXEHHe 3aJIiWaeTbCn He3MIHHN.

1. BIMKHYTN HACOC, BNIHARTH BINHKY 3 PO3eTKN 3a6e3neHTN 3AXICTBID YBMKHeHHR.
2. 3HATN KPNK Ky MaHOMETPNUHOr BO BIMNKaHa.
3. 3MiHa TnCKy yBIMKHeHHr:peRyIIOBaHHr ROIOHOI HATNCKHOI npYHnHn (11) (pO3mip KIOOa 9 MM; 1 O6epT npHbL.0,1-0,15 6ap). PnUcbOMy TnCK BIMKHeHHr 3MIHOCTbCMAJKe npONOpuiHo!
4. 3MiHa TnCKy BnIMKHeHHr: peryIIOBaHHr nepenady TnCKy (12). Tnch yBIMKHeHHr 3aIIHuaTeBcR He3MIHHM.
5. BCTaHOBnTH Ha MlCe KpHkHy MaHOMETPnHHORO BMIMKaHa NepeBipHTn npaBnIbHcTb MOtAHTy.
6. BBeCTN HAcOC B EKCNyAtaUcH, nepeBipNTn BiNObIaHiCTb 3aHaHm 3HaYeHHMa 3a DonOMOrOo MAHOMeTpA (11).
7. Y pa3i Heo6xHocTi NoBtOpNTn KpOKn 1-6 do OTPMAMHH bKaHaHnx 3HaYeHb.

YBaRa! Bka3aHm MaKcMmaIbHn TnCK HacOca He Mae 6yTH npeBpuJeHn. TnCK yBMKHHeHHMaHOMeTpHOro BMNkaHaeMae 6yTH 3abXd 6JIbue TnCKyPiKnBHeHHpeCnBepaMH. Ha 0,2 6ap (1,56ap, nB.p03in

9.4). ⅡOb yHMHHTn qactoro yBIMKHeHHaHocca, cnIb BCTAHOBINOBATn MaHCMAJIbNH nepenad TcNc (HanpNKlad, nonepedhe HanaWtYBaHHn npnbl.1,86ap).

9. Ipo6JIemn i HecnpaBHOcTi

He6e3neka!

-Перед 6уд-як imm роботamn 3 пиладom:
- BntarHitb wTenceIbHy BNkY 3 po3eTKN.
- IpekoHaTeC8, 0 npiia i nHIOueHe npiaIra 3haxoIaTbca He nI d TnCKOM.

9.1 Hacoc He npaioe

• Hanpyra Mepeksi BiccyTHa.

IpeepiTe npemHKaYBIMK/BIMK, Kaebb, BNky, po3eTKy i 3an06hHK.

• Hanpyra Mepexi 3aHaTo Hn3bKa.

BnKOpNCTOByTe NIOOBKyBaIbHNI Ka6eJIb 3doCTaTHIM NonepeuHm NepepiSOM HIN.

• EneKtpoBnHy npeperpiN, cnpaioBaB 3axnCT DnHyHa.

• PICIAOXIOJIDHEHHe HAOC BKLIOUHTbC3HOBYaBTOMATHNO.

• 3a6e3neueHHAocTaTHb0iBEHTNIAJI BEHTNIAIHIOTBOPMMAOTb ByIN BIDKpNTI.
  -ДOTРПМУТЕССМACHIMмьНОТtemпepаТури nopondaal.

• EneKtpoBnHyr rHyntb, aIe He 3anyckaetbca. - Notpi6Hm peMOHT, nB. po3d11.
  Hacoc 3acmitnbca6 a6o HecnpaBn.
  P036epiB i npOCHITb Hacoc. IpOCHITb a0b 3aMihB dNdy3Op. IpOCHITb a0b 3aMihB p0oChe KOleco. DHB. po3di 11...
  TnCKBJIiH /HaBXOjI BUNe TnCKy yBIMKHeHHHaCOca.
  -Пдкючтп радуктор,дв.роздн2.

