P 6000 Inox - Pump METABO - Free user manual and instructions

USER MANUAL P 6000 Inox METABO

Original Instructions

1. Declaration of Conformity

We hereby declare that these pumps/domestic water works/domestic water automatic systems, identified by type and serial number *1),meet all relevant requirements of directives *2) and standards *3).Technical documents for *4)- see page 3.

2. Specified Use

This device is used for conveying clean water in the house and garden area, for sprinkling and watering, as a well pump, rain pump and domestic water pump and for pumping out swimming pools, garden ponds and water tanks.

The pump is not intended for:

• continuous operation

• industrial or commercial use

The pump is not suitable for transportation of:

• drinking water

-food

salt water

• explosive, flammable, aggressive, or hazardous materials (e.g. chemicals)

• liquids over 35^

• water containing sand and liquids with an abrasive effect

The pump is not suitable for increasing pressure: if the pump is connected to a line that is already pressurised then a suitable pressure regulator should be installed upstream of this. The maximal pressure of the system must not exceed the stated maximum pressure of the pump under any circumstances. It should also be borne in mind that the inlet pressure is added to the cut-off pressure of the pump!

This device is not designed for the use of persons (including children) with limited physical, sensory or mental aptitude or lack of experience and/or knowledge.

Unauthorised modifications to the device and the use of parts that are not tested and approved by the manufacturer are prohibited.

All improper use of the device is regarded as nonspecified use; this can result in unpredictable damage! The user bears sole responsibility for any damage caused by inappropriate use.

Generally accepted accident prevention regulations and the enclosed safety information must be observed.

3. General Safety Instructions

Pay attention to all parts of the text that are marked with this symbol for your own protection and for the protection of your device!

WARNING - Reading the operating instructions will reduce the risk of injury.

WARNING Read all safety warnings and instructions. Failure to follow all safety ings and instructions may result in electric k, fire and/or serious injury.

Keep all safety instructions and information for future reference.

Pass on your pump only together with these documents.

Information in these operating instructions is designated as shown below:

Danger! Risk of personal injury or environmental damage.

Risk of electric shock! Risk of personal injury from electric shock.

Caution! Risk of material damage.

4. Special Safety Instructions

Children, adolescents and persons who are not familiar with the operating instructions must not use the device.

Children should be supervised to ensure that they do not play with the device.

The provisions of DIN VDE 0100-702 and -738 must be observed when the pump is being used in swimming pools and garden ponds and in the protected areas around them.

The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).

The device must not be used if there are persons in the water.

The statutory water and waste water specifications and the provisions of DIN 1988 must be observed when used for the domestic water supply.

The following residual risks essentially remain when operating pumps and pressure vessels (equipment-specific) - they cannot be fully eliminated even if safety measures have been introduced.

4.1 Danger from the environment!

Do not expose the device to rain. Do not operate the device in a damp or wet environment.

Do not use the pump in potentially explosive locations or near flammable liquids or gases!

4.2 Danger from hot water!

Danger! Install a check valve at the suction connection (10) to prevent water from flowing back into the suction line. This can reduce the following danger:

Hot water can cause damage and leaks on the device and the connection lines, allowing hot water to escape. Danger of scalding!

Devices with the designation HWW....: if the shut-off pressure of the pressure switch cannot be reached due to poor pressure conditions or a defective pressure switch, the water can heat up within the device as a result of internal circulation.

Devices with the designation P.... do not operate the device against a closed discharge line for longer than 5 minutes. Water that

circulates inside the device is heated up.

In the event of a fault, unplug the device from the power supply system and allow it to cool. A specialist must check the system to make sure it is in perfect working order before it can be used again.

4.3 Risk of electric shock!

Never direct the water jet directly at the device or other electrical components! Risk of fatal electric shock!

Always disconnect the device from the power supply system prior to installation and maintenance tasks.

Do not touch the plug with wet hands! Always pull on the plug and not the power cable to disconnect it.

Do not buckle, squeeze, drag or drive over the power cable or extension cables; protect them from sharp edges, oil and heat.

4.4 Danger due to deficiencies or faults on the device!

Check the device for possible damage - especially the mains cable, mains plug and electrical components before each use. Risk of fatal electric shock!

A damaged device must only be reused after it has been correctly repaired.

Do not attempt to repair the device yourself! Only specialists are permitted to repair pumps and pressure vessels (equipment-specific).

Caution! To prevent water damage, such as flooded rooms, caused by deficiencies or faults on the device:

• Provide appropriate safety
  measures, e.g. alarm device or collection tank with monitoring The manufacturer is not liable for any damage caused by:
• Improper use of the pump.
• Overloading of the pump through continuous operation.
• Failure to operate and store the pump in a frost-free environment.

• Unauthorised modification of the pump. Repairs to electrical equipment may only be carried out by qualified electricians!

• Use of spare parts which have not been tested and approved by the manufacturer.

• Use of unsuitable installation materials (fittings, connection lines etc.).

Suitable installation materials:

• pressure-resistant (min. 10 bar)
  -heat-resistant (min. 100^)

When using universal swivel couplings (bayonet couplings), only use versions with an additional securing ring to ensure safe sealing.

5. Overview

See page 2. The illustrations are regarded as exemplary for all devices.

1 LED (error)

2 LED (on, standby, info) *

3 Button (on, off, "mode A", reset if necessary) *

4 Control panel

5 P u m p

6 Pressure vessel ("vessel") *

7 Air valve for pilot pressure

8 Water drain screw

9 Pressure gauge (water pressure) *

10 Suction connection

11 Water filling screw

12 Pressure connection

13 Key

14 Cover*

15 Filter unit

16 Receptacle

17 Filter*

18 Check valve

equipment-specific

6. Commissioning

6.1 Installation

The unit must be set up horizontally at a dry (humidity max. 80% ), well-ventilated site that is free of atmospheric influences. Ensure that the unit is positioned on a secure, level and firm base when full of water. The air vents must not be covered or suck in dirt. There should be a clearance of at least 5 cm from walls and other objects. Protecting against frost - see section 8.3.

The device should not be bolted on but rather positioned on a resilient base to avoid vibrations.

The device must be installed in a flood-proof location and secured against falling in for operation in garden ponds and swimming pools. Additional statutory requirements must be taken into consideration.

6.2 Connecting the suction line

Caution! The suction line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.

Caution! Use an intake filter to protect the pump against sand and contamination.

Caution! The check valve is absolutely essential to prevent the water from draining when the pump is switched off. We recommend the installation of check valves at the intake opening of the suction hose and at the suction connection (10) of the pump. A check valve may already be integrated depending on the model (see section 13. Technical Specifications).

Seal all fittings with thread seal tape (approx. 10-15 windings in the thread direction). Leaks result in the intake of air and reduce or prevent the intake of water.

The suction line should have an internal diameter of at least 1^ (25 mm); it must be kink- and vacuum-resistant.

The suction line should be as short as possible because the longer the line length, the lower the conveying capacity.

The suction line should rise uniformly towards the pump to prevent air pockets.

An adequate supply of water must be guaranteed and the end of the suction line should always be under water. Ensure that the suction line is not on the ground so that no sand or dirt is sucked in. It is possible, for example, to use a floating intake as an accessory.

6.3 Connecting the discharge line

In order to reduce friction losses, the discharge line should have an interior diameter of at least 1" (25 mm). If using smaller diameters, such as 1/2 then application problems may arise due to inadequate ventilation.

Caution! The discharge line must be installed in such a way that no mechanical or twisting forces are exerted on the pump.

Note: HWWI, HWAI. (Pumps with integrated filter): fill the pump before connecting it (see section 6.7).

Seal all fittings with thread seal tape to prevent water leakage (approx. 10-15 windings in the thread direction).

All discharge line components must be pressure-resistant and installed correctly.

Danger! The discharge line can burst during operation if non-pressure-resistant components are installed or they are assembled incorrectly. Injuries are possible if highly pressurised fluids are ejected!

6.4 Connection to a pipe network

The device should be connected to the pipe network with flexible hose lines to reduce vibration and noises.

In the case of fixed pipes, it is recommended that these are laid only rising in the first 2 metres to ensure optimal ventilation.

6.5 Power supply connection

Risk of electric shock! Never operate the device in a wet environment and only under the following conditions:

• Connect it only to an earthed outlet that is properly installed, earthed and tested.
• The mains voltage, mains frequency and fuse protection must correspond to those stated in the "Technical Specifications".
• The device must be supplied with a rated residual current of max. 30mA through a residual-current device (RCD).
• The electrical connections must not be under water and must be located in a flood-proof area. The connections must be splashproof for outdoor use.
• Extension cables must have sufficient conductor cross sections. Cable reels must be fully unrolled.
• National installation specifications must be observed.

6.6 Setting the pilot pressure (only HWW..., HWWI...)

Set the pilot pressure before the initial operation. See section 9.4.

6.7 Filling the pump and suction

Caution! The pump must be filled with water with every new connection and in the case of water loss or air intake. Operating the pump without filling it with water will destroy it! In order to

ensure trouble-free operation, we recommend sufficient removal of water so that the system is fully ventilated before initial use.

Note: HWWI..., HWAI... (Pumps with integrated filter): to fill the pump, remove the filter and additionally fill it through the pressure connection (12).

• Unscrew the water filling screw (11) with gasket.
• Slowly pour in clean water until the pump is filled.
• Screw in the water filling screw (11) with gasket again.
• Open the discharge line (open the water tap or spray nozzle) so that air can escape during suction.
• Switch on the device (see section 7.).
• The device is ready for operation when water emerges evenly.

Note: the suction line does not need to be filled because the pump is self-priming. However, it may take some time until pressure is built up depending on the length and diameter of the line. To shorten the suction time: install a check valve at the intake opening of the suction hose and fill the suction line too.

7. Operation

Caution! The pump and suction line must be connected and filled (see section 6.).

Caution! The pump must not be allowed to run dry. There must always be sufficient reying medium (water) available.

A protective circuit shuts down the motor if the pump is blocked by foreign bodies or the motor is overheated.

7.1 Electronic functions

Shutting down the pump when the discharge line is closed (standby):

HWW.... HWA.... HWWI.... HWAI.... The pump switches to standby mode after a follow-up time. If the discharge line is closed when the pump is running (close the water tap or spray nozzle). The electronics initially monitor whether water flows through the pump, and if no flow is recognised then the LED (2) flashes green for 40 or 70 seconds (depending on model). The pump motor is then switched off, the pump is on standby, and the LED (2) slowly flashes green. The pump starts automatically after opening the discharge line.

P 6000 Inox: the LED (2) slowly flashes green for 20 seconds and then quickly for a further 5 seconds if no water flow is detected. Then the pump motor is switched off and the LED (2) lights up red.

Dry run protection:

The LED (2) starts to slowly flash red if the pump cannot convey water after 20 seconds. The pump motor stops for 5 seconds (LED (2) flashes red + green quickly) and then tries convey water for 3 further cycles if no water can be conveyed after a further 100 seconds. The pump stops and the LED (1) lights up red continuously if water can then still not be conveyed.

Putting the pump back into operation: press the ON/OFF button (3) briefly.

Restart protection:

The device has a factory preset restart protection function that prevents it restarting unintentionally in the event of a fault or power failure.

The device does not start up automatically after a power failure and must be put back into operation by pressing the ON/OFF button (3).

Note: it is not possible to use watering control systems or ballasts (timer, Hydromat) when the restart protection is activated. The restart protection can be deactivated in all devices (with electronics) by changing the operating mode.

Changing the operating mode / using ballasts:

Insert the mains plug and press button (3) for longer than 3 seconds. The LED (2) switches from green to blue. The pump can now be repositioned and connected to the ballast. Returning to "normal mode": insert the mains plug and press button (3) for longer than 3 seconds. The LED (2) switches from blue to green. The pump can also be switched on/off in "mode A" with button (3). The dry run protection operates in the same way as in normal mode.

ENGLISHen

7.2 Using the device

Garden pump

(Device designation P...)

Principle of operation: the device runs when it is switched on.

1. Insert the mains plug.

2. Fill the pump if necessary - see section 6.7

3. Switch on the device:

To switch on the device, press button (3) ON/OFF) briefly, the LED lights up green (blue in operating mode "A").

1. Open the discharge line (open the water tap or spray nozzle).

2. Check that water emerges!

3. Switch off the device when work is complete. To switch off the device, press button (3) ON/OFF) briefly. The pump switches to fault and the red LED lights up if this is not observed, see section 7.1.

If the pump is activated by a ballast (e.g.

Hydromat, timer), it needs to be switched to "mode A", see section 7.1.

Domestic water automatic system

(Device designation HWA..., HWAI...)

Principle of operation: the device switches on when the removal of water causes the water pressure to fall below the switch-on pressure; it switches off again when switch-off pressure is reached.

1. Insert the mains plug.

2. Fill the pump if necessary - see section 6.7

3. Switch on the device:

To switch on the device, press button (3) ON/OFF) briefly, the LED lights up green (blue in operating mode "A").

1. Open the discharge line (open the water tap or spray nozzle).

2. Check that water emerges! The device is not ready for operation.

3. The device switches on and off as required. (See section 7.1)

Domestic water works

(Device designation HWW..., HWWI...)

Principle of operation: the device switches on when the removal of water causes the water pressure to fall below the switch-on pressure; it switches off again when switch-off pressure is reached. The pressure vessel contains rubber bellows that are under air pressure ("pilot pressure") when delivered; this permits the removal of small volumes of water without the pump starting up.

