HWW 330025 G - Pump METABO - Free user manual and instructions

USER MANUAL HWW 330025 G METABO

(Vice President Product Engineering & Quality)

*4) Metabowerke GmbH - Metabo-Allee 1 - 72622 Nuertingen, Germany

Original Instructions

1. Declaration of Conformity

We hereby declare that these pumps/domestic water works/domestic water automatic systems, identified by type and serial number 1 ), meet all relevant requirements of directives 2 and standards 3 . Technical documents for 4 - see page 3.

For UK only:

UK We as manufacturer and authorized person to compile the technical file, see *4) on page 3, hereby declare under sole responsibility that these pumps/domestic water works/domestic water automatic systems, identified by type and serial number *1) on page 3, fulfill all relevant provisions of following UK Regulations S.l.2016/ 1091,S.l.2016/1101,S.l.2001/1701,S.l.2012/ 3032 and Designated Standards EN 60335-1,EN 60335-2-41,EN IEC 63000:2018.

2. Specified Use

This device is used for conveying clean water in the house and garden area, for sprinkling and watering, as a well pump, rain pump and domestic water pump, for pumping empty of garden ponds and water tanks.

The pump is not intended for:

• continuous operation

• industrial or commercial use

The pump is not suitable for transportation of:

• drinking water

-food

• salt water

• explosive, flammable, aggressive, or hazardous materials (e.g. chemicals)

• liquids over 35^

• water containing sand and liquids with an abrasive effect

• liquids containing chlorine (e.g. pool water)

The pump is not suitable for increasing pressure: if the pump is connected to a line that is already pressurised then a suitable pressure regulator should be installed upstream of this. The maximal pressure of the system must not exceed the stated maximum pressure of the pump under any circumstances. It should also be borne in mind that

the inlet pressure is added to the cut-off pressure of the pump!

This device is not designed for the use of persons (including children) with limited physical, sensory or mental aptitude or lack of experience and/or knowledge.

Unauthorised modifications to the device and the use of parts that are not tested and approved by the manufacturer are prohibited.

All improper use of the device is regarded as non-specified use; this can result in unpredictable damage! The user bears sole responsibility for any damage caused by inappropriate use.

Generally accepted accident prevention regulations and the enclosed safety information must be observed.

3. General Safety Instructions

Pay attention to all parts of the text that are marked with this symbol for your own protection and for the protection of your device!

WARNING - Reading the operating instructions will reduce the risk of injury.

WARNING Read all safety warnings and instructions. Failure to follow all safety ings and instructions may result in electric k, fire and/or serious injury.

Keep all safety instructions and information for future reference.

Pass on your pump only together with these documents.

Information in these operating instructions is designated as shown below:

Danger! Risk of personal injury or environmental damage.

Risk of electric shock! Risk of personal injury from electric shock.

Caution! Risk of material damage.

4. Special Safety Instructions

Children, adolescents and persons who are not familiar with the operating instructions must not use the device.

Children should be supervised to ensure that they do not play with the device.

When the pump is being used in garden ponds and in the protected areas around them, the provisions of DIN VDE 0100 -702, -738.

The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).

The device must not be used if there are persons in the water.

The statutory water and waste water specifications and the provisions of DIN 1988 must be observed when used for the domestic water supply.

The following residual risks essentially remain when operating pumps and pressure vessels (equipment-specific) - they cannot be fully eliminated even if safety measures have been introduced.

4.1 Danger from the environment!

Do not expose the device to rain. Do not operate the device in a damp or wet environment.

Do not use the pump in potentially explosive locations or near flammable liquids or gases!

4.2 Danger from hot water!

Danger! Install a check valve at the suction connection (8) to prevent water from flowing back into the suction line. This can reduce the following danger:

Hot water can cause damage and leaks on the device and the connection lines, allowing hot water to escape. Danger of scalding!

Devices with the designation HWW...: if the shut-off pressure of the pressure switch cannot be reached due to poor pressure conditions or a defective pressure switch, the water can heat up within the device as a result of internal circulation.

Devices with the designation P.... do not operate the device against a closed discharge line for longer than 5 minutes. Water that circulates inside the device is heated up.

In the event of a fault, unplug the device from the power supply system and allow it to cool. A specialist must check the system to make sure it is in perfect working order before it can be used again.

4.3 Risk of electric shock!

Never direct the water jet directly at the device or other electrical components! Risk of fatal electric shock!

Always disconnect the device from the power supply system prior to installation and maintenance tasks.

Do not touch the plug with wet hands! Always pull on the plug and not the power cable to disconnect it.

Do not buckle, squeeze, drag or drive over the power cable or extension cables; protect them from sharp edges, oil and heat.

4.4 Danger due to deficiencies or faults on the device!

Check the device for possible damage - especially the mains cable, mains plug and electrical components before each use. Risk of fatal electric shock!

A damaged device must only be reused after it has been correctly repaired.

Do not attempt to repair the device yourself! Only specialists are permitted to repair pumps and pressure vessels (equipment-specific).

Caution! To prevent water damage, such as flooded rooms, caused by deficiencies or faults on the device:

• Provide appropriate safety measures, e.g. alarm device or collection tank with monitoring The manufacturer is not liable for any damage caused by:

• Improper use of the pump.

• Overloading of the pump through continuous operation.

• Failure to operate and store the pump in a frost-free environment.

• Unauthorised modification of the pump. Repairs to electrical equipment may only be carried out by qualified electricians!

• Use of spare parts which have not been tested and approved by the manufacturer.
• Use of unsuitable installation materials (fittings, connection lines etc.).

Suitable installation materials:
- pressure-resistant (min. 10 bar)
- heat-resistant (min. 100^ ). When using universal swivel couplings (bayonet couplings), only use versions with an additional securing ring to ensure safe sealing.

5. Overview

See page 2. The illustrations are regarded as exemplary for all devices.

1 On/Off switch
2 P u m p
3 Pressure vessel ("vessel") *
4 Air valve for pilot pressure
5 Water drain screw
6 Pressure switch
7 Pressure gauge (water pressure) *
8 Suction connection
9 Water filling screw
0 Pressure connection
1 Pressure switch - adjustment of the cut-in and cut-out pressure
2 Pressure switch - adjustment of the differential pressure
equipment-specific

6. Commissioning

6.1 Installation

The unit must be set up horizontally at a dry (humidity max. 80% ), well-ventilated site that is free of atmospheric influences. Ensure that the unit is positioned on a secure, level and firm base when full of water. The air vents must not be covered or suck in dirt. There should be a clearance of at least 5 cm from walls and other objects. Protecting against frost - see section 8.2.

The device should not be bolted on but rather positioned on a resilient base to avoid vibrations.

The device must be installed in a flood-proof location and secured against falling in for operation in garden ponds. Additional statutory requirements must be taken into consideration.

6.2 Connecting the suction line

Caution! The suction line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.
Caution! Use an intake filter to protect the pump against sand and contamination.
Caution! The check valve is absolutely essential to prevent the water from draining when the pump is switched off. We recommend the installation of check valves at the intake opening of the suction hose and at the suction connection (8) of the pump. A check valve may already be integrated depending on the model (see section 13. Technical Specifications).
Seal all fittings with thread seal tape (approx. 10-15 windings in the thread direction). Leaks result in the intake of air and reduce or prevent the intake of water.
The suction line should have an internal diameter of at least 1^ (25 mm); it must be kink- and vacuum-resistant.

The suction line should be as short as possible because the longer the line length, the lower the conveying capacity.
The suction line should rise uniformly towards the pump to prevent air pockets.
An adequate supply of water must be guaranteed and the end of the suction line should always be under water. Ensure that the suction line is not on the ground so that no sand or dirt is sucked in. It is possible, for example, to use a floating intake as an accessory.

6.3 Connecting the discharge line

In order to reduce friction losses, the discharge line should have an interior diameter of at least 1" (25 mm). If using smaller diameters, such as 1/2 then application problems may arise due to inadequate ventilation.

Caution! The discharge line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.

Seal all fittings with thread seal tape to prevent water leakage (approx. 10-15 windings in the thread direction).

All discharge line components must be pressure-resistant and installed correctly.

Danger! The discharge line can burst during operation if non-pressure-resistant

components are installed or they are assembled incorrectly. Injuries are possible if highly pressurised fluids are ejected!

6.4 Connection to a pipe network

The device should be connected to the pipe network with flexible hose lines to reduce vibration and noises.

In the case of fixed pipes, it is recommended that these are laid only rising in the first 2 metres to ensure optimal ventilation.

6.5 Power supply connection

Risk of electric shock! Never operate the device in a wet environment and only under the following conditions:

• Connect it only to an earthed outlet that is properly installed, earthed and tested.
• The mains voltage, mains frequency and fuse protection must correspond to those stated in the "Technical Specifications".
• The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).
• The electrical connections must not be under water and must be located in a flood-proof area. The connections must be splashproof for outdoor use.
• Extension cables must have sufficient conductor cross sections. Cable reels must be fully unrolled.
• National installation specifications must be observed.

6.6 Setting the pilot pressure (only HWW...)

Set the pilot pressure before the initial operation. See section 9.4.

6.7 Filling the pump and suction

Caution! The pump must be filled with water with every new connection and in the case of water loss or air intake. Operating the pump without filling it with water will destroy it! In order to ensure trouble-free operation, we recommend sufficient removal of water so that the system is fully ventilated before initial use.
- Unscrew the water filling screw (9) with gasket.

• Slowly pour in clean water until the pump is filled.
• Screw in the water filling screw (9) with gasket again.
• Open the discharge line (open the water tap or spray nozzle) so that air can escape during suction.
• Switch on the device (see section 7).
• The device is ready for operation when water emerges evenly.
  Note: the suction line does not need to be filled because the pump is self-priming. However, it may take some time until pressure is built up depending on the length and diameter of the line. To shorten the suction time: install a check valve at the intake opening of the suction hose and fill the suction line too.

7. Operation

Caution! The pump and suction line must be connected and filled (see section 6.).
Caution! The pump must not be allowed to run dry. There must always be sufficient conveying medium (water) available.

A protective circuit shuts down the motor if the pump is blocked by foreign bodies or the motor is overheated.

7.1 Using the device

Garden pump

(Device designation P...)

Principle of operation: the device runs when it is switched on.

Danger! Run the pump for a maximum of 5 minutes if the discharge line is closed because otherwise overheating of the water in the pump can cause damage.

1. Insert the mains plug.
2. Fill the pump if necessary - see section 6.7
3. Switch on the device:
   Turn on the device at the switch (1).
4. Open the discharge line (open the water tap or spray nozzle).
5. Check that water emerges!
6. Switch off the device when work is complete. Turn off the device at the switch (1).

Domestic water works (Device designation HWW...)

Principle of operation: the device switches on when the removal of water causes the water pressure to fall below the switch-on pressure; it switches off again when switch-off pressure is reached. The pressure vessel contains rubber bellows that are under air pressure ("pilot pressure") when delivered; this permits the removal of small volumes of water without the pump starting up.

1. Insert the mains plug.
2. Fill the pump if necessary - see section 6.7
3. Switch on the device:
   Turn on the device at the switch (1).
4. Open the discharge line (open the water tap or spray nozzle).
5. Check that water emerges! The device is not ready for operation.
6. The device switches on and off as required.

8. Maintenance

Danger! Prior to all work on the device:

• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.
• Repair and maintenance work other than that described in this section should only be carried out by qualified specialists.

8.1 Regular maintenance

• Check device and accessories for damage, in particular electrical and pressurised components, and repair if necessary.
• Check suction and discharge lines for leaks.
• Clean the intake filter and filter element (if installed) and replace if necessary if the conveying capacity decreases.
• Check the pilot pressure of the pressure vessel (3) (equipment-specific) and increase it if necessary (see section 9.4 Increasing the pilot pressure).

ENGLISHen

8.2 If there is a risk of frost

Caution! Frost (< 4°C) destroys the pump and accessories as both always contain water!

• Disassemble the pump and accessories and store them in frost-free conditions (see the following section) if there is a risk of frost.

8.3 Disassembling and storing the device

• Switch off the device. Disconnect the mains plug.
• Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
• Completely drain the pump (2) and vessel (3) as follows:
• unscrew the water drain screw (5).
• remove the suction and discharge lines from the device.
• store the device in a frost-free room (min. 5^ ).

8.4 Set pressure switch (HWW 3500/25 G only. Contact the Metabo service team for setting all other HWW models.)

Danger! Risk of electric shock at the terminals on the pressure switch! Only trained electricians should open the pressure switch and carry out changes.

The pressure switch is pre-set on site for the most common application areas and can be adjusted as follows if required:

Note: Adjustment of the main pressure spring (11) results in almost proportional changes in the cut-in/ cut-out pressure, the difference in pressure remains unchanged. An adjustment of the difference in pressure (12) only changes the cutout pressure, the cut-in pressure remains unchanged.

1. Switch off the pump, turn off at the mains, and ensure that no voltage is carried.
2. Remove the cover from the pressure switch.
3. Changing cut-in pressure: adjust main pressure spring (11) (SW 9 mm; 1 rotation ca. 0.1 - 0.15 bar). This adjustment also changes the cut-out pressure to a practically proportional extent!
4. Changing cut-out pressure: adjust (12) pressure difference. The cut-in pressure remains unchanged.
5. Mount the cover on the pressure switch and check professional installation.
6. Operate pump, check desired target value (7) on the manometer.
7. Repeat steps 1-6 if necessary until the desired values are set.

