BRIGGS & STRATTON 435447 - Small Equipment Engine BRIGGS & STRATTON - Free user manual and instructions

USER MANUAL BRIGGS & STRATTON 435447 BRIGGS & STRATTON

Briggs & Stratton is a registered trademark

of Briggs & Stratton Corporation

© 2008 Briggs & Stratton Corporation,

Milwaukee, WI, USA. All rights reserved.

Form No. 277110EST A

01999-B8006

General Information

For replacement parts or technical assistance, record below the engine model, type, and code numbers along with the date of purchase. These numbers are located on your engine (see the Features and Controls page).

Date of purchase:

MM/DD/YYYY

Engine model:

Model:

Type:

Code:

Engine Power Rating Information

For 3/LC engines, gross power ratings are based on SAE J1995 criteria and net power ratings are based on SAE J1349 criteria. Actual power output of production engines installed in applications may vary depending on a number of factors, including the engine RPM limit of the application, environmental conditions, engine/equipment maintenance, and other variables.

Operator Safety

SAFETY AND CONTROL SYMBOLS

Fire

Moving Parts

Oil

Toxic Fumes

Slow

Fast

Stop

Explosion

Shock

Fuel

Choke

On Off

Fuel Shutoff

Kickback

Wear Eye
Protection

Hazardous Chemical

Read Manual

Hot Surface

Frostbite

Hot Liquid or Steam

The safety alert symbol is used to identify safety information about hazards that can result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard symbol may be used to represent the type of hazard.

DANGER indicates a hazard which, if not avoided, will result in death or serious injury.

WARNING indicates a hazard which, if not avoided, could result in death or serious injury.

CAUTION indicates a hazard which, if not avoided, might result in minor or moderate injury.

CAUTION, when used without the alert symbol, indicates a situation that could result in damage to the product.

WARNING

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

WARNING

Briggs & Stratton does not approve or authorize the use of these engines on 3-wheel All Terrain Vehicles (ATVs), motor bikes, fun/recreational go-karts, aircraft products, or vehicles intended for use in competitive events. Use of these engines in such applications could result in property damage, serious injury (including paralysis), or even death.

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start the engine, make sure you add oil according to the instructions in this manual. If you start the engine without oil, it will be damaged beyond repair and will not be covered under warranty.

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes before removing the fuel cap.
• Fill fuel tank outdoors or in well-ventilated area.
• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of neck to allow for fuel expansion.
• Keep gasoline away from sparks, open flames, pilot lights, heat, and other ignition sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if necessary
  If fuel spills, wait until it evaporates before starting engine.

When Starting Engine

• Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in place and secured.
• Do not crank engine with spark plug removed.
• If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle (if equipped) to FAST position and crank until engine starts.

When Operating Equipment

• Do not tip engine or equipment at angle which causes gasoline to spill.
• Do not choke the carburetor to stop engine.
• Never start or run the engine with the air cleaner assembly (if equipped) or the air filter (if equipped) removed.

When Changing Oil

• If you drain the oil from the top oil fill tube, the fuel tank must be empty or fuel can leak out and result in a fire or explosion.

When Transporting Equipment

• Transport with fuel tank EMPTY or with fuel shut-off valve OFF.

When Storing Gasoline Or Equipment With Fuel In Tank

• Store away from furnaces, stoves, water heaters or other appliances that have pilot light or other ignition source because they can ignite gasoline vapors.

WARNING

Starting engine creates sparking.

Sparking can ignite nearby flammable gases.

Explosion and fire could result.

If there is natural or LP gas leakage in area, do not start engine.
- Do not use pressurized starting fluids because vapors are flammable.

WARNING

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

Start and run engine outdoors.
- Do not start or run engine in enclosed area, even if doors or windows are open.

• Operate equipment with guards in place.
• Keep hands and feet away from rotating parts.
• Tie up long hair and remove jewelry.
• Do not wear loose-fitting clothing, dangling drawstrings or items that could become caught.

WARNING

Running engines produce heat. Engine parts, especially muffler, become extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

• Allow muffler, engine cylinder and fins to cool before touching.
• Remove accumulated debris from muffler area and cylinder area.
• Install and maintain in working order a spark arrester before using equipment on forest-covered, grass-covered, brush-covered unimproved land. The state of California requires this (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal land.

RNING

Severe thermal burns can occur by escaping steam or hot coolant.

DO NOT remove radiator cap or reservoir cap if engine is warm or running.
- Stop engine and allow it to cool before removing radiator cap or reservoir cap and before changing or adding coolant.

WARNING

Unintentional sparking can result in fire or electric shock.

Unintentional start-up can result in entanglement, traumatic amputation, or laceration.

Fire hazard

Before performing adjustments or repairs:

• Disconnect the spark plug wire and keep it away from the spark plug.
• Disconnect battery at negative terminal (only engines with electric start.)
  Use only correct tools.
• Do not tamper with governor spring, links or other parts to increase engine speed.
• Replacement parts must be the same and installed in the same position as the original parts.
• Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during operation.

When testing for spark:

Use approved spark plug tester.
- Do not check for spark with spark plug removed.

Features and Controls

Compare the illustration 1 with your engine to familiarize yourself with the location of various features and controls.

A. Engine Identification Model Type Code
B. Engine Identification Date Code
C. Glow Plug
D. Dipstick
E. Oil Fill
F. Oil Filter
G. Oil Drain Plug
H. Injector Nozzle
I. Electric Starter
J. Injector Pump
K. Thermostat
L. Turbocharger
M. Oil Pan
N. Alternator
O. Coolant Temperature Sending Unit
P. Fan
Q. Fan Belt
R. Exhaust Manifold
S. Oil Cooler (if equipped)

Operation

Oil capacity (see the Specifications section)

Oil Recommendations

We recommend the use of Briggs & Stratton Warranty Certified oils for best performance. Other high-quality detergent oils are acceptable if classified for service CF or CF-4. Do not use special additives. Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart to select the best viscosity for the outdoor temperature range expected.

* Below 40^ (4^) the use of SAE 30 will result in hard starting.
** Above 80^ ( 27^ ) the use of 10W-30 may cause increased oil consumption. Check oil level more frequently.

How To Check/Add Oil - Figure ② ④

Before adding or checking the oil

• Place engine level.
  Clean the oil fill area of any debris.
• Remove the dipstick (A) and wipe with a clean cloth (Figure 2).
• Completely insert the dipstick.
• Remove the dipstick and check the oil level. It should be at the FULL mark (B) on the dipstick.
• If low, remove the dipstick and add oil slowly into the engine oil fill (C). Do not overfill.

Important: When adding oil, adequate venting is required as follows:

• Remove the dipstick.

• Make sure adequate clearance (D) is maintained between the oil fill device (E) and the engine oil fill (C). See Figure 4.

• After adding oil, install the dipstick. Start and run engine at idle for five minutes. Shut off engine. Wait three minutes and check oil level. If required, add oil to bring oil level to the FULL mark (B) on the dipstick (Figure 2).

• Install the dipstick.

Oil Pressure

If the oil pressure is too low, a pressure switch (if equipped) will either stop the engine or activate a warning device on the equipment. If this occurs, stop the engine and check the oil level with the dipstick.

If the oil level is below the ADD mark, add oil until it reaches the FULL mark. Start the engine and check for proper pressure before continuing to operate.

If the oil level is between the ADD and FULL marks, do not start the engine. Contact any Briggs & Stratton 3/LC Authorized Dealer to have the oil pressure problem corrected.

Fuel Recommendations

Fuel must meet these requirements:

• This engine is certified to operate on diesel fuel. If incorrect fuel is used, black smoke, power loss, and damage to the engine will occur, which will not be covered by the warranty.
• Use clean, fresh diesel fuel with a minimum of 40 cetane. Fresh fuel prevents gum from forming in the fuel system. Purchase fuel in a quantity that can be used within 30 days. See the Storage section.

CAUTION: Do not use kerosene or gasoline instead of diesel fuel. Failure to observe this caution will damage the engine and void the engine warranty.

How To Add Fuel - Figure 5

WARNING

Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes before removing the fuel cap.
• Fill fuel tank outdoors or in well-ventilated area.
• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of neck to allow for fuel expansion.
• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if necessary.
  If fuel spills, wait until it evaporates before starting engine.
• Clean the fuel cap area of dirt and debris. Remove the fuel cap (A, Figure 5).
• Fill the fuel tank (B) with fuel. To allow for expansion of the fuel, do not fill above the bottom of the fuel tank neck (C).
• Reinstall the fuel cap.

Coolant Recommendations

Coolant capacity (see the equipment manufacture's manual)

Important: This is a liquid-cooled engine. A 50 / 50% mixture of phosphate-free antifreeze and tap water is required for cooling, rust resistance, and lubrication of the water pump.

How To Check/Add Coolant

WARNING

Severe thermal burns can occur by escaping steam or hot coolant.

• DO NOT remove radiator cap or reservoir cap if engine is warm or running.
• Stop engine and allow it to cool before removing radiator cap or reservoir cap and before changing or adding coolant.
• Before operating, check the coolant level. The coolant level must be between the FULL and the LOW/ADD marks on the coolant reservoir. If the coolant level is low, add a 50 / 50% coolant mixture of phosphate-free antifreeze and tap water to the reservoir.
• To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir cap. Slowly turn the reservoir cap counterclockwise to remove.

• If the reservoir is dry, then add coolant to both the reservoir and to the radiator. See the equipment manual for location, operation, and maintenance of the coolant reservoir and the radiator.

• To remove the radiator cap after engine is cool, place a thick cloth over the radiator cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized steam escapes from the cap, stand back to avoid injury. After all pressure is released, push down and turn the radiator cap counterclockwise to remove.

Gauges And Lights

The gauges and lights shown are typical and represent various options that can be used. See the equipment manual for location and operation of gauges and lights.

Coolant Temperature Gauge

Indicates coolant temperature when the electric start switch is in the ON position.

