PowerMaxx BS 12 BL Q Pro - Drill METABO - Free user manual and instructions

Product type	Cordless drill/driver
Brand	Metabo
Model	PowerMaxx BS 12 BL Q Pro
Rated voltage	12 V
Motor type	Brushless
Chuck capacity	10 mm
No-load speed (1st gear)	0 - 400 rpm
No-load speed (2nd gear)	0 - 1500 rpm
Max torque	40 Nm
Weight (with battery)	1.2 kg
Dimensions (L x W x H)	180 x 65 x 200 mm
Battery system	CAS (Cordless Alliance System) 12 V
Compatible battery type	Li-Ion 12 V
Lighting	Integrated LED
Main functions	Drilling, screwdriving
Safety	Motor brake, overload protection
Maintenance and cleaning	Clean with a dry cloth
Spare parts and repairability	Spare parts available from Metabo
General information	Intended use: drilling and screwdriving in wood, metal, and plastic

Frequently Asked Questions - PowerMaxx BS 12 BL Q Pro METABO

Which chargers are compatible with my Metabo battery?

The manual indicates that compatible chargers include the ASC ultra, ASC 145, ASC 145 SE, ASC 30-36, ASC 55, ASC 55 SE, SC 60 Plus and SC 30 models. Check the voltage and capacity of your battery.

How to properly charge a Li-Ion battery?

Insert the battery fully into the sliding compartment until it stops. The control indicator flashes during charging. When finished, the indicator stays lit continuously, indicating a full charge.

What does the flashing of the control indicator mean?

The control indicator flashes during charging. If the warning indicator flashes, this indicates a defective or improperly inserted battery.

The warning indicator is permanently lit, what to do?

This indicates that the battery is not being charged due to too high or too low temperature. If the battery is between 0°C and 50°C, charging will start automatically.

Can I leave the battery in the charger after charging?

Yes, the charger automatically switches to trickle charge mode. The battery remains operational at all times without risk of overcharging.

What are the important safety precautions?

Never recharge non-rechargeable batteries. Do not use defective batteries. Protect the charger from moisture. Keep children away. Unplug if there is smoke.

How to clean the charger?

Unplug the charger before cleaning. Use a dry cloth to clean the exterior. Do not insert objects into the ventilation slots.

Where can I get my Metabo charger repaired?

Repairs must be carried out by a specialist. Contact your Metabo representative. Addresses are available at www.metabo.com.

What type of battery should not be recharged?

Never attempt to recharge non-rechargeable batteries (explosion risk). NiCd batteries can only be recharged by ASC 55/ASC 55 SE chargers for the 12 V/1.7 Ah model.

What to do in case of battery acid leakage?

In case of skin contact, rinse thoroughly with water. If splashed into eyes, rinse with clean water and consult a doctor immediately.

USER MANUAL PowerMaxx BS 12 BL Q Pro METABO

Two Metabo brand thermocouple units (no visible text or symbols on the devices themselves)

Original instructions

1. Declaration of Conformity

We, being solely responsible: Hereby declare that these chargers, identified by type and serial number *1), meet the requirements of all relevant directives *2) and standards *3). Technical documents for *4) - see page 3.

For UK only:

UK We as manufacturer and authorized person to CA compile the technical file, see *4) on page 3, hereby declare under sole responsibility that these chargers, identified by type and serial number *1) on page 3, fulfill all relevant provisions of following UK Regulations S.I. 2016/1091, S.I. 2016/1101, S.I. 2012/3032 and Designated Standards EN 60335-1, EN 60335-2-29, EN IEC 63000:2018.

2. Specified Conditions of Use

Chargers are only suitable for charging Metabo and CAS (Cordless Alliance System) battery packs.

This device is not designed for use by persons (including children) with physical, sensory or mental disabilities, or with insufficient experience and/or knowledge, unless they are supervised by a person responsible for their safety, or have received instructions on how to use the device by this person.

ASC 30-36 is suitable for charging Li-ion battery packs (14.4 V - 36 V, 1.3 Ah - 10 Ah, 4-10 cells).

ASC 55, ASC 55 SE is suitable for charging Li-ion battery packs (12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells).

ASC 145, ASC 145 SE is suitable for charging Li-ion battery packs (12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells).

ASC ultra is suitable for charging Li-ion battery packs (corresponding to the print on the tool, either 14.4 V - 36 V, 1.3 Ah - 10 Ah, 4-10 cells, or 12 V - 36 V, 1.3 Ah - 10 Ah, 3-10 cells).

SC 60 Plus is suitable for charging Li-ion battery packs (14.4 V - 18 V, 1.3 Ah - 10 Ah, 4-10 cells).