Caution! The stated maximum pressure of the pump must not be exceeded. The cut-in pressure of the pressure switch must always be at least 0.2 bar over the precharge pressure of the chamber (1.5 bar, see Chapter 9.4). To prevent regular switching of the pump, the chosen pressure difference should be as high as possible (e.g. pre-set at ca. 1.8 bar).

9. Troubleshooting

Danger!

• Prior to all work on the device:
• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.

9.1 Pump does not run

• Noms voltage.

• Check the on/off switch, cables, plug, socket and mains fuse.

• Mains voltage too low.

• Use an extension cable with an adequate conductor diameter.

• Motor overheated; motor protection relay has tripped.

• After cooling the pump will switch ON again.

• Ensure that there is adequate ventilation, keep air slots free.

• Observe the maximum supply temperature.

• Motor hums, but does not start.

• If repairs are required, see Chapter 11.
• Pump clogged or defective.

• Disassemble and clean the pump. Clean the diffuser and replace if necessary. Clean the impeller and replace if necessary. See section 11.

• Line/inlet pressure greater than pump cut-in pressure.

• A pressure regulator should be installed upstream, see Chapter2.

9.2 Pump not drawing in correctly or running very loudly:

• Lack of water.
• Ensure that there is an adequate supply of water.
• Pump not sufficiently filled with water. - See section 6.7.
• Suction line leaking.
• Seal the suction line, tighten the screw couplings.
• Suction height too high.
• Observe the maximum suction height.
• Insert the check valve, fill the suction line with water.
• Intake filter (accessories) obstructed. - Clean and replace if necessary.
• Check valve (accessories) blocked.
• Clean and replace if necessary.
• Water discharge between motor and pump, shaft seal leaking. (Minor discharge of water (max. approx. 30 drops per day) is normal with the use of shaft seals).
• Replace the shaft seal. See section 11.
• Pump clogged or defective. - See section 9.1.

9.3 Pressure too low or pumps runs continuously (continuous switch-on/off):

• Suction line leaking or suction height too high. - See section 9.2.
• Pump clogged or defective. - See section 9.1.
• HWW...: pressure switch adjusted.
• Read off the switch-on and switch-off pressure on the pressure gauge (7) and check the values (see section 13 Technical Specifications). Please contact Metabo Customer Service if a modification is required. See section 11.

• HWW.... pump starts up even after a small volume of water is removed (approx. 0.5 l)

• Check whether the pilot pressure in the pressure vessel is too low. Increase the pressure if necessary. See section 9.4.

• HWW...: water is running out of the air valve.
  Rubber bellows in the pressure vessel are leaking, replace them. See section 11.

9.4 Increasing the pilot pressure (only HWW...)

If - in the course of time - the pump starts up even after the removal of a small volume of water (approx. 0.5 l), the pilot pressure in the vessel must be restored.

Note: the vessel pilot pressure (air pressure) cannot be read on the pressure gauge (water pressure) (7).

1. Disconnect the mains plug.
2. Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
3. Unscrew the plastic cap on the front face of the pressure vessel; the air valve is located behind it.
4. Mount the air pump or compressor hose with a "tyre valve" connection and pressure gauge on the air valve.
5. Pump up to the specified pilot pressure (1.5 bar; see section 13. Technical Specifications).
6. Connect the device again and check it works.

10. Accessories

Use only genuine Metabo accessories.

Use only accessories that fulfil the requirements and specifications listed in these operating instructions.

See www.metabo.com or the catalogue for a complete range of accessories.

11. Repairs

Danger! Repairs to this device must be carried out by qualified electricians only! Please contact your Metabo service centre if you have Metabo devices that require repairs. See www.metabo.com for addresses.

For shipment: drain the pump and vessel completely (see section 8.3).

You can download a list of spare parts from www.metabo.com.

12. Environmental Protection

Observe the national regulations on environmentally compatible disposal and on the recycling of disused tools, packaging and accessories.

Packaging materials must be disposed of according to their labelling in accordance with municipal guidelines. Further information can be found at www.metabo.com in the "Service" section.

Only for EU countries: never dispose of power tools in your household waste! Used power tools must be collected separately and handed in for environmentally compatible recycling in accordance with European Directive 2012/19/EU on waste electrical and electronic equipment and its implementation in national legal systems.

13. Technical Specifications

Explanatory notes on the specifications on page 3. Subject to change in accordance with technical progress.

The pump characteristic curve (diagram on page 3) shows the conveying capacity that can be reached depending on the conveying height (suction height 0.5m and 1^ suction hose).

E E l e c t r V=Check valve integrated on the suction connection (8) of the pump

K =Mains cable

U =Mains voltage

f =Frequency

P1 = Rated input power

Pstandby=Standby consumption

= Rated power

C =Operating condenser

n =Rated speed

F_V, = Max. conveying capacity

F_h, = Max. conveying height

Fp,max =Max. conveying pressure

p1 =Pressure switch switch-on pressure

p2 =Pressure switch switch-off pressure

S_h, = Max. suction height

S_temp = Max. supply temperature

Ttemp = Ambient temperature

S1 =Splash protection class

S_2^ =Protection class

S_3^- =Insulation class

M =Pump housing material

G = Grey cast iron

M_B = Pump shaft material

M_W = Pump impeller material

D_s^w =Suction connection female thread

D=Pressure connection female thread

TV =Vessel volume

Tp,max =Max.vessel pressure

Tp.1 =Vessel pilot pressure

A' = Dimensions:

length x width x height

m =Weight (with mains cable)

AC power

The technical specifications quoted are subject to tolerances (in compliance with the relevant valid standards).

A Emission values

These values make it possible to assess the emissions from the power tool and to compare different power tools. The actual load may be higher or lower depending on the operating conditions, the condition of the power tool or the accessories. Please allow for breaks and periods for assessment purposes when the load is lower. Arrange protective measures for the user, such as organisational measures based on the adjusted estimates.

Typical A-effective perceived sound levels:

LpA =Sound-pressure level

L_WA(G) =Guaranteed acoustic power level as per 2000/14/EC

Wear ear protectors!

Notice originale

Pomp verstopt of defect.

-Ziehoofdstu9.1.

m = 311

5

e

3

：

M =Materialipumpeakselen

Mw =MaterialeipumpensIpehjul

D_s =Sugetilkobling, innvendige gjenger

Reservedelslicer kan downloads pa www.metabo.com.

12. Miljobeskytelse

S3 =Katnyopia movwtkou uikou

Tp,max =Mey. pieon λeβnta

Tp.1 =Piocn nponlnpomega s λeβnta

A = △iaστáσεις

MnKoC x nAtoC x uOos

Hacoc He paccuHTaHa TaKaHe ycIOBnA:

• npoDOnJIHKeIbHaN 3KcNJaTaUa

-ПROMbIJIeHHOEИЛпрфecCNoHaJIbHOe HcnoJIb3OBAHHe

Hacoc He noDxOoNT IJIa nepeKaUHbAHn TaKnx HJDKOCTeI:

-NTBeBaB B0da
-ПИЗЕВIELnpODYKTbl
- COJIeHaB BOda
B3pbIbOONaChBie, rOpUHne, arpeccnBHe iJIN onaChBe IJI 3DOpOBbMaTePnaJIbI (HanpIMep, XIMHKaTBI)
- HNIOCTn C TemnpaTypoB BIIe 35 ^ C
- BODa C COepeKHaHnEm NecKa N a6pa3nBhbIe HNkOCTN
-xlopcoedepekauxx HnKocTei (B0da B6accseHax)

Hacoc He paccunTaH Ha nobIeHne daBHeHHa.
nPi OndKIOUeHN HACoCA K IINHn,
HaxOJaueCe NOd DaBHeHMe, Heo6XoIMo
ncONoJb3OBaTb NOxOJaun peyKTOp.

MaKcHmAbHoe DaBHeHne B CnCTeMe He DoJIHHo npeBBbAty Kaa3AHHO MaKcHmAbHoe DaBHeHne HAcOca.CJeDyET YHTbIbTb,HTO BXOHe O daBHeHne CymMpyTeC dABHeHnEM BBkIOuHHeNHaCocA!

DaHbHn HAcoc He npedHa3HaueH dIa
NcNoJIb3OBAHn IiUAMn (BkIOuHg ATeT) C
OrpaHueHehBMn Fm3NuCeKHM, CeHCOpHbIMn
NIn NcHXHneKHM nCOno6HObCTMn,
HeIOCTaTOUYbIM ONbITOM m/nu 3HaHNIM.

3anpeaaetcramoBolbHoe BHeceHne
n3MeHENB KOHCTpyKuHn HAcoca,a TaKHe
NCNoIb3OBaHne DeTale, He npOweDnIX
NCbTaHAne Hp a3peWeHHbIX K pPmEHNIO
n3ROTOBHTeJIem.

JIIO6OE HcNOJb3OBAHHe HAcOca C HApUeHNEm
npABINr ERO 3KcNlYatauCnCHTaETCR
HCNoJb3OBAHHe He No Ha3HaNeHIO; TaKoe
HCNoJb3OBAHne MOKeT NOBLeHb 3a CoBoI
HepeDbHEnHb yuePb6!3a yuePb6,BO3HKnH
Bpe3yJbTate NcNoJb3OBAHnE He No
Ha3HaYeHIO,OTBeTCTBeHHOCtB HeCeT TOnbHO
NoJb3OBaTeB.

Heo6xOJIMO coklaDaT obSeOpnHtBle npaBnHa npeD0TbpaEHeN HeCuaCTbX Cnyaeb, a TaHOg YKazAHn NO TeXHnke 6e3oNaCHOCTn, npuBeEHhIbe B daHHOM pyKOBOcTBe.

3. 06uhe yha3aHnno TeXnKe 6e3oNaChOCTn

ДлгБашен co6cTbeHHHOB 6eONACHOCHIN 3aunbI yCTpoiC7Ba OT NOBpeKdENH COJIIOJaTe Yka3AHJN,OTMeYehHbIe DaHHBM

CNMBOLOM!

PDEYUNPEHXDAHNE-BcEJX CHINHEN PINGA TpaBMbI nPoTHTe DAHOHe pyKOBOCTBO NO 3KCNlyatauim.

PPEyIPEHDEHNE! PpOHTte Bce HNCTpyKuIN uKa3aHnNo TExHHe

6e3onachocn. HecobJIOdeHne HNCTpyKmI N yka3aHN IO TeXHIne 6e3oNaChOCTn MOKeT npBcETn K nopaKeHnIO 3JIeKTpUeCKM TOHOM, BO3HNHOBEHnIO NOkapa N/INK N OLYHeHIO TReJeIbIX TpaBM.

CoXpaHnTe BceMHCTpyKunH yHa3aHHNo texHnke 6e3onachOCTn dIy nCnONb3OBaHHn B 6dyuem.

JaBHeu npepaay Baewo Hacoc aOcUyecTBnAeTObBO BMeCTe C3TmN DOKYMHTAMI.
HOpMaun O603NaueHa B DaHHOM pyKOBODCTBe NO 3KcNyaataun CneDyou o6pa3OM:

Onachoctb!PpeynpeKdEHeNc o6 onaCHoCTn TpaBMblnn O BpeDe IJH aHOooJIe cpebl.

Onachoctb noulyehn TpaBm OT ydapa 3JIeKTPuYeCKM TOHOM!

IpeDyIpEKeHEne 06 onaChOCTn TpaBMbl npi pa6oTe c 3JeKToo6OpoyoBaHNem.

BnmaHne!IpeDynpexKdeneo BO3MOXHOM MaTePnaJbHOM yuepe6.

4.Oco6bIe yHa3aHnI NO TEXHNKe 6e3oNaChOCTn

He pa3pe7aeTcNcNoIb3OBAHne HacocA DeTbMn NIOpOCTKaMn, a TaKHe IuCaMn, He O3HaKOMNBUsIMNCr C pyKOBOdCTBOM IO KcNlyaTaCNI.

TeHdoJHHbI HaxOHTbcra NOD NOCTOARHHbIM HaJIIODeHNEM, YTO6bI OHN He NCIOJIb3OBaJIH HAcOC B KaueCTBe IrgpuKn.

PnEKnIyatauB npydx
DolHbI coJIIOdaTbcra
noJKeHn DIN VDE 0100-702, - 738.

Питанne arperaTa DoJHKHO OcyuEcTBЯTbCЯЧe3 yCTpoIcTBO 3aUHTHO OTHIOUChENy (Y3O) C yCTaHOBJIeHHbIM TOKOM yTeuKN MaKc.30 mA.

He pa3pewaeTcIcNoJIb3OBAHne Hacoca,ecIn B BOe HaxoJrTCa IIOu.

Pn3KcNpyTaunB DomaunHe
CNCTeMe BOOCha6KeHn
DOJIHHbI CO6JIOdaTbcra
3aKpeJIeHHbIe 3aKOHOM
PpeINHCAnHr OTHOCHTeJIbHO
BOOCha6KeHn
BOOOITBeHn, a TaKHe
NoIOKeHn DIN 1988.

При ЭКслуацин НасOCOBи Нанорньхpe3epByapOB(B ЗавсимоCTNOTKOMпгТаци СуцесытО СLEдУкци OCTaTOчныеОпаCHOCTN，KOTOPbie HeьзЯ ПОЛHOCTBЮУCTpaHNTb， Дажприпяв habд�жаци Меры БeЗОпаСHOCTN.