1. Insert the mains plug.

2. Fill the pump if necessary - see section 6.7

3. Switch on the device:

To switch on the device, press button (3) ON/OFF) briefly, the LED lights up green (blue in operating mode "A").

1. Open the discharge line (open the water tap or spray nozzle).

2. Check that water emerges! The device is not ready for operation.

3. The device switches on and off as required. (See section 7.1)

8. Maintenance

Danger! Prior to all work on the device:

• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.
  Repair and maintenance work other than that described in this section should only be carried out by qualified specialists.

8.1 Regular maintenance

• Check device and accessories for damage, in particular electrical and pressurised components, and repair if necessary.
• Check suction and discharge lines for leaks.
• Clean the intake filter and filter element (if installed) and replace if necessary if the conveying capacity decreases.
• Check the pilot pressure of the pressure vessel (6) (equipment-specific) and increase it if necessary (see section 9.4 Increasing the pilot pressure).

8.2 Cleaning the suction filter (equipment-specific)

1. Unscrew the cover (14) (using the key (13) if necessary).

2. Pull the filter unit (15) vertically upwards.

3. Disassembling the filter unit: hold the receptacle (16), turn the filter (17) clockwise and remove it from the receptacle (bayonet fitting).

4. Clean the receptacle (16) under running water and the filter (17) with a soft brush.
5. Assembly again in reverse order. Make sure that the filter unit (15) is inserted until it stops.

8.3 If there is a risk of frost

Caution! Frost (< 4 °C) destroys the pump and accessories as both always contain water!
- Disassemble the pump and accessories and store them in frost-free conditions (see the following section) if there is a risk of frost.

8.4 Disassembling and storing the device

• Switch off the device. Disconnect the mains plug.
• Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
• Completely drain the pump (5) and vessel (6) as follows:
• unscrew the water drain screw (8).
• remove the suction and discharge lines from the device.
• store the device in a frost-free room (min. 5^ ).

9. Troubleshooting

Danger!

• Prior to all work on the device:
• Disconnect the mains plug.
• Ensure that the device and connected accessories are depressurised.

9.1 Pump does not run

• No mains voltage.
• Check the on/off switch, cables, plug, socket and mains fuse.
• Mains voltage too low.
• Use an extension cable with an adequate conductor diameter.
• Dry run protection has tripped - red LED lights up
• Ensure that enough water is available.
• Press button (3) (ON/OFF) briefly to switch the device on again.
  P 6000 Inox: safety switch-off when the discharge line is closed - red LED lights up
• Open the discharge line
• Press button (3) (ON/OFF) briefly to switch the device on again.
• Motor overheated; motor protection relay has tripped.
• After cooling the pump will switch ON again.
• Ensure that there is adequate ventilation, keep air slots free.
• Observe the maximum supply temperature.
• Motor hums, but does not start.
• If repairs are required, see Chapter 11.
• Pump clogged or defective.
• Disassemble and clean the pump. Clean the diffuser and replace if necessary. Clean the impeller and replace if necessary. See section 11.
• Line/inlet pressure greater than pump cut-in pressure.
• A pressure regulator should be installed upstream, see Chapter 2.

9.2 Pump not drawing in correctly or running very loudly:

• Lack of water, dry run protection is activated. Red LED flashes, green LED lights up continuously, see section 7.1
• Ensure that enough water is available.

• Pump not sufficiently filled with water.

• See section 6.7.

• Suction line leaking.
• Seal the suction line, tighten the screw couplings.
• Suction height too high.
• Observe the maximum suction height.
• Insert the check valve, fill the suction line with water.
• Intake filter (accessories) obstructed.

• Clean and replace if necessary.

• Check valve (accessories) blocked.

• Clean and replace if necessary.

• Water discharge between motor and pump, shaft seal leaking. (Minor discharge of water (max. approx. 30 drops per day) is normal with the use of shaft seals).

• Replace the shaft seal. See section 11.

• Pump clogged or defective.

• See section 9.1.

9.3 Pressure too low or pumps runs continuously (continuous switch-on/off):

• Suction line leaking or suction height too high. - See section 9.2.
• Pump clogged or defective.
• See section 9.1.

• HWW...: pressure switch adjusted.

• Read off the switch-on and switch-off pressure on the pressure gauge (9) and check the values (see section 13 Technical Specifications). Please contact Metabo Customer Service if a modification is required. See section 11.

• HWW.... pump starts up even after a small volume of water is removed (approx. 0.5 l).

• Check whether the pilot pressure in the pressure vessel is too low. Increase the pressure if necessary. See section 9.4.
• HWA... HWAI...: pump continuously switches on/off because of a low flow rate (less than approx. 60 l/h, depending on the model).
• The use of an expansion tank is required when small volumes are removed.
• Domestic water works (HWW...HWWI...) are suitable for the removal of small volumes of water.
• HWW...: water is running out of the air valve.
  Rubber bellows in the pressure vessel are leaking, replace them. See section 11.
• LED (2) lights up blue.
• "Mode A" is activated. See section 7.1.

9.4 Increasing the pilot pressure (only HWW..., HWWI...)

If - in the course of time - the pump starts up even after the removal of a small volume of water (approx. 0.5 l), the pilot pressure in the vessel must be restored.

Note: the vessel pilot pressure (air pressure) cannot be read on the pressure gauge (water pressure) (9).

1. Disconnect the mains plug.
2. Open the discharge line (open the water tap or spray nozzle), allow water to drain off completely.
3. Unscrew the plastic cap on the front face of the pressure vessel; the air valve is located behind it.
4. Mount the air pump or compressor hose with a "tyre valve" connection and pressure gauge on the air valve.
5. Pump up to the specified pilot pressure (1.5 bar; see section 13. Technical Specifications).
6. Connect the device again and check it works.

10. Accessories

Use only genuine Metabo accessories.

Use only accessories that fulfil the requirements and specifications listed in these operating instructions.

See www.metabo.com or the catalogue for a complete range of accessories.

11. Repairs

Danger! Repairs to this device must be carried out by qualified electricians only!

Please contact your Metabo service centre if you have Metabo devices that require repairs. See www.metabo.com for addresses.

For shipment: drain the pump and vessel completely (see section 8.4).

You can download a list of spare parts from www.metabo.com.

12. Environmental Protection

Observe the national regulations on environmentally compatible disposal and on the recycling of disused tools, packaging and accessories.

Packaging materials must be disposed of according to their labelling in accordance with municipal guidelines. Further information can be found at www.metabo.com in the "Service" section.

Only for EU countries: never dispose of power tools in your household waste! Used power tools must be collected separately

and handed in for environmentally compatible recycling in accordance with European Directive 2012/19/EU on waste electrical and electronic equipment and its implementation in national legal systems.

13. Technical Specifications

Explanatory notes on the specifications on page 3.

Subject to change in accordance with technical progress.

The pump characteristic curve (diagram on page 3) shows the conveying capacity that can be reached depending on the conveying height (suction height 0.5m and 1^ suction hose).

E = Electronics / dry run protection

V = Check valve (18) integrated on the

suction connection (10) of the pump

K = M a i n s c a b l e s o g m e n t f = F r e q u e n c y o e n t r a c t i o n

P1= Rated input power PStandby= Standby consumption I = R a t e d p o w e r

C=Operating condenser

n =Rated speed

F_V,max = Max. conveying capacity

Fh,max =Max. conveying height

Fp,max =Max.conveying pressure

p1 =Pressure switch switch-on pressure

p2 =Pressure switch switch-off pressure

S_h, = Max. suction height

S_temp = Max. supply temperature

Temp Ttemp =Ambient temperature

S1=Splash protection class

S2 =Protection class

S_3^2 =Insulation class

M =Pump housing material

M_R = Pump shaft material

M_W = Pump impeller material

D_s =Suction connection female thread

D_p^s = Pressure connection female thread

TV =Vessel volume

Tp,max =Max. vessel pressure

Tp.1 =Vessel pilot pressure

A' = Dimensions:

length x width x height m =Weight (with mains cable)

AC power

The technical specifications quoted are subject to tolerances (in compliance with the relevant valid standards).

A Emission values

These values make it possible to assess the emissions from the power tool and to compare different power tools. The actual load may be higher or lower depending on the operating conditions, the condition of the power tool or the accessories. Please allow for breaks and periods for assessment purposes when the load is lower. Arrange protective measures for the user, such as organisational measures based on the adjusted estimates.

Typical A-effective perceived sound levels:

LpA =Sound-pressure level

LWA =Acoustic power level

KpA, KwA = Uncertainty

L_WA(G) =Guaranteed acoustic power level as per 2000/14/EC

Wear ear protectors!

Notice originale

WAARSCHUWING-Lees de

WAARSCHUWING Lees alle

Pomp verstopt of defect.

Pompverstoft of defect.

Mw =pumphjulsmaterial

D_s =suganslutting,innerganga

3 Painike (ON, OFF, tarv. "Mode A", RESET) *

Tp max =maks. sailiopaine

Tp1 =sailion esitayttopaine

LDA =aanen painetaso

LWA =aenan tehotaso KpA, KWA=epavarmuus

M =Materialepumpeaks

Mw =Materialie i pumpens Iopehjul

F_p, = maks.pumpetryk

p1 =Pressstat: Tilkoblingstryk

p2 =Pressostat:Frakoblingstryk

S_h, = maks.sugehjde

Stemp =maks.tillobstemperatur

T_temp = Omgivelsestemperature

M =Materiale papep peakslen

Mw =Materiale pa pumpelobehjulet

D_s =Sugetilsuttingensindverdige gevind

Dp =Tryktilstuttingens indvendige gevind

TV =Kedelvolumen

Eeaiyevpu,poostia evavti Enpnc Aetoupyiac evpyn.

He donyckaIte 3aJOMOB, 3aJHMaHnHa Hae3da Ha ceTeBOH uYdInHHTeJIbHbI Ka6JIb; 6peRHTe OT KOHTaKTA C OCTpbIM KpOMKaMn, MaCJOM N BbICOKOH TEMpePaTypoi.

4.4 OnachocTh BcJeIcTBHe DeΦeHTOB HnH HeNCnpaBHOCTeHacoca!

Пюверяпт haoc,В OOC6eHHoCTn CeTeBOI Ka6elb, BnKHy n 3JIeKTPnuYeCKHne DeTaIIHa Ha HAIuHne NOBpeKdEHN IpePeKaKDbIM BnIIOUeHHeM. OnaCHocTb dIЯ JN3Hn, OBycNoBLeHNaYdApOM 3JIeKTPnuYeCKHm TOKOM! IOBTOpHoe NcNoJIb3OBAHne NOBpeJDeHOrO HaCoca DOnyChaeTcra ToIbKO NocJe OCyUeCTBJIeHnpeMOHTa KBaJIuФицPoBAHHbIMN CNeuJaINCtAm.

He BbINOJIHnTe
camoCTOaTeIbHbIpeMOHT
Pnp6opa! PpOBedeHne pemOHTa
HaococB n HApOpHBIX
pe3epByapOB (B 3aBnCmOCTn OT
KOMnleKTAuN) pa3peuaeTcR
TOJbKO KBaINΦuNpOBaHHbIMN
CpeuJaNCTamN.

BHHMaHHe!ДЯTOrOyTO6bI n36eKaTb yUep6a OT BODbl, HAnpIMeP 3aToPJIeHnI NOMEuEHN, Bbl3BaHHORo DeΦeKTAMn IIN HeNCnPabHOCTaMn HaCOca:

-П配电CMTOPTNE NOxOJUHMeMepb6e3oNaCHOCTN，HaNP.:ycTPOINCTBOaBAPnHO CNrHaJI3aUNnIINpHEmHbIpe3epByapCfYHKuEn KOHTPOJIA

Pon3BODTeIb He HecET HnKaKoI OTBeTCTBeHHOCTN 3a yUepe6, KOTOpbIMoKet 6bITb HaHeceH B pe3yIbTaTe

• INCNoJIb3OBAHnY yCTpoIcTBA He NO Ha3HaueHIO;
• neperpuy3KN BCJeCDTBHe HnpepbBHO pa60TbI;
  -3KcNlyaTaunn Hnn XpaHEnn yCTpOiCTBa 6e3 3aunTbI OT MOp03a;
• CamocToTeIbHO BHeceHn H3MeHEnB KOHCTpyKUnyCTPOINCTBa;POn3BOiNTb peMOHT 3JIeHTpOpnp6OpOB

pa3pewaeTcra Tolbko Cneuannctam-3nEeKtpnKaM!

-NCNoB3OBAHn3aNaChbIX
YacTeN, He npOBepeHHbIX N He
YTBepKdEHHbIX
PpON3BOIDTeJIem;
- HcnoJb3OBAHnHa HeNoJxOJaIeRo MOHTaXHOr MaTePnaIa (apMaTypa, CoeHNHTeNbHbIe Tpy6OpOBoDbI N.T.I).

IopxOJn MOHTaHbIM MaTePnaI: -BbIDepKnBaET daBHeHne (MnH 106ap);

-TeNIOcToHKn (MnH.100°C)
Pn NcNoJIb3OBAHN
YnIBeRpaCaJIbHbIX NOBOpOTHbIX
(6aJHOHeTHbIX) MyΦT B cIeJIax
HaDeXHOCTn rIaPON3OJIaCNI
DOJIxHbI NCNoJIb3OBAbTCr TOJIbKO
BapNaHTbI NCNoJIHeHnC
DOnOJIHHTeJIbHbIM PpHHmHbIM
KoJIbUcOM.