Normal range 80^ - 90^ C (175^ - 195^ F

Dangerous range above 105^ (220^)

Hour Meter Gauge

Indicates the total number of operating hours.

Fuel Gauge

Indicates the fuel remaining in the fuel tank. To minimize condensation, keep the fuel tank full.

Temperature Light

If the temperature light comes on, the engine is overheating. Stop the engine and check the coolant level (see the How To Check Coolant section). Check the radiator for debris that could restrict air flow.

Ignition Light

When the electric start switch is turned to the ON position, the ignition light should be on. When the engine is running, the ignition light should go out.

If the ignition light is out when then electric start switch in the ON position, check for a blown fuse.

Engine Oil Pressure Light

When the electric start switch is turned to the ON position, the engine oil pressure light should be on. When the engine is running, the engine oil

pressure light should go out. If the engine oil pressure light comes on when the engine is running, immediately stop the engine. First, check the oil level (see the How To Check/Add Oil section). Next, check the electrical system.

Charge Light

When the electric start switch is turned to the ON position, the charge light should be on. When the engine is running, the charge light should go out.

If the charge light comes on when the engine is running, check the electrical system.

Heat or Glow Light

When the ignition switch is turned to the heat/glow or the on position, the glow light will indicate to indicate that the glow plugs are preheating the

combustion chamber.

Fuel Filter Light

The fuel filter light comes on when excess water has collected in the fuel filter. The light should go out when the excess water is drained from the

fuel filter. If the fuel filter warning light illuminates while engine is running, stop the engine and drain the water from the fuel filter.

How To Start The Engine - Figure 6

WARNING

When Starting Engine

• Ensure that muffler, fuel cap, and air cleaner are in place and secured.
• If engine floods, set choke (if equipped) to open/run position, move throttle (if equipped) to fast position, and crank until engine starts.
• To prolong starter life, use short starting cycles, not to exceed 15 seconds per minute. Extended cranking can damage the starter motor.

WARNING

Engines give off carbon monoxide, an odorless, colorless, poison gas. Breathing carbon monoxide can cause nausea, fainting or death.

Start and run engine outdoors.
- Do not start or run engine in enclosed area, even if doors or windows are open.

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start the engine, make sure you add oil according to the instructions in this manual. If you start the engine without oil, it will be damaged beyond repair and will not be covered under warranty.

CAUTION: Before starting the engine for the first time, charge the battery as

recommended by the equipment manufacturer. Failure to do so can cause damage to the engine.

Note: Some engines and equipment have remote controls. See the equipment manual for location and operation of remote controls.

1. Check the oil level. See the How To Check/Add Oil section.
2. Make sure equipment drive controls, if equipped, are disengaged.
3. Turn the fuel shut-off valve (A), if equipped, to the on position (Figure 6).
4. Move the throttle control (B) to the slow position.

Note: For starting in cold weather (below -10°C or 14°F), move the throttle control to the fast position.

1. Turn the electric start key (D) to the ON or HEAT position (Figure 6). The glow light will indicate that the glow plugs are preheating the combustion chamber.
2. When the glow light goes out, turn the electric start key to the START position.

CAUTION: To prolong starter life, use short starting cycles, not to exceed 15

seconds per minute. Extended cranking can damage the starter motor.

1. When the engine starts, release the key. The glow light will illuminate for about 20 seconds and then go out.
   CAUTION: Do not accelerate or race a cold engine. Failure to observe this caution can cause engine damage.
2. Allow the engine to run and warm up for several minutes before operating the equipment.

How To Stop The Engine - Figure

1. Move the throttle control (B) to the slow position.
   CAUTION: Before stopping a turbo-equipped engine, allow the engine to idle for one minute to cool the turbocharger. Failure to do so can damage the turbocharger.
2. Turn the key switch (D) to the off position (Figure 6). Remove the key and keep in a safe place out of the reach of children.
3. After the engine stops, turn the fuel shut-off valve (A), if equipped, to the closed position.

Maintenance

Use only original equipment replacement parts. Other parts may not perform as well, may damage the unit, and may result in injury. In addition, use of other parts may void your warranty.

We recommend that you see any Briggs & Stratton 3/LC Authorized Dealer for all maintenance and service of the engine and engine parts.

CAUTION: All the components used to build this engine must remain in place for proper operation.

CAUTION: The manufacturer of the equipment on which this engine is installed specifies the top speed at which the engine will be operated. Do not exceed this speed.

Emissions Control

Maintenance, replacement, or repair of the emissions control devices and systems may be performed by any non-road engine repair establishment or individual.

However, to obtain "no charge" emissions control service, the work must be performed by a factory authorized dealer. See the Emissions Warranty.

WARNING

Unintentional start-up can result in entanglement, traumatic amputation, or laceration.

Fire hazard

Before performing adjustments or repairs:

• Disconnect battery at negative terminal (only engines with electric start.)
  Use only correct tools.
• Do not tamper with governor spring, links or other parts to increase engine speed.
• Replacement parts must be the same and installed in the same position as the original parts.
• Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during operation.

Maintenance Chart

Every 8 Hours or Daily

• Check engine oil level • Check coolant level

First 50 Hours (initial Break-In)

• Change engine oil *

Every 100 Hours

• Check fan belt tension • Clean radiator • Clean air filter • Check muffler and clean spark arrestor (if equipped)

Every 150 Hours

• Change engine oil * • Replace oil filter

Every 600 Hours or Annually

• Replace air filter • Check valve clearance • Replace fuel filter▲

Every 1500 Hours

• Check injection nozzles ◆

Annually

• Change engine oil * • Replace oil filter • Change coolant • Check fan belt tension • Clean radiator • Check muffler and clean spark arrestor (if equipped) • Replace air filter • Replace fuel filter▲ • Check valve clearance■

• Service more often when operating under heavy load or in high temperature.
  Follow the manufacturer's maintenance schedule if non-Briggs & Stratton part is used.
  Service must be performed by an authorized DENSO dealer.
  Not required unless engine performance problems are noted.

Inspect Muffler And Spark Arrester

WARNING

Running engines produce heat. Engine parts, especially muffler, become extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

• Allow muffler, engine cylinder and fins to cool before touching.
• Remove accumulated debris from muffler area and cylinder area.
• Install and maintain in working order a spark arrester before using equipment on forest-covered, grass-covered, brush-covered unimproved land. The state of California requires this (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal land.

Inspect the muffler for cracks, corrosion, or other damage. Remove the spark arrester, if equipped, and inspect for damage or carbon blockage. If replacement parts are required, make sure to use only original equipment replacement parts.

WARNING: Replacement parts must be the same and installed in the same

position as the original parts or fire could result.

How To Check Coolant

Important: This is a liquid cooled engine. A 50 / 50% coolant mixture of phosphate-free antifreeze and tap water is required for cooling, rust resistance, and lubrication of the water pump.

WARNING

Severe thermal burns can occur by escaping steam or hot coolant.

• DO NOT remove radiator cap or reservoir cap if engine is warm or running.
• Stop engine and allow it to cool before removing radiator cap or reservoir cap and before changing or adding coolant.
• Check the coolant level. The coolant level must be between the FULL and LOW, or ADD, marks on the coolant reservoir. If the coolant level is low, add a 50/50% coolant mixture of phosphate-free antifreeze and tap water to the reservoir.
• To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir cap. Slowly turn the reservoir cap counterclockwise to remove.
• If the reservoir is dry, add coolant to both the reservoir and to the radiator. See the equipment manual for location, operation, and maintenance of the coolant reservoir and of the radiator.
• To remove the radiator cap after engine is cool, place a thick cloth over the radiator cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized steam escapes from the cap, stand back to avoid injury. After all pressure is released, push down and turn the radiator cap counterclockwise to remove.

How To Change The Oil - Figure ②

CAUTION: Used oil is a hazardous waste product and must be disposed of properly. Do not discard with household waste. Check with your local authorities, service center, or dealer for safe disposal/recycling facilities.

Remove Oil

1. Remove the oil drain plug (G, Figure 3). Drain the oil into an approved container.
2. After the oil has drained, install and tighten the oil drain plug.

Change The Oil Filter

For replacement intervals, see the Maintenance chart.

1. Drain the oil from the engine. See Remove Oil section.
2. Remove the oil filter (H, Figure 3) and dispose of properly.
3. Before you install the new oil filter, lightly lubricate the oil filter gasket with fresh, clean oil.
4. Install the oil filter by hand until the gasket contacts the oil filter adapter, then tighten the oil filter 1/2 to 3/4 turns.
5. Add oil. See Add Oil section.

Add Oil

• Place engine level.
  Clean the oil fill area of any debris.
  See the Specifications section for oil capacity.
• Remove the dipstick (A, Figure 2).

• Pour the oil slowly into the engine oil fill (C). Do not overfill. Important: When adding oil, adequate venting is required as follows:

• Remove the dipstick.

• Make sure adequate clearance (D) is maintained between the oil fill device (E) and the engine oil fill (C). See Figure 4.

• After adding oil, install the dipstick. Start and run engine at idle for five minutes. Check for leaks. Shut off engine. Wait three minutes and check oil level. If required, add oil to bring oil level to the FULL mark (B) on the dipstick (Figure 2).

• Install the dipstick.

How To Service The Air Filter - Figure

WARNING

Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death.

• Never start or run the engine with the air cleaner assembly or the air filter removed. CAUTION: Do not use pressurized air or solvents to clean the filter. Pressurized air can damage the filter and solvents will dissolve the filter.
  See the Maintenance Chart for service requirements.
• Open the latches (A) and remove the cover (B). See Figure 7.
• Remove the air filter (C).
• To loosen debris, gently tap the air filter on a hard surface. If the air filter is excessively dirty, replace with a new air filter.
• Install the air filter.
• Install the cover and close the latches.

WARNING

Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death.