4.1 Onachocb, cBraHHa c OkpyhaIouei cpeo!

He octabnIte Hacoc noD
doXdEm.He nCnoJb3yIte Hacoc
BO BnaKhbIX N cbIpblx
POMeueHnX.

He nCnoJb3yIte Hacoc BO B3pbIOONaCHbIX NOMUeHnAX

HIN B6JIH3n TOpIOUHX HNdkOcTeH INIra3OB!

4.2topaBbOa npedctablaetco6oonachoctb!

OnacHOCTb!YcTaHOBnTe 6paTHbI KlaPAnHa BCaCbIBaIOUeM NaTpYbKe, (8) YTO6bI He DOnyCTHTb O6paTHoro OTToKa BObl BO BCaCbIBaIOUeJ LHNH.NTO N03BOJNTymHeHbWHTb CJeDyIOUne ONaCHOCTN:

Bpe3yIbTaTe BO3dEInCTBnI RopAeN BODbl MOrYT BO3HNKHyTb NOBpeXDeHnI HRepeMeTHuHOCTb HacOca I COeINHITbHbIX Tpy6oPBOOBo, B pe3yIbTaTe Yero rOpraa BOa MoKeT noCTyNaTb HapJHy. OnachocTb Oxora!

Pn6Opblc 6o03NaeHHeM HWW....ecn DaBLeHne BbIKIIOUeHn IHeBMaTHueCKOro BbIKIOUaTeJI He DOCTNfAeTcR BCJeDCTBHe HeKOppeKTHo BbINOJIeHHbIX HaCTpoEKNI BCJeDCTBHe DeΦeKTA camoro IHeBMaTHueCKOro BbIKIOUaTeJI, BOda n3-3a cnpKyJlauCIN BHyTpN yCTPOICTBa MoKeT HarpeBaTbCra.

Pn60pbIc 6o3NaeHnem P...: yCTPOINCTBO He DOJHKHO pa6OtaTb C 3aKpbITbIM HAnOpHbIM Tpy60npoBODm DoJIbSe 5 MNHyT. Boda, UnpkUnpyUo7a BHyTpN HAcoca, HaRpeBaetc.

B clyuae HeNCnpaBHOCTN OTcoeHNHTe HAcOC OT 3JeKTPnueeCHOcTe N DaIte Emy OCTbITb. Ipeep NOBTOPbIM BBODOM B hCnIpyaTuIO CNEUJIINCTbI DOJHKnbl PPOBepNTb NCpnaBHOCTb fYHKUOHOHPoBaHn yCTaHOBKn.

4.3 Onachoctb, 06ycnoBHeHHa NCIOJIb3OBAHnEm 3JIeKTPo06OpyDoBaHnI!

He HaprabJrTe CtpyIO BObI HeNocpeDCTBeHNO Ha HAcOC Nn DpyRne 3JIeKTPnueckNe y3JIb! OnacHocTb dJa Jn3HN, o6ycloBJIeHHa YdapOM 3JIeKTPnuecknM TOKOM!

He donyckaetc npoBeHne pa60 nO yCTaHOBKe N TexHNueCKOMy 06CnyJHKBaHIO Hacoca, NOdKIOUeHHORO K 3JIeKTpueckO CEtn.

PYCCHNru

He 6epntecb 3a ceTeByIO BnIky BlaJhbIM pyKaMn! Bcerda TAHnte 3a ceTeByIO BnIky, a He 3a Ka6eJIb.

He donyckaIte 3aJOMOB, 3aKIMaHnI Hn Hae3da Ha ceTeBOH uYdInHHTeJIbHbI Ka6JIb; 6peRHTe OT KOHTaKTa C OCTpbIM KpOMKaMn, MaCLOM N BbICOKOH TEMpePaTPOI.

4.4 OnacHOCTb BCJIeIcTBHe deΦeHTOB HnH HeNCnpaBHOCTeHacoca!

Пюверяпт haacoc,В OOC6eHHoCTn CeTeBOI Ka6elb, BnKHy n 3JIeKTPnuYeCKHne DeTaIIHa Ha HAIyue NOBpeKdEHN IpePeKaKDbIM BHLIOUyeHEm. OnaCHocTb dIЯ JN3Hn, OByCNoBLeHnA yIapOM 3JIeKTPnuYeCKHm TOKOM! IOBTOphoe NcNoJIb3OBAHne NOBpeJDeHHOrO HaCOca DOnyCkAeTCra TOIbKO NocIe OCyUeCTBJIeHnI peMOHTa KBaJIuФицIpOBaHHbIMN CNeuJaIInCTamN.

He BbINOJIHnTe
camoCTOaTeIbHbIpeMOHT
Pnp6opa! PpOBedeHne pemOHTa
HaocOCOB n HApOpHBIX
pe3epByapOB (B 3aBnCmOCTn OT
KOMnIeKTaun) pa3peuaeTcR
TOJbKO KBaIIHnΦUnpOBaHHbIMN
CpeuaJIInCTamn.

BHHMaHHe!ДЯTOROTOTo6bI 36eKaTb yUep6a OT BODbl, HAnpIMeP 3aTOnJIeHnI NOMeUeHn, Bbl3BaHHOrO DeΦeKTAmn NIN HeNCnPabHOCTaMn HaCoca:

-П配电CMTOPTNE NOxOJUHMeMepb6e3oNaCHOCTN，HaNP.:ycTPOINCTBOaBAPnHO CNrHaJI3aUNnIINpHEmHbIpe3epByapCfYHKuEn KOHTPOJIA

Pon3BOJNTeJIb He HecET HnKaKoI OTBeTCTBEHHOCTN 3a yep6, KOtOpBIMoKeT 6bITb HaHeceH B pe3yJbTaTe

• INCNoJIb3OBAHnY yCTpoIcTBA He NO Ha3HaueHIO;
• neperpuy3KN BCJeCDTBHe HenpepbIBHO pa60TbI;
  -3KcNJIyaTaUHn Hn XpaHeHnYcTpoIcTBa 6e3 3aUHTbI OTMOP03a;
• CamocToTeIbHO BHeceHn H3MeHEnB KOHCTpyKUnyCTPOINCTBa;POn3BOiNTb peMOHT 3JIeHTpOpnp6OpOB

pa3pewaeTcra Tolbko CneuannCTam-3eKtpnKaM!

-NCNoB3OBAHn3aNaChbIX
YacTeN, He npOBepeHHbIX N He
YTBepKdEHHbIX
PpON3BOIDTeJIem;
- HcnoJb3OBAHnHa HeNoJxOJaIeRo MOHTaXHOr MaTePnaIa (apMaTypa, CoeHNHTeNbHbIe Tpy6OpOBoDbI N.T.I).

POnxOJaMmOHTaXHbI MaTePnA1:

-ВыдерЖиBaET daBleHne (MnH. 106ap);
-TeNIOcToHKn (MnH.100°C)
Pn NcNoJIb3OBAHn
YHINBepCaJIbHbIX NOBOpOTHbIX
(6aJHOHeTHbIX) MyΦT B cIeJIax
HaDeXHOCTn rIaPON3OJIaCNI
DOJIHXbI NCIOJIb3OBAbTCr TOJIbKO
BapNaHTbI NCIOJIHHeHnC
DOnOJIHHTeJIbHbIM PpHHIMHbIM
KoJIbUcOM.

5.0630p

Cm. ctp. 2.ИЗбразжени могут И спльзоватсь в Качестve пимерда BCEx пиборов.
1BbIKIOuateIeIb
2Hacoc
3 HanopHy pe3epByap ("KoTeJ")
4 Bo3dyuHbI Klaanah dIaBHeHn POdNtK
5 Pe3b6oBaI np06ka BODocnBHOrO OTBepCTH
6 MaHOMETPNueckn BbIKIOUaTeIb
7 MaHOMeTp (dAbJIeHne BOIbI)
8BcabsbAiouni naTpy60
9 Pe3b6oBa npo6Ka HAIINBHO O TBepCTnA
10 HanopHbI naTpy6oK
11 MaHOMeTpNueckn BbIKIOuateIb — peryIINPOBkDaJIeHn BbIKIOeHn I bIKIOeHn
12 MaHometprnueckn BbKIOUoateIb peryInpOBka nepenada daBLeHna
B 3aBnCIMoCTN OT KOMJIeKTAuIN

6. BbOaB 3Hcnpnyatauio

6.1 yctaHOBka

YcTpoCTBO CLeDeyET yCTaHaBnBaTb B CyXOM (MaKc. BLaHxHocTb BO3Dxa 80 %), xopoJIOpeBTpRbAemOM, 3aUeHHENOM OT HeNORoDbI MecTe, Ha TOpH3OHTaLBHOM OCHOBAHIN. Heo6xoJIMO o6eCneuHb NaedeHXOCb I yToTHNoBcTB TaKe npri MaKcHmALbHM HanoJIHeHn BODoB. BeHTNJraHOnHbIe OTBepCTnI DOJKNbIb 6bITb OTKpbITb N aUeHneBb OT nonaDaHn rP3n. PacCToHnne Do CTen H dpyrnx npEMeTOB He Mehee 5 cm. 3aunTa ot MopO3a — CM. IaBby 8.2.

TObbln36EkaBbN6paaHm HAcON He DoJIHHe 6bIb JKecKTO PnBUNHeH, OHJKeH eYCTAHABINBATcHAn 3NaCTaHNOJNDIoJHKy.

Pn3KcNpyaTaunHa npydx HAcocdoJKeH6bItb yCTaHOBJeC yETOM BO3MOxHOro NObema yPOBnB OdbI N 3aUnuEh OT naDeHn. Heo6xoImo TaKe npHHMaTb BO BHmHaHe DOIOJIHNTeJbHbIe 3aKOHDoAteJbHbIe Tpe6OBaHn.

6.2 PoiKluoyeHne BCacbIbaIOueJINHH

BHMaHHe! BCaCbIbAIOUaJIINHnOJINHa MOHTNObAITcTaHmOBpA3OM,QTObiOHa HE OKa3BIAJa HNKArOTo MExAHmEeCKOrO BO3DeIcTbIg NIn HanPraJeHHa HaHAcOC.

BnHMaHHe!NcNoJb3yIte npneMHbI 1nBbTp,HTo6bI 3aUHTNTb HAcO OTNecha N 3arp3AHEHn.

BHHMaHHe!YTo6bI B0a He BbITeKaHa N3 OTKIOUHO HAcOa,OB3aTeJIbHOHyKeoibaHKnAnH.MbpeKOMeHdyem YcTaHObky oBaTHbIX KlanAHO Ha BXOqHMOTbEPCTIN BCacbIAOJero WLaHra N Ha BCaCbIbAOUeM naTy6ke (8) HAcoCa. B 3abNCmOCTOn MOpEni, oBaTHbIK KlanAHMQeT bItb yHe yCTaHOBJen (cm. raby 13. TexHnueChne XapaKTepnCTHN).

Bcepe3b60bIe coeHNHeHn CneJeT
repeMtn3IOBpAaC NMOOuBHy yNtOHNTeJIbHn
IeHTb (Pnp61.10-15 oOpTOB B HapabLeHH
XoJa pe3b6bl).Yepe3 HepeMpTeUHbMeCTa
ponCXoHIT NOcOC Bo3dYxa, BpeyltaTe Yero
CHNJaetcRnn PnepKauaTec BCacbHaHne
BOJb.

BcacbIbaOuaa IINHn DOJNHa IMeTb BHTpeHHn DnAmEtp He MeHee 1" (25 MM); OHa DOJNHa 6bITb YCTOuHbA K3aIOMAM H BaKyyMy. BcacbIbaOuaa IINHn DOJNHa 6bITb HAcTOJbKO KOPOTKo, HACOJIbKO 3TO BO3MOHHO, TAK KaC C yBeJIeHNHeM DInHbI IINHn YMeHbJaTeCt MoUHOCt b NpaHn.

Bcabsibaoua JINHJ DOLIKHa NocTOrHHO NOHNMaTbCnNo HAnpBaJIeHmIO KHaCCcy,ДЯTOrO TcObI He DOnyCTInb BO3NtKHOBeHnBO3DyUhBix KapMaHOB.

Heo6xOJHMO oecneuHT bocTaTOHybnoB OBO b, a KOHeU BCaBCIbAOUe IINHHIOJIEN BcERda HaxoNtCB R BOJE. CLeDn 3a TEM, YTOb6 bCacBbIOAou JAMNH He HaxoDInAc h A DHe, YTOb6I NcOK nII rpr3b He nonaIN BHytp. C 3ToI ueJbO MOKET sbITb NCNOB3OBAH PIIABAOU WBODO3aOp, BXOJaW II nepeueHb PnHaIaeXHOCTeH.

6.3 PoiKIOUeHne HAnOpHOro Tpy6oPobOda

Tc06bI cH3NTb nOtePn HAnopa B pe3yIbTaTe TpeHH, BHTpeHHN dAmetp HAnopHOro Tpy6OpBOba DOJKeH 6bTb He MeHbWe 1" (25 MM). Pn INCIOJIb3OBAHN MeHbUxN dAmetPOB, HApIMep, 1/2" MOrYt 6bTb np06JIeMb Ipn 3KcNJIyATAuIN, CBr3aHHbIe C pioxHM YdaJIeHm Bo3DyXa.