5.0630p

OnacHOCTb,06yCNOBHeHHaH NcNoJIb3OBAHnEM 3JeKtpoo6OpyDoBaHnHa! He NcNoJIb3yIte HAcOC B cbIpBX

NOMeueHnX N BbIOnHnTe CLeDyUcne ycNoBn:

-Hacoc pa3pewaeTcnoKIOUOaTb TOnbKO KPO3eTKAMC 3aHTbIM KOHTaKTOM,KOToPbIE HaJIeKaIIM06pa3OM yCTaHOBHeHbl,3a3EmLeHbl I npOBepHbl.
- HanpJxHHe cTeN, qacToTa n npedoxpaHnTeIb DOJIHHbI COOTBeTCTBOBaTb TEXHueCKHM XapaKTePncTnKaM.
-ПиТанne arperaTa Должно OcyusectBJIaTbCЯЧepe3 yCTpoIcTBO 3aUHTHO rOTHIOUChENy (Y3O)c yCTaHOBJeHHbIM TOKOM yTeHKn MaKc.30MA.
-3JIeKtpnueckne coeHHeHna 3aIpeaaetcOnyCKaTbB B ONDOJIHHbI HAXODNTbcR B 3aIuIeHHoNOT 3aTOIpHeHn 3OHe.IpnEKCIIyaTaunn BHE NOMEseHn OHN DOLJHHbI 6bITb 3aUINHeHbI OT 6pbI3r.
- YdHnHTeIbHbIe Ka6eJI NDoJXHbI HMeTb DoCTaTOUHOe nonepueHoe ceeyHe Jn. Ka6eJI DoJXHbI 6blTb NOHOCtBIO pa3MOTaHbIC 6apabaha.
-Heo6xOJMo CO6JIOpaTb HaunOHAbHbIe IpeDncaHnno MOHTaKu N yCTaHOBKe.

6.6 YcTaHOBb DaBHeHn NoDnTHn (ToIbKO HWW...., HWWI...)

Ipeep BBODOM B3KcNlyatauHIO HAcTpoTe daBHeHne NOpNTKn.Cm.Rnaby 9.4.

6.7 3aNoJIHeHne HacOca N BCacbIbAHne

BHMaHHe!Pn KaHDM HOBM NOJIOUeHN HIN npYteKe BObl Heo6xOIMO 3anoJHb HAcOC BDOI. 3KcNpyataaHACoca 6e3 3anoJHHeNBA DOOpa3pyuaeT HAcoc! Jra rapaHTn BEcnepeboHn PAoBTb peKOMeHdyem npn nepBOM BBOe B 3KnpyaTaHIO ObecneHTb DOCTatoCHb 3aOp BObl dI INoIHO YdaJIeHNA 03CNCTEmbl. Yka3aHHe: HWWI... HWAL... (HacocBo co BCTpOeHHbIM ΦHbTpOM): nepE 3anoJHHeHEM HACoca CNeDeyET BByHbTFb NnIbTp HAnoJHbTpe3 HApOnhBn NaTPy6ok (12).

• BbIbHNTte pe3b6ObyIO np06ky HAJIbHOro OTBepCTn (11) BmecTe C yIINOTHEHnEM.
• MeJIeHnHO 3aJIbMaTe YIcTcy JO Body, nOHa HAcOC He HAnOIJIHTC.
• ChoBa 3aBHTIe pe36bOByIO npo6Ky HAIIBHOrO OTBepCTn (11) BMeCTe C yIITNOTHEHmE.
• OThpoIe HAnOpHbI Ty6OpOBoD (NoBepHITe BOIPOpOBOHyI KpaH IN CONIIO), YTObI pI IN BCAcbIBaHHM BByXODHTb BO3dYX.
  BknIOHTe HAcOC (cm. rnaBy 7.).
• EÇın BoDA bbIXoNDI pABHOMePHO, HACOC TOBOT K ΚΕΚΝΙΝΑτΑΥΝΙ.

Yka3aHHe: BCacbIbAioUIO LInHIO 3aOpNlHaTb He Tpe6yeTc, TaKAK HAcOC CamOBcAcBIAoOu. B 3aBHCmocnTO DAnHbI NdAmEtPa LNNH MoKeT NPoiTN HEKOTOPOE BpEM Do Tex NOP, noka 6ydtcO3aHO Heo6xOJIMoe DaBJIeHHe. Ecnbl XoHTe COKpATNTb BpEM BCACbBaHnry, yctaHObTE o6paTHb Klanah Ha BXoHOM OTBePCTN BCacBlaIOUe OILHaTRA u TaHoke 3aOpNlHtE BCacbIbAOUIO LInHIO.

7.3Kcnnyataun

BHHMaHHe! Haocn N IINHn BcscBaHnA DOnKHHb 6bTb NOHIOHeHn H3aONJIHeHb (cm. rnaBy 6).

BHHMaHHe! He donyckaeTc paOta hacoc 6e3 zanolHeHn. Heo6xOIMO NOCTHOHE HAIuHne DOCTaTOHOrO KOJIueCTBa nepeKaHbAeMoC pEdbI (BODbI).

Pn6boknoBKe Hacoca HHOPOdbIM TeIOM nnn Pn nperepee3JeKTOPODBrAteTJI CNTEMA 3aunntbOTKHIOUeAET3JeKTOPODBrAteTJIb.

7.1ФyHKHm3JIeKtpOHnK

OThKIOUeHHe HAcoca npn 3aHpbITNI HanOpHoro Tpy6OpPObOda (peKIM OHJDAHIN):

HWW....HWA....HWWI....HWAI.....ecn npia pabotaouehem HACOe 3aKpbTb HAnOpHbI Tpy60npoBd (peepkpbTb BOOnpOBOhB KpaHnn COH, cnyCTBaPem Bb6era HAcOpe9KIOUHTCB PexHM OxNDAHn. 3JeKtpoHnKa npOBepaET npoteKaHne BDOJIpe3E HACOc, eCN NOTOK BOBd He o6hApYKeH, MInraet 3eHbckTOID (2) B TeTeHne 40 nII 70 CeyHd (B 3aBucmocnt OT MoJEn). 3aTEM DnIRaTeIb HACOCA OKLIOHaETCBAccopXODIT B PEXHM OXNDAHn. 3eHbI CBTOID (2) MeJEnHO MInraet. Ppi ONKpBTN HAnOPHO Tpy60npoBOda HACOC BHLIOHaETCABOTMATHeCKn.

P6000 Inox; npn OTCyCTBnN NOToKa BOdbI CBEtOndoHb NHNkAtop (2) MIRaet 3eJeHbIM MeJNEHNO BTEeHNe 20 CEkyHd, 3aTeM 6bICTPO B TEeHne 5 CEkyHd. 3aTeM 3eKtPoDnRaTeNb HACCCA OKTIOHcAeTcN CBeTOnOHDhINHNkAtop (2) Ropnt KpaChbIM.

3aunta ot cyxoro xoda:

EcHn HAcOC He nepeKaunBaET BoY B TeueHne 20 cekyHd, CBeToDnHObH INnHKnAToP (2) NaHnAEt MeNHeNo MrraT b KpaChbIM. Ecl B TeueHne cdeNyUOxH 100 cekyHd Hacoc He nepeKaunBaET BoY, 3eKeTPOBnIaTeJIb HAcoca OCTaHaBnBAeTc H5 CeKyHd (CBeTODnHObH INnHKnAToP (2) bIcTPO MraE T KpaChbIM n 3eNeHbIM), Nocce Yero DeJeAeT NOnBtIK NepeKaunBaHH BoDbI B XoDe 3 NocLeJeuOuXu UINHO. EcN ChOBA BoBHT, HACOC OCTaHaBnBAeTc INnHKnAToP (1) dInTeJIbHo ROpHT KpaChbIM.

Дя NOВТОРΗΟ 3ануcka HAcOca: KpaTHKOБЕмEHо HaKMITE KHONky BKN/BlHJ (3).

3aunTa ot nobTOphoro nycha:

Pnp6op nocTabIeTc 3aBODa C BkIoueHHo3aunTOI OT nobTOPHOrO nycha, KOTOPARnpdoxpanReT np6Op OT HeKOHtpOJIpyeMORBbKIOHnNOCLe NOBpeJKeHn HnNepepbBA B3JeKTHPOCHa6XeHN.

BkHIOUeHHe npb60pa nocne nepepbIbA B 3JIeKTPoCHA6HEHN He pONCXOaNT CAMOCTOReTbeHO, dJNA 3TOr HOyKHO HauKaTb KhONky BHJI/BblKJI (3).

Yka3aHHe:HCNoJIb3ObaHHe6IbOKOBynpaBHeHH
OpoCHTeJIbHbIMN CnCTeMAMNI
NyCKOperyIpyUOuXn npIbOpOB (TaImeP
BKIOHEny,INpOMAT) cAKTHINPOBaHHOH
3aUNTOOT NOBtOPHOrO NyCA HeBO3MOHHO.
3aunTA OT NOBtOPHOrO NyCA MoHET 6blTb
OTKIOHeHa B IIObOM pNBope (cJNEKtPOHnKO)
NYTEM HmEHeHH PAboHero peHima.

N3meHHe pa6OeRo peKnHa / nCnoJIb3OBAHne nycOperyIHypUoInx np6Bop08:

BCTaBbTe BnIKy Bpo3eTKy, HaNKMITE KHOINKy (3) N YDEPKBaIte He MeHee 3 CEYHd.

CBeToIOHbI INHdHAtOp (2) I3MeHIT uBc T 3eJeHOro HA cINH. Tepeh Bacoc MOHHO OIOKnIOUHT b N cyCHOPeryIHypIyOeMyIpi6Opy. DJIa BO3BpaTBACTaHdApTbHI peKHM: CCTAbTe BUNkYbPO3eTK, HAnMHTe KhoNky (3) UyepKBAWte HE MeHee 3 cekyHd.

CBeToNDHOHbI HdHaTOp (2) H3MeHHT CBET C cnHero Ha 3eHeBn. B "peHmE A" BKHIOUeHne/ BbIKIOUeHne HacocA TaHKe OCUJECTBIAETCR NOMOuBo KHOHNI (3).3aunTAOT CYXTO XoDa HNIOHNPyET TAK JHe, KaK B cTaHApDTHom peHmE.

7.2 NcnoJb3ObaHne Hacoca CaoobbHacoc

(0603haeHne np6opa P...)

PpHnnpa60tI: np6op pa6oTaET, noka OH BkIOueH.

1. BCTaBbTe BnIKy Bpo3eTKy.
   2.Пи Heo6xOdMocTH 3aONHnTe Hacoc-Cm. rnaBy 6.7
   3.BHIOUeHHe np6opa: KpaTHKOBpeMeHO HAnMnTe KHONHy (3) (BHJI/ BbIKJI), CBeToNDHbI INHnKaTOp 3aoropITcEzeJeHbIM (B"peJHmE A"-CNHM).
2. OTHPOIte HAnOpHbI Tpy6OpPoBdO (NOBepHHTe BOOpPoBOdHbI KpaH NJIc cnono).
3. Y6eHNTecb, YTO BODa NOwla!
4. Nocle OKOHaHnRA paObTb OTKIOHTe HAcOC: KpaTKOBpeMeHHo HaKMITE KHONy (3) (BHJI/BblHJ). PnHApyuEHNrPnABnB 3KcNpyaTaADn HAcOC NepeKIOHaTeCB B peKIM HeINCPaBHOCTn, RopNT KpaCHbI INDHkATOP, CM. rABy 7.1.

pnn 3ncnlyaataun Hacocac
nycKpOeyIpyoUHmC yCTPOCTBOM (rHDPOMaT, TaMep BRIOUeHINN d.) Heo6xOIMO
nepeKIOuHTb ero B"peKIM A", CM. rna7.1.

ABTomatHueckn HAcoc dIa DOMOBORO BOOCHa6KeHHA

(0603HaueHne np6opa HWA..., HWAI...)

PnHun npabToI: np6op BkIOuHaTcR,ecINBpe3yIbATE paXoDa DaJIbeHHe BObl NaaTeHNHe NOpRa BkIOUeHn, INCHOBbIKIOuHaTcPnpDcTOHKeHHNPOrA OTHIOUeHn.

1.BctaBbTe BnIky Bpo3eTky.
2. ПИн Heo6xOdMnOCTN 3aIOnHnITE HAcOC - CM. rIaBy 6.7
3.BHIOUeHne np6oba: KpaTHKOBpeMHO HAnMMte KHNHy (3) (BHJI/ BbIKI), CBTODnHObl NnHnKaTOp 3aTOpNTc3eJeHbIM (B"peJHmE A"-CnHM).
4. OTHPOIHTe HAnOpHbI Tpy6OpBoD (NoBepHHTe BOOpBOpOHyKpaH NmI cOnnlo).
5. 86eJIInTeCb, YTO BOda nouila! PnIb6Op rOToB KpaBoTe.
6.ПибборВнIOUOaTeСТИ ВБИКIOUOaTeСТNO Heo6xOДmOCTn.(CM.RIaby7.1)

Hacocha CTAHU

(0603haueHne np6opa HWW...., HWWI...)