• Disconnect battery at negative terminal (only engines with electric start.)
• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if necessary.
• Before replacing the fuel filter, drain the fuel tank or close the fuel shut-off valve.
• Replacement parts must be the same and installed in the same position as the original parts.
  If fuel spills, wait until it evaporates before starting engine.

If the fuel filter warning light illuminates while the engine is running, stop the engine and drain water from fuel filter as follows:

Replace fuel filter

1. Disconnect the sensor wire (D).
2. Remove the drain plug (B) and discard the O-ring (E).
3. Remove the fuel filter (A) with a filter wrench.
4. Install a new fuel filter by hand until gasket (F) contacts the housing. Then tighten an additional 1/3 turn.
5. Install the drain plug with new O-ring.
6. Connect the sensor wire.
7. Activate the primer pump (C) until resistance is felt.
8. Start the engine and check for leaks.

Drain water from fuel filter

1. Stop the engine.
2. Place a drain pan under the fuel filter (A) and loosen drain plug (B) approximately one turn.
3. Water should drain from the fuel filter. If necessary, operate the primer pump (C) to drain water, but only until fuel flows from the fuel filter.
4. Tighten the drain plug.
5. Start the engine. Make sure that the warning light is off. Check for leaks.

How To Check/Adjust The Fan Belt - Figure 9

Check Fan Belt

1. Check the condition of the fan belt (A, Figure 9). If the fan belt has cracks or is damaged, replace with a new belt.
2. Check the tension of the fan belt. Press on the center (C) of the fan belt. If tension is correct, the belt will move 3/8 - 1/2 in (10 - 12mm) if 22 lbs (10kg) of force is applied to the center of the belt. If the tension is too loose, adjust as follows.

Adjust Fan Belt Tension

1. Loosen the alternator mounting bolts (D) and (E). See Figure 9.
2. Position a pry bar (F) against the alternator (G) and the side of the engine block. To tighten the fan belt, pull on the pry bar. Temporarily tighten the alternator mounting bolts.
3. Check the tension of the fan belt. See Check Fan Belt section. If necessary, repeat the procedure.
4. Tighten the alternator mounting bolts. Torque bolt (D) to 14 ft-lbs (19 Nm). Torque bolt (E) to 45 ft-lbs (61 Nm).

Storage

WARNING

Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death.

When Storing Fuel Or Equipment With Fuel In Tank

• Store away from furnaces, stoves, water heaters or other appliances that have pilot lights or other ignition sources because they can ignite fuel vapors.

Engine Oil

While the engine is still warm, change the engine oil.

Troubleshooting

Need Assistance? Go to BRIGGSandSTRATTON.COM or call 1-800-233-3723.

Specifications

Engine Specifications

Model	520000
Displacement	51.87 ci (850 cc)
Bore	2.677 in (68 mm)
Stroke	3.071 in (78 mm)
Oil Capacity	3.5 qt (3.3 L)

Engine Specifications

Model	580000
Displacement	58.09 ci (953 cc)
Bore	2.835 in (72 mm)
Stroke	3.071 in (78 mm)
Oil Capacity	3.5 qt (3.3 L)

Tune-up Specifications *

Model	520000, 580000
Intake Valve Clearance▲	0.008 in (0.2 mm)
Exhaust Valve Clearance▲	0.008 in (0.2 mm)

• Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and 1% for each 10^ F( 5.6^ C) above 77^ F( 25^ C) . The engine will operate satisfactorily at an angle up to 15^ . Refer to the equipment operator's manual for safe allowable operating limits on slopes.

Check when engine is cold.

Common Service Parts

Service Part	Part Number
Air Filter	820263
Oil Filter	820314
Fuel Filter	820311
V-Belt (940 mm)	821075
V-Belt (970 mm)	820893

^+ We recommend that you see any Briggs & Stratton 3/LC Authorized Dealer for all maintenance and service of the engine and engine parts. Use only genuine Briggs & Stratton parts.

LIMITED WARRANTY

Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions stated below. For warranty service, find the nearest Authorized Briggs & Stratton 3/LC Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM, or by calling 1-800-233-3723, or as listed in the 'Yellow Pages'.

There is no other expressed warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from purchase, or to the extent permitted by law and all implied warranties are excluded. Liability for incidental or consequential damages are excluded to the extent exclusion is permitted by law. Some states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which vary from state to state and country to country.

OUR PRODUCT

Warranty Period

Consumer and Commercial Use

Vanguard™ 3/LC

2 years

Major Parts Warranty *

3 years

Parts & Labor *

2 years

• Note the following special warranty periods: For purposes of this warranty policy, Parts & Labor coverage is 2 years. Major parts only coverage is extended through the third year of operation. Major Parts Warranty (M.P.W.) covers but is not limited to or exclusive to cylinder block, cylinder head, crankshaft, camshaft, gears, pistons, rods, flywheel, flywheel housing, oil pump, fan, pulleys, mechanical governor, intake manifold, and oil pan. M.P.W. does not cover and is not limited to piston rings, replaceable bearings, water pump, any electrical component, valve train components, accessory parts, seals, gaskets, carburetors, exhaust manifold, hoses, all fuel system components, injectors, injector pump, turbocharger, muffler, any filters, radiator, thermostat, spark plugs, glow plugs, and fuel transfer pumps. The warranty period begins on the date of purchase by the first retail consumer or commercial end user and continues for the period of time stated in the table above.

No warranty registration is necessary to obtain warranty on Briggs & Stratton products. Save your proof of purchase receipt. If you do not provide proof of the initial purchase date at the time warranty service is requested, the manufacturing date of the product will be used to determine the warranty period.

About Your Warranty

Briggs & Stratton welcomes warranty repair and apologizes to you for being inconveniently. Any Authorized Briggs & Stratton 3/LC Service Dealer may perform warranty repairs. Most warranty repairs are handled routinely, but sometimes requests for warranty service may not be appropriate. For example, warranty would not apply if engine damage occurred because of misuse, lack of routine maintenance, shipping, handling, warehousing or improper installation. Similarly, warranty is void if the serial number of the engine has been removed or the engine has been altered or modified.

If a customer differs with the decision of the Service Dealer, an investigation will be made to determine whether the warranty applies. Ask the Service Dealer to submit all supporting facts to his Distributor or the Factory for review. If the Distributor or the Factory decides that the claim is justified, the customer will be fully reimbursed for those items that are defective. To avoid misunderstanding which might occur between the customer and the Dealer, listed below are some of the causes of engine failure that the warranty does not cover.

Normal wear: Engines, like all mechanical devices, need periodic parts service and replacement to perform well. Warranty will not cover repair when normal use has exhausted the life of a part or an engine. Warranty would not apply if engine damage occurred because of misuse, lack of routine maintenance, shipping, handling, warehousing or improper installation. Similarly, warranty is void if the serial number of the engine has been removed or the engine has been altered or modified.

Improper maintenance: The life of an engine depends upon the conditions under which it operates, and the care it receives. Some applications, such as tillers, pumps and rotary mowers, are very often used in dusty or dirty conditions, which can cause what appears to be premature wear. Such wear, when caused by dirt, dust, spark plug cleaning grit, or other abrasive material that has entered the engine because of improper maintenance, is not covered by warranty.

This warranty covers engine related defective material and/or workmanship only, and not replacement or refund of the equipment to which the engine may be mounted. Nor does the warranty extend to repairs required because of:

1 Engines that are not properly applied to equipment. It is strongly recommended that the factory be contacted prior to applying a B&S 3/LC engine to equipment that did not originally use a B&S 3/LC engine.
2 Problems caused by parts that are not original Briggs & Stratton parts.
3 Equipment controls or installations that prevent starting, cause unsatisfactory engine performance, or shorten engine life. (Contact equipment manufacturer.)

4 Leaking carburetors, clogged fuel pipes or injectors, sticking valves, contaminated injector pumps, or other damage, caused by using contaminated or stale fuel. Use clean, fresh fuel (lead free gasoline, diesel fuel) and Briggs & Stratton fuel stabilizer, Part No. 5041.
5 Parts which are scored or broken because an engine was operated with insufficient or contaminated lubricating oil, or an incorrect grade of lubricating oil (Check oil level daily or after every 8 hours of operation. Refill when necessary and change oil and oil filter at recommended intervals). OIL GARD may not shut down running engine. Engine damage may occur if oil level is not properly maintained. Read Operator's Manual.
6 Repair or adjustment of associated parts or assemblies such as clutches, transmissions, remote controls, etc., which are not manufactured by Briggs & Stratton.
7 Damage or wear to parts caused by dirt, which entered the engine because of improper air cleaner maintenance, re-assembly, or use of a non-original air cleaner element or cartridge. At recommended intervals, clean and/or replace the filter as stated in the Operator's Manual.
8 Parts damaged by over-speeding, or overheating caused by grass, debris, or dirt, which plugs, clogs radiator or air cooling access openings, or damage caused by operating the engine in a confined area without sufficient ventilation. Engine damage caused by not using accurate mix of anti-freeze and tap water, or water entering the engine due to any cause.
Engine or equipment parts broken by excessive vibration caused by a loose engine mounting, loose cutter blades, unbalanced blades or loose or unbalanced impellers, improper attachment of equipment to engine crankshaft, over-speeding or other abuse in operation.
10 Routine tune-up or adjustment of the engine.
11 Engine or engine component failure, i.e., combustion chamber, valves, valve seats, valve guides, or burned starter motor windings, caused by the use of alternate fuels such as, liquified petroleum, natural gas, altered gasolines, etc.

Warranty service is available only through authorized service dealers by Briggs & Stratton Corporation. Locate your nearest Authorized Briggs & Stratton 3/LC Service Dealer in our dealer locator map on BRIGGSandSTRATTON.COM or by calling 1-800-233-3723, or as listed in the 'Yellow Pages'.

Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection Agency (U.S. EPA) Emission Control System Warranty Statement (Owner's Warranty Rights and Obligations)

Emissions control warranty coverage is applicable to certified model year 2007 and later engines, which are purchased and used in California, and to certified model year 2007 and later engines, which are purchased and used elsewhere in the United States.

California and United States Emission Control Warranty Statement

The California Air Resources Board (CARB), U.S. EPA and B&S are pleased to explain the Emission Control System Warranty on your model year 2007 and later off-road spark-ignition engine over 19kW (25HP). In California, new off-road large spark-ignition engines must be designed, built and equipped to meet the State's stringent anti-smog standards. Elsewhere in the United States, new Non-road spark-ignition engines over 19kW certified for model year 2007 and later, must meet similar standards set forth by the U.S. EPA. B&S must warrant the emission control system on your engine for the period of time listed below, provided there has been no abuse, neglect or improper maintenance of your engine.

Your emission control system includes parts such as the carburetor or fuel injection system, the air cleaner, ignition system, muffler, and catalytic converter. Also included may be hoses, belts, connectors and other emission related assemblies.

Where a warrantable condition exists, B&S will repair your engine at no cost to you including diagnosis, parts and labor.

Briggs & Stratton Emission Control Warranty Coverage

The 2007 and later off-road spark-ignition engines are warranted for two years.

If any emission-related part on your engine is defective, the part will be repaired or replaced by B&S.

Owner's Warranty Responsibilities

As the engine owner, you are responsible for the performance of the required maintenance listed in your Operating & Maintenance Instructions. B&S recommends that you retain all your receipts covering maintenance on your engine, but B&S cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance.

As the engine owner, you should however be aware that B&S may deny you warranty coverage if your engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. You are responsible for presenting your engine to an Authorized B&S Service Dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have questions regarding your warranty rights and responsibilities, you should contact a B&S Service Representative at 1-800-233-3723.

EMISSION COMPLIANCE PERIOD: 1000 HOURS

Briggs & Stratton Corporation Emission Control Warranty Provisions

The following are specific provisions relative to your Emission Control Warranty Coverage. It is in addition to the B&S engine warranty for non-regulated engines found in the Operating & Maintenance Instructions.

1. Warranted Parts

Coverage under this warranty extends only to the parts listed below (the emission control systems parts) to the extent these parts were present on the engine purchased.

a. Fuel Metering System

• Carburetor and internal parts (if applicable)
  Cold start enrichment system (if applicable)
• Fuel injection system (if applicable)
  Air/fuel ratio feedback control system (if applicable)
• Fuel pump
  Fuel filter

b. Air Induction System

Air cleaner
Intake manifold
Throttle body (if applicable)

c. Ignition System

Spark plug
- Ignition coil
- Ignition processor (if applicable)

d. Exhaust System

• Exhaust manifold (if applicable)

e. Catalyst System

• Catalytic converter (if applicable)

f. Miscellaneous Items Used in Above System

Pressure, temperature, position, speed sensitive devices
Electronic controls
- Connectors and assemblies
Hoses

1. Length of Coverage

B&S warrants to the initial owner and each subsequent purchaser that the Warranted Parts shall be free from defects in materials and workmanship which caused the failure of the Warranted Parts for a period of two years from the date the engine is delivered to a retail purchaser.

1. No Charge

Repair or replacement of any Warranted Part will be performed at no charge to the owner, including diagnostic labor which leads to the determination that a Warranted Part is defective, if the diagnostic work is performed at an Authorized B&S Service Dealer. For emission warranty service, contact your nearest Authorized B&S Service Dealer as listed in the "Yellow Pages" under "Engines, Gasoline," "Gasoline Engines" "Lawn Mowers," or similar category.

1. Claims and Coverage Exclusions

Warranty claims shall be filed in accordance with the provisions of the B&S Engine Warranty Policy. Warranty coverage shall be excluded for failures of Warranted Parts which are not original B&S parts or because of abuse, neglect or improper maintenance as set forth in the B&S Engine Warranty Policy. B&S is not liable to cover failures of Warranted Parts caused by the use of add-on, non-original, or modified parts.

1. Maintenance

Any Warranted Part which is not scheduled for replacement as required maintenance or which is scheduled only for regular inspection to the effect of "repair or replace as necessary" shall be warranted as to defects for the warranty period. Any Warranted Part which is scheduled for replacement as required maintenance shall be warranted as to defects only for the period of time up to the first scheduled replacement for that part. Any replacement part that is equivalent in performance and durability may be used in the performance of any maintenance or repairs. The owner is responsible for the performance of all required maintenance, as defined in the B&S Operating & Maintenance Instructions.

1. Consequential Coverage

Coverage hereunder shall extend to the failure of any engine components caused by the failure of any Warranted Part still under warranty.

Osha Hhopmaia

3a pe3ePBNH qACTn IIN TExHuaCheKa NMOoi 3aIuHte NO-dOy MoDeNa, BNuA n KOobete Ha DvIarateJIc C daTata Na KynBuHaTe My. TeNs KOobete Ce hAmupat Bbpy BaIHHBvIarTeJ. (BIXke CTpaHnUATA EnMeHTN uypBaJIeHN).

Data Ha KynyBaHe:

MM/DAIITTT

Moden ha DviraTeJ:

Moden:

Tun:

KoI:

HOpMaIg 3a HOMHaIHaT a MoUHOCT Ha DnBraTeJIte

3aDbiratene 3/LC (Tpiu ninnnnpoBn c BDOHO oxnaJdHe) nbHata MOUHOCCT OCHOBABA h KpItePnnte CbrLnacHO IpaBnHnka J1995 HA SAE (DpyxjcETBOto HnHXeHPNE tO ABTOMOBnHATA npOMuIeNcHOT TpaHCnOpTa), a NOE3HaT aMOUHOCCT -CBrAChO KpItePnnteOT J1349 HA SAE. POIE3HATA npO3BODCTBEH aMOUHOCHT Ha DBIRATEN, MOHTnPaHn 3a pa3nHn npINIOXeHN, MOXe Da BapuBa 3aBNCIMOCT OT rONM6poj fakToPi, BKNIOHTeNO rpaHnHNTe OOBpOt HA pINIOXHn MEXAH3bM, YCNOBnTA ha OKoJIHATA cpeDa, noDPbXkKaTa h da BrinraTe/ogbOpYBaHeTo n Dpyr nPOMEHNIb.

Texhika 3a 6e3oNaChOCT Ha onepaTopa

CIMBOJIN 3A BE3ONACHOCT IN YYPABJIEHNE

Orheonacho

DbNxKeun Ce yactn

Macno

OToPbHn Ra3OBe

Бьрзи обopotи

BabHN oboptn

Cron

BzPbBOOnaCHO

Onachoc3a npaxeHHOT eNektpnueckn TOK

TopNo

Cmyka

Bkn. N3Kn.

PpekpatBahe abaheTo Ha rop

06paTeH yap

Ja ce hocat npedna3Hn Ovnila

Onachny xumkaani

Ppoyete PboBOCTBO

Ropea noBbpxHOCT

OnachoctOT 3Mpb3BaHe

Iopeua Teuhoct mnpapa

IpeDynpTeiHTNnTcMBOJ 3a OAnCHOCT onpeDJIe IpeOxpaHITEnHa INΦOPMaUH 3a PCKOBe, KOITMO MOrAT Ja DOBeJAT Do HapAHBaHE Na nepCOHana. CnHahm3npuza dMya (OpACHO, IPEUYPEXKDEHNE uH BHIMAHIE) Ce noCTaB3aEDHO CpeDynpTeiHTeHcMBOJ, 3a Da NOCOH BepoTHOCTTA i NOTEHuaHATA cepMO3HOT Ha HapAHBaHETO. DOnbHtHeHO, EInH cMbON 3a OAnCHOCT MoKeJa nOKa3BA BnDa Ha OAnCHOCTTa.

ONACHO nocouba onachoct, korto, ako he 6bnde n36erhata, ue doBeede do cmbpt uH cepno3HO hapaHBAhe.

PNEpyPExKDeHNE noocBa onaCHOCT, KOaTo, aKe He 6bJe n36erHata, MoKe Da doBoeDo cMbpt Nn Cepno3Ho HapaHaBaHe.

BHIMAHHE nOCOyBa ONaCHOCT, KOrTo, aKo He 6bJe N36ErHata, MoXe da DOBeDe Do MaIka IIN cpeHa CTeneH Ha HapaHbAhe.

BHIMAHHE, n3no3BaHo 6e3 npEynpeDntENHn CmBON, noCOUBA cnTuacna, KOrTo 6n MoRNa da doBede do nobpeKdahe Ha npOdykta.

PNEyPPEKDEHNE

I3ropEnite ra306 ot To3n DInraTeN cbdbpKxat XmMueeckn CbeDnHeNHa N3EcTHNa Ha ta KaNfOpHna Kato npuHnHTeN Ha paK, yBpeXdAnH npaPaxdaHe, nIi dpyrYyBpeXdaHn, Cbbp3aHn C penpoDyKTHBHOCTTa.

PPEyPExEHH

Kopnpaunn Briggs & Stratton He oobpna H ne no3bONBa n3no3baHETO Ha Te3n DBIrAteJI BbPxy BCbExdoJI HA 3 KOJena, MOTOUKNETn, YBEcENIeNTN/KOJIUmK3a KaTpHTN, JTeaTEHNI anapATn INI TpaHCnOpTHn CpeCTBa 3a Yuactne B cBCTe3aTEHN MeponpuaTn. N3no3BaHTo Ha Te3n DBIrAteJI H TAkINBA MaWHNMOEJa DA BODE Do MAtePnaJIH N eTt, CepNO3Hn HapaHABaHn (BKIOUChEnHO npaJINa3) I dOPI Do CMbpt.