BHHMaHHe! HanOpHbI Tpy6OpBoOd D0JIeH MoHTHpOBaTcH TaHIM O6pa3OM, UTo6bIO Hc HE OKa3BaJIbH NkAkoRO MExaHueCHoRO BO3eCTBnH Nn HAnPjaKeHn Ha HAcOC.

Bce pe3b60bIe coeHHeHn CneDyET
RpeMTNIOBaTc NOMOtuYILOTHENTbHOJ
JIeHTb BO I36KeHAnHe NPOTeKaHN BoDj (npNoBn.
10-15 6obopoT B HapnbLeHN XoJa pe3b6bl).

Bce DeTaJIH HAnOpHOro Tpy60npOBoJa DoJIHHbI BbIePknBabT HApOp, INX MOHTaJX OcyuCTBaIeTcK BaJIHΦnUpOBAHHbIMC CneJIaNtCTAMn.

Onachoctb!PnHaJIyHmHe npOyBx DeTaeN HEBaIINPHIOPOBaHOM MOHTAke HApOBHy TpyOONpOBoMDoKMeT JIoNHyt BO BPEM 3KnIpyatau. BBybIBaOuaJcRn oD bICOKHM dABNeHem KJIKoCTb MoKet TpaBMnpoBaT Bac！

6.4 PoiKJIuOeHne H cetn Tpy6oNpOBoD OTObI CHN3NTb BNpaun N Wymbl, HAcOC DOJHKHe NIOHIOUaTbC K CcETn Tpy6oNpOBoD OPi NOMOUs 3laCTNuHbIX CoeINHInTeBbIX WJHaHOB.

B clyuae ctaunohapbIx Tpyb pehomeHdyeTcMoHTnpoBaTb NpBbIe 2 Metpa C npDjBeMOM, YTO6bl o6ceNeHtMbMCnMaJIbHbI BblNyCKB03Dyxa.

6.5 PoiKluoyeHne H cTeH 3/NTaHn

OnacHOCTb,06yCIOBJIeHHaH NcNoJIb3OBAHHEM

3eKtpo60pOyOBAHnI! He HcNoJIb3yIte HaOC B cbIpBX NOMeueHNx N BblOJIHnTe CNeDyUOuHe yCIOBnA:

Hacoc pa3pewaeTcnoKIOUaTb TOIbKO Kpo3eTKaM C 3aHTbIM KOHTaKTOM, KOToPbIE HaJIeKaUm

6pa3OM yCTaHOBLeHbI, 3a3emLeHbI npoBepeHbI.
- HanpJxHHe cTeH, yAcToTa n npEdoXpaHHTeJIb DOJIHHbI COOTBETCTBOBaTb TEXHueCKHM XapaKTePncTnKaM.
-Питаяне arperaTa Должно OcyшесТьЯТбяЧepe3 yCTpoIcTBO 3auntHOrO OTHIOUChENy (Y3O) c yCTaHOBJIeHHbIM TOKOM yTeuKN MaKc.30 mA.
-3JIeKtpnueckne coeHHeHna 3aIpeaaetcOnyCKaTb B Body, OHn DOJIHHbI HaxOHTbcB 3aUHHeH0NOT aTOJIeHn3OHe. Pn nKcIIpyaTuIN BHe NOMeH Neu OHn DOJIHHbI 6bITb 3aUHHeHbI OT 6pbI3r.
- YdHnHTeBbIe Ka6eHn DOJHHbI NMeTb DOCTaTOUHOe NOpeHuOceCeyHne JNl. Ka6eHn DOJHHbI 6blTb NOHOCTbIO pa3MOtaHbIC 6apa6aHa.
- Heo6xOaHMo c6bIoudaTb HaunOHaJIbHbIe IpeIINcaHnI NO MOHTaKHy UcTaHOBKe.

6.6 YcTaHOBbKa DaBHeHnNoDnHTN (ToIbKO HWW...)

Ipeep BBODOM B3HcNJIyatauHIO HAcTpoTe daBHeHne NOpNTKn.CM. rnaBy 9.4.

6.7 3aNoJIHeHHe HAcOca N BCacbIbAHne

BHHMaHHeI Prn KaKdOM HOBOM NOJIIOHcEHNI NIN pYteHHe BObl HEO6XoHMo 3aONJHb HAcO BDOi.

3KcnIyataaHACo6a 6e3 3anIOJIHeHnB OBOO
pa3pyuAeT Hacoc! Ira rapaHTNI
6ecnepe60HnP aBoTo bPeKoMeHdyem npi
npEBOM BBODe B 3KcNlYATAuTHO ObecneHTb
DOCTaTOHbI 3a6Op BODbI DnI NOHOrO
ydaJIeHOB Bo3Dyxa N3 CNTEmbl.

• BbINHTIpe360byIO npO6ky HAJIIBHOOTBepCTn(9)BMecTe CynIOTHHHeM.
• MeIaIeHNo 3aJIbBaTe YIcStyO Body, noka HAcoc He HAnOpIHITcA.
• ChoBa 3aBHTInTe pe36bOByIO npO6Ky HAHbHO TO TBepCTN (9) BmEte C VJNtOHHeHEM.
• OTkpoIte HAnOpHbI Tpy6OpPObOg (NoBepHnTe BOOnpOBoDHy bKpaH INI cNOII,TObSb Ipn BCaCbBAHN MOr BByXoDITb BO3dVx.
  -BKIOUHTe HAcOC (CM.7.)
• Ecnln BOda BbIXoDn PabHOMepHO, HACOC TOBOT K 3KcNpIyatau.

Yka3aHHe: BCacbIbAIOUIO LINHIO 3aONJHrTb He Tpe6yETc, TAK KAK HACOC CAMOBcAcBIAOuHm. B 3aBHCIMoCTN OT LInHb I NAmEtPa LINH MoHTe PnOITN HEKTOPOE BPEM DO TEX NOP, NOKa 6ydtc Oo3aHO Heo6xOdHMoe DaBJIeHne. ECnn Bbl XOTNTe COKpATNTb BPEM BCACbBaHn, yctAOHbTE O6pTaHb Klanao HA BxOJHOM OTBePCTN BCACbIbAOUero UJHaHra N TaKHe 3aONJHnTE BCacbIbAOUIO LINHIO.

7.3Kcnnyataun

BHMaHMe! HAcoc NInHNA BCaCbBAHnA DOJKNbI 6bTbN POnKlIOHeHb I 3aONJIHeHb rnaBy 6.).

BHHMaHHe! He donyckaetcpa6oTa hacocae 6e3 zanOHHeHH. HeoXoDnMo NOCTOHHoe. Hmwe DOCTAOHORO KOJIMEcbTA
ekAHBaemOn Cpebl (BObl).

9.1 Hacoc he pa6oTaet

CetBoe HapRJaHHe OTCyTCTByET.
IpoBepBe TnepeKIOUaTeB BHJI/BbIKJI, Ka6eJI, ceTeByo BnIKy, po3eTKu npeoXpaHHTeB.
- CeTeBoe HaprrKeHne CInuKOM Hn3Koe.

• IcnoIb3yIte ydHInHTeJIbHbI KAb6Ib C DOCTaTOHbIM NOpEpeHbIM CeEHnEM XINJ.

• Dnuratelb neperpet, cpa6otana 3aunrta Dnuratela.

IocLeOxJaKeHnHaHCoC BkJIIOHTcCHOBa ABTomatHeCN.
-ДьОБЕСЕЧЕВДОCTАТСН�В BHTNЛУЦИDEPКNTE BHTNЛУЦИNOHYYU шель ССБОДНО.H
- Co6IIOJaTe MaKcHMaJIbHyO TeMnepaTpyo nOaDaI.

PYCCHNru

3NeKtpoDbBnraTeIb rHyNT,He 3ayncKaeTcA. Tpe6yETcpeMOHT,CM.rJaby11.
Hacoc 3acopnncnn HncnpaBeH.

Pa36epnte n npOHCTnTe 3JIeKTPoDBrInaTeIb. IpoHCTnTe nn 3aMeHNTe dHfOy3Op. IpOCHCTnTe nn 3aMeHNTe paOooey KONEo.Cm.rnaBy 11.

-Давлиец Влини / Hab BXOde Bblwe dablenHn BkIOUeHn HaCOca.

• PoiHIOUHTb peDyKTOp, cm. rnaBy 2.

9.2 Hacoc BCacbIbAeHT HenpaBnIbHO nn pa60aTeOueHrPOMHO:

• HexBaTka BoDbI.

• Y6eHntecb, yTo HMeetcA DoCTaTOHbI 3anac BObl.

Hacoc HeoctatoHOn3aONHeN BDOJ. -CM.rnaBy6.7.

HerepmetnHa BcacbBaHoaJAAJIHHIA.

-06cneybeTepreMetnHocbBCacbIbaoueJINHH,3aTAHHTpe3b6oBbIE COEINHEHNA.

CINUKOM60lbwABarBbICOTaBCaCbIBAHNA

• C6bIpaTe OpaHnueHn NO BbICote BCaCbBaHn.

• YcTaHOBnTe 6opbThbM KlaNaH,3aNoHNTe BCacbIBaOuO LyHHIO BOdOI.

ΦnIbTp BCaCbIBaHOseJIINHH (DOnOJIHNTeJIbHOe OobOpyOBoAHne)3acOpNlscr.

• PpoHCTHe nIIN, npn Heo6xOaMocTN, 3aMeHHTe.

• O6paTHbI KlaanAH (DOnONHHTeNbHoe 06OpydoBaHne) 3aBIOKINPOBaH.

• PpOuNCTHe Hn, npH Heo6XoHMoCTn, 3aMeHHTe.

• YteKa BObi MeKdy 3JeKTePbDnRaTepaIeMn HAcOCOM,TOpcEBoe yNtOHeHHe HerepeMeTuHO. (He3aHuTeBHaYteKa BOB1 (MaHC.30 Kaenb B DeHb) oycLobHeHa KOHCTpyKnei TopcEBOrO yNtOHeHna.

• 3aMeHnTe TopeBoe yIIOThHeHne. Cm rIaby 11.

Hacoc3acopnIcnnHeNcnpaBeH.

• CM. rnaBy 9.1.

9.3 DabJIeHHe cIINIKOM HnI3Koe HInHacoc pa6oTaet HenpepbIBHO (NoCTOraHHoe BKNIOHHe/BbIKIOHHeHne):

BcacbibaQuaJINHnHeRpeMHTuHaNnY BbICota BCacbibaHnCmUKOM 60JIa.

-CM.rnaBy9.2.

Hacoc 3acopnncnn Hecnpabeh. -CM.rnaBy9.1.

• HWW....: HeBepHo HacTpoEH MaHOMeTpueckn IpeKJIIOuataTeIb.

3aMepbTe DaBnHeNBEHIOUeHIN BbHIOUeHIN pIn NOMOUs MAHOMeTpA (7) INPOBepBe 3HAeHINrCm. rIaby 13. TexHMueChne XapakTepuCTHN. Bcnyae Heo6XODIMOCTHn HAcTPOIKN o6paTIteCb B KJIHeHTCHyO cLyK6y KomNaHH Metabo.Cm. rIaby 11.

HWW....: Hacoc cpa6aTaBbAeT yKe npn He3NaHTeJIbHOM (OK.0,5I) 3a6ope BObl.

• PpOBepeTe, He cHnUkOM Hn H3Koe dABLeHeNc NOPTNH B KOTne. Pn HEOxOdMocT yBEnuHbTe daBJeHne.Cm. rnaBy 9.4.

• HWW...BODA TeuETn3 BO3duHoro KlananaHa.

• Pe3nHOBaI DnaΦparMa B KOTne HeRepeMTeuHa; 3aMeHnte. Cm. rIaby 11.

9.4 yBEnuyeHne daBnEHH noDnHTKn (ToIbHO HWW...)

EcnHacoc-cTeueHemBpeMeHH 3anyChaeTc4daKe npH He3HaHTeHbHom 3a6ope B0bl (Ok.0.5n),Heo6XoMnO BOCCTaHOBNtB KOTIE DaBHeNE NOHNTHK.

YkaaHne: daJIbHeHne NOJNTKn KOTNa (daJIbHeNc BO3dya) He n3MePReTcMaHOMeTpom (daJIbHeNc BObl) (7).

1. N3BNEKNTe BUNKy H3 pO3eTKN.
2. OThpOHTe HAnOpHbTyPbOpOBoD (noBepHnTe BOOpOBoHDbKpaHnnI conNo), NOHIOCTbO CNYCTne BOy.
3. OTBnHTHe nlaCTNKOByIO KpbIbHcy Ha TopceBOB CTOpOHE KOITJa; 3a HeN HaxoDNTCA BO3dyuHb BEHTnHb.
4. NODCOEHNHTE BO3DyWHbH HACOC INN WJAHKOMPpeccopac HAKOHeHHKOM

HakayBaHHaHH MaHOMETp K BO3dyuHOMy BEHTNIIO.

1. HanaHbaiTe do DocTHHeHnepDyCMToPHeHOro DaBHeHnNoDnHTKn (1,56ap;cm. rIaby 13.TexHneckheXapahtepNCn).
2. Choba nokloute hacoc n npobepbte ero Функшонрованe.

10.Пинадлесноctn

NcnoB3yTe ToIbKO opnHaJIbHbie npHaJNeXHOCTN KOMNaHH Metabo.