SC 30 is suitable for charging Li-ion battery packs (12 V - 18 V, 1.3 Ah - 10 Ah, 3-10 cells).

ASC 55, ASC 55 SE is suited for charging NiCd battery packs (12 V, 1.7 Ah, 10 cells).

Never attempt to charge batteries that are not rechargeable. Danger of explosion!

The user bears sole responsibility for any damage caused by inappropriate use.

Generally accepted accident-prevention regulations and accompanying safety instructions should be observed.

3. General Safety Information

WARNING – Read the operating instructions to reduce the risk of injury.

WARNING Read all safety warnings and instructions.

Failure to follow all safety warnings and instructions may result in electric shock, fire and/or serious injury.

Keep all safety instructions and information for future reference.

Before using the charger, carefully read through and familiarise yourself with all closed safety information e Operating Instructions.

Keep all enclosed documentation for future reference, and pass on your charger only together with this documentation.

4. Special Safety Instructions

For your own protection and for the protection of your power tool, pay attention to its of the text that are marked is symbol!

Danger - electrical voltage!

A slightly acidic, flammable fluid may leak from defective Li-ion battery packs!

If battery fluid leaks out and comes into contact with your skin, rinse immediately with plenty of water. If battery fluid leaks out and comes into contact with your eyes, wash them with clean water and seek medical attention immediately!

ENGLISHen

Do not recharge a fully charged battery pack!

Only for use in indoor rooms.

Protect the charger from moisture.

Never allow children to use the device.

Children should be supervised to ensure that they do not play with the tool.

Keep children away from the battery charger and the working area!

Keep your battery charger out of reach of children!

Pull out the mains plug immediately if the battery charger starts to smoke or flames emerge!

Do not insert objects into the ventilation slots on the battery charger – there is a danger of electric shocks and short circuits!

Do not use faulty battery packs. In areas with high metal dust exposure do not charge any battery packs with AIR COOLED chargers.

5. Overview

See page 2. The illustrations are regarded as exemplary for all devices.

1 Battery pack (not in scope of delivery)
2 Sliding seat
3 Operation display
4 Warning display

6. Initial Operation

Before commissioning, check that the rated mains voltage and mains frequency stated on the type plate match your power supply.

Devices like these that generate direct current can influence simple earth leakage protection devices. Use a type F or better, with a release current of max. 30 mA.

Before commissioning the charger, ensure that the air slots are free. Minimum distance to other objects is 5 cm!

6.1 Self-test

Plug in.

The warning display (4) and the operating indicator (3) light up one after the other for approx. 1 second and the installed fan runs for approx. 5 seconds.

7. Use

7.1 Charging battery pack

Push the battery pack completely to the stop on the sliding seat (2).

The operating indicator (3) flashes.

Note: To have the charge level displayed on Li-ion battery packs, first take the battery pack out of the charger and then press the button on the battery pack.

7.2 Conservation charge

Once the charging process has finished, the battery charger automatically switches to conservation mode.

The battery pack can remain in the battery charger and is therefore always ready for use.

The operating display (3) lights up continuously.

8. Faults

8.1 Warning display (4) lights up continuously

Battery pack is not charged. Excessive/insufficient temperature. When the temperature of the battery pack is between 0 °C and 50 °C, the charging process begins automatically.

8.2 Warning display (4) flashes

• Battery pack is defective. Remove the battery pack immediately from the charger.
• The battery pack was not pushed correctly onto the sliding seat (2). See chapter 7.1.

9. Repairs

Repairs to the charger must only be carried out by qualified electricians.

If the mains connection cable of this device is damaged, it must be replaced by the manufacturer

or the Customer Service department of the manufacturer or a similarly qualified person to prevent endangering personnel and property.

If you have Metabo charges that require repairs, please contact your Metabo service centre. See www.metabo.com for addresses.

10. Environmental Protection

Observe national regulations on environmentally compatible disposal and on the recycling of disused machines, packaging and accessories.

Only for EU countries: never dispose of power tools in your household waste! According to European Directive 2012/19/EU

on Waste from Electric and Electronic Equipment and implementation in national law, used power tools must be collected separately and recycled in an environmentally-friendly manner.

11. Technical Specifications

See page 3.

U = voltage ranges of the battery packs
C = battery pack capacity
l_C = charging current
t = charging time

^1) Depending on the residual capacity and the temperature of the battery pack, real charging times may deviate from the specifications.

Recommended ambient temperature when charging: 0 °C to 40 °C

Changes due to technological progress reserved.