PnHnHn paBoTb: npH6Op BkIIOUaTeC,ecnBpe3yIbTaTe pacXoDa daBJeHne BObl NaaTe HHe nOpora BkIOUeHn, uCHOBa BkIOUaTeC npDooTHKeHHn nopora OTHIOUeHH. KToEt NMeet pe3NHOByo DnaΦpaMy, HaxOraSyuOcN oD aBJeHnEM Bo3Oyxa ("DaBJeHne NOIINTK"); 3TO No3BOJrAOT cOyueCTBIArTB 3a6Op He6oJIbXIN KOIMHeCTB OBObl, He 3aNycaH Haoc.

1. BCTaBbTe BnIKy Bpo3eTHy.
   2.Пи Heo6xOdMocTn 3aIOnHInTe HAcOC-CM. rnaBy 6.7
   3.BKJIIOHHe npIbopa: KpaTHKOBpeMeHO HAnMnTe KHNHy (3) (BHJI/ BbIKJI), CBeTOnIOHbIy INHdNkAToP 3aTOpNTc3eJeHbIM (B"peJHXMe A"-CHNM).
2. OThpoIte HanoPbIy Tpy6OpnoBd (NoBepHnTe BOJOpBoDhI KpaH nnI conIIo).
3. 6bEaTEcB, yTO BOda nooJla! PnH6Op roTob K paObe.
   6.ПибовВнIOHuaeTcNИБИKIIIOUaeTcN NO Heo6xOJIMOCtN.(CM.IIaby7.1)

8. Texnuechoe 6cbnyhBaHne

Onachoctb!peepnpoBeeHnemIIO6bix pa60Ha np6ope:

• N3BNEKHTe BnIky n3 po3eTKN.
• Y6eIntecb,уTO npIbOp nOIOKlnIOUeHHO HEMyOBpyOBOaHHe HAXOJaTcnoD DAJIbNeHem.
  Bce OINCAHbHe 3eCbe pa60tbo n ToxobcIyKuBaHnIO HpeMOHTy DOJIKNHbBiBOINHTbC TOJbKO CneMaJNCTAMn.

8.1 PeryJIaRHOe texHnuechoe 06cIyKHBaHne

• PpOBeBPte npHbOp n OTHoCnueecK HEmy oOpyDoBaHne,OCoBeHHo 3JIeKTPnuecKeN I hXaDIOuEeON IO DaBHeNMe DEtaJIn,Ha OTCyTCTBnE NOBpeKdEHN,piP Heo6xOAnMoCTOn OTaIte B peMOHT.
• PpOBepbTe BCaCbBaIouzm HAnOpHbI Tpy6OpBoDbl Ha repMetnUHOCtB.
  -Пи снгжени мошостп подачи рочитп Илл заменITE BCaыBaоши Флььт и Сменийфлььтуюши лемент (при Нeo6хдимoctn).

PYCCHNru

• PpOBepbTe DaBHeHne NOpNtKn KoTna (6) (B 3aBnCHMOCTH O KOMPNeKToAun), npn Heo6xDMocTH YBeJIuHbTe DaBHeHne (CM. rIaby 9.4 YBeJIuHHe Hae DaBHeHn pOtnTNk).

8.2 OuNTKa BCacbIbAoUeO fNJIbTpA (B 3aBnCmOCTH OT OChaueHna)

1. OTHpyTHe KpbIuKy (14) (npn Heo6xOIMocTu C NOMOUsbKIOUva (13)).
2. BbHbTe 6nok fNbTppa (15) BeptnKaIbHO BBepx.
3. Pa36epnTe 6IOK ΦnIbTpα: ydpeHnBaTcAaH (16), NOBEPnTe ΦnIbTp (17) noCacoBoN CTpeJIke N CHIMTE Co cTaKaHa (6aHHeTHOE COeINHeHne).
4. PpOMoHTe CTAkAH (16) NOJ pPoTOH OBOH, OHCTHTe FmIbTp (17) MfKOH UcTKOi.
5. C6epeHne 6Iok fIbIpa B o6paTHoNocEIOBaTeJIbHOCTN.O6paTne BHIMaHHe HaTo, 6Iok fIbIpa (15) 6blBCTabJeHdo ynopa.

8.3 Pn onachoctn 3aMepe3aHn

BHHMaHHe!Mop03(<4°C)pNBoDnT K NOBpeHDeHIO yCTpOHTBA H pNHaIeJHEoCTe, TAK KaH B HNX NcTOaHHO COepKHTCA BOA！

• Pn onacnoctn 3aeme3aHnH Heo6xOdmo pa3o6paTb np16op n npnaHadJeXHOCTn npaHnTb B 3aunuEHmOH OT MOp03a MeCTe (CM. cneDyUosn pa3deJ).

8.4 Demontan XpaHHe np6opa

• BbIKIOHTe npH6Op. N3BJIeKITe BNJky n3 pO3eTKN.
• OtkpoIte HanoPbH Tpy6oPBOd (noBepHnTe BOIOPOBOHbIKpaHnnCOnIO), POJIHOCTbO CNYCTNE BOyD.
  -NonHOCTbO ONOPOKHHTe HAcOC (5) nKOTen (6), 173T0rO:
• BbHpyTne pe3608yIO npo6ky BOOcINBHOOTBepCTna (8).
• DEMOHHTpyuTe BCacbIbAIOuMn HAnOpHbIM TpyoONPOBOdI arperaT.
  -XpaHntbarperaTcneyETBHe3aMepe3aIOuE MoneueeHHMn.5C).

9.1 Hacoc he pa6oTaet

Cetbeoe HapraKeHHe OTCyTCTBye. -PnoBepbTe nepeHIOuHateIb BkJI/BblKJI, KaebI, cetBeYIO BuNHy, po3eTHy npeDoxpaHHTeIb.
CetEBoe HAnpRHeHHe CnIuKOM Hn3Koe. -NcNoIb3yIte ydInHHTeJIbHbI KabeIb cdoCTaTOUHbIM IOnpeUHbIM CeEHnEM JnnI.
Cpa6o7ana 3aunTa oT cyXoro XoJa - ropnt KpaChbI INHdkaTop.

Y6eHNTecb, YTO BOBbl DOCTaTOHNO.

-ⅡIIOBTOHPORO BHIIOHENKpaTHOBpeMeHHo HAKMHTe KhoNky (3) (BHJI/BblHJI)

P 6000 IInox: 3aunTHoe OTKIIOUeHHe NpN 3aKpbTOM HAnOpHOM TpybOpBOe - TropNT KpaChBn INHNkATOp

• OTKpoTe HAnOpHbI Tpy6oPoBOd
  Дл NOBTOPHORO BHLIOYEHINKpaTkoBpeMeHHo HAXMmTe KhoNkY (3) (BHJI/BblHJ)

• DBuratelb neperpeT, cpa6otana 3auuTa DBuratela.

• NocJe OxlaJxdeHn HAcOC BHLIOHTcCHOBABTOMATNUeCKH.
  -Длобесс electндостаюнов BEHTNIAHINDEPHTeBEHTNIAHNOHHU OJIeIb CBOOHDH.
• C6bIIOJaTe MaKcHMaJIbHyIO TempePty npaH.
• 3neKtpoDbnBraTeNb rHydN, He 3anyckaetc.
  Tpe6yETcpeMOHT,cm.rnaBy11.

Hacoc 3acopnncn HnneepaBeH.
- Pa36epnte n npochtne 3JIeKTOPOBnArTeIb. IpoocHTne nn 3aMeHInTe nDΦyO3p. IpoocHTne nn 3aMeHInTe pa6ooye KOleco. CM. rJaby 11.
-AbHeBnHn/HaBXOeBbIeDaBHeNBAKIOUeHnHaCocA.
- PoiKIOHHTb peykTOp, cM. rnaBy 2.

9.2 Hacoc BcacbBaet HenpaBnIbHO nIpa60aTeOeHb rPOMHO:

• HexBaTKa BOJbl, aKTHBHa 3aUHTa OT cyXoro XoJa.
  KpacbHnHdkaTOp Mrraet,3eHehBnHdkaTOp ropnt NoctoHHO, CM. rnaBy 7.1
• y6eHntecb, YTO BOBblOCTaTOH0.
  Hacoc HeoctatoHc 3aONHeB Odoi.
• CM. rnaBy 6.7.
  HerepmetnHa BcacbBaiouaa JInHna.
  -ObecneYbTe repMeTHuHOCb BCacbBaHOueJ LInHH,3aTaNHTpe3b6oBbIe CoEINHeHn.
  CnnKOM 60JbwaBbICota BcacbBaHnA.
• C6bIpaTe orpaHnueHn no BbICote BCaCbIbAHn.
• YcTaHOBInTe 6oPaTHbM KlaHn, 3aNoJIHnTe BCaCbBaIOUyIO HnHIO BOOn.
  ΦNJIbTp BCacbIbAIOUSeJ IINHIN
  （DOnonHnTeIbHoeO6OpyObaHne）3acopnncr.
• PpOuHCTHe HJI, pN Heo6XoHMoCTH, 3aMeHHTe.
• O6paTHbI KIIaANH (DOnONHTeJIbHOe 606pyoBaHHe) 3a6IoKINPOBaH.
• PpOuNCTHnE nI, pPn HEO6XoDmOcTn, 3aMeHInTe.
• YTeUHa BODbI MeHJy 3JIeHTpOdBnraTaeIeMn HAcOCOM, TOPcEBoE yNtOThHeH HeRpeMeTuHO. (He3HaUHeTbeHbAa YTeUHa BOBb (MaHC. 30 Kaenb B DeHb) oByCLOBHeHa KOHCTpyKUnne TOpueBOrO yNtOTHHeHNA
• 3aMeHHTe TOPueBoe yIIOThHeHHe. CM. rIaby 11.
  Hacoc 3acopnncn Hn HcnnpaBHe.
• CM. rnaBy 9.1.

9.3 DabJIeHne CInnHOM Hn3Hoe HnHacoc pa6oTaET HenpebpBbHO (noCToRHaHoe BKNIOHe/BlkIOHeHc):

BcacbBaHuaJINHnHerepMeHTHaNn BbICota BCacbBaHHCmUKOM 60JIbuaa.
-CM.rnaBy9.2.
Hacoc3acopnIcnnHeNCpPaBeH.

Cm.rnaBy 9.1.

HWW...HeBepHO HacTpoEH MaHOMetpueckn IpeekIIOuOaTeJIb.

3aMepbTe daBHeHne BkIOUeHn H ByIKJIOeHn npN NOMOJI MaHOMeTp a (9) nI pOBeBte 3aHcEHn (CM. Tnaby 13. TexHnueckn XapAHTepcTnKn). B cnyae Heo6XoDMOCtN HAcTPOHn ObaPntEcb KInHeTcKyO cNy6y KOMpAHm Metabo.Cm rNaby 11.

HWW....:Hacoc cpa6aTaBbAet yhe npn He3NaHTeNbHOM (OK.0,5) 3a6ope BODbl.

E =3JeHTPOHnKa / 3aunTa ot cyxOro XoVa V =06paTHbI HAnan (18) Ha BCacBbIAOuEM nATpy6ke (10) HAcoca

K = cTeB0N Ka6eIb U = HapJKeHnE ceTn
f = cactota P1 = HOMHnAIBHMA
PStandby=paCXoB BpeKHeMoeOHHaHn

HOMHaJIbHbI TOK

C = 10aBouyKoHDeHCATOp
n = HOMINAHbAa CHKOpSTbPaB
FV,max =MaHC.Ipon3BODInTeIbHoCTb
h,max =MaHC.BbICOTa nodaqu
Fp,max =MaHC. dAbHeHne noDaun

p1 =MaHOMeTpueChn nepeKIOHaTeIb: daBHeHne BkIOUeHn

p2 =MaHOMETPNUChKNIpeHIOuHaTeIb: DabJIeHNEOTKJIOUeHHN

S_h,max = M a K C BbICota BCacBHaHnA S_temp = M a K C TEmpepaTpyaNoaHn

Ttemp =TeMnepaTypa OKpyKaOuSe CpeDbI

S1 =Knaacc3aunntbIOT6pb13r

S =Knaacc 3aunTbI

S3 =Knaaccn0laun

Mp =MaTePnAknKOpnycaHacoca

M=MaTePnA BaJa HacOca

Mw =MaTePnA pa6Oyero Koleca Hacoca

DS =BHYPTeHHa pe3b6a BcacbIbaiooera naTpv6ha

Dp =BHyTpeneHHpe3b6a noHIOueHn HAnOpHOnIINHN

TV =EMKOCb KOTla

Tp,max =MaKc. daBHeHne B KOTNe

Tp.1 =aBHeHne noDnNTK KOtna

A = pa3Mepbl:

INHaX WInpHnA X BbICota

BEC (C CTeBbIM KaBeJEM)

～ nepemehhboTOK

Ha yka3aHhIbe TexHHeCKHe XapaKTepnCTHKn paYpOcTpaHIOKTO COnyCN (PpeyCMTopeHHbIe DeHTBvOuIMM CTaHApTaMn).