BHIMAHHE: HactoanrT DnirateIe doctabr ot Briggs & Stratton 63 macno. Pnei da cTAPtnpate Dniratne Ie yBepete, ye CTe Hanei MaNo B Hero cnopei INCTpykunite B TOBA pkoBOcTBO.AKO ro cTAPtnpate 63 macno, toi ca ce NOBpe 63 da 6bde BbMOxHO da ce peMOHTnpa n rapaHunrtna Hma da npokpBa. ueTaTa.

PNEyPPEKDEHNE

Béh3nHbT n HEROBNTe napn ca n3KJIIOUHTeJH0 orHeonacn n 136yXnBn.

Ioxkap nJI B3pNB MOraT da npuHnHT cepNo3Hn ObrapHnN nIcmbpt.

PpI dOJImbaHe Ha rOpNB0

• ɪəʌnʌŋeTe DɪbɪræTJIŋ I rO octaBete Da ce OXlaɪn Haɪ-Maɪko 2 Mɪnʊtɪn, npeɪn Da CBAJInte Kanaʊkata Ha pe3εpBoap a 3a ropɪnBO.
  -Пьн electe pe3epboapa 3a ropnBO ha OTkpnto nB do6pe BENTnnpaHOMeueHne.
  He npbIbaiTe pe3epBoapa 3a ropNo. TbHHeTe ro np6bn3nTeHo 1,5 Hua (38 mm) no-HNcKO oT roPnHa TbBpOBNHata, 3a da n03BOJnte pa3wnpeHne Ha roPbBOTo.
  -ДрьжTe 6eH3nHa daneu OT NCKpn,OTKpTu NJIaMbucn,CINHaHn JAmn,TOnnHa nI DpyrN 3anaJIteHn I3TOUHcN.
  IpoBepBaIte CheTo roPbONpOBoIne,pe3epBoapa,kanaKaTaNcEINHeHnTa 3a NyKHaTHnHnNII TeOBe.3aMeHete n,aKe e Heo6xOdmo
• Ako ropmboto ce pa3nee, n3aKaIte dokato TO ce n3napi, npedn da cTaptnape Dbratena.

PnCstaptnpaHn DnBnataeIa

• Vérepète CE,Ye 3aanañntelhata Cbeiu, Wymo3arIywniTENn, Kanaykata Ha pe3epBoapara 3a rOpBIO bB3dUnHnΦnTTbp (aKO IMa TAkbB) Ca HA MCTOTO CN ca o6e3onacEH.
  He pa3BbptaIte DnBaTeTcN 3NaJIteHa CBeU.
• Ako DBVIRATEJNT CE 3a,dabu, NOCTABeTe CMyKaUa (ako IMa TAKbB) Ha no3uIMRA OPEN/RUN, npnDbNVKeTe pTuHaTa ra3 (ako IMa TAKaba) Ha no3uIMRA FAST m pa3bByTaeIte, DOkATO DBVIRATEJNT cTAPtnpa.

Ppi pa6oTea MaunHa

He haknahnyTe Dniratena IJIM MaunHaTa NOd bI, KOITOBIO DO pa3JIbBaHe Ha 6eH3nHa.
He 3anyuBaIte kamepaTa Ha Kap6ypaTopa, 3a da cnpeTe DnirataTna.
- HmKora He CTapuPae I He pa6oTe C DmRAteJI npI DeMOHTnpAH KOMnNEKT Ha Bb3duHnIaФHb(pAOKIMTaKaBb) INI cAMO Bb3duUWeHФnTbp(aKO IMMa TaKbB).

Pn CmehBaHe Ha MacNo

• Ako n3TOyBaTe macnOTo OT rOpHaTa Tpb6a 3a nbJIHeHe C macNo, pe3ePBOapbT 3a rgBO TpRb6a Da 6bDe npa3eH, INI To MOKe Ja noTEe H da npuHInn IOxAp IIN EKcNlNo3N.

Ptp TaHcnpOpTnpaHe Ha MaunHaTa

• TpahncopnpaTe c PPA3EH pe3epBoap, nIc KpaH 3a noJaBaHe Ha rOpBHO ha no3nua OFF.

Korato cknadnapate 6eH3n HnO6OpyDaBe n c roPnBO B pe3epBoapa

• CkJaIpaIe Te daJIeOT neIeI, neIeK, BOHOHaRpeBaTeI IIN mDpyr eIeKtpUeCKn npIbOPI, KOITOMAT CNTaHNA JAMNa IIN DpyR 3aIaNITeEN H3TOHNN, 3aOToT e MoRAT Da Bb3NlAmEHTB E6H3NIOHbTIe NaPi.

PNEyPPEKDEHNE

IyckaheTo Ha IaBnraTeNa Cb3daBa NcKpeHe.

IckpeheTo MoKe Ia Bb3PnAmEH HAMnpaUte Ce HaOKoNo 3anaJIIMn ra3OBe.

ToBa moKe da doBeDe do ekCnNo3n n noXap.

Ako mHa n3TuHaHe Ha npirodeH nnBteUHe r3 npOnaH B nomueHneTo, He cTApTnpaTe DmRaTeJI.
He n3no3BaIte ropnBa 3a NaaHNO 3aanlaBHe NOD HAnraHe, 3aOTo napTe IM ca 3anaJIteJIH.

PNEyPEXKDEHNE

Дигате Дунскат Вглесорд Okис, Кйто e otpober ra3, 6e3 Мирис ИцВТ.

BdIiBaHTo Ha BbIePoJe H Okc MoKe Ja npuHn radeHe, npnAdbK nJn Cmpt.

• Cтартураити паBOTeTe CДВИгАТЕН Habьн.
  He cnapaTe n He pa6oTe Tc DnrgaTeIb B 3atBopeHo NomeeHne, dOpu npO tBOPeHn BpaTn nn np03Opu.

PNEyPPEXKeHNE

BbptTnTe Ce Yactn Morat Da Donpat Nn 3axBaHAT Pbue, KpaKa, Koca, oIeKIO nII pInHaadJeXHOCTN.

Mоже да се дoctиг He Do TpaВMaTHuHa amnytaци Илс срно3Hн hapaHЯBaHe.

Pa60TeC dBnrgaTeJI npi nOCTabeHn 3aunTHn Kana.
-Дрьктepьсeteи Кра��а си далец OT Вьгпси ce actN.
- Пивьрзваite Дыгente KOCи CBаЯт e ykaшеняta.
He hocete no c6e cn wipoko oBleknO, BnCraun uHypoBe nnBveu, KOITOMorat da 6bdat 3axbaHaTn.

PNEyPPEXKeHNE

Pa6oteuHte DnBraTeJN OTdJIaT TOIINHa. Yactne Ha DnBraTeJIte, OocboHo wymo3arLyuWnteJ, CTaBAT N3KJIIOHTeJIHO ropeu.

Pn donnp moKe da noluynte cepno3Ho n3rapHe.

TOpMnTe OTnabTu, KaTo Jncta, TpeBn, XpactaIak N npyrn, Morat da ce 3anaJrT.

OCTaBeTe 7yM03aRn7uNtTeIa, 7nHbpaHa DnBraTeIa n pe6paTa da ce oxlaJAT, Ppei Da rDOKOCBaTe.
- Otrcpahe T haTpyanHte OTJOMKn OKOLO yMOn3aIyUWntEINu cInHHbpa.
- MohtnpaIte n pOdbpXkaIte B pa60THo CbCTOHne NCKporacnteHJI, Ppei da m3PON3BaTe DnIraTeJHa 3aJIeCEHn MeCtA, 3aTpeBHeH N IIOoi, IIOoi c XpaCTN Heo6pa60TeHn MeCTa. UaTbK aNl6OpHn N3cKbTa TOBa (B Pa3dE1 4442 Ha KaINOpHnCKn npabUHnK 3a o6IeCTBeHn pecypcn). Bb3MOxHO eDpyrN qatn Da IMAT IOdoHn 3aKOHn. FedePAHInTe 3aKOHn ce npinlarat Ha fedeepalna TepITOPHn.

PNEyPPEKDEHNE

Morat da ce noJyat cepno3n n3rapnO NT OCB60kdaBaata ce napa nn OT ropeaata oxlaXdaTa TeHocT.

HE CBAJIYIte KanaayKeTe OTo paDnAToPa IIn pe3epBoaAp, Ako DniratJeT e ropeu nn pa6oTu.
Cnpete DnirateneH nro octabeTe Da ce OXlaDn, npede Ca CbaIaHe KanaUckite Ha paIaIatopa IIN pe3epBoapa I npede CMHaTAt IIN HauBaHTo H a OxLaKdaTaTeuHOCT.

PNEyPEXKDEHNE

CnyauHIO nckpeHe moKe da IOBeDe do NOxkap NIn Nopa3raBaHe OT eNEKtpnueckn TOK.
HeBONHO cTAPtnpaHc MOxJe da DOBeJe Do 3axBaUaHc, TpaBMaTHuHa amnytaunIIMdo paHbAhe.

Onachoct ot noxap

Ipeu n3Bpwahe ha peryunpoBkn nonpaBkn:

• OTKaueTe Ka6ena Ha 3anaJIteJIHaTa CBeu n roДрьЖTe daley OT HeJ.
• O Tkauhe Te MmHyc-KJIemata Ha akymyIaTopa (cAmO npn DniratEn C eJekTpueckn cTapTeP).
• IV3noJ3BaIte cAmO IOXoJauN INHCTpymeHTN.
  He 3actonopraBate c perynnapaata npyxina, loctobnte cnctemn nC npyrn actn, 3a da nobniute oobotnte Ha Dbratela.
• Pe3epBnHTe qactn Tp6Ba da 6bDaT cbC sbOTo KaueCTBO n da CE MOHTnpaT B CbUaT a N03uH, KAKTO opunHaHnHTe qactn.
  He ydprrte maxobnka c uyk nIIN TBbpr npedmet, 3aTOTo TOn MoKe da ce cTpown no BpeMe Ha pa6ota.