Device of protection class II

\~ AC Power

FRANÇAISfr

Notice originale

C = accupack-capaciteit

I_C = laadstroom

t = laadtijd

Uju wtuwlyh wupftpp, npn6f qt6tpwg6m1d t6 hwnwnwnm6 hwnw6f, lwpnn t6 mqn9L yhi6ptpt6ghwL mwqwhnl1s ufswnhyskph dpu: Yhpwnl5 F wkwnlp, lquw wnwljlwqn2j6p 30 d1U, wfswnndwl hwnwlfnl wejwnwnn daq4p:

^1 npdwnphnufgh wwng hwnqyltf, np onwnphnufwgh mfgftpju hgnfujmds st6: Nmhqnukl wnfujmq6 5 nd hlnwnlpapnjuni wjl wnwnphnuklph gllwnndwdp:

6.1 Ummiqnli

kynngmhlq shmgfkl hnumfgh ympnmlhfi:

UqqnW6cmW6Jh6 (4) h wcjwnwnGfH h6nhlhwwnnpGtph lmjutpp (3) ymnjnu6 t6 hwgnpnpwpw dwnwnlpwnwtu 1 yph. empuftmuh, gtpumppfjmd hnlmgfdh hndwlmpqq mcjwnmmuf k dum. 5 yph. empuftmuh:

7. Чршннід

C = Uwpunlqngh hqnpncpjnufp

IC = lhglwl|npdufihnuufif

t = 1,hgfu|npduw|duufulw|

1) qubqud hghduwupuuhg le yapuwumfuuhq wujuwukphg hghwunpufu hpulwui duwuwuhp lwpqn k wnppptpkl fclud duwuwuhwhwniuwditphg:

Ighfuwapufu duwufuw ouunfuw ykpudwnuhfu^ hg uhyu 40 ^:

Bcpwqk k ynhnfowg wkjgghwqg pwptlmufw6 Guwwwnql:

□ II ηωυρ υωσωνωθmρμι6

\~ Φnμnμmμg hnuugf

№ ЕАЭС RU C-DE.ГБ09.B.00131/20, qnpδnul t, ulquw 10.02.2020 άh624 09.02.2025 pp., mpjbl t, «'Ukqwllhuftuwm έfwnlρωnhq» UΩC' wpnnwnpwflh hw|wwnnwwqpndwi δwpd6h hqn6hg, hwugl (hpwnlwpwnwlquf l qnpδnkl(###pjw6) ' 115280, θnclwwnnw, fwunuf U'nuljlu, φnngg Ιt6hghuhwju U1npnnu, ct6f 19, 2-pn hwph, ut6jwh6tp ' 21w8, 21w9, 21w10, 21w11: Ztnwnpu ' [phone]; ηL. φnwnhl hwugt' [e-mail]: Znw|wwnnwwqpndwi άhμwqhp No POCC RU.0001.11ГБ09 wn 09.09.2014 p.:

Zwduuununluwufprjwh hwnunupwquhp ' No EA3C N RU Д-DE.ГБ09.B.00348/20, qnpdnif k uluwd 04.03.2020 üh6b 26.02.2025 pp., qpwbgylt k «Ükqwlluhwjw fhuwtpwnhqw» UФ' wpmwnpw6f hwnlwnwnqpw6 dmp6h hnp6fg, hmugt (lpwnlpw6mhw6 h qnpdnftm pwr6f)' 115280, fbnwnwnwfi, fuqnuf Unaljlu, qhnng l,lghfuhwjw Ulnpnnw, ct6f 19, 2-pn hwph, ut6jwl6tp '21w8, 21w9, 21w10, 21w11: Ztnwnwnn' [phone]; ξL. qwnwnh hmugt' [e-mail]: Zwnlwnwnmqrwn6 ylmwjwqhp No POCC RU.0001.11ГБ09 mm 09.09.2014 p.:

Upumnprufng kphhp' Qfghwnwnng, qjkwngmd Upumnprunq "Metabowerke GmbH", Utkwnpnwnltyk 1, D-72622 Ujnpuhfiqfg, qkpufngjm Ukpufndqn fncnuunnwnngmd' "Utkwnpn bilpuulm" UfC Pncnuunnng, 127273, Unuqlju Φ. fKpnqnqnlwjm wltw, umt6 5 a, ch6.-6 7, qpwnutgjwlq 106 htn.' [phone]

Upwnnpudw wduwpplp gcalmd k Lhgfwlpudw uwpfh qpm Tnpdft h dwnwnmpjw6 dmuhtpw 7 uwpfh k: hnphmprn sh wpfnd wnuhfg hwiofwqm hnuiqdwf oqwnqnptk l qnpdftp wpwnnpudw wduwpllg uhumd '5 mmph cmpnfdmh wjh wpnhntwnmqlaplg hlaan (wpwnnpudw wduwphlp ndu whunwl h ipw):

Shukhupjuli qianpnh huiup.

Zwduwquwnu]vwGnIpJw6 hwylwunnwqhp.