3HaueHn 3MnCCn Wyma

3TN 3NaueHnnaoNOBnOHT OueHnBaTbN CpaBnHBaTb 3MnCCnIO Wyma pa3AInNHbIX 3NeKTPOHCTPymeHToB. 3aBACmocnOT ON yCNoBn 3KcPiNyatau, COCTOBHn 3NeKTPOHCTPymeHaTa HnNCnObl3yEmoH INCHPTyMeHtAHLHO OChAcTKn PaHTNuEcKaar HaPy3Ka MoTe 6bITb BbIe Nn HnKe. DnO ueHKn npImepHoY oPoBHg 3MnCCnn YUHTbBAHe Tne nepepbIBb I BaOte Nn Pha3bPaObTbc NoHNHeHHo WymoBO Harpy3KoJ. OnpeJeNte NepeyeHb Me, HanpImep, opraHn3aunOHbIX MepOpnpAITn, NO 3aUnTe nObl3OBateLa C yYeTOM Tex Nn HhBx 3NaueHn 3MnCCn Wyma.

TINHnHbAmIHTyHO-B3BeWeHHbI yPoBHeB.

3BYKOBOO DaBJIeHnI:

LpA =yPOBeHb 3ByKOBOrO daBHeHnA

LWA =yPOBHeB 3BYKOBOMOuHOCTH

KpA, KWA=Ko3ΦΦnμηENTnORpeWHOCTN

LWA(G) = rapaHTnpoBaHHbI ypoBeHb 3ByKOBOI

MOUHOCn corlacho 2000/14/EG

HcnoIb3yIte cpeCTBa 3aunIbI opraHOB cnYxa!

EAC

HΦopmaqnaДЯ noKynataeIa:

CepTHΦHKAT COOTBETCTBNA:

No TC RUC-DE.5J08.B.01787, cpoK DeiCtBnA C 10.10.2018 no 09.10.2023 r., BvldAn OprAHOM nO ceTpNfKaun npOdyKnun «IBAHOBO- CEPTNUHAT» OOO «IbAHOBCNΦOnd CeTpNfKaun); AApEc(lop.nΦaKT.): 153032, Pocchckan Aedepaun, IBaHOBCa o6n..r. IBaHOBO, yL.CtaHKoCTpOnTeJe, d. 1; TeJ. [phone]; E-mail: [e-mail]; ATTectat aKKPeDHTauu No RA.RU.115J08 ot 24.03.16 r.

CtpaHa n3rTOBHeNHa: HtTaI

Пожибовиел: "Metabowerke GmbH", Metaboallee 1, D-72622 Nuertingen, Германь

HmnpTeB Pocn: OOO"MetaboEpaia
Pocn,12723,MockBa yI.5epe308a aJIe,45a,ctp7,oΦnc 106 TeI.:[phone]

Data npn3BODCTBa 3aunPhiPobAHa B 10-3NaHOM CepHHOM HOMe HNCTPymeHTa, YK3aHHOM Ha Eero nnBHe.1 auPpa o6o3NaHaet rO, HapnMep «4» o6o3NaHaet, YTO n3dJe NpOIN3BeEOH B 2014 roy. 2 n 3 auPpbI O6o3NaHOT HOpE MecaBa R doy PnpOH3BOCTBa, HapnMep «05» - MaJ

Cpok cny6bln3dEInna coctabnre7 let. He peKOMeHdyetcK 3KnIpyatauIN NO nCTeHeHN 5 let xpaHEnN C DaTb N3rTOBLeHn 6e3 PnpaBapntelbHn npOBeKn (DaTy H3rTOBHeHn cm. Ha 3tNKeTke).

OprihaIbHa iHctpyKci3 ekpnyataqii

1. DeHnnapaui npo BiDIOBIDHictb

3i BcIEO BiNObIaIbHicTIO 3aBbIeMo: iHaHacOH/ NobyTOBI HAcOCHI CTaHJIABTOMaTHHI HAcOCHI cTAHJI 3IeHTnPHiKaIeEO 3a THNOM I HHomePOM MoEJI *1) BiNObIAoTb YcIM dIOHM nIOJHOHN M DpeKTHIB *2) I HopM *3).TexHiHy DOkymeHTaIio Jn4 *4)-DIN. H CTOP.3.

2.BnKOpncTaHHa 3a npH3NaeHHaM

LepnnpnaD npn3NaHEn nI npaHHN YnCTO BOnn npn oCbYrOBvAHHi 6yHNKB i caDBHX DJIHOK, nI dOoUyBaHH nI 3pOuYBaHH, k CBepdIOBHNn HAcOC, HAcOC IINNEPONMnyBaHH DoOuOBx I TexHIhNX BO, I BIDNOMNyBaHH BoN 3 baceHIB, CTABKIB i pe3epByap.

Hacoc He po3paxoBaHH Ha TaKi yMOBn:

LcH npnAa He NOBHe HBNOPNCOTByBaTNC OOC6AMn (BHIOUOaOuN DIteH),RiH He CNpOMoHHI BNOPaTHC3 3HMM B CNY CBOIX O6MeKeHNX fHIHNX,NCHXUYHX a0b CeHCOPHNX MOHINBOCTe, a TAOK B CNY BiCyTHOCTI 3HAH Ta/a0 DoCBiDy.

3a6bopohnctcbcamaobilhe BHeceHHN 3MH B KOHCTpykuio Hacocaa, a TAOX BHOKNPCTAHNI DeTaeIJI, He NI pOuWIn BNIpOboBaHHi HE Do3B0JEnI Do 3actocybaHHNBIPO6HNKOM.

Byb-RAe BNKOpNCaHHa HAcOca 3 NopyWeHHAM npabnI NOr EKCpNlAyatai BBAxAeTbCBA BNKOpNCtAHm He 3a pN3HaHeHHAM,Ke MOKe np3BecTN Do HenepedBaayHex 36ntkIB Ta TpaBM! 3a NowKOHeHHARBVKNiKaHI eCNPiYatauieHO He 3a np3HaHeHHAM,Hece BIbONiAbJbHCTb BHKIOUHO KOPcICTyBaV.

Heo6xioH DoTpmyBaTHc 3aRaIbHOnpNnHrTnx npabU H3ao5BirAHn HeuacNHm BuaJaKAM, a TaOK npabIn TexHkN 6e3neKn, npBeDeHNX B ciHCTpyHui.

3. 3araIbHI npabHla texHiKn 6e3neKn

IaBooi BlaChoi 6e3neKn I 3axHcTpynpAHy BID yUkOJKeHbDpIMyHTecB bHa3iBOK,IO BiMdyHeIzHM CmBOOM!

NONEPEDHEHHH-3IJIIO 3HNKHeHHn pINHNYOTPMAHNR TEINECHXyIKOKeHb PPOHTAHTe IIO HCTpyKUio 3

eknnyataui.

PONPEДЖEHHA- OЗнайOMTeC3 3ycima npabHAMn Ta BkazBkAmn 3

TexHki 6e3eHH. HeOpTpMaHH npabn Ta Bk3iBOK 3 TexHki 6e3eHH MOHe pN3BcTeN DO yApDy eEeHTpHUM CTpyMOM, NOKeHi Ta/abo TAKHKII TIECHHX YUKOJHHeB.

36epiraTe npabnTa bHa3ibH 3Texhih 6e3neKn JIA MAH6yTHbO R BHOpNCtAHN. IpepaBte BaW HACo TIlbKn pa3OM 3UIMN DOHYMEHTAMN.

Inhopmaqia no3haueHa Buii iHCTpyKu3 3eknlyataaHactynHM YHOM:

He6e3neka! NonepexdKeHH npo He6e3neky TpaBMyBaHH a60 WkoDN IJIa IJNA.

He6e3neHa ypaKeHnHa eHeHTPNuHM CTpyMOM!IonepeJHeHHnpo He6e3neKy TpaMyBaHH 360ky eHeTpKNi.

Ybara!PonepeHKeHHn npo MoHJIbIMATEpiJIbHi 36HTK.

4. CneuaJIbHi npabnla texhikn 6e3neHn

He Do3BOJAEbCByNKOpNCtAHHnHaCOca DiTbMn iPiDiITKaMn,a TaKoX OcO6aMn, IIO He O3HaNoMmIINc3 KepiBHNCTBOM 3EeKnLyataii.

CniHynte 3a DiTbMn, Oo6 BOHn He BnKOpNCTOBvBaJI npHaI dIy irop.

PnBnKOpncTaHHi y 6aceHax i CTaBkax Tpe6a DToTpMByBaTnCn noJxHeB DIN VDE 0100-702, - 738.

ПдкюаTe npILAДdo
eIekTpOmepeKi uepe3 npncTpii 3axnCHoro BiKIOUeHn（ПЗВ）з MaKcIMaJIbHm CtpymOM BHTOKy 30 mA.

HeD03BOJAEbCBAHKOpNCaHHHaocOa，Akuo yBoDi3HaxOJaTbcraIIOuN.

PnPiKluOeHHI DO NO6yTOBOi
CNCTeMI BOOnoCTaHaHn
NOBnHi BnKOHyBaTnC
NIOJKeHHaKHOY BiDHOcHo
BOOnoCTaHaHHi
BOoBIIDBeDeHHa, a TaKOH
NoJKeHHi DIN 1988.

PnEcknlyaTauiHacociB i HanipnXpe3epByapB (3aJIeKHO BiKOMnIeKTAuii) icHyIOb HAcTyNHi 3aIIuKOBi He6e3neKn, Rki He MoKHa NOBHcTIO yCyHyTu, HabITb BKNBUn HaJIeKHi 3axOJn 6e3neKn.

4.1 He6e3neka, nob'3aHa 3 BnINBOM HABKOINHbOro cepeOBuca!

He 3aIinwaIte Hacoc nID Doouem. He BnKOpncTOByIte HACOC y BOIOrnx i CnpNx npMiuIeHHx.

He BnKOpncToBvIte Hacoc y Bn6yXoHBe3neuHnx npMiuEHHa6o n6Ln3y ropUOuNX pIDIN Ta ra3iB!

4.2 He6e3neHa, NOB'3aHa 3 rapraHIO BOHO!

He6e3neKa! BcTaHOBiTb 3BOpOTnKlaNaH Ha BCMOKTyBaIbHOMy naTppy6Hy (10), 3aNo6iTn 3BOpOTHomy BiTOky BOIn y BCMOKTyBaIbHi IiHi. Ye DO3BOJNTb 3MeHUnTI NaCTynHi He6e3neKn:

Tapraa BOda MoKe Ipn3BecTn do NOWKoJxHHe a60 HeRepMeTnUHOCTi Hacoca i 3'EdHyBaIbHnx Tpy6OpBoDIB, BHacIIOK YOTo rapya BOda MOKe NoCTyNaTn Ha3OBHi. He6e3NeKa onIKIB!

Hacocn 3 no3haueHHaM HWW....
RAIO TNC BiKJIIOUeHHA
MaHOMEtPnuHOro BVIMKaHa He
DOcraEbCBAHcIIOK
HEKOpeKTHnx HalaTuBaHb a60
DeΦeKTy camOro
MaHOMEtPnuHOro BVIMKaHa,
BOda B pe3yJbTaTI BHyTpiaHbOi
UnpKylaui ycepeDiHi npncTpoIO
MOHe HarPiBaTnCra.

Hacocn 3 no3haueHHm P.... TpNBaicTb ekCnlyaTauii Hacoca npn 3akpnTomy HanipHomy Tpy6oPBODi He NOBnHa nepeBnUyBaTu 5 XBnInn.BoDa, UnpKuIIOUa ycepeDnHi Hacoca, HarpiaCTbcra.

Y pa3i HecnpaBHOCT BiJ'EDHaNTe
Hacoc BiE eJeKtpnHoi MepeXi i
daIte Iomy oxoIoHyTu. NpeEd
NOBTOPHM BBeDeHHM B
EeKnIyatauio DopyuITb faxIBcM
nepeBipNTn CnpaBHiCtB
fynKciOHyBaHNr npnaLy.

4.3 He6e3neHa, NOB'3aHa 3 eIeHTpHIO!

He HanpaBnIte CtpymiHb BOni 6e3nocepedhbo Ha Hacoc a6o Ha iHsi eJeKTPnHi KOMNoHEHTN! He6e3neKa dJa JHTT, NOB'3aHa 3 ypaJxehnM eJeKTPnHm Ctpymom!

He donyckaetbc npOBeHnro pObit 3 MOHTaKy i TexHiuHoro o6cIyROByBaHHra Hacoca, nIKIOueHOro do eJIeKtpnHoiMepexi.

He 6epitbcra 3a MepeKeBy BnIky BOIOrIMn pyKaMn! 3aBKnTgHiTb 3a WTeNcEJIbHy BnIKy, a He 3a KaBeIb.

He donyckaTe neperHaHHa3aTnCKaHH,po3TayBaHH a60Ha3dy Ha Ka6eIb JHnBLeHHnIOOBKByBaIbHN Ka6eIb;6epeKiTb BiD KOHTaKTy 3ROCTpIMN KpOMKaMn, OJNBi BHCOKHX Tempepatyp.

4.4 He6e3neKa BhaCNIIOH DeΦeHTIB a6o HecnpaBHOCTeHaOcA!

IpeBipraHte HAcOC,oc6nBO Ka6eJIb KINBHeHHa,STeKepi

eIektpnHi DeTalHa Ha HaeBHicTb yKoDKeHb Neped KOHHM BKnOueHHa. He6e3peKa dJa KHTT, NOB'3aHa 3 ypaKeHHa M eIektpnHm CTpyMOM!

NoBTopHe BnKOpNCTaHnHa NoHKoJKeHOro HAcOca DOnyckaTbCra TIlbHn NiCJIpeMOHTy KBaJIΦIKOBaHmN faxiBqMn.