NcnoIb3yIe ToIbKO TaKHe npHaIeJHocTH, KOTOBIE OTBeaIOT TpeBOBaHm I napaMeTpaM, nepeHCJIeHHbIM B daHHOM pyKOBoDCtBE NO 3KnLjayatauIN.

PonHbI accOpTmEHT npHaJNeJHoCTeM CM. HacaiTe www.metabo.com JUN B KaTanoRe.

11. PemohT

OanachOCTb!PnoH3BOJNbpeMOHT daHHOro arperata paaseaTaTc TOLbKO cneuaHNTam-3IeKTKnAM！

Дяремота порунmetaboобашатесь berHOHAHbOe npEcdTabTeBCTBO Metabo. Adecaam. Na caite www.metabo.com.

Ia nepecbiHK: noHocbHO onOpOHnTe Hacoc H KOTe (CM. rnaBy 8.3).

IpeuHn 3anaChbix yacteM MoKHO 3aRpy3ntb c caTt a www.metabo.com.

12.3aunTa OKpyHauouei cpebl

C6bnoaTHe HaunohalbHbe npabnla 3KoIorueckn 6eOnachOytnuN3auu n nepepa60THN OTCnyHNBWH INHCTpyMeHTOB, ynaKoAKn n pinnadneXHcOteN.

YnakoobOHyIe MaTePnaJIb IyTNIN3NpyIOTcB COOTBECTBmC INX MapKnPOBKO CORNACHO KOMMyHaJIbHM PnABnAM. DOnONHITeJIbHYIO HHΦOpMaUNO MoKHHO HAHTN Ha cante www.metabo.com B pa3dene «CepBNC»

ToIbKO dIraCTpaH EC: He BbIbpaCbIbAte 3JIeKTHPOINHCTPymeHTbBMECTc b6bTOBbIMN OTxOdAMn! COrlacho EBpOneckoI DnpeKTHBe 2012/19EU no OTxOaAM 3JIeKTHPmEChORo n 3JIeKTHPOINHO O6OpyDObAHn H ee npImMeHeHIO B paMHax HaunOHalbHO 3aKHO@ATEbCTBa 6blWHe B yNtOpe6JIeHN 3JIeKTHPOINHCTPymeHTb NOJNeKaT pa3JeNbHOMy c6Opby C ceJIbNo Ix NoCJeNyUoiEe KcONOLrueckn 6be3onachno nepepa60tKn.

13. TexHueckne xapakTepeNCTHH

PorrcheHnK daHHbIM, npBBeHeHbIM Ha cTp.3. OctaBnem 3a co6oI npAbo Ha TexHueckne n3MeHeHn.
「pαnuecka xapaKTepeNCTHaHacoca (DnAarpMaM, Ctp. 3) noKa3bIbaeT erO npOn3BOiNTeBbHOCTb B 3aBNCIMoCTn OT Hanopa (Bbcota BCacbIbAHn0,5 M N BCacbIbaIOuŋ m IJahr1"
E =3JIeHTPOHnKa/3aunTaOT cyxOro xoJa V =6paTHbI KIanah HA BCacBIAoUeMaTpy6ke (8) HacocA
K = cTeBOI KaBebIb
U HapnpeHne cTeN
T = yactota
P1 =HOMHaJIbHaRA MOUHOCTb
Pstandby=pacxOdBpeKHMoeOKHdAHNA
HOMINHaJIbHbI IN TOK
C = pa6o7n KOHdeHcaTOp
n =HOMHHaJIbHaJ CKOpOCTb BpaUeHHA
Fv,max =MaRC.npoIN3BOAnTeJIbHOCTb
h,max =MaRC.BbICota noDaun
Fp.max =MaKc. daBneHne noDaun
p1 =MAHOMETPNUCHKNEpeKELIOUATELeB: DABNEHE BKNIOUEHNIA
p2 =MAHOMETPNUChNpehKIOuOATEb: DabJIeNEOTKIOUHeN
Sh.max =MaKC.BbICOTa BCacbBaHnA
Stemp =MaKc.TeMnepaTpyaNoDaH
Itemp =TemnepaTypa OKpykaUoce npdebl
S1 =Knaacc3aunTbIOTOpbl3r
S2 =Klaacc3aunTbI
S3 =Klaccn3OJIaIIN
Mp =MaTePnAaN KOpnyca Hacocca G= CepBb+HyTg

MR =mATEpnaBalaHacoca

Mw =MaTePnA1 pa6Oyero K0leca Hacocca

Ds =BHTypeHnRA pe3b6a BcacbIbaOuOero naTpy6Ka

Dp =BHTPENHpape3ba noDKIIOHnA HNAPHOPLINH

TV =eMKOCTb KOTJia

Tp,max =MaKc.ДaBHeHne B KOTNe

Tp.1 =aBHeHne NOdNTHK KOtla

A =pa3Mepbl:

LpA =ypoBeHb 3ByKOBOrO DaBHeHn

LWA =ypoBeHb 3ByKOBOM MOUHOCTN

KpA, KwA=HO3ΦΦHnueHNT norpeuHocTN

L_WA(G) = rapaHTnIOBApAHbIy yOpeBHe b3yKOB0MouHocT corlacho 2000/14/EG

IcnoJb3yIte CpeICTBa 3aunTbI opraHOB cnyxa!

EAC

HΦopmaunn nnoynateJIA:

CepTHΦHKaT COOTBETCTBIA:

Ne TC RU C-DE.5J08.B.01787, cpoK DeiCtBna c 10.10.2018 no 09.10.2023 r., ByidaH opraHOM no septHnФинчи npOdykUn «IBAHOBO-

CEPTNΦHAT»OOC«IbAHOBCKNΦoHd
CepTnΦHauaun»;Adpec(Iop.ИФАТ.):153032,
PocchckaФepepaun,IIbAHOBCKaOBsI,г.
IbAHOBO,yu.CtaHNOCTpONTeJIe,I.1;TeI.
[phone];E-mail:[e-mail];ATTecTaT
aKHeNTaUNNeRA.RU.11BLO8OT24.03.16

CTpanaH3rOToBJeHn:KHTaI

Pon3BOnTeIb: "Metabowerke GmbH",

Metaboallee 1, D-72622 Nuertingen, RepmaHnA

HmnpTeB Pocn:

OOO "MeTa6o EBypa3n

Pocn,127273,MoKBa

yI. Bepe3oBa aIner, I 5 a, cTp 7, oΦnc 106

ten:[phone]

Data npOn3BODCTBa 3aunHpObaHa B 10-3NaHOM cepHnHOM HOpeme IHCTyMeHTA, yKa3aHHOM Ha ero IwnbIKe. 1 aIuPpa Oo3NaHaayr oT, HapnMep «4» o6o3NaHaayeT, YTO n3JeIne npOn3BeHeHO B 2 rN 3 uNpbl Oo3NaHApOT HOpem Mecaua B rOy D npOn3BODCTBa, HapnMep «05» -MaJ

CpOK CnyK6bl N3dEInna CoCTaBnReT 7 ne.T.He peKOMEHdyetcK KcNlPyatauIN NO HCTeUeHN5 5IET xpaHEnn C DaTb I3rTOBLeHn 6e3 npedBapntelbHn npOBepKn (Daty H3rTOBLeHn CM. Ha 3tNkETHe).

OprihaIbHa IIncTpyKciJ 3 ekCnLyataci

1.Дeнларuaи npo BiDIOBIDHicTh

3i BcIEO BiIDNOBIAIbHicTIO 3aARbIeMo: Ii HAcOCH/ NObyTOBI HAcOCHI CTAHJIABTOMaTHHI HAcOCHI cTAHJII 3IeHTNfikAciEIO 3a TINOM I HOMePOM MoJIe *1) BiNDoIBaIObY CcIM DIouHM nIOJHOHNHMMIpeNTHB *2) i HopM *3).TexHiHy DOKyMeHtauIO dNIA *4)-DIN. H CTOp.3.

2.BnKOpNCTaHHa npH3HaueHHaM

Lepnpctpi npn3HaueHm dIy nOaHn yHCToI BODn pnp 6OcLyOBvBAHNb HdyNHKB i caDobNX dIiHOK, dIy DOuSyBAHH a3pOvBaHH, JK CBepdIOBnHHn HACOC, HACOC dNpePONMnyBAHH DooBHX i TexHiHNNX BO, dN BiDnOMpyBAHH BoN 3 baceHIB, CTABKIB i pe3epByapib.

Hacoc He po3paxoBAHn Ha TaKi yMOBn:

• Tpmbana ekcnnyataui

• npomnclobe afo npopeciHne BnKOpNCtAHH

Hacoc He npn3NaueHm IdaI nodaI TaKnx pIDH:

• NITHA BODA

-xapOBI npOdyKTn

• COLOHA BODA

• Bn6yXoHe6e3neHry, rOpUci, arpeCnBHi a60 He6e3neHHy dIa 3doPob'MaTePiaJN (HanpKnAd, XIMiKAtN)

-pidHH3 TemnepaTpyo Bnue 35°C

• BODa 3 BMICTOM nicky n a6pa3nBHi pIDHHI

• xlopBMiCi piDHHn (Happ., Boda 3 baceHy) HAcoc He npN3aHcEHHn pIbBnUeHOrTO TchCy: npnPiKlIOuEHHI HacocA do TyboNPoBOy, 100 3hAoXoHbTcBnPd TCHKOM, noTropHbNnonpeepDbHo BKIOHHe peykTOp. MaKcMaJIbHn TnCK B CNTEMI He NobHHe npeBbUyBaTHn BkA3aHm MaKcMaJIbHn TnCK HacocA. CnI DbpaxOByBaTHn, 100 BxIDHn TnCK CyMyETbC3 TnCKOM BIMKHeHHH HacocA!

Lepnad He NOBHe HBNOPcTOByBaTNC OOCaMn (BKNIOUaOuN DItei),KHe CnpOMoKHi BNOPATNC3HIMBCNLYCBOIXO6MeXeHXF3HNNX,NCNXUYHX a0CeHCOPHX MOHJBOCTE,aTAOKB CNLYBIDCYTHOCTI3HaHB Ta/a0docbipy.

3abopohreTcbc camobIbhe BHeceHHaMIBKOHCTpykuHacocca，aTAKOHBnOKPcTAHNDEtaJIe，IO He npoiWNBnpo6yBaHHi I HeIOZbOBJEHIO 3ACTOcYBaHHaBnPOOBHHOM.

Byb-He BHKOpNCTaHH HAcoca 3 NopyWeHHM npaBnHOIe EKnPlyataJIi BBKaHaTcBc BHKOpNTAHmHE 3a NpIm3HaeHHM,Ke ME MOKE npIN3BeCTn DO HenepeD6aueHHx 36bNTKIB Ta TpABM! 3a NowKOdKeHHN, BKNlHAnHi eCNPlyataJIeEO He 3a NpIn3HaenHHM,Hece BiNDoBIaNbHcIcTB BHKIOUHO KOpNCTyBaH.

Heo6xioHO DoTpmyBaTncb 3aRaJIbHOnpHnHrTnx npabIN 3anaOcirAHnHEuacNHm BInpaIqXAM, a TAKoN npabIN TehKn 6e3neKn, pInBeDeHNB Cui i nCTpykuii.

3. 3araIbHI npaBnla TexHIn6e3neHH

ДяBaоoiВlaacHoi6e3neKиI3axNCTy
PnIaDyBIDyUHKoDKeHb
DOTpMnyTeCbBkA3iBOK，IOBdMIChHi
LIMCnMBOLOM!

DNEPEDHHEH - 3JUJIO 3HHKHeHH 3NHYOTPMAHN TINECHN YUKOKeHb OHHTAte TUHOCTpyuIIO 3

ekcnnyataa.

NONEPEDHEHH - O3haomtec3 Ycima npabnamTa Bha3iBkAm 3 TexHNI 6e3neHN. HeodpumHaN npaBn Ta BkA3iBOK 3 TexHNI 6e3NeK MoHe Pn3BecTu DO yApdJeEHTPNHm CTpyMOM, NoKeKi Ta/a60 TAKHX TiNECHX YWKOHDHeB.

36epiraIte npabnla Ta Bha3iBHN 3 TexHIHb 6e3neH ymaBHyTHbO R BHOpNCtAHN. IpepeabaiTe baw hacoc Tlbn pa3om 3 uMmDOKyHMeHTAMn.

Inhopmaqno3haeHaBuiiHCTpyK3 EKpIyatauHACTYNHIM YINHOM:

He6e3neKa!IonepeDkeHHra npo He6e3neKy TpaBMyaHHa a6o Kdo n da IOBkIIJIA.

He6e3neka ypaKeHHN eIeKtpnHMM cTpyMOM! IhonepeJKeHH npo He6e3neKy mByaHH 360ky eIeKtpnH.

Ybara!PonepeJxHn npoMOHnBi MaTepiJIbHi 36nTkn.

4. CneuaJIbHi npabHla texhiKn 6e3neHH

He Do3BOJAEbCByNKOpNCtAHHn HaOc0a DiTbMn iPiDiNITkAmn, a TaKoX OOC6AMn, 10 He O3HaONMIINc3 KepiBHNCTBOM 3 EKcNlyaTaui.

CniKnyTe 3a DiTbMn, 06 BOHn He BnKOpNCTOBvBaI npIlaD Ira irop.

PnBHKOpNCaHHi y CTaBKax Tpe6aDToTpmyBaTncnnoJIOKeHb CtaHapTy DIN VDE 0100-702, -738.