PnH3npo6BaHe 3a nckpa:

• I3noI3BaIte Oo6peH TnTtecTeP 3a Cbeu.
  He npabete npoBepka 3a nckpa npn n3BaDeHa 3aapanTeHa Cbeu.

Elenentny uypablenia

CpaBHeTe NIOCTpaIraTa 1 C BaIMa DnIgAteN, 3a Da ce 3ano3HaTe c pa3NIoJIOXeHHeTO Ha pa3JIuNHHe EJEMEHIn UynpABNeHn.

A. Mapknupobka Ha dBirataJIa Moen TnKoJ
B. Маркиморвka на Дагиателя Data Kod
C. PoioprrBaasa CBeu
D. HUBONOKa3aTeN
E. OTBOP 3a HajiBaHe Ha macNo
F. MaclenhФиntbP
G. Пробka 3a ИЗTOУBAне Ha macLoTO
H. JIO3a 3a BnpbckBaHe Ha rOpnBOTO
I. EneKtpnueckn cTapTeP
J. TOpINBO-HaHetaTHeHa NOMnA
K. Tepmoctat
L. Typ60komnpecop
M. KapTeP 3a macNoTo
N. AntepHaTop
O.Датук 3a Temпетатура淘汰хлaxдция areHT
P. BeHTnJaTOp
Q. Pembk 3a BEHTnJaTopa
R.ИЗпскатейенКОЕКТOP
S. Oxlaantel Ha MaCNoTO (aKo HMa TaKbB)

Pa6ota

Bmectmoct 3a macno (HnpaBte CnpBaKb B pa3deTexHuYecken DaHHN)

Ppenopbkn 3a MacNoTo

3a nonyubane Ha ha-n-do6pn Texnueckn nokaatei npenopbvaame n3no3baheTo HA macnata Ha Briggs & Stratton c rapaunna n ceptnpukat 3a kaeeCTBO. DpyrBnBCOKOKaeeCTBeHm MaCna C mneu npicaKn ca pnpemlnBn, aKO ca KlaacmUnpaHn3a pa6oTH PexkMn CF nI CF-4. Da he ce n3no3BaT cneuaJHn Do6aBkn. BbHnTe TEmnpaTyPOnpeJeT npabInHn BnCKoNTeHa macNoTO 3aDbiratEny. N3no3BaAte Ta6nmuTa, 3a da n36epete Ha-n-do6pn BnCKoNTe 3aOcAKBHn Dnana3OH Ha BbHnHTe TEmnpaTyPi.

* Ako npn Temnepatypno 40F (4^) ce n3no3ba maclo SAE 30, toba ue doBede do Tpydno cTaptnpahe na Dniratelj.
** Питtemператуниху [27°C] Излобанeto на масло 10 W-30 може на пошнионсимашита на масло. Роверразиные по чесу НВОТо м.

Kak ce npOBepraBa/HaJIbBa MacNo -ФИгура

IpeiHaIBaHe IINI npOBepBaHe Ha MacJIoTO

Pa3noJoxTe XOpu3oHTaJIHO DnBraTeJIa.
- Почистете мостOTO OKОLO OTBopa 3a Налване на MacNo OT BCNUKN OTJOMKN.
1. CbaneTe HUNBONOKa3aTeJIa 3a MacITo (A) N fo N36bPwTe C YHCT PIIAT (FInypa2).
2.ИЗЦАЛБМБКНЕТЕНВОПОКАЗATEЛЯ3aTROPIBOTO.
3. Cbane HNBOKoKa3aTeI I npOBepe T HNBOTo Ha MaCnOTo. To Tp6Ba Da 6bJe do MapKnPOBkata FULL (B) Ha HNBOKoKa3aTeIa.
4. Ako e HnCKO, CBAIeTe HNBONOKa3aTeJI N haJIeTe BHNMaTeJIHO MaCIO npe3 OTBOPa 3a IIbJIHeNe Ha dBnIaTeJIe (C). He ro npenbIbaIte.

Baxho: KoraTo HauInBaTe MacNo, npaBnHTo BcHTnIpaHe ce NsICKBa, KaKTo CneBa:

CbaNETe HNBONOKa3aTeJIra 3a MACJOTO.
- Y6eTeCe, Ye NOIbIbPxKATE HxKyHOTO pa3CTOHNHe (D) MEXydy FyHnIa 3a NaIbMaHe Ha MaCNo (E) I CTeHATA Ho OTBopa 3a IIbJIHeHe Ha DnBtAteJr (C). BxKTe ΦNyrpa 4.

1. Cnéд наимbaheTo ha macnoto, noctabete HNBONOKaTeJI. CTaptnaIte n octabete DBNATeJI Da paobTu NET MmHTu Ha npa3EH XoJ. N3KJIIOUcTe DBnATeJI. N3kaKeTpe TpM mHyTu INPObepTe HNBOTo Ha macnTo. AKO ce HAlara, HaNJIe Te OSe MaCNo, 3a Da DCtNTHa HNBOTO My Do MapKnipOBkATA FULL. (B) Bbpxy HNBONOKaTeJI (ФИгур2).

2. IocTabete HNBONOKa3aTeJHa MaCnOTo.

HaJrahe Ha MacJoto

Ako HNBOTO HA MACNOTO E MHORO HNCKO EHN DAHTNK 3A HANRAHE (aKO hMA TaKbB), MIO Ue Cnpe DnBtEra, IINI Ue 3AedCTBAIAPAHOTO MY cTPOCTBO. AKO TOBA CE CUYU, CNPTE DnBtAEY INPOBEPETe HNBOTO HA MACNOTO C HNBONOKa3aTeNA.

Ako HIBOTO Ha Macnoto E NOI MapKIpOBkata ADD, IO6abete MacNo, IOKaTO doCTHReMapKIpOBkata FULL. CtapTnpaIte DnBnateJ INpOBepeTe HAnraHTo, npEeI da PNOblXnTe Da pAbOTHe.

Ako HIBOTO Ha macloto e mexdy MapknpoBknte ADD n FULL He cTaptnpaTe Dbratraten. Obphtete ce kMn HNKy uYbHMOohme npdctabraTeHa Briggs & Stratton 3a Dbratraten 3/LC, 3a da OTCtpanhe np6bneMa hanyabaHTo Ha macloto.

Ppenopbkn 3a ronpBOTO

TopNBTO Tp6Ba Da otROBapHa cJIeHNHe N3NCKBAHn:

To3n Dbraraten cbc septncikat 3a pa6ota c dnn3eNo BO ropnBO.AKO He ce m3no3Ba NOxOAnTO TROPBO MOKe Da ce NOnyUH CHepeH DNIM, 3ary6a Ha MOnHOCT N NOBPeHa HDBrAteJIa, KOATO HMa da 6bJe NOKPITa OT rapahnuraTa.
- I3noI3BaIte YIcTcO, IIpaCHO, DnI3eIOBO rOpNBO C MmHIMaIIHO UeTaHOBO YIcTcO 40. IprCHOTo rOpNBO ppeDITbPAITBA O6p3aYBaHETo HA CMOnA B rOpNBHTa CnCTema. KyuBaIte rOpNBO B KOJIneCTBO, KOETo MOKe da Ce I3noI3Ba B pAMKNTe Ha 30 dIi. BIXTE pa3dEn CkIaNipAhe.

BHIMAHHE: He n3no3BaIte Kepocn HJIN 6eH3nBMECTO n3eJIOBO rOpBO.

He3na3BaHTo Ha ToBa H3nCKBaHe BoN Do NOBpeHa Da BnIraTeJIa anyInpaHe Ha rapaHuaTa My.

Kak ce HajiBa Macno - Fmrypa ⑤

PNEyPPEKDEHNE

TropBOTO NHEROBITE napn ca n3KJIIOHHTeINHO ORHEONACHN N36yXJIINB.

Ioxap nIIN B3PnB MoRat Da npuHnT cepNo3nObrapnNn CMBPT.

Ppi DJIINBaHe Ha rOpNBo

-ИЗкlioчete Двигателги nTo OCTaBete Da ce OxlaDi n Hai-MajIko 2 MmHyTn,прdi Na CBaJIte Kanaykata Ha pe3epBoapa 3a roPBO.
-Пьн electe pe3epBoapa 3a roPbOHa OTkpIto nBdope BENTnnpaHOMeueHne.
He npenbnaite pe3epboapa 3a ronpBO. PbnHete ro npnbni3nTeHNO 1,5 Hua (38 mm) no-HNcKO oT roPNHnPB6 Ha TbPbONBnHa, 3a da nO3BOJnTe pa3wnpeHne HA roPBOTO.
- DpBXTe rOpBOTO daney OTOCKPn,OTKpnTn PnAmbci, CnHaJIHn JAMn, TOnJIHaN aDpyr 3anaJIteJIHn n3TOUHmI.
- PpOBePbBaIte YecTo rOpBnPoBoOuIte,pe3epBoapa,KanauKaTa n CbeDInHeHnra 3a NyKHaTnHn N TeOBe.3aMeHraTe n aKO e Heo6xOdmo.
Ako ropuBTo ce pa3nee, u3aKaaiTe dokaTo To ce u3napi, npedn da cTaptnape Dbratena.
1. Повстете.netростанчебто OKОКANAчКATA на розербаа за рорив OT mьсочи и насноявань.Сбалене сankayakata(A，Фигура)5.
2. HanbIhTe pe3epBoapa 3a ropINO (B) c ropINO. 3a da no3boJInTe pa3uHpeHne ha ropINOTo, He bIhHeTe Hd doJIHaT aOCHoBa Ha rbPNOHnTa 3a HaNBaHe ha ropINO (C).
3. NocTabete 6paTHo KanaaKaTa.