He HamaraTecra camocTiHOBiDpeMOHTyBaTu Hacoc! PemOHTHacociB i HanipHnx pe3epByapib(3aJIeKHO BiKOMnJIeKTAuI)DO3BOJRAETbCra TIIbKNKbaIiΦIKOBAHmΦaxIBaMn.

YBara!ДЯTORO，06 yHnKHyTN3bNTkIBBIDBOHN, HAnpNklaad3aTOnJIeHHJ npMlueHb,BnKlnKaHOro DeΦeKTamna6o HeCnpaBHOCTaMnHaocca:

-3anlaHynte HaleJHHi 3axONI 6e3neHn, HanpHKlaI aBapiny CnHaJI3aIIO a6o npNIMaJIbHNI pe3epByap 3ФyHNJIeIO KOHTPOJIIO

Bnpo6HnK He Hece BiIIOBIAaJIbHiCTb 3a 36NTKN, BHKInKaHI HaCTyINHMn DjamN:

-BNKOPnCTaHHHaHCoCa He 3a npn3HaueHHM;

• NpeBaHTaKeHnBhAcIiOk 6e3nepepbHOi po60t;

• ekcnnyataia a60 36epirahnHaacoca 6e3 3axncty BiD MOp03y;

• camOCTiHHe BHeCEeHHa 3MiH B KOHcTpyKciH Hacoca. PemOHTeJIeKTHPOIHcTpymeHTy NOBHeH 3diINCHIOBAtncr TIlbKn KBaJIiΦIKOBaHmN φaxiBzMaMeJIeKTHpKNAm!

-BNKOpNCtAHH3aNaChHX qactnH,He nepeBipeHnx i He 3aTBepdKeHx Bnpo6HkOM;

-BNKOPNCaHHHeHpNiDaTHOROMONTaXHOrMaTepiany (apMaTpya,3'edHyBaIbHi Tpy6oPBoODoNToio).

HaJIeKHi MaTepiAIn DnA MoHTaKHNx pObiT:

-BNITpmyIOTb TnCK (MiH.106ap)

-TeNIOCTiKi (MIn. 100^ )
Pn BNKOpNCtAHHi
yHBepcalbHnx NOBOPOTH
(6aNoHETHX) MyfT dIa H
rIdpoisOlaqii NOBHHI
BNKOpNCTOByBaTHcA TiNb
BapiaHTN BIKOHAAHH3
DOaTHOBIM npNTNCKHM
KiIbceM.

5.Orna

INB.CTOP.2.MaIOHKnMOHyb CnyKHTn npHnaDMBAIX MOeNei.

1 CbitIoDHN iHnKaTOp (nomnka)
2 CbIIOJHn iHnKaTOp (yBIMK.,peHnM OiYBaHH, iHo)
3 HhONKa (yBIMK., BMMK. a60 "peKIM A", CKNDAHH)
4 NaHeIb ynpabHnHa
5Hacoc
6 HanipHHn pe3epByap (pe3epByap) *
7 Nobitprn H Knaan TnTCHy nHnBHeHH
8 Pi3b60Ba npo6ka BOO3JIbHOrO OTbOpy
9 MaHOMeTp (TnCK BODN)
0BCMOKTyBaIbHn naTpy60K
1 P3b60Ba npo6ka HAnBHorO OTbOpy
2 HanipHH natpy60
3 Hniou
4 Kpnuoka
5 EnoK fInbTpY*
6 Kopnyc
7Φinbtp
8 3BbopoTHn Klaan
3aJIeKHO BiKOMPJIeKToaJIi

6. BBeHb EcknIyataciio

6.1 BctaHOBHeHH

Pnncpii cnid BCTaHOBIOBATn ropn3oHTaJIbHO, BCyOMy (MaKc. BOIoricb NOBITpr 80 %), Do6pe npOBITPOBAHOMY, 3axuHEOMY BiD atMocFepHNX BINBIIM CMIci. Heo6xIDHO 3a6e3neuHTN HADHIcTBtCIHtIKCTb TaOKxPi MAHCMAHBOMHYANOBHeHHI npCTpOIO BOIOIO, BeTHnLIJI Hi OTBOPN MaOTb ByTN BiDKPNI T 3axuHEni BiD notpAnHHN6pyd. BiDctaHb DO CTIH Ta iHUNX npEdMeTIB - He MeHue 5 cm 3axnCT BiD MOpO3Y -DN.B.Po3dn 8.3.

UOyHKHTBipauiHACOCHeMa6byTN KOPCTKINPIRBNHeyH,BIH NOBHeH BCTAHOBIOBaTcHa eactHyPiHkaHy

Pn ekcnnyatau y cTaBkax i
6aceHax hacoc Mae 6yTH
BCTaHOBLeHn 3 ypaxyBaHHM
MOxJIbBOrO pIiNOMy pIBH BOni
3axNiueHn BiJ NaIDHH.
Heo6XiDn ToKoX BpaxOByBaTH
DoaTHKOBI BmOrn, No3HaueHi B
3aKOHODaBcHx aKTax.

6.2 PidKIOeHHBcMOKTOBaJIbHOJIiHII

Ybaral BCMOYBAJbHa LiHMa 6yTN 3MOHTOBAHa TAK, IOB OHA He YHHJIa HIAKOI MEXAHIOI iI abo HanpyrHa Ha HACOC.

Ybaaral BnokopctobuyTe npHmAbhnni 0fInbTp，zoo3axnCTHTn Hacoc Biid ncky i 3a6pydHeB.

YBara!IooB Oda He Bntikana 3 BiHIOUeHO HacocA,06OB'RAKOBO

NOTp6eH 3BOPOTHNI Klanah.MI peKOMeHNyEMO BCTAHOBJIeHH 3BOPOTHIX KlanahIB Ha BXiDHOMY OTBPOBCMOKTYBaIbHOrO WlaHaRaI HA BCMOKTyBaIbHOMy NaTPb6Hy (10) Hacoca. 3aJeHXIO BI MODeI, 3BOPOTHI Klanah MOKe 6ByTN BkE BCTAHOBJIeHH (INB.po3d1n 13. TexhiHi XapaKTePncTkn).

Yci pi3b6oBi 3'cHaHH MaOToB 6TyN
reMpTeH3OBAHI 3aDonMOTOU yuINbHOBaIbHOi CTpiHK (10-15 0eptAanh b HanyPmKpy p3b6n).
Yepe3 HePeMpTeHHi Micra BiDyBaETbcra
PiDCMOK TYBaHNr NOBITpR, BhAClIOK YOrO
3HNHyETbcA ao PnINHReTbcBCMOK TYBaHHBOHN.

BHytrpiuHiametp BCMOKrYBaIbHOI liHHIOBNiHEnCKlaTaHNe MeHeue 1"(25 MM)BOHaMae6ByTnCTiHaNo3aIyMaYBaHbIbAkyM.

BCMOKTyBaIbHa LiHr Ma6 ByTN HAcTInBKn KOPOTHO, HAckJIbHN Ce MOxJIINBO, OCKJIbKN 3i 36IbIbHEHHoDBKHN LiHII 3MeHJyETbCn NOTyHKHcTb NpaHn.

BCMOKTYBaHbHaJIHrOBINHnNoCTIHNOiNDHMATNCyHANRPMHyDo HACOCA,06eHoDONYCTNTBIMNKHPHEHHNOBITPRHNXKNIWEHb.

Heo6xioHO 3a6e3neuHTIOCTaTHIE NIBBeEHNA BODnA KHeCb BCMOKTyBaJIbHOI NIIHIOBENHE 3ABHN3HAOINCHy BOiCNIkyTe 3a THM, Oo6 BCMOKTyBaJIbHa IInHe HE 3hAXOINAC Ha DHI, o6 nicOH ao 6bpd He nOTpanHH BCEpDHy. 3JieIO MeTOHO MOKHa

CHOPNCTyBaTnCn PIIaBaOHm BOO3a6OpOM,IO BXoDnTb Do nepeliny npnilaJa.

6.3Пднluчehн Haniphoro TpybocpoBody

Uo6 3HnHTBpTaTH TCKBye3yIbTaTI TepT B HNYtpiuHNI diametrp HanipHOJ NOBITPAHOJI NIIHMI MaE 6yTH He MeHue 1" (25 MM). PnP BNKOpNCaHHI MEHNx dAmepTe, HApNKnKaAD, 1/2" MoKytb 6yTN np6bNm npEcknlyataa, nob'3aHi 3 noraHMM BdAJeHHM NOBITpr.

Ybaral Hanipn Tpy60npoBid Mae 6yTN 3MOHTOBAHnTAK,IO6 Bi HE WnHB HIRKOI MEXAHHOOI DI a6b HanpyrHa HaHoc.

Bka3iBk: HWWl... HWAI... (Hacoc 3 B6yOboAHM fIbItpom): HAcC CnI HAnOBHTN nepeD nIKIOHeHHAM (dMb. po3d 6.7).

Yci pi3b60bi 3'cDHaHH MaIOb 6yTN repMeTn3OBAH3a DOnOMORO yUJIbHOBaBHO CTPIK, Uo6 3ano6BfTIN BtOKy BoN (10-15 o6eptahy Hnpanky Pi3b6).

YciTeTani HanipHoro TpybOpOBody NOBHHI BHTPNMyBaTH NtCH;ix MOHTAK 3dINCHOETBCRA KBAJIΦIKOBAHMIM daxIBzMR.

He6e3neka! HerepeMteTuHdiTeTani HeKbaniΦIKOBaHHMOHTAX MOKYTB

npn3BCTH no p0o3PbHnAhiPiHOro Tpy6OpnoBovO npiHac EKcnIyataui. PiHa, no BpuNbaeTbcn iN BNCOKHM THCKOM,MOKe TpaBMByBatn Bac

6.4 PnKIOUeHHoMpeKITpybOpOBod

Uo6 3n3nH i6pauii i uymh, hacc Tpe6a nkiNIOHTa Do mepeKx typonpOBOIG 3a donOMORO enactINHX 3eHNBAIbHNx IaHrib.

CtaioHApHi Tpy6n peKoMeHdyE7bCMAOTyBaTN nepi2 Mepn3 nIaIbOMom, 0o3 a6e3neHTIN MAKcIMMaJIbHe BIVdAJIeHHN BOITpr.

6.5 PnKlueyHn do eneHTpomepehi

He6e3neKa, noB'3aHa 3 eIeKtpnKIO! He

BHKOPNCOTOBYIte HAcOCy BOLOROMyCEpeIOBNIi O6OB'3KOBO BHKOHUITE HaCTynHi yMOBN:

-Hacocdo3BOJHcBcR niknouaTNIbKn Do p03eTOK i3 3axnCHM KOHTOM, kHaJIeHHm YHOM BCTaHOBJeHi, 3a3emJIeHi i nepeBipeHi.
-Hanpyra mepeki, qactota i 3ano6iKHN KOBHHI BiIOBIAATN TexHcHm XapaKTepNCtHKam Hacoca.
-Пдкюан Te npиладdo eNeKtpomepeKi uepe3 npncTpii 3axnCHOro BiDknUoyenHn（N3B）3 MaKcImaJIbHnM CTpyMOM BHTOKy 30 mA.
- ENeKtpnHi 3'EdHaHHa3a6OpOHReTbC8 Onyckatn yBOy, BOHn NOBHHI3haxOHTncBnue MOJINBOrOpiHOMpyIBHnBoN.IiYaceknlyaTaui No3aPnMIeHNHMBOHMaOTb6ytn 3axuheHi BiD bpn3OK.
-ПОДОВИУBAЛБИ Кабел NOВИНHI MaTNdoCTaTHI NOPEECHN Ipepei3 JIN. Ka6elIMaOTb 6yTN NOBHICTIO pO3MOTAHI 3 6apa6aHa.
-Heo6xidHO DoTpMByBaTnCHaIioHaIbHnx npuNcIB 0doMOHTaKy i BCTaHOBLeHHra.

6.6 PeryIOBaHHaTcKHy niHKnBHeHHa (tiNbKn HWW..., HWWl...)

Ipeep BBeEeHHB EKcNpyatauio Tpe6a BCTAHOBHTH TCK iDKNBHeHH. Nb. po3in 9.4.

6.7 3anOBHeHHHaHoca i BcMOHTyBaHH

Ybara!PnKoXHOMyHOBOMy iDkiUOeHHI a60 pRn BHTOHy BOiNeO6XIHO 3anOBHIoBAtn HAcOC BDOIO.EKcNlyatauia HACoCA 6e3 3anOBHeHHBOIOpyHye HaCoc! Dra rapaTHT 6e3nepe6iHoPi PooTo peKoMeHdyEMo pRn PeIPOOMy BBeDEHNI B EKcNlyatauio 3a6e3neHTn DOCTaTHI 3abip BOiDN NOBHOrO BHaJaEHHN NOITpI 3 CNTEMN. BkazIBKa: HWWI... HWAI... (Hacocn 3 B6yDoBaHHMΦJIbTpOM:Peep3anOBHeHHAM HACoCA CnID BnHHTNΦJIbTpI DogaTKOBO HAnOBHTN Ype3 HanipHn NaTy6OK (12).