ПидкюаTe npILAДdo
eIeKTpOmepeKi uepe3 npncTpI
3axnCHoro BiKJIuOeHn（ПЗВ）3
MaKcIMaJIbHm CtpymOM BHTOKy
30MA.

HeD03BOJRAETbCBNIKOPNCaHHHaocca,AKUoYBODI3HaxOJaTBcRJIIOH.

PnPiKluoyehHi Do NObyTOBoi
CNCTeMI BODOnocTaayHn
NOBHHI BIKOHyBaTnC
NIOJKeHHaKOHy BiHOCHO
BOOOnocTaayHn i
BOOIBBeDEHHa TaHOx
NoJKeHHa DIN 1988.

PnEcknyatauiHacocib I Hanipnix pe3epByapib (3aJIeJHo BID KOMNLeKTAuii) icHyIOTb HAcTyHi 3aIIuKOBi He6e3neKn, RKi He MoJHa NOBHCtIO yCyHyTN, HabiTb BHHBUn HaJIeKHi 3axOJn 6e3neKn.

4.1 He6e3neHa, NOB'3aHa 3 BnINBOM HABKOLHbOro cepedobuca!

He 3aIinwaIte Hacoc nID doouem. He BnKOpncTOByIte HACOC y BOIOrnx i CnpNx npMiuJeHHx.

He BnKOpncToBvIte Hacoc y Bn6yXoHBe6e3neuHx npimiueHHa6o n6n3y ropouhns pDIN Ta ra3iB!

4.2 He6e3neKa, NOB'3aHa 3 rapraQIO BOdoI!

He6e3neka! BcTaHOBiTB 3BOPOTnKlaanHa BCMOHTyBaJIbHOMy NaTpHy (8), Uo6 3aNo6irTu 3BOpOTHomy BiTOkY BOuY BCMOHTyBaJIbHi JInii. Lc Do3BOJNTb 3MeHUnTH HaCTynHi He6e3neKn:

Tapya Boda MoHe npn3BecTn do
noWKoJKeHHa60
HerepMeTuHocTi Hacoca i
3'EDHyBaIbHnx Tpy6OpBoDiB,
BHacIIOK YOro rapya Boda
MOHe NOCTyNaTH Ha3OBHi.
He6e3neKa onIKiB!

Hacocn 3 no3haueHHm HWW....
Rkso TnCK BiKJIIOUeHH
MaHOMEtpyHoro BVIMKaHa He
DOcRAeTbcB HAcIIOK
HEKOpeKTHnx HaJauSTyBaHb a6o
DeΦeKTy camOro
MaHOMEtpyHoro BVIMKaHa,
BOda B pe3yNbTaTI BHyTp1iHhBoi
CIPKylaui ycepeDnHi npncTpoIO
MOHe HarpiBaTnCra.

Hacocn 3 no3haueHHm P...: TpnbaiicTb eKcnnyaTauii Hacoc a npn 3akpnTomy HanipHomy Tpy6oPBODi He NOBnHa nepeBnuuYbaTu 5 XBnInn.Boa, uNPKUIOUa ycepeDnHi Hacoca, HarpiBaCTbcra.

Y pa3i HecnpaBHOCT BiE'EnHaHTe
Hacoc BiE eIeKtpnHoi MepeXi i
daIte Nomy oxoOnHyTN. Peep
NOBTOPHM BBeDEHHM B
EeCNyatauIO DopyuITb faxIBcM
peBipNTn CnpaBHiCTb
fynkuioHyBaHH npnaLy.

4.3 He6e3neHa, NOB'ra3aHa 3 eIeKtpnko!

He HanpaBnIe CtpymiHb BODn 6e3nocepedHbO Ha Hacoc a6o Ha iHwi eIeKtpnHi KOMNOHEHTN! He6e3neKa dJa JHTT, NOB'ra3aHa 3 UpaKeHHm eJIeKtpnHm Ctpymom!

He donyckaetbcnpoBedeHnro pObit 3 MOHTaKy i TexHiuHoro o6cIyROByBaHHra Hacoca, nIiKIOueHOro do eJeKtpnHoiMepeKi.

He 6epitbcra 3a MepeKeBy BnIky BOLOrHM pyKaMNI 3aBKnTgHiTb 3a WTeNCEJIbHy BnIKy, a He 3a Ka6eJIb.

He donyckaTe nepeHHaHH, 3aTnCKaHH, po3TayBaHH a60 Ha3dy Ha Ka6eJb JnBLeHH i NOOBKByBaHbN Ka6eJb; 6epeKiTb BiD KOHTaKTy 3 roCTpMn KpOMKaMn, OJNBi I BVCOKHX TemepaTyp.

4.4 He6e3neHa BnacIioK DeΦeKTIB a6o HecnpaBHOCTeHacoca!

IpeBipraHte Hacoc,OCO6nBO Kaebb JnBHeHHaTeKeepi

YKPAIHcBAuk

eNeKtpnHi DeTani Ha HaaBHCtbyWKoJKeHb Neped KOxHbM BKNUoyehnM. He6e3neKa IyHNTTa, NOB'raHa 3 ypaKeHHa M eNeKtpnHm CTPymOM!

IOBTOPHe BnKOpNCaHHN PONKOJKeHOro HAcOca DONYCKaETbcr TIlbKn NiCJIpeMOHTy KBaJIiΦIKOBaHNMI faxIBaMn.

HeHAMaraTecra camocTiHOBiDpeMOHTyBaTH HAcOC! PemOHTHacociB i HanipHnx pe3epByapib(3aJIeKHO BiKOMnJIeKTAciI)do3BOJRAETbCra TIIbKNKbaIΦIKOBaHmN φaxIBzAymN.

YBara!ДЯTORO，06
yHnKHyTN3bNTkIBBIDBOHN,
HaPnKlaJad3aTOnJIeHHra
IpMIiUeHb,BNKlnKaHORO
deΦeKTamna6o
HeCnpaBHOCTaMnHaCOca:

-3anlaHynteHaJIeKHi 3axOdi 6e3neHn, HApnKlaIa aBapiny CunHaI3aIIO a6o npnMaJbHni pe3epByap 3ФyHKciEIO KOHTpOJIIO

Bnpo6Hn He Hece BiIDNoBIaIbHiCTb 3a 36HTN, BHKInKaHI HaCTyHHMn DiAMn:

-BNKOpNCtAHHHaHCoCa He 3a npn3HaueHHM;

• nepeBaHTaKeHHBHaCJIIOK 6e3nepepBHOIpo60Tu;

-ekcnnyataaia 6036epirahnHaHacocaa63axncty BiMop0sy;

-camocTInHe BHeceHHa 3MiH B KOHCTpyKciH Hacoca.PeMOHT eKeTPOiHCTpyMeHTy NOBHeH 3diCHIOBAtncra TIlbKn KBaJIiΦIKOBaHmN φaxIBqMaMneKeTpknAmn!

-BNKOpNCtAHH3aNaCHHX qactnH,He nepeBipeHnx i He 3aTBePdKeHx BnPo6HkOM;

-BHKOpNCtAHHHeNpNiDaTHOROMOHTaXHOrMaTepiany (apMaTypa,3'eHyBaJIbHiTpy6oPBoDoToio).

HaJIeKHi MaTepiAn IJn MOHTaKHNx pO6iT:

-BNITpmyIOTb TnCK (MiH.106ap)

Pn BnKOpNCaHHi
yHIBePCaJIbHNx NOBOPOTHX
(6aNoHETHNX) MyΦT dJa HAdiHoI
rIdpoIsOlauci II NobHHI
BnKOpNCTOByBaTnCra TlNbKn
BapiaHTN BnKOHaHHa3
IDoDaTKOBnM PrNTnCKHM
KilbEm.

5.OrnA

Hb. cTOp. 2. MaJIOHN MOHyt b CnyHHTN pRHKaIOM DJI BCIX MoDEJIeI.

1IpeemKauYBIMK/BIMK

2Hacoc
3 HanipnpeepByap (peepByap)
4 NobitprnH Klaanah dny TnCKy nDxHnBHeHH

5 Pi3b60Ba npo6Ka BOdo3nHBHO O TBOpY

6 MaHOMeTpNHH BmHKaay

7 MaHOMeTp (TnCK BODN)

8BCMOKTyBaIbHn natapy60

9 Pi3b6oBa npO6Ka HAnIBHOrO OTbOpY

10 Hanipn nnatpy6o

11 MaHOMeTpnuHn BmHKaaypeyIIOBaHH TnCKy VBIMKHeHHN BIMKHeHH
12 MaHOMeTpnuHHN BmHKaaypeyIIOBaHHn nepenady Tncky

*3aJIeKHO BID KOMnJIeKToaJI

6. BBeDeHnB EeknIyatauio

6.1 BCTaHOBJEHH

Pnncpti cnid BCTaHOBIOBaTHrop3oHTaIbHo, B cyxomy (MaKc.BoIorictb nobITpr 80%),do6pe npOBtPOBAHOMy, aXnueHEOMy Bi dAtmocepHnx BnINbMicui. Heo6XiHO 3a6e3neuHTn HadiHCTb CTNIKCTb TAOH pNp MaKcIMaNBOMy HanOBHeHHPiNCPTPO BOIO. BeHTnJIaHI OTBOPN MAOTb BYKn BiDkpNTI N 3axuHi BID notpannnHn 6pyd. BiCTaHb Do CTIH Ta iHUNX npedmetB-He Me nue 5 cm 3axnCT BiD MOpO3y -INB. po3dn 8.2.

LIO6 yHNUKHTy BIBpaui, HACOC He MaE 6yTN JOKCTHO PnIRBHNHEIN, BII NOBHeH BCTAOHIOBATCN Ha eIaCTNHy nIKnLaNDK.

PnEckpnyatau y cTaBkax npncTpiMae 6yTN BCTaHOBJIeHm 3ypaxyBaHHm MOJINBOrO NiIMy pIBH BOi i 3axNueHn BiD naIHn.

Heo6xIDHO TaKOH BpaxOByBaTN DoaTKOBI BmOri, No3HaueHb 3aKOHoDaBvNx aKTax.

6.2 PIIKHOUeHHB CMOKHTyBaIbHoiJIiHi

Ybarla!BCMOKHTyBaJIbHaJIiHIA M6 ByTN 3MOHTOBAHaTak,IOB BOHA He YHINHa IHIKOI MEXAIIHOI DII a60 HAnpyrHa Ha HAcoc.

Ybara! BnOOPMCTOByTe npHMaIbHnI 0iBtP,io63axHCTHTn Hacoc BiNicky i 3a6pyDHeB.

Ybara！Uo6BoJaHeBNTiKaJa3 BjIKJIOeHOro HAcocA，O6OB'3KOB0
NotpiEben3BOPOTnKlanAna.MpeKOMeHpyEmo BCTAHOBJIeHHN 3BOPOTnHXKlanAnaHbHaBXIDHomy OTBOpI BCMOKTyBaIbHOro WlaHraI ha BCMOKTyBaIbHOMy naTp6ky（8）Hacoca.
3aENKHO BiM OMeI，3BOPOTnKlanAnMoKe 6ByT BBe CBAHObEnHn（INB.p03d13. TexHiHiXapAKTePncTHKn).

Yci pi3b6oBi 3'εdHaHH MaOToB 6yTn
repMeTHaBOH aI dONOMOTU yuJIbHOBaBbHOi CTPIH (10-15 o6ePTAHb H anpMpy p3b6).
Yepe3 HerepeMeTHuHi Micu BIDbyBaETBCR
PiDCMOK TYBAHNA NOBITPBA, BHACIIOK YORO
3HNKcTBcA BOO pINNIHReTBC BCMOKTYBAHH BOIN.

BHytpiHmI qIaMeTp BcMOHTyBaIbHOI IiHII NOBHEN ChIkaTn He MeuHne 1 (25 MM); BOHA Mae ByTN CTiHaK Do 3aJIaMyBaHb I bAkyMy.

BCMOKryBaIbHa NiHrMa 6yTN HAcTINbKn KOPOTKO, HAcIKJIbKn CE MOxJIbNO, OCKIIbKn 3i 36JIbUeHNrM DOBxHn LiH II 3MeHJyETcBc NOTyHKHtB NOHaHH.

BCMOHTyBaIbHaJIHIO NobHHaNocTIIHO nIDHIMATNCY HANPMy DO HAcoca, 106 He OONYCTNTBHNKHeHNEHNOBTIPrAnx KIWeHb.

Heo6xHIO 3a6e3neHTn DoCTaThe NiIBeEHNA BODi, a KIEcB BCMOKTYBaBHOJI liHH NOBIHEH 3aBHKn 3haxOHDNcR yBOi. CnIKyJrTe 3a THM, 0o6 BCMOKTYBaBHa LiHH He 3haxOdNac Ha DHI, 0o6 nicok abo 6pyd He Notpann HBCpeHNy. 3 ciEHO MeTOIO MOKHa CHOPICTyBAHtnc PIAbaOHIM BOO3aBOpOM, 0o BXoDnTb Do npelniKy npnilaJa.