Ppenopbkn 3a oxlaekdaeta Teuhoct

BmecTmOCT 3a OxJaxJaauTa TeHOCCT (BnXTe PbKOBoDcTBOTo 3a pa6OHa npOn3BOdntela Ha o6OpyDbAHeTo)

Baxho: Toba e Dniraten, Oxlanqan C oxlanqdaa TeuHoc. 50/50% cmeoT Hecbdpjkaa fccpaTu aHTnOprn3 n BOdnpoBOHa BODa e HEO6XoIMa 3a Oxlanqdahe, OcnpyBaHe yCTOnuHOBCTTa Ha KOpO3nI n Cma3BaHeTo Ha BoDHaT NOMna.

Kak ce npOBepraBa/haJIbBa oxJaXDaIaTa TeuHOCT

PNEyPPEKDEHNE

Morat da ce noLyutce npno3n n3rapnna ot ocbooxdaBaata ce napa nn OT ropeaata oxlaqdaa TeHocT.

HE CBAJIAYTE KanaayKeTe OTo paDnAtopa IIn pe3epBoapa, Ako DniratJeT e ropeu nn pa6oTu.
Cnpete Dbriratena I ro octabete Da ce OxnaI, npdeI ca cBaJIHe KanaaKInTe Ha paIaIatopa IIN pe3epBOapA IN ppeI CmHaTa IIN HAIbHaTe HO OxlaXdauTa TeyHOT.
1. Праздау，在охлaxdaata TeHocT.НьOTO u Tpr6ba da 6bde Мжду Маркпорвкite FULL 和 LOW/ADD, OTблзани на pe3eрьогараза oxlaqdaanza TeHOCT.Ако НьOTO с и НСКО, нале tire В pe3eрьогараза 50/50% Смсота anHtppn3, кOTо He CBdPka Фocpatи И ВOAотВODOCHaNTeHATA mpexka.

1. 3a da cbaJIne Tana KaTata Ha pe3epBoapra, CneI KATO dBnrtAeTI e OXnAdeH, noCTabete napYe de6eN Inilat Bbpy HcE. BHmATEHNO a OTBnTE B nocOKa, oBaPAHa h DaBnxKeHTo H aCOCOBHKoBA t CPENKA.
2. Ako pe3epeBoapbTe npa3eH,doJeIe B Hero N B paJmaTopa OxJaaTa TeHOCr. HanpaBeTe cnpBaK b PbkOBOCTBTO 3a pa60Ta C o6OpyDbaHeTo OTHOcHO pa3noJoxKeHMe,po60TaTaNIOdpBxKaTa Hpe3epeBoapaN paJmaTopa 3a OxJaXDaUaTe THeOCT.
3. 3a da cbañite Kanaúkata Ha paáñatopα, cnei KaTo dBiratelaT e oxlaedn, noctabete naphe debeI nIAT pBxpy He. BInmaTeHIO r OTbniTE B NOCOKA, o6paTHa H DaNBIXeHNTo HA cacOBHKnOBaTa CTpeNka Do IIpBPOTU cnpaHe. Ako ND He i3n3a npa IpoI hnaIraHe, 3actaHete Ha3ad, 3a da I36BerHe TnapaBaHe. Cnei KaTo HAnraHete CnIaHne, HATNCHEte KanaúKATA Ha padNaTopa HADONY I a OTBniTE B NOCOKA, o6paTHa Ha dBixKeHMeTo Ha cacOBHKnOBaTa CTpeNka.

I3mepBaTeJIHn ypeDN i CBETJIINHHN INHdNKaTOPN

Ioka3aHnTe I3MePbATEHNHypeDNi NCETNIHHN INHnDKaTOpN ca TcAndapTHN i CbueCTByBAT B pa3NIHn OINi, KOHTo MORAT Da 6bDat N3NO3BaHn. HanpaBeTe cnpBaKbA B PkoOcbTO 3a pa6ota C o6OpyDbaHETo OTHOCHO pa3NoIOXeHnEO pa6oTaTaNIM.

Tepmometbpa 3a OxnaKdaaata TeHOCt

Показва Temпера typа на охлaxдашатугост, korогот контейнат Клич с поимя ON (Вкл.). Hopмален 06xbat - 80° - 90°C (175° - 195° F) Onaceн 06xbat - Нд 105° C (220° F)

Yacobn6poa

OTHTa cymapnna 6poi pa60TH nucoBe.

I3mepBaTeJEn ypeed 3a HaJIuHOrROPBO

Ioka3BaOCTaBauIoTO Bpe3epBoaparopnBO.3a daHamaInTe KOHN3aunraTa HbOa, BnHarnIOndbpxajTe nbIeHpe3epBoap.

CBeTInHeH INHdNkaTop 3a TemnepaTypa

Ako CBETNIHHNAT INHDMKATOP 3a Temnepatypata CBETHE,3NAU, YDE BnBAtenat e nperepAn. Cnpete DnBtareTne Npopebete HNBOto HAoxNaDauTaTe TcHOTC (Bxte paoEpaKa

OxnaJaata TeHocT).IpoBepBaIte paIaIatopa 3a HacIOBaHN, KOITMOrata da OparruAT B3dyuHnI NOTOK.

CBeTJIHHeH INDnKaTOP 3a 3anaJIbAHe

Korato KOHTAKTHNAT KJIIOU e Ha NO3nIaON (BKnL.)CBETNIHHNRT INHINKATOP 3a 3anaIbAbe TpR6Ba DA cBTN. LOM DBNRATENRT 3apa6OTM, BNTpR6Ba da Ia3rache.AKO INHINKATOpBT He CBTN pRiKOHTAKTEH KJIOU aON (BKnL.) npOBepeTe 3a n3rOPI npEtnaNTen.

CBeTtHnEH nHnKaKOp 3a haMaNToB bDnRaTeIe Korato KOHTAKTHNAT KIOUe hA no3nua ON (BKn.), CBeTtHnHHaRn HnHnKaKOp 3a HnAHaTHeTO Ha MaNToT PTo6Ba dCBTu. IOM

Дигателт ЗаразOTN, CBETINHнгИ ИДКATOP 3a HAJIraHETO Ha MacNoTO TpR6Ba DA 3aRaCHE. AKO CBETINHnHTI INdKATOp 3a HANrAHeTO Ha MACnOTo CBETN pRi npa6ToeI DnBAten, He3a6abNO ro cnpTe. ПьрBo npOBepe HbBOTo Ha MacNoTO (HanpaBete cnPabKa B pa3dEN KaK e npOBepBa/HaHnBa macNo). CneT ToBA npOBepe eJekTpueckata cnCTema.

CBeTJInHeH INdKaTop 3a 3apeXdaHe

Korato KOHTaKTTHnT KJIIOU e Ha N03uIN ON (BKnL).CBETNIHHNt INHnKATOp 3a 3apeJdaHe TpI6Ba Da CBETn. LOM DnRatEnT

3apa60tn, INHdkaTopbT Tp86ba Da n3rache. Ako CBetJINHHnT INHdkaTop 3a 3apeKdaHETo CBeTI npn pa6Oteu Dnuratel, IpOBepete eEnktpueckata cnCTema.

CnHaJIHa JAmNa 3a HarpeBHa CBeu

Korato KOHTAKTHIANT KIIOU e Ha no3uHne heat/glow nIIN no3uHn ON, CINHAHATA lamna ue noka3Ba, Ye harpeBhnte Cbeu npedbapntelHO opOBHNTa Kamepa.

CBeTInHeH INdKaTOp 3a fNtBpa 3a rOpNBO

CBeTINHHNAT INHnKaTOP 3aΦnITbpa Ha rOpBOTO CBETBa, KOraTO BvB ΦnITbpa ce e Hacb6pala MHOBOda. INHnKaTOPbT TpIb6Ba da

3araChe, KORAto N3NIHnHaTa BOda CE N3OTOn OTФNITbPa 3a ROPBOTO.AKO CBETJIINHHNHT INIHKaTOp 3aФNITbPa HrOPIBOTO CBETHE, KORATO DBIRAteJIAT pa60TN, CIPTeJ DIBrAteJIa N I3OTcE To BOdTa OTФNITbPa 3a ROPBOTO.

Kak ce cnapa Dnrgatele - Hrypa 6

PNEyPPEKDEHNE

TOpNBOTO HHEROBNTe napn ca N3KJIIOHHTeHNO ORHeONaCHN N36yXJIbN.

Tóxap NIN B3pNB MOraT Da IpiNHyrT cepNo3Hn ObrapAHH NIN CMbpt.

PnCTaptnpahe Ha dBiratena

Vbepete ce, ye uymo3aargyunitejT, kanaaKATA ha pe3epBOapa 3a ropBO n Bb3duHnT fnnIbP ca Ha MeCTata m n ca do6pe 3akpenen.
- Ako DvgrateTneTc 3a,dabn, noctabeTe CmykaHa (aKO Ima TaKbB) Ha nO3uHn open/Run, npIzDBeHe Tbe pHuHaTae (aKO Ima TaKaba) Ha nO3uHn "fast" n pa3BbPTaTne, doKaTO DvgrateTne STaptna.
3a da npOdbIJIKTe KJIBOTA Ha cTapepa, 3nON3BaJIte KpaTK cTapTOBn UIKJN, He no-dIbIgnt ot 15 cek/MH. PpOdbIJIKTeHNO pa3bPtaHe moKeJa nOBpeDi cTapepa.

PNEyPPEKDEHNE

Дигатеите n3nyckat BbyrlepoDEH OKUC, KoITo e OTPOBEH ra3, 6e3 MIMPC N CBRT.

BdmbaHTo Ha BbIepeDoH Okc MoKe da npuHHn radeHe, npnnaDbK nIn Cmpt.

• CtaptnpaTne npa6oTe c DbVraTeJn HABhN.
  He cIapTpaIte n He paOteTe C DnIraTeIa B 3aTBOpEHO NOMEeHne, Iopn n npn OTBOpEH BpaTIu nn PpO3OpU.