-BirBnHTiB p3b6OBy np6kny HAnHBHO O TbOpY (11) pa30m 3 yuiNbHeHHM.
- PoinbHO 3aJIbAHTe YHCTy BDOy, NOKHaCOC HANOBHITcB.
-3HOBy 3aBnHTiB pi3b6Oby npo6ky HAIINBHOROTBOPY (11) pa30m 3 yuiJIbHeHnM.
-BidkpyTe HanipnHnTYpOboPiD (noBepHtBoOpnpbiDn KpaH aBO conIIO), 06 npBCMOKHTyBAHNI BHXoNDIO NOBITP.
- YBIMKHITb HaCOC (nVB. po3di7.).
JKAIO BOda BNXOOnTb pIBHOMIPHO，HaCOC roTOBNIdoEHCnnyataii.

Bka3iBkA: BCMOKTYBaIbHy LiHiO 3aNoBHObTuHE Tpe6a, OckIbHN HAcOC e CaOBcOK TYBaIbHIM. 3aJeKHO BID DOBxHHN iDiamETpy liHIO MKe npOtn DaeknI YAC, TOKN TnCK DoCHe Heo6XdHorO pIBRN. RKnO Bu XOeTE CROPOTn Yac BCMOK TYBaHHA, BCTaHOBIT 3BOPOTn Klanah NaBXIDHomY OTBOp1 BCMOK TYBaIbHORO WlaHaT I TAOK ZANOBHTb BCMOK TYBaIbHu LiHiO.

7. Eknnyatauia

Ybaral Hacoc i BCMOKtyBaIbHaJIHIMAIOb 6yTu nIKIOUHei i zAnOBHei (DMB. PO3dIN 6.).
Ybara! He donyckaetbca po6ota Hacoca 63 BOiH. HAcOC 3ABXn MaE 6byN 3aOBHeHM pIDHOIO (BOIOO) yDCtAHTbMy 06c3I.
Pn6IohyBaHHi Hacoca YHKopiDHNM TINOM a60
Pn nepeRPIBANHII EJekTPOdBNHyHa CCHTeMa
3axHcy BIXKIIIOAcE JEkTOPOBBNYH.

7.1ФyHHJIeNEKTPoHIN

BidHIOUeHHHa cOca np3aKpHTTI HanipHOI nobITPAHOI lii (peHM oukyBaHH):

HWW....HWA....HWWI....HWAI....Kuio npin ppaiooOmy Hacoci 3akpnTn HaniPHy NOBITpHy liHIO (peepnTn BOOpOBiHN kpan a60 coNLO, 豫e3 deHN Yac BnBiy HACOC nepexoTb B peHM OkyBaHH. Eektpohia nepebipre npoxodKeHHBOype3 HACOC, kiootIK BOHN He BnBBLHNN, 6JIMcEzeHNN CBtIOJIOd (3) BnPOobjK 40 a60 70 cekyND (3aJIeHXoBID MoJI). NtIM dBnYH HACoCA BMnKaETbC, HACOC nepexoTb B peHM OUYBaHH, 3eHN CBITIOJIOd (3) NOBIbHO 6JIMae. Pn BiKpNTn HaniPHOI NobITpHOI NiHII HACOC BMnKaETbC ABOTMaTHUO.

P6000Inox:3a BiCyTHOCTi NOTKYBOIN CBITIOIOHN IHNkATOP (2) 6nIMae 3eNEHM NOIBHbBnPODOBx 20 cEHyND,NOTIM WBNIO BnPOOBK5cEHyND. Ntim eJekTPODBNYH HACOCA BmNkAeTBcR,ICBITIOIOHN IHNkATOP (2)ROPNTb YepBOHMM

3axnCT Bi cyxoro xoja:

KaHIO HACOC He nepenomnye BDOy BnpoobK 20 CEHyD, CBITIOIOHN IHNtAOT (2) noHHae NOBIBHO 6IIMaTe YepBOHM. RaHIO BnpoDBK HAcTyNHx 100 CEHyD HACOC He nepenomnye BOY, ENEHTPOBDYN HACOCA 3ynnHReTBcHA5 5 CEHyD (CBITIOIOHN IHNtAOT (2) WBnKO 6bnMae YepBOHM i3JeHm). NICr yoro PObTb cPOnbN nepenomnyBaHH BDOy B xOj3 NODaJIbXuIKnIB. RaHIO 3HOBy BOy HEmae, HACOC 3ynnHReTBcN IHNtAOT (1) TpNbAo IOPrHb YepBOHM.

PpHnPi npoBt: Hacoc npaIoe, DOKN BIN YBIMKHeHNI.

1. BCTaBTe BnIky Bpo3eTHy.
2. B pāzī notpe6h 3aŋoBnHt b hacoc -dɪv. pɔzdi n 6.7.
3. YBIMKHeHHn npHnady: KOPOTHOcAHO HATCHiHTb KHONky (3) (YBIMK/ BIMK), cBITIOADHnIHINKaHtOp 3aropntbcn 3eHnHM (B peKmM "A" - CnHm).
4. BädkpniTE HanipHNI Tpy6OBpOBD (noBepHb BOODpOBDHN KpaH a60 conNo).
5. IpekoHaTeCra, 0o B0a nIiJa!
6. NcIra 3aIKHueHHPOBOTBNBMKHTb HACOC: KopoTkoHAcHOHaTHCHtB KHONky (3) (YBIMH/ BMHK). PnnpopyuweHH npabnEekCNyatauJI HACOC nepEMKaTeBcR y peKIM HecnPpABHOCTi, ROpNtB YepBOHN iHdNKaTOP, DnB. pozdiJ 7.1.

npn EKcNpyataaHacoca 3
nyckoperyIIOBbHM npnctpoem (riDpomat, TaMep yBIMKHeHH TOU) Heo6xIdHO
nepeMkHyTn IHO B"peKIM A", IVB. po3di7.1.

ABTomatuHa Hacocha cTanhui (P03nauHn npnaHy HwA.., HWa...

PnHnPi npobTo: npnlaB BMNkaeTbC8, RkIo B pe3yIbTaTI 3ab0py BoND TNC NAdE HNNue nopory yBIMKHeHHa, I3HOBy BMNkaeTbC8 pIno DocraHHI nopory BiKnIOHeHH.

1.BCTaBTe BnIky Bpo3eTky.
2. B pārii notpe6ni 3aŋoBHiTb hacoc -dɪn. pɔzdi n 6.7.
3. YBIMKHeHn npHaJy: KOpOTKoHaO HATNCiHTb KHONKY (3) (YBIMK/ BMHK), cBtIIOIoHN IHNKAtoP 3aropntbcn 3eJIeHmN (B peXnimi"A" - CnIHM).
4. BiKpnIte HanipHn Tpy6onpObi (NOBepHITb BOONPOBIHN KpaH a0 conNo).
5. Npeekohntecra, 0o Boda niilna! Pnlaq, roTOBNI DO pOBoTH.
6.Пилад BMнкаetbсг И BMнкaetbсг,КOLIN ce notpi6Ho.(dHb.po3di7.1).

Hacocha cTaHua

(No3haeHn npnaHy HWW.., HWWI...)

PnHnHp o6oTn: npnlaB BMHaetbca, RaIO B pe3yIbTaTI 3a60py BODn TnCK NaadE HnKHe npOry yBMkHeHHa, I3HOBy BMnHaetbca Pnp DoC8aRHHI Nopory BiDknUoyEHn. Pe3epByap Pe3epByap OchaueHn rymOBm CnIbfoHOM, nOCTaBnAeTbC3 3aBOy 3 BCTAHOBNEHM NOBITPRHM TnCKOM ("TnCK niDNMBHeHH"); ce DO3BONae 3diCHOBaTH a6ip HeBeJIHKX KIIbKOeTe BOHy, He 3aNyckAOnH Haoc.

1. BCTaBTe BnIky Bpo3eTky.

2. B pāzī notpēbī 3aṇobhīt b hacoc - ἡνι. pòzdi n 6.7.
   3.YBIMKHeHH npHaLy : KopoTtKaOaH aHTnCihb KHONky (3)YBMHK/ BIMK), cBtIaIOJdHmIHdHaTOp 3aRopntbCa 3eJIeHM (BpeHMI "A" - CINH).

3. BiKpnIte HanipHn Tpy6oPiBid (IOBepHITb BODOpOBiDnH Kpan aObo conNo).

4. NpehoHaTeCra, 0o Boda niwla! Pnilaad roTOBNI do pOBoTn.
   6.Пилад BMNkaeTbcaи BMMKaeTbca,KOJIIN ue notpi6Ho.(nVB.p03d17.1).

8. Texhiye 06cIyroByBaHHa

He6e3neka!pepe6ydb-ramnpo6otamn 3 npnilaDom:

-BNTaTHiB WTeNCeIbHy BnIKy 3 pO3eTKN.
- IpekoHaTecs, 0 npna i nkiuohne
Ppnaan 3HaxoTbcn He nD TnCKOM.
- OniHai daji p6oTn 3 TeXHHTHORO
OcBnyBOyBaHHI I pEmOH TY Do3BOJAEbCR
BKNOHyBaTN TiBkH #aXIBUm.

8.1 Perylahe texhue 06cnyrobyaHH

• PnepebiTe npnlaDi i BiNobiHe npnlaDja, Oo6bIbO eEleKTPuHl DeTaIa T KaOMNoHETHn NiTNCOM Ha BIDcYTHICtB yHKDoKHeB, B pAsi Notpe6n BiDaaiTe B peMOHT. -PnepebiTe BCMOHTyBaIbHm I HanipHm TyboPBOOnHa repMeTuHicTb.
• Ppi 3HnKeHH npOdyHTBHOCTi Hacoca npOCTtB a60 aAMHtB pnnMaHbN pflTp i pflTpYBaHbN eIeMEHT (B pa3i NotpeBn).
• NpeBipTe TnCK NiDHNBHeHnPe3epByapa (6) (3aJIeHXo BID KOMPLeKTAuJIi, y BNAnky Heo6XiHOCTI 3bIbWnTe (INB. POzDIJ 9.4 36IbWeHHr TnCKy NiDHNBHeHHa.

8.2 OunueneHH npHmAbhoro oinbtpy (3aJIeKHO BID OcHauneHH)

1. BiKpyTtB KpNshky (14) (B pa3i noTppe6nCKOpHCTaHTecrKJIIOyem(13)).
2. BnIMtB 6IOK fiNbtpy (15) BeptNkAibHO BROPY.
3. Po36epiBb 6I0K fIbTpY: yTprnmyOuH KOpNyc (16), NOBepHITb fIbTp (17) 3a roDHHHOBOO CTpiIKoIO 3HIMITb 3 KopnyCy (BaOHETHE 3'EHNHNA).
4. Ppomnnte Koprnc (16) nD npToOHO BOIOO, OCHCTIb fioBtp (17) M'KHOO uTKOHO.
   5.36eptb 6loK pIbtpy B3oPOTNIocnIOBHOCTI.3epeHITb yBaIHy Ha Te,io6 6loK pIbtpy (15) 6yB BCTabIeHH Do npoy.

8.3 Pn He6e3neci 3aMeP3aHH

Ybara! Mop03 (< 4°C) pyHnye hacoc i npIaIaIa, OCKJIbKn BOHN IOCTIINHO MICrTb BDOY!
- Pn H6e3neci 3amep3aHnH Heo6xidno p03ipatn Hacoc i npnaIadra I 36epiratn B 3axHHeOHy BiM MOpO3y MiCi (INB. HactynHn po3di).

8.4 Demohtak i 36epiraHHCTaHui

-BMHHHtB IHCTpyMeHT. BHTAHTb WTeNCeJIbHy BNIKY 3 P03ETKNI.
- BldkpiHte HanipHni TpyoBnpoiD (noBepHtB BOIOpOBIHNI KpaH a00 c0JIIO), NOBHiCTU cnYCTIb BOy.
-Повсп'tо ВиорожнітБ-hacoc (5)i pezeруар (6),длвуboro:
BUNBHINTb pi3b6Oby npo6ky BOo3JIINBHOOTBOPY (8)
-Демонтунтувсмоктуваьни i Hanipни Trpyбогровду arperatу.
-36epiratnerarperatc cnlaB he3aemep3aoyomy npimuiEHHI (He MeHue 5^

9.ПобLEMи i HecnpaBhocti

He6e3neke!

• Ppea 6yDb-AMMPO6oTaMn 3 npHaJIoM:
• BntarHitb wTeNceIbHy BNkHy 3 po3eTKN
• PpekoHaTeC, 10 npnla i nHIOUeHe npnaIra 3hXoAraTbca He nI d TcKOM.

9.1 Hacoc He npaioe

• Hanpyra MepeXi BiDcyTHa.
• Ipepeipre nepeemkau YBMH/BIMK Kaebb, BnIky, po3eTky i 3anobixHHK.
• Hanpyra mepejx3aHaTo Hn3bka.
• BHKOPINCTOByTe NIOOBKByBaJIbHI KAbeJIb 3doCTaTHIMNONepeHnIM nepepi3OM HJII.
  CnpaioBab 3axnCT BiD cyxoro xOdy - rOpntb cepBOHNI INdikatop

• IpekeohaiTeec, 0o 3anac BODn DocTaTHi.