6.3ПИДКИLOЧЕНHAHINPHOROTpy6oNPOBODY

Uo6 3Hn3HTBpatTN TCKy B pezylbTaTI Teptra, BHyTpiuHi diametp HanipHOI NOBITPRAHOI JIniMae

6yTHHe MeHHe 1" (25 MM).PnBHKOpncTaHHI MeHuxDiAMetPi, HapnHnAd, 1/2"MOxHyb 6yTH np6bnm Pn eKcnPyatai, nob'3aHi 3 NoraHM BvdaenHHM Nobitpi.

YBaRa! HanipHn Tpy6oBpOiMa 6yTu3MOHTOBaHn Ta, o6 Bi He uHHB HIAKoi MexaHIOI di a60 Hanpyu Ha HAcoc.

Yci pi3b60bi 3'edHaHH MaIOb 6yTu
reMpTeN3OBAHI 3a DonOMOIO yUJIbHIOBaIbHOi
ctPiKHi, Uo6 3anoBITn BNTOKy BoN (10-15
0epeTaHb y Hapmky pi3b6n).

Yci Detani HanipHoro Tpy6opOBody NOBHHI BHTPMyBaTH TNCH;IX MOHTa3dIHcEObCRA KBAIΦIOBAHIMD paxIBQMR.

He6e3neKa! HerepeMeTuHi detani i HEKBaJIoIIOKAOBAHNI MOHTAK MOHytB np3BeCTn Do pO3pNBy HanipHO rTyOpNOBOy NiD qac EChNlayatauji.PiMaHa, 10 BuPbNAeTbcra NiD BOCOHIM THcHOM,MOHE TpaBMyBaTH Bac!

6.4 PIIKIOUeHHoMepexi Tpy6oNpOBoDIB

Uo6 3Hn3HTN Biopaui i Wymn, Hacoc Tpe6a nIiHIOuATn Do MEpexi TybompOBdIB 3a DONOMORO eJACTHHHX 3'EDyBaIbHNx IuaHrib. CtaiohApHi tybu peKoMeHdyTcBc moHTyBatn nepi2 MeTpni 3 NiJiOMom, Uo6 3a6e3neHTn MAHCIMAbHe BIDAAJIeHNNOBITpr.

6.5ПинlueyHЯdoeNekTpomepeki

He6e3neKa, NOB'3aHa 3 eIeKtpnKOIO! He BnKOpNCToByuTe HAcOC y BOIoromy cepedOBuNi O6OB'3KOBO BnKOHyTe HaCTyPiHi yMOBN:

-Hacocdo3BOJAEbCn iHIOUaTN TINbKN DO PO3eTOK i3 3axNCHM KOHTaKTOM, kHaJIeHHNm YINHom BCTaHOBJeHi, 3a3emJIeHI npeBipehi.

• Hanpyra MepeKi, Yactota i 3aNo6iKHNK NOBHHI BiNOBiDaTI TEXHcHIM XapakTePncTnKam HacOca.

-ПдкюаиTe npnilaДdo eIeKTpOmepeKi uepe3 npicTpii 3axnchoro BiKlHoueHHra（ПЗВ）3 MaKcHMaJIbHIMC TpyMOM BHTOKy 30 mA.

• EneKtpnHi 3'EdHaHHa3abOpHHeTbc8O npyckatu yBOy, BOHn NOBHHi3haxoHTncBnue MoJInBOrOPiNOMpyBnHO. PidvacEcnnyataui No3aPnMIeEHnMn BOH MaOTb6TyN 3axnuehi BiD 6pn3OK.

Ipeep BBeEeHHB E KcNpyaTaio Tpe6a BCTAHOBHTN TNC iDKNBLeHHA. NIB. po3in 9.4.

6.7 3anOBHeHHHaHocOa I BCMOKTyBaHHa

Ybara!PnKoXHOMyHOBOMy iNkHIOUeHHI a60 npn BtOKy BOiN Heo6xJH0 3anOBHIbATn HAcOC BDOJO. EKcNlyaTaJr HAcoCa 63 3aONBOHEHH BOIOO pyHyE HaCoc! Dra rapaHTi 63nepe6iHoi pOboTn

peKOMeHny6MO npn nepwOmy BBeDeHHi B EKnNyatauio 3a6e3neUHTN DocTAHI 3a6ip BOi IJIOBHORO BHaIaJIeHHra NOBITpI 3 CNTEMN.

Bunbnttbpi360by np6ky HaHnBHoro OTbopy (9)pa3OM 3yuiiIbHeHHaM.
-Повьно ЗаимьтЕЧМСТУВOD,ПОКИHAOCHEHANOBHNTCB.
-3HOBy 3aBHTitb pi3b6Oby np06ky HaJIINBHOROTBOPY(9)pa3OM 3yuiNbHeHHM.
BIDKpnIte HanjinHnTYpOBoPiD (NOeBPHTb BODOpBOiDHN KpaH a0o cnoIIO), 06 pRBCMOKTYBaHH BIXOAnIO NOBITPRA.
- YbIMKHiTb HAcOC (INB. po3di7.).
-HKUO BODA BNXOUNTB PIBHOMIPHO, HACOC ROTOBN DO EKCNyataJI.

Bka3iBa: BCMOKTyBaIbHy LiHiO 3aNoBHOBaTH He Tpe6a, OckIbHn HaocC 6 CamOBKOTyBaIbHnM. 3aJIeJHO BID IOBKnHn I diametpy LiHII MoKe npOnI DeKeHH QAC, NOKI TNC DOcRHe HEo6xHOrO pIBHa. RkIoO BN XOHTe CKOpOTn Hac BCMOK TYBaHHB, BCTaHOBIbT bSOpOTn HKLanAH BaXIDHomY OTBopi BCMOKTyBaIbHoro WJaHaIg I TaKOH 3aNoBHITb BCMOKTyBaIbHy LiHiO.

7. Eknnyatauia

6).

Ybara! He donyckaetbca po6ota hacoca 6e3 BODn. Hacoc 3abKmae 6ytu

OBHEHIM pIDHIOO (BODOIO) y DOCTaTHbOMy 131.

Pn6bOyBaHHi HAcOa YKxOpjDnHM TlOM a60 npnpeperPiBaHHI eJeHTpOdBHyHa CnCTema 3axNCTY BIDHIOue eJeHTpOdBYNH.

7.1 BnKOpNCTaHHHaHacOca

CaoBn Hacoc

(No3naeHH npHnady P...)

PpHnnpo60Tn: Hacoc npaue,doKn BIn yBIMKHeHn.

He6e3neKa! npn 3aHrTOMy HanipHOMy TpybONpOBoDi Haoc He NoBHHen

npaobatn 61bIbue 5XbnHIn,HaKwEpe3 neperpBaHHB OBN Haoc MoKe 6yTN nowkDkeHN.

1. BCTaBTe BnIky Bpo3eTky.
2. B pa3i noTpe6n 3aNoBHt b Hacoc -DIN. po3d16.7.
3. YbIMKHeHH npHnay:
   yBIMKHiTb PnIa3a DOnOMoIO NepEMHKaHa (1).
4. Bɪdɪkɒpɪnɪte HɑnɪpHɪnɪ Tpɪyɒbɒpɒbɪd (NobepHɪt b Bɔdɒpɒbɪdʒn Kpʌn aʊc oʊ cɒnlo).
5. NpekeKaHTeC, 0o BOna niWJa!
   6.ПИСЯЗАКIHHEHня рОБТУВIMKHIb HAcOC: BIMKHIb II pIINaD 3a DOnOMOROI NpeMnKaHa (1).

Hacocha ctaHua

(No3HaueHn npHnady HWW...

PpHnH npoBTo: npHaad BMNkaeTbC8, RaKIO B pe3yIbTaTIa60py BOIN TNC NaaE HNNue nopory yBIMKHHeH, i3HOBY BMNkaeTbC8 pnpDocraHHI nopory BiKnIOUChEH.

P3eepByapP3eepByap OCHaueHn rymOBnM CnIbΦOHOM, NOCTABJIεTcB 3 aBODy 3 BCTaHOBHeHMM NOIBITPrHnM TNCOM ("TNCK NiDHNBLHn"); CE ΣO3BOJRE 3dJIiCHIOBATN 3aBip HeBeINHX KIIbKoCTeB BOiN, HE 3aNyCKaOHy HACOC.

1.BcTaBTe BnIky Bpo3eTky.
2. B pāzī nötpēb 3aŋoBhɪt b hacoc -dɪn. pɔzdi n 6.7.
3. YbIMKHeHH npHnaDy:
YBIMKHTIb pInJaI 3a DOnOMOIO NOpeMnKaHa(1).
4. Bɪdɪkpɪnɪte Hænpɪnɪ TpɪyɒbɒpɔBɪd (NobepHɪt b Bɒɒpɒbɪdɪŋ Kpʌn aʊc oʊ cɒnlo).
5. NpeekohaiTeec, 0o Boda niuHa! PnnaI rtoBn do po6oTH.
6.Пилад BMнкаETbCЯ N BmMnKaETbCЯ,КOLIN ue notpi6Ho.

8. Texhiye 06cIyroByBaHHa

He6e3neha!Ipeed6ydb-yaHmnpo6oTAMn 3 npnaadom:

-BNTARHITbWTeNCeBHy BUNKy 3 pO3eTKN.
- PpehoHaTecra, 10 npnla i nkiKIOuehe npnaI3HaxOaTbcr He nID TNCOM.

• Oncahi dani p60to3 texiHoro
  OcnyroBaHaHH i peMOHTy do3BOLReTbc
  BHKoHYBaTH TlBkH faxiBAM.

8.1 Perylarphe texhichne 06clyroByaHHA

• Ipebeipte npnla i BiNobiHne npnlaIa, OcObIbO eEeKTPuHI DeTani Ta KOMHOHTNI TCHKOM HA BiCyTHtB yHODHeHb, B pasi NOTpebn BiDaaiTe B pemOH.
• NepeBipTe BCMOKTyBaIbHn i HanipHn
  Tpy60npoBOnHa repMeTHHicTh.
• Pn3HKeHHI npOyKTHBHOCTi HAcoc a npOHTb abo 3aMihTb nPiMaBHN iBnTp i BtpyBaHbHN eMeHET (B pasi NTpe6N).
  IpepeipTe TnCK NIKBLeHnpeepByapa (3) 1eNHO BID KOMNIIeKTAii),Y BnAHy Heo6xIHocTi 36IbUneTte (DvB. pozil9.4 36IbUeHHN TnCKy NiKbNeHn).

8.2 Pn He6e3neci 3aMeP3aHH

Ybaral Mop03 (< 4°C) pyHye hacoc i npIaIaIa, OCKJIbKIN BOHN IOCTIHO MICTATb BOy!
- Pn He6e3nei 3amep3aHna Heo6xidno
pos3ipatn Hacc0i npnaadj 36epiratn B
3axnueHOMy BiM MOpO3y MiCi (DVB. Hactynnn
po3di).

8.3 DEMOHTaH i 36epirAHnCtahui

-BMHHItb IHCTpymeHT. BnTARHITb wTeNceIbHy BNKHY 3 pOeTKI.
-BidkpniTe HanipnH TpyoBpOIB (noBepHtB BOIOpOBiDn H kpaH aOo conIIO), NOBHCIO cnycITb BODy.
-ПовсгTO BnnpoKHTb Hacoc (2)ipesepeByap(3)，DЯцboro:
BUNBHITb pi3b6OBy npo6ky BOIO3JIINBHOOTBOPY (5).
- DEMOHTyHe BCMOKTyBaIbHn I HanipHm
TpybonpoBoArperaTy.
-36epiratn arperat cr Nb He3aempe3aoOmy npimuHenni (He MeHne 5°C).

8.4 PeryIIOBaHH MaHOMeTpNHO BIMnHa（TlBn HWW 3500/25 G.DIpe rpyIIOBaHH iHmX MoJeH HW W 3BepHtBC B cepBicHy Metabo)

He63neHa He63neHa ypaHexHH eEeKTPnHm CTpyMOM pN KOtAKTI 3 KJIeAMn NiKIIIOeHHa MAHOmETPNHOro BIMNKaHa!O6pHbA MHOmETPnHn BIMNKaI o6bHn HaaJbYBaHHa MaOtB npT TINKBKAIIDIKOBAHJEeKTPHK.

MaHometrpNHyBmHKaHaJaawTobAHn Ha 3aBoDi Ha HAIIOINPeHIi cpep 3actocyBaHN, y pa3i Heo6xIHOpCT MoHHa BiDperYIOBATn Noro TAHM YHOM.

BkasibKa: npn peryIIOBaHHI rOIOBHOHaTNCHOI pyKHHN (11) 3MHIoETbCn TCH yBMIXHEHH N BIMKHeHH MauJIe npOnOpuHIO, npeNaD TnCKy 3aIIMaTebCn He3MIHHN. Pn peryIIOBaHHi nepenady TnCKY (12) 3MlHOEtbc TaIbKn TnCK BIMKHeHH, TnCK yBMIXHEHH 3aJIINaEeTcBc He3MIHHN.