9.2 Hacoc npaioe HenpaBnIbHO a6o dyHe rnuHo:

• Hecta BODN.

• PpekeonaiTeC8, 103anac BOnD IOCTaTHiN.
  Hacoc 3aONBHeHn BOOIO HeoCTaTHbO.
  -Див.pozdi6.7.
  BCMOKTyBaJbHaJIiHrHerepMeTnHa.
  -3a6e3neTe repMeTHuHtcb BCMOKTyBaIbHOJIiHII, 3aTnHiTb pi3bObi 3'EdHaHH.
  3aHaToBeIMKaBnCotaBCMOKtYBaHHA.
  -OTpMMyTecbO6MeXeHHNo BNCOTBCMOKTYBaHH.
  BcTaHObITb 3BOpOTnH Klanan, 3AnOBHItb BCMOKTyBaIbHy JInIO BOIO.
  PnHMaJIbHmIΦJIbTpBCMOKTyBaJIbHOI LiHII (DoaTkoBe yCTaTKyBaHH) 3aCMTUBC.

• Ipoounctitb Horo, B pa3i notpe6n 3amHITb.

3BOpOTHnKlnaHaN (OdaTkoBe yCTaTKyBaHHa) 3a6IOKOBaHn.
Ipoynctitb noro, B pasi notpe6n 3amHITb.
BntIK BODn MIK eIeNTPODBNYHom I HAcOCOM, TOpueE yuJIbHeHHr HErEpMeTHyHe. (He3aHnN BNTIK BODn (MaCc. 30 Kpanelb B DeHb) oByMOBLeHN KOHCTpyKUIEIO TOpueBOr OyuiJIbHeHHr).
3amHITbTOPueBe yuINbHeHHa.IIB.po3di11.
Hacoc 3acmitnbca6 hecnpaBn.
-IMB.po3d9.1

9.3 Tnck 3aHaTo Hn3bKn a6o Hacoc npauoe nocIHO (noCTiHo BIDyBaTeBcYBIMKHeHHBIMKHeHHA):

BCMOKTYBaJIbHaIiHrHEPeMTeNHa, a60 BHCOTACBMOKTYBaHHaHaTToBeJINa.
-ДиВ.pozdiN9.2.
Hacoc3acmitHBcraaboHecnpaBnI.
-ДиВ.po3dIn9.1.
HWW...：36nncraHaIawyBaHHaMAHOMeTpHOroBmNkaa.
3aMpTe TnCK YbIMKHeHHI BIMKHeHHI 3a DOmOMorOIO MAHOmeTpA (7) I nepebipte 3haupeHHI (INB. po3di 13, TexhiHi XapaKTepnCTHNI). KIIO e NOTpe6a B NOBTOPHOMY HANAWTYBaHI, 3BePHTbcrdo KJIeHtCB0I cIyHb6n KomNaHII Metabo. INB. po3di 11..
- HWW....: Hacoc BMnKaTeBcra npu He3HaHOMy 3a6opi BOIN (npu6n.0,5 n).
- PepeBipTe, Neu He 3aHaTTo Hn3bKn TnCK nIXnBHeHnY y pe3epByap. Y BnPaNky Heo6xHnOCTi 3oJIbWnte TnCK. NIB. p03d19.4.

YKPAIHcBHAuk

• HWW... BODa Teue i3 NobitprHoro KlaanaHa.

-ΓyMOBn CnIbfoH ype3epByapi HeepMeTnUHni;3amHItb.1uB.p03d11..

9.4 36iNbweHH TnCKy nIDKHBneHH (TinbKn HWW...)

JaHIO HAcOC-3 YacOM-BMnKaETbCnHaBtbpnpn He3NaHOMy 3aOpI BODn (npHbL.0,5n), Heo6XiJHO BiDnOBHTn Bepe3epByapi TnCK nIDKMBHeHH.