• NOBTOPHORO yBMKHeHHK KOPOTKOHACHO HATNCHTb KHONky (3) (YBMH/BMHR
  P 6000 IInox:3axHNcHe BIDKIOUHcHnI npN 3aKpITOMy HanipHOMy Tpy6OpPoBODI - rOpHTb YepBOHIN IHDNiHaTOp
  -BiDkpInTe HanipHn TpyoBpObiD
  A NOBTOPTHORO YBMHEHHN KOPOTKOHACHO HATMCHITb KHONY (3) (YBMH/BIMH)

• EneKtpoDbuRyH nepeRpiTn, cnpaOobab 3axnCT DnuRyHa.
• PICIAOXIOJIDHEHHe HAOC BKLIOUHTbcra 3HOBY ABOTOMATNUHO.
  JIa36ae3neueHHN DoCTaHTBoH BEHTNHLIJI BEHTNHLIJIH NTBOBPI MaTOB 6TyH BIKKPTHI.
  -ДOTРПМУТЕСТМAKСМАЛБНОТЕМЕРаТуРи NOДаи.
• EneKtpoDbBnHy rynTb, ane He 3anyckaetbcra.
  Notpi6Hn pemOH, nB. po3di 11.
  Hacoc 3acmitnBCa a6o HecnpaBHH.
• P036epiB i npOCHTITb HACo. IPOOHCTITb a0b 3amHITb DnOy3Op. IPOCHTITb a0b 3amHITb pOoohe KOLeo. DHB. pOaD11...
  TnCKBniH /HaBXOJI BUNe TnCKy yBIMKHeHH Haocca.
  -Пдклочи npeуктор,ДИВ.роздн2.

9.2 Hacoc npaioe HnnpabnlbHo a6o dyhe ryHHO:

HectaBoi,3axnCT BiD xoIOCToro XOdy aHTNBH. YepBOHm IHdkatop 6bMaE,3eJIeHn rOpNTb noctiHo, DvB.p03d17.1
- PpekoHaTeC8, 03anBODnIOCTaTHi.
Hacoc 3aONBHeHn BOOHO HeoCTaTHbO. -INB.p03d16.7.
BCMOKTyBaJIbHaJIiHrHerepMeTnHa.
3a6e3neuTe repMeTHUHcHcTB BCMOKTyBaIbHOI liHii, 3aTnHtB pIsbOBoi 3'edHaHH.
3aHaToBeNkA BnCotaBCMOKtYBaHH.
-ITDPIMyIteCb 6MEXeHHaNO BNCOTI BCMOKTVBaHH.
BcTaHOBITb3bOpOTnHKnIaHa,3anOBHITb BCMOKTByBaIbHyLiHIOBODOIO.
-ПиIMaIbHnФiJIbTpBCMOHTyBaIbHOIJIiHII (doaTKOBeYCTaTHyBaHH)3cMITUBC.
- PpOuNCTiB NOrO, B pasi nOTpe6n 3amHITb.
3BOpTHN KJIanaH (doaTHOBe yCTaTHyBaHH) 3a6JIOKOBAHNI.
- Ipoounctitb Horo, B pa3i notpe6n 3amHtB.
BNTIK BOIN MIX ENEKTPOBNYHOM I HACOCOM, TOPeBE yuINbENHHa HERepMeTNUHe. (He3aHN BNTIK BOIN (MaKc. 30 Kpanelb B DeHb) ObyMOBLeHNI KOHCTpyHciEIO TOpCEBOrO yuiINbENHHa).
3amHITbTOPueBe yuiNbHeHHa.11.
Hacoc3acmitHBcraaboHecnpaBHH
-ДиВ.po3dIn9.1.

9.3 Tnch 3aHaTOn Hb3bKn a6o Hacoc npaOoe nocTIHO (noCTiHO BiDyBaTeBcYBMKHeHr/BMkHeHHA):

• BCMOKTyBaJIbHaJIiHrHeRpeMTeuHa, a60 BHCOTa BCMOKTyBaHHr3HaADTO BeIINHa.
  -ДиВ.po3diN 9.2.
  Hacoc 3acmtmbcra6o HecnpaBn. -INB.p03jin9.1.
  HWW...：36nncraHaalawyBaHHa MaHOMeTpHOro BmNka.
  3aMpTe TnCK YbIMKHeHHI bIMKHeHHa 3a
  dONOMORIO MaHometpe (9) i nepebipte
  3HaueHHI (NIB. pos3Jl 13, TexHiHi
  XapakTepnCTnKi). RkIo e noTppeBa B
  NOBTOPHOMY HanaHTyBAHHi, 3BePHTbcrdo
  KJIeHTcBkoI cnykbn KomNaHII Metabo. NIB.
  pos3Jl 11..
  HWW...Hacoc BMnKaTeBcra npHe3HaHOMy 3a6opi BOn (npn6n.0,5n).
• PepeBipTe, YH He 3aHaTTo Hn3bKn TnCK niiKMBLeHHy Pe3epByapi. Y BnnaKy Heo6xInHOCTI 36IbWnte TnCK. NIB. pO3dIN 9.4.
  HWA..., HWAI... HACOC noCTIHO BMHKaETbCAI BMMKaETbCn Pn3 3abOp1 3aHaTTO MAnOI KINbKOCTI BOHn (MeHHe 60 n/3aJIeXHo BiD MoDeJI).
• Pn noaui HeBnKoi KJIbKocI BOn notpiEben BnipHBnH pe3epByap (6aK).

Hacochi cTaanii (HWW...., HWWI...) ndxodTb Ia n odaHi HebeInKxO6'EMB BOIN.
- HWW...BODa Tehe i3 nobirpHoro KnaHa.
- Tymobn cnIbfoh y pe3epByapi
HerepMeTnHn;3amHITb.1nB.p03in 11..
CbitIOJHnIHdkaTOp(2)ropntb cnHIM.
- "PeHHM A" aKTHBOBaHm. nB. po3di7.1.

9.4 36iNbWeHHnTcKHy nIiKHBneHHn (TilbKn HWW...., HWWl...)

HaHoc-3YacOM-BMHaCtBcHabItb npn He3NaHOMy 3aOpI BODn (np6Bn.0,5 n), Heo6XiHO BIDHOHTN Bpe3epByapi TnCK NiXKnBHeHH.

BkaibBa: TCHK NIDHNBNEHNA ype3epByapi (NOBITPAHNI TCK) HE MOHNA BnSAHHTN 3a DONOMORIO MAHOMETPa (9a

1. BntarHnltb utenceJIbHy BNILy 3 pOstETKn.
2. Bdknne HaneipnH TpybOpOBiD (NoBepHtB BODOpOBiDHN KpaH aBO conLo), NOBHCIO CNYCTTB BOY.
3. BvdBnHTbIpaTmHOBy KpUHcy Ha TOpueBcI cTOPOHIpePbByapa; 3a HeO 3HaXoDITbcNOBITPAHBEHTNb
   4.Пд'снaite nobITprHn Hacoc a6o shaHr KOMPecopa 3 HAOHECHNKOMДЯshHHNX KlanahI MaHOMetpdo nobITprHoro BEHTnIy.
4. Hanomnyte DoocRHeHnB BiJIOBdHOro TCHy nIiKbIeHnra (1,56ap;IbN.p03dn 13. TECHHI XapAKTePcHtIKu
5. 3HOBy NiHKJIOHcTB HAcoc i nepeBipTe Noro fYHKUOHyBaHHJ.

10. PpHnlaDra

BnKOpncToByTe TIlbKn opnirHaIbHe npHaJaMetabo.

BnKOpHCTOByTe TlBn Te npHaJa, JKe BiNDoBiae BmORam i napameTpam uei IHcTpkyuii 3 ekCnnyataqii.

PobHn acopTmEHT npHaJaIaIb. Hc caiTi www.metabo.com a6o B KaTAlo3i.

11. PemOHr

He63eNaIJaOpyAaItepeMOHT npHJaTyIbKn KBaJIΦIOBAHIM QaxIBaM-

Дя ремOTуну HCTPmEHTB Metabo 3BepTaIteCBAperIOHaJIbe PnEDcTabHnTBO Metabo.ApEscINb. Na caiT www.metabo.com.

IpeD BiInpaBHeHnM: NOBHCTIO BnNopOHHiTb Hacocipe3epByap (INB. po3in 8.4).

CnNCH 3anaChnx yactIN MOxHa 3aBaHTaKHTNa caNTi www.metabo.com.

12.3axnct doBknlln

DotpmyTecaHaioHaBnHex npabN 63neHoi yTmIlaaui nepeo6Kn BIKOPcTahnx IHCTpyMeNTIB, naKyBaIbHnx MaTepiAIB i npnaad.

NaybaIbHi MaTepiAIn yTuIn3yOToBc BiINoBIdHO Do IXHbOro MapHyBaHNr 3rJIO 3 KOMyHaJIbHMn npabnIaMn. OdoATKoby IHOpmaJIO MOxHa 3HaHTn Ha caTl www.metabo.com y po3diN «Cepbic’.

TilbKn Iy KpaH IN EC: He ytni3y Te eIeKtpoHCTpyMeHTn pa30m 3 no6yTOBnIMn BIXxOamn! 3riJHO 3 npeKTHBOIO EC
2012/19/EU npo BHKOPACTaHH eIeKTPNHi i eIeKToPOnHI pncTPOI Ta BiDnOBiDNHMn
HaioHAlbNHMM HOpMaMn BIdnpaIbOBaHI
eIeKtpoHCTpyMeHTn NiIraIaOTb P03dInbHi
YtHN3auii 3 MeTOO Tx NodaIbWoI ekONlOrHNO
6e3neuHO nepepO6Kn.

13. Texhiyhi xapaHTepnCTHNI

PONCHEHHaDaHnx,HaBeDeHnx Ha cTOp.3.

3aJIHuaMo 3a co6oIO npaBO Ha TeXhiHi 3MiHN.

XapakTepeHCTnHa KpBa Hacoca (diarpama, ctop.3) DEMOHCTpye IYO pOyoKTHBHCt b 3aJIeKHO BID TCHy (BNCOTCABCMOHTyBaHHo 0,5Mi BCMOKTYBaBHmIshAhr 1"

E =eIeKtpoHika / 3axnCT BiD cyxoro xOdy

V =Hacoc 3 B6ydoBaHIM 3BOPoTHIM HanaHOM (18) HA BCMOHTyBaIbHomy natpy6Ky (10)

K KaBcJIb KINBnEHRA

U = Hanpyra MepeKi

T 1

P1 =HOMIHahBaHa NOTyHKHCTb

P Standby=BNtpaTBApeKIMQyBaHH

HOMHaJIbHNCTpyM

C = pobouyKoHdeHcaTOp

n =HOMIHAlbHa KINbKICThoOeptTb

Fy,max =MaKc.npOdyKTnBHiCtB

Fh,max =MaKc.BnCOTa noDaYi

F p.max =MaHC. TnCK nOdaY

p1 =MaHOMETpNHHBIMNKaT

yBIMKHeHHA

p2 =MAHOMETPmHHIN BUMHKA:THCKBUMHKAHHA

S h.max =MaHC. BNCota BCMOKTyBaHH

Stemp =MaKc.TEmpepaTpaNoaHi

Temp =TemnepaTypa HABKOLINHbOro cepedOBuHa

S1 =Klaac 3axnCTy BiD 6pn30K

S2 =Kla3axnCTy

S3 =Knaic 0raui

M=MaTepiAn Kopncy Hacoc

M =MaTePiaI Bala HacOca

Mw =maTepiAnpo6OuroKoIecaHacoca

Ds =BHyTpiriunHpi3b6aBCMOKTyBaJIbHO r naTpy6ka

Dp =BHyTpiHn pi3b6a HanipHoro naTppy6Ka

TV =o6eMpe3epByapa

Tp,max =MaHC.TNCKype3epByapi

Tp.1 =TnCK nIDKNBHeHHpe3epByapa

A = po3MipH;

OBKINHaXIUPINHaXBUCOTa

m =Bara(3KaobelemKINBneHHRA)

～ nepemHHn CTpyM

Ha Bk3a3hi Texhiyhi XapaHTepnCTHIN noNHPIObCBOynCKn,pepe6bAehi DIOYMM CTaNdAPTAM.

3HaueHHaemiciyMy

L3Ha6EHHJIO3BOJHOJBTOUHOBaTHI NopIBHOATmEICIO WMy p3HNX ENEKTOPIHCTPMEHTIB.3AENHO BID yMOB EKCnlyatau, CTAHy ENEKTOPIHCTPMEHTy aPObOHX IHCTPMEHTIB PAHTNHE HABATAHMOKE 6yTN BNIe abo HNKe.ДЯ OUHHK 3p3AOHBO rBHe MECII BPAOxyBHTe nepep Poboti i pAsn pOBoTn Si 3HnKeHM (WMOHBAHATKeHHM.Bi3NaHTe nepenik OprAh3auiHHx 3axoDj IOdo 3axncty KOpHCTByaHa 3ypaxyBaHHM Tnx aO bHINX 3HaHeh bEMCii WMy.

PibeHb 3ByKOBOrO TnCKy 3a TnONAM:

LpA =piBeHb 3ByKOBOrTO TnCKy

LWA =piBeHb 3ByKOBoI NOTyXHOCTi

KpA, KWA=HOeΦiuiEHT NOXHn

LwA(G) = rapaHTOBAHn pIBeHb 3ByKOBoi noTyXHocTi 3riDHO 32000/14/EG

BnHOpncToByyTe 3axHcT opraHb cnyxy!

TOB "MeTa6o YkpaiHa

ByI. 3Op8 Ha, 22

c.CBtoneTpbcbke

Knibcbka 06n

08141, KuiB

www.metabo.com

Metabowerke GmbH

Metabo-Allee 1

72622 Nuertingen

Germany

www.metabo.com