1. BIMKHYTN HACOC, BINHAYTN BINKY 3 PO3eTKN 3a6e3neuHTN 3axUCT BiD yBIMKHEHHR.
2. 3HATN KPNK Ky MaHOMETPNUHOr BO BIMNKaHa.
3. 3MiHa TnCKy yBIMKHeHH: peryIIOBaHHra IONOBHOI HATNCKHOI npyHnHn (11) (pO3mip KIOUa 9 MM; 1 O6epT npbJL.0,1-0,15 6ap). PnI cBOMY TnCK BIMKHeHH 3MIHOCTBCMAJIKe npONOpuiHo!
4. 3MiHa TnCKy BnIMKHeHHr: peryIIOBaHHr nepenady TnCKy (12).Tnch yBIMKHeHHr 3aIIHuaTeBcR He3MIHHM.
5. BCTaHOBnTH Ha MlCe KpHkHy MaHOMETPnHHORO BMmKaua NepeBipHTn npaBnIbHcTb MOtAHTy.
6. BBeCTN HAcOC B EKCNyAtaUcH, nepeBipNTn BiNObIaHiCTb 3aDaHm 3HaYeHHMa 3a DonOMOrOo MAHOMeTpA (11).
7. Y pa3i Heo6xHocTi NoBtOpNTn KpOKn 1-6 do OTPMAMHH bKaHaHnx 3HaYeHb.

YBaRa! Bka3aHm MaKcMmaBn TnCK HacOca He Mae 6yTn PepeBnueHn. TnCK yBMKHHeHHMaHOMeTpHOro BMNKeHaMae 6yTn 3abXd 6blBe TnCk PnDHNbHeHH peCnBepa MIn. Ha 0,2 6ap (1,56ap, nB. po3in

9.4). ⅡOb yHnHyTH qactoro yBIMKHeHHaHocca, cnIb BCTaHOBIOBATn MaHCMAJIbNH nepenad TcNc (HanpNKlad, nonepedhe HanaWtYBaHHra npNo1.1,86ap).

9. Ipo6JIemn i HecnpaBHOcTi

He6e3neka!

-Перед 6уд-як imm роботamn 3 пиладom:
- BntarHitb wTenceIbHy BNkY 3 po3eTKN.
- IpekoHaTeC8, 0 npnla i nHIOueHe npnaIra 3NaXoAraTbca He nIa TnCKOM.

9.1 Hacoc He npaioe

• Hanpyra Mepeksi BiccyTHa.

IpeepiTe npemHKaYBIMK/BIMK, Kaebb, BNky, po3eTKy i 3an06hHK.

• Hanpyra Mepexi 3aHaTo Hn3bKa.

BnKOpNCTOByTe NODBHyBaIbHNI Ka6eJIb 3doCTaTHIM NonepeuHm NepepiSOM HIN.

• EneKtpoBnHy npeperpiN, cnpaioBaB 3axnCT DnHyHa.

• PICIAOXIOJIDHEHHe HAOC BKLIOUHTbC3HOBYaBTOMATHNO.

• 3a6e3neueHHAocTaTHb0iBEHTNIAJI BEHTNIAIHIOTBOPMMAOTb6yTN BIDKpNTI.
  -ДOTРПМУТЕССМACHIMмьНОТtemпаТуРи NOДаH.

• EneKtpoBnHyr rHyntb, aIe He 3anyckaetbca. - Notpi6Hm peMOHT, nB. po3d11.
  Hacoc 3acmitnbca a6o HecnpabHn.
  P036epi b i npOCHiTb Hacoc. IpOCHiTb a0b 3aMihTb dNHy3op. IpOCHiTb a0b 3aMihTb poBoohe KOeCo. DInB. po3di 11...
  TnCKBJIiH /HaBXOjI BUNe TnCKy yBIMKHeHH HaCOca.
  -Пдкючтп радуктор,дИВ.po3дн2.

9.2 Hacoc npaioe HenpaBnIbHO a6o dyHe rnuHo:

HectaBoH.
- PpekeonaiTeC8, 30 3anac BOnD IOCTaTHiN.
Hacoc 3aONBHeHn BOOIO HeoCTaTHbO.
-Див.pozdi6.7.
BCMOKTyBaJbHaJIiHrHerepMeTnHa.
-3a6e3neTe repMeTHuHtcb BCMOKTyBaIbHOJIiHII, 3aTnHiTiPi3bOBoI 3'EdHaHH.
3aHaToBeIMKaBnCotaBCMOKtYBaHHA.
-OTpMMyTecbO6MeXeHHNo BNCOTBCMOKTYBaHH.
BcTaHObITb 3BOpOTnH Klanan, 3AnOBHItb BCMOKTyBaIbHy JInIO BOIO.
PnHMaJIbHmIΦJIbTpBCMOKTyBaJIbHOI LiHII (doTaKOBe yCTaTKBaHH) 3aCMTNBcR.

• Ipoounctitb Horo, B pa3i notpe6n 3amHITb.

3BOpOTHnKlnaHaN (OdaTkoBe yCTaTKyBaHHa) 3a6IOKOBaHn.
Ipoynctitb noro, B pasi notpe6n 3amHITb.
BntIK BODn MIK eIeNTPODBNYHOM I HAcOCOM, TOpueE yuJIbHeHHr HErEpMeTNUHe. (He3aHuN BntIK BODn (MaKc. 30 Kpanelb B DeHb) oByMOBLeHN KOHCTpyKUIE TO TOpueBOr OyuiJIbHeHHr).
3amHITbTOPueBe yuINbHeHHa.IIB.po3di11.
Hacoc 3acmitnbca6 hecnpaBn.
-IMB.po3d9.1

9.3 Tnck 3aHaTTo Hn3bHn a6o Haoc

npaioe noctiHo (noctiHO

BIDbyBaTbca yBIMHHHeHHa/BUMHHeHHa):

• BCMOKTyBaIbHa IiHr HeRpeMTeNHa, a60 BHCOTa BCMOKTyBaHH 3aHaTTo BeJIInKa.
  -ДиВ.pozdiN9.2.
  Hacoc3acmitHBcraaboHecnpaBnI.
  -ДиВ.po3dIn9.1.
  HWW...：36nncraHaIawyBaHHaMAHOMeTpHOroBmNkaa.
  3aMpTe TnCK YbIMKHeHHI BIMKHeHHa DOmOMoOIO MAHOMeTpa (7) I nepeBipTe 3aHaeHenn (INB. po3dIN 13, TexHiHi XapaKTepnCTnIK). JKnUc e nToP6Ba G NOBTOPHOMy HauAHTyBAHHi, 3BePHTbcrdo KJIeHtCb0i CnyKb6 KomHaHII Metabo. INB. po3dIN 11..
  HWW....HACOC BMKAeTbcra npn He3HaHOMy 3abopi BOIN (npn6n.0,5n).
• PepeBipTe, Neu He 3aHaTTo Hn3bKn TnCK nIXnBHeHnY pEeepByap. Y BnPaNky Heo6xHnOci 3oJIbWnte TnCK. NIB. P03dI9.4.

YKPAIHcBHAuk

• HWW... BODa Teue i3 NobitprHoro KlaanaHa.

-ΓyMOBn CnIbfoH ype3epByapi HeepMeTnUHni;3amHItb.1uB.p03d11..

9.4 36iNbweHH TnCKy nIDKHBneHH (TinbKn HWW...)

HaHcO HAcO-3 YacOM-BMnHaεTbCn HaBtB npn He3NaHOMy 3aOpI BODn (npHbL.0,5), Heo6XiHNO BiHOBHTn Bepe3epByapi TnCK nDkHbEHHN.

Bka3jBa: Tnck NIIKNHbIeHNy y pe3epByapi (NOITPBHN TnCK) HE MOHA Bn3HaHTN 3a DOJONMOFO MAnOMeTpA (7).

1. BntarHnItb wTeNceIbHy BNkky 3 po3eKn.
2. BiiKpnIte HAnipHn Tpy6oPobiD (NoBepHtB BOOnpObiDHH KpaH a6o CoNIO), NOBHCTO cnYCTITb BOvY.
3. BiodrBnHTNb PAnCTNKBOy KpNtUHa TOpueBcI CTOpOni Pe3epYapa; 3a Heo 3hAxOxDbCn BOITOPHNBEHTNlb.
   4.Пд'бнaite nobitprHn Hacoc a6o shaHR KOMnPecOpa 3 HAcOHeHHKOM dJIa SHINHIX KlanahIB imAHOMetp Do nobitprHoro BEHTNJIH.
4. Hanomiyte do DoocrHeHHaBIObHOrTO TnCKy nDHNBHeHHA (1,56ap; DnB. po3d13. TexHHiX hapaTePcTmNtHu
5. 3HOBy nIKHIOuITb HAcoc i nepeBipTe Noro fYHKUIOHYBaHHa

10.Пи�адя

BnKOpncToByTe TiIbKn opnrHaJIbHe npuJaIaI Metabo.

BnHOPCTOByTe TINbK Te npHaAJa, IKe BIDNOIBaIe BHMoR aI npamETpam IcIe iNCTpykui 3 ekCNyataaui.

PobHn acopTmEHT npHaIaIy IuB. Ha caiTi www.metabo.com a6o B KaTaIaO3i.

11. PemOHr

Hebe3eKApI DopyaHTe peMOHT npHnlaDy TInbKn KBaJIΦIOBAHIM QaxIBaM- eJeKTPNkAM!

ДлpeMoHTyInCTpymeTIBMetabo3BepTaIteCnBperioHJIbe npedctabHnTuBOMetabo.ADpeCnDHB.Na caiTl www.metabo.com.

Ipeed BiinpaBneHHAM: nobHicTIO BNnopoKHiTB Hacocip eepByap (DINB. po3JIn 8.3).

CnNCKH3aNaChHXyACTINHMOKHa 3aBaHTaKHTNa Ha caTti www.metabo.com.

12.3axnct doBknna

DToPmMyTeCnHaioHbNHX npaBn63neHooYtNiIaaii I nepeo6Kn BHKOpCTaHIXIHcTpymTIB, NaKyBaHbNHX MaTepiAIB i npnaJMa

TkyBaIbHi MaTepiAn yTuNl3yOToBc BiIDNoBIdHO do IXHbOro MapKByAHn 3rJHo 3 KOMyHaJIbHMn npaBnAmn. OdaTkoBy IHOpMaJIO MOxHa 3HaHT Ha caTI www.metabo.com y po3diNi «CepBIC’.

TilbKn Iy KpaH EC: He yTni3yIe eKTKPOIHCTPymeHT na303 nO6yTOBHMn BIXdoaMNI 3riJHO 3IpeKTHBOHO SC
2012/19/EU npo BHKOPNCtAHI eKETPNHi i eKTKPOHI pncTpoi Ta BiNobiHNMI
HaJIOnAJIbHHMM HOpMaMI BIIpauBoBHAI
eKTKPOIHCTPymeHT niJaIaOTb po3diNbHi
yTNH3aui 3 MeTOI IX NpaJIbWoI ekONOrIHoo
6e3neHoi nepepO6Kn.

13. Texhui xapaKthepnCHN

TOrcHnHa DaHnx, HabeDeHHx Ha CTOp.3. 3aIinaeMo 3a co6oIO npaBO HA TexHi Hi 3mHN.

XapahTepeHcTHHa KpNba Hacoca (diarpama, CTOp.3) DEMOHCTpye NIOPOyKTNBHCTb 3aJIeKHO BID TCHy (BNCOTA BCMOKTyBaHHr O,5Mi BCMOKTyBaBHmShnahr 1"

E =eIekTpoHikA / 3axnCT BiD cyxOro xOyDV =HAcOC 3 B6yDoBAHIM 3BOpOTHM KlaNaHOM Ha BCMOKTyBaIbHOMy naTpy6Ky (8)

K Ka6eJIb HINBNEHHA
U = Hanpyra mepeXi
f = yacToTa MepeKi
P1 =HOMiHaIbHa nOtYKHiCTb
PStandbyBntpaTaBpeKIMOuyKaBaHHA

HOMiHaJIbHnCTpyM

C = po6oHn KOHdeHcaTOp

n =HOMIHJIbHa KIIbKICTho6eptiB

Fv,max =MaKc.npoDyHTNBHICTb

Fh.max =MaHC.BNOCaNoDAci

Fp,max =MaHC.TNCHNoDAqi

p1 =MaHOMETPNHHBIMNKa:TNCK

yBIMKHEHHA

p2 =MAHOMETPUMHHIN BIMHKaT:THCKBIMHKAHH

Sh.max =MaKC.BUCOTa BCMOKTYBaHHA

Stemp=MaKc.TEmnepaTpya nOdai

Temp Ttemp =TemnepaTpa HABKONHbOro

cepeoBnua

S1 =Klaac 3axnCTy BiD 6pn30K

S2 =Klac 3axnCtY

S3 =Knaac 10JnA

M_P = matepiaI koprnyc y hacoc a G=cipniyabyni

M=MaTePiaI Bana Hacoca

Mw =MaTepiApo6OuroKoIecaHacoc

DS =BHTpiHRA p3b6a BCMOKTyBaIbHORO

natapy6ka

Dp =BHytpiwnpi3b6aHanipHoro naTpy6ka

TV =06'EM pe3epByapa

Tp,max =MaKc.TnCKype3epByapi

Tp.1 =TNCKnDKNBHeHHpe3epByapa

A= po3Mipn:

DOBXHnHaXuHnHaXBnCota

LWA(G) = rapaHTOBaHH pIBeH 3ByKOBOI

notyHKo3rJHO 2000/14/EG

BnHOpNCTOByIte 3axnct opraHIB cLyxy!

TOB "MeTa6o YKpaHa"

ByI. 3OpHa, 22

c.CBtoneTpbcbke

Kmibcbka 06n.

08141,KnIB

www.metabo.com

Metabowerke GmbH

Metabo-Allee 1

72622 Nuertingen

Germany

www.metabo.com