Bka3jBa: Tnck NIIKNHbIeHNy y pe3epByapi (NOITPBHN TnCK) HE MOHA Bn3HaHTN 3a DOJONMOFO MAHOMeTpA (7).

1. BntarHnItb wTeNceIbHy BNkky 3 po3eKn.
2. BiiKpnIte HAnipHn Tpy6oPobiD (NoBepHtB BOOnpObiDHH KpaH a6o CoNIO), NOBHCTO cnYCTITb BOvY.
3. BiodrBnHTNb PAnCTNKBOy KpNtUHa TOpueBcI CTOpOni Pe3epYapa; 3a Heo 3hAxOxDbCn BOITOPHNBEHTNb.
   4.Пд'бнaite nobitprHn Hacoc a6o shaHR KOMnPecOpa 3 HAcOHeHHKOM dJIa SHINHIX KlanahIB imAHOMetp Do nobitprHoro BEHTNJIH.
4. Hanomiyte do DoocrHeHHaBIObHOrTO TnCKy nDHNBHeHHA (1,56ap; DnB. po3d13. TexHHiX hapaTePcTmNtHu
5. 3HOBy nIKHIOuITb HAcoc i nepeBipTe Noro fYHKUIOHYBaHHa

10.Пи�адя

BnKOpncToBvTe TlIbKn opnirHaJIbHe npnlaJa Metabo.

BnHOPCTOByTe TINbK Te npHaAJa, IKe BIDNoBIAe BmORaI npamETpam IciE iNCTpykui 3 ekCnJyataaui.

PobHn acopTmEHT npHaIaIy IuB. Ha caiTi www.metabo.com a6o B KaTaIaO3i.

11. PemOHr

Hebe3eKa! DopyaHte peMOHT npHnlaNy TInbKn KBaJIΦIOBAHIM QaxIBZAM- enKeTpNkAm

ДлpeMoHTyInCTpymeTIBMetabo3BepTaIteCnBperioHJIbe npedctabHnTuBOMetabo.ADpeCnDHB.Na caiTl www.metabo.com.

Ipeed BiinpaBneHHAM: nobHicTIO BNnopoKHiTB Hacocip eepByap (DINB. po3JIn 8.3).

CnNCKH3aNaChHXyACTINHMOKHa 3aBaHTaKHTNa Ha caTti www.metabo.com.

12.3axnct doBknna

DToPmMyTeCnHaioHbNHX npaBn63neHooYtNiIaaii I nepeo6Kn BHKOpCTaHIXIHcTpymTIB, NaKyBaHbNHX MaTepiAIB i npnaJAA.

TkyBaIbHi MaTepiAn yTuNl3yOToBc BiIDNoBIdHO do IXHbOro MapKByAHn 3rJHo 3 KOMyHaJIbHMn npaBnAmn. OdaTkoBy IHOpMaJIO MOxHa 3HaHT Ha caTI www.metabo.com y po3diNi «CepBIC’.

TilbKn Iy KpaH EC: He yTni3yIe eKTKPOIHCTPymeHT na303 nO6yTOBHMn BIXdoaMNI 3riJHO 3IpeKTHBOHO SC
2012/19/EU npo BHKOPNCtAHI eKETPNHi i eKETPOHI npcTpoi Ta BiNobiHNMI
HaJIOnAJIbHHMM HOpMaMI BIIpauBoBHAI
eKETPOIHCTPymeHT niJaIaOTb po3diNbHi
yTNH3aui 3 MeTOI IX NpaJIbWoI ekONOrIHoo
6e3neHoi nepepO6Kn.

13. Texhui xapaHTepnKu

TORCHEHNN DO daHINx, HABeDEHINx HA CTOP.3. 3aJIuaeMo 3a co6oIO npaBO HA TEXHiN3MiHN.

XapahTepeHcTHHa KpNba Hacoca (diarpama, CTOp.3) DEMOHCTpye NIOPODyKTNBHCTb 3aJIeKHO BID TCHyB (BNCOTA BCMOKTYBaHHO 0,5Mi BCMOKTyBaBHmShnahr 1").

E =eIekTpoHikA / 3axnCT BiD cyxOro xOyDV =HAcOC 3 B6yDoBAHIM 3BOpOTHM KlaNaHOM Ha BCMOKTyBaIbHOMy naTpy6Ky (8)

K Ka6eJIb HINBNEHHA
U = Hanpyra mepeXi
f = yacToTa MepeKi
P1 =HOMiHaIbHaNOTyKHiCTb
PStandby= BntpataB peKIMOuyKyBaHHA

HOMiHaJIbHI NCTpyM

C = po6oHn KOHdeHcaTOp

n =HOMiHaJIbHa KJIbKicTb 06eTpIb

Fv,max =MaKc.npoDyHTNBHICTb

Fh,max =MaHC. BnCota noDaui

Fp,max =MaHC.TNCHNoDAqi

p1 =MaHOMeTpNHHBIMHKaT:THCK

yBIMKHEHHH

p2 =MAHOMETPUMHHIN BIMHKaT:THCKBIMHKAHH

Sh.max =MaKC.BNCOTA BCMOKTyBaHHA

Stemp=MaKc.TEmnepaTpya noDaqi

Temp Ttemp =TemnepaTpa HABKONHbOro

cepeoBnua

S1 =Klnac 3axnctTy BiD 6pn30K

S2 =Klaac3axncty

S3 =Knaac 10JnA

M_P = matepiaI koprnyc y hacoc a G=cipniyabyni

M=MaTePiaI Bana Hacoca

Mw =MaTepiApo6OuroKoIecaHacoc

Ds =BHTpiHRA3b6aBCMOKtyBaHORO

natapy6ka

Dp =BHytpiwnpi3b6aHanipHoro naTpy6ka

TV =06'EM pe3epByapa

Tp,max =MaKc.TnCKype3epByapi

Tp.1 =TNCKnDKNBHeHHpe3epByapa

A= po3Mipn:

DOBKNHaXxHpiHnX BnCoTa

m =BaRa(3KaBeneMKNBHeHHa

～ nepemHHn CTpyM

Ha Bha3aHi TexhiHni XapAHTpeNCTnHn
NooHpiOIObCra DOnyCKn, NpeE6baeHi DiIOUHMn
CTaHdpTAM.

3HaenHemiciiWmy 3HaenHHo3BOJHO

nopiBHOaTN emCIO wMy pi3HIX eEKeTPOINCTpyMeTIB.3aJIeKHO BID yMOB EeCNLIyatau, CTaNy eEnKTPOINCTpyMeTHy a60 pOboHX IHCTpyMeTIB paHTNue HabaHTaKeHH MoKe 6bTH BmUe a60 NnXue. JIn OuHNs 3pa3KOBO rPiBH emiCII bPaxoByte nepePBn B pOboTI pAni pOboTI 3I hKeHH m (WMOBM) HabaHTaKeHHm. Bn3HaYte nepeNIk oPaTHi3auiHnx 3axoDII uOdo 3aXHCTy KOpHcTyBaHa 3ypxaYbaHHm Tnx a60 IHxN 3HaHe b emCii wMy.

PIBEhB 3BYKOBOrTO TnCKy 3a TINOM A:

LpA =piBeHb 3ByKOBOTo TnCKy

LWA =pibehb 3ByKOBoi NOtyHHOCTI

KDA，KW=KoeΦiεHTnoxN6KN

LWA(G) = rapaHTOBAHn piBeH 3ByKOBOI

notyHKo3rJHO 2000/14/EG

BnHOpncTObyIte 3axnct opraHIB cLyxy!

TOB "MeTa6o YKpaHa"

ByI. 3OpHa, 22

c.CBtoneTpbcbke

Kmibcbka 06n.

08141, HnIB

www.metabo.com

Metabowerke GmbH

Metabo-Allee 1

72622 Nuertingen

Germany

www.metabo.com