BHMHAHVE: HactoHHTBnATeIeOCTaBbOT Briggs & Stratton 6e3 Macno. Ppei Da cTAPATE DnBnATeJIe CE yBepete, ye CTe Hanei MaNo B Hero cnopei nHCTpyKuHTE B TOBA pkoBOcTBO.AKO rCtAPATE 6e3 MaNo, ToJ ca CE NOBPeIe 6e3 Da 6bDe Bb3MOxHO Da ce peMOHTnpa I rapaHUnrTa HMa da NOKpNbA uetata.

BHMMAHME: IpeDn Da CTApTnpaTe DnIraTEna 3a IbPbN bT, 3apeDeTe akymnaTopa, kako Te CpneOpBvO BA TpOnBIOAnTeHa NBOpdyBaHToE. Hec3nA3BaHETO HA TOBA N3cMbCAHe MOKe DA npnnH NOpeBa HbDRIATeRn.

3a6eJekka: HЯкои Двгагети и оборудане сcaбденис усточьа 3a дuctанциону упавленье. Hanpa bate cnpa в Бковodztb0to 3a pa60ta c obopydbaheTo 3a pa3noJokheneto n pa60tatac yсточьbata 3a duCTahunHOnH ynpablenHe.

1. Поберете НИВОТа на macIoTO.Наравete справka в раздаЯ Кak ce npobepBa/HaJIbMa MacNo.
2. YBepete ce, ye 3aDbNkBaunTe ynpabNeHnHa o6OpyDbaHTo, aKO nMa TaKnBa, ca N3KnIOHeHn.
3. 3aBpTeTe KpaHcTo 3a noDaBaHe Ha rOpIbO (A), aKO nMa TaKOba, Ha no3nur "on" (Фигур6).
4. Пемец се Лоста на рьчата ra3 (B) на позця slow

3a6eJekka: 3a cTapTnpaHe B cTsyEno BpeMe (noD -10° C nIin 14° F), noCTabeTe nocta 3a pChnata ra3 Ha no3nua fast

CmHa Ha MacJIeHnФJITbP

OTHOCHO INTEPBANITE 3a CmHaTMy HAnpaBete CnpabKa B KapTaTATExHuecko 06CnYKBaHe.

1.ИЗТоУВанеHaMACЛOTOOTДВИАтЕЯ.HanpaBeteCnpaВkaВpa3дeNИЗТоУВанeHaMACЛOTO.
2. CbaneTe MaclenHnA FInIbP (H, FInnypa3) n ro deNoHnpaTne no noXdoHnna HauH.

1. Ппедида моHTирате HOвИ МаСЛЕн ФИNTьр, ЛЕК Oмжete ФИNTьрНATA rapHNTypa C HОВО, YИСТСО МАЛNO.
2. MohtnpaIte MaclenHnФnTbp Ha pBka,doKaTo rapHnTypa Onpe BbBФnTbpHnAaIaTpep, cnei Koeto ro 3aterHeTe c oue 1/2 do 3/4 obopota.
3. HanaBaHe Ha macNo. HanpaBeTe cnpaBka B pa3JeH aHa macNo.

HaHnBaHe Ha MacJo

Pa3noJIOXeTe xOpn3OHTaJIHO DnBraTeJIa.
- Почисту мостOTO OKОLO OTbopa 3a Налване на MacJO OTO BCNUK NOTJOMKN.
Hampabete cnpabka Ba p3denn Texnueckn daHHN OTHOCHO BmectMOCTTA 3a macnoto.

1. CbaIeTe HbONOKa3aTeJIa (A,ФИгура 2).
2. Hajeite BnmaTeHIO macIoto B dBirataTeI pye3 OTbopa 3a nbHe (C). He npenbIbaIte.

Baxho:Korato Hauinbate Macno, npabunHBo BHTnIpaHe ce 3NCKBa,KaKTo cneBa:

CbaJeTe HbONOKa3aTeJIa 3a MacIto.
- Y6eTe CE, Ye NOIdbpxkATE HxHHTO pa3cTOrHHe (D) MEXydy FyHnraTa 3a NaIbMaBe Ha MaCNo (E) i CTeHATA Ha OTBopa 3a IIbJIHeHa DAIBrAteLn (C). BHXTe CFNyrpa 4.

1. Cnéд наиbaheTo ha macnoto, noctabete HNBONOKa3aTeJI. CTaptnpaite n octabete DBNRatJIЯда paobotNI net MHNyTn Ha npazeh XOD. ПpoBepete 3a TeYObE.ИЗКЛIOЧЕ DTBnATJIe.ИЗраКITE TpN MHNyTn INpoBepete HNBOTO Ha macnoto. Ako ce HeJARa, HaneiTE OiIe MacNo, 3a Да DOCTHRe HNBOTO My Do MAPknipOBkata FULL (B) Bbpyx HNBONOKa3aTeJIa (Фиура 2).
2. NocTabete HNBONOKaTeJHa MaCJIOTO.

Kak da ce o6cnykBa Bb3dyuHnHaФnTbp-Фnrgpa 7

PNEyPEXKDEHNE

TogIBOTO HHEROBITE napc ca N3KNIQUHTeHNO ORHEONACHN IN36yXINBn.

Itoxap nIIN B3pNB MOraT Da npuHnHT cepno3Hn ObrapnHn nn CmbpT.

Hikora He cTaptnape Te He pa6oTe C DniratEn npN OTcpanen KOMnneKTH Bb3dyuHn4 pntbp.

BHIMAHNE: He n3nON3BauTe CbrCTeH Bb3dYx NIN pa3TbOpNTEn, 3a da NOChCTBaTe fNtba. CbrCTeHrBb3dYx MOKe da NOpeDn fNtTa, a pa3TbOpNTeTo ra3TbAPrt.

OTHOCHO3NCKBaHnra 3a cepBn3HO 06cnyXbaHe, HnpaBeTe cnpabKa B Kaprata 3a texHnueckoto 06cnyXbaHe.

1. OTBOpTe cHKcatOpnte (A) n cBaJIte Te KanaKa (B). BuxTe ΦIrgypa 7.
2. CbaJIeTe Bb3dUwHnA qmIITbp (C).
3. 3a da OTCTpaHNTe HACNORBAHnra, BHMMATEHNO NOyKBAITE Bb3dUHHIN φmTTbp Bbpx Tbprda IOBbpxHOCT. Ako e npekaIeHO 3ambpcEH, CMeHETe rC HOB φmTTbp.
4. MoHTpaIte Bb3dUshnHnФnTbp.
5. NocTabete Kanaka n 3aTbOpTe dKcatOpnte.

Kak ce cmeHa qnntbpa 3a ropnBO - Hnrypa 8

PNEyPPEKDEHNE

TOpIBOTO HcEROBnTe nap ca n3KlIOuHTeJIHO orHeONaChn n 36yXnBn.

Iopkap IIN B3pNB MORaT Da npuHnHT cepno3Hn ObrapnHn IIN CMBpt.

• OTKaYeTe MInHyc-KJIeMaTa Ha akymyIaTopa (cAmO npi DniratEn C eJeKtpueckn cTapTep).
  -ДрьхтеторвOTOдалачOTNCKPn,OTKpntINПамьс,СИгнанилamnI, TOnnHaHиДугиЗаалNTeHLNи3TOUHNi.
• PpOBePbBaIe Te cecTo rOpBONpOBoJnTe, pe3epBoapa, KaanKaTa n CbeDInHeHnra 3a NyKHaTnHn I TeOBe. 3aMeHnTe rN aKO e Heo6xOdmo.
• Ppei CmHa Ha qHITbpa 3a rOpINBO, n3TOUe pe3epBOap a 3a rOpINBO nI IN 3aTbOPe KpAHcETO 3a IOnDaBaHe Ha rOpINBO.
• Pe3epBnHTe qaTn Tp6Ba da 6bDaT cbC cbTo KAueCTBO n Da CE MOHTnpat B CbUata N03uH, KaKTO opunHaHnHTe qaTn.
• Ako roporboTo ce pa3nee, n3uakaiTe dokato To ce n3napi, npedi da ctapnpate DbratetaE.

AOKBcETNIHHNRTnpEduynpeJdaaUHdNKatOp3aФnITbpaHa rOpNBOTCBETHE, DOKATO dBiratelTAPoBTu, CNpTeToIuN3TOHTeBODataOTΦnITbpa3a rOpNBOTO, KAkTO CNEBa:

CmeHete nJITbpa 3a rOpNBOTO

1. Pa3eɪnHeTe npOBoNDnka Ha daTynka D.
2. CbaIeTe np6kata 3a n3ToBaHe (B) u n3xBpIeTe O-tpbCTeHa (E).
3. CbaIeTe nITbpa 3a rOpNBTo (A) c raeueH KIOU 3a fNITbp.
4. MohtnpaIte HOB qinTbp 3a ropnB0TO Ha pbka,doKaTo raphNtpyata (F) onpe B KapTepa.CneToba 3aTeHHe TOnbInHTeJIHO c oJe 1/3 o6OpOT.
5. MoTnpaIte npo6kata 3a n3TOUbaHe C HOB O-npbCTeH.
6. Cbpxkete KaebJa Ha daTnuKa.

7. 3aDééntbain Te nokkauBaata nomna (C),doKaTo ycetnte cbnpotnBneHne.

8. CtraptupaTe DniratTeN npOBepe 3a TeObe.

I3toe BoDaTa Of qHnTbpa 3a rOpNBOTo

1. Cnpete dBuraTeJIa.
   2.Пoctabete BaHATA 3a n3TOUbaHe noIФиЛТьра 3a rOpnBO (A) n pa3xJa6eTe npo6kata 3a n3TOUbaHe (B) c OKOJI OEDIN O60pOT.
2. BODaTa TpRbBa Da nI3Tee OT pINITbpa 3a rOpINO.AKO e Heo6XoIMO, 3aJeICTBaIte NOKaUBaJATa NOMA (C), 3a Da nI3TOUHTe BOJa, HO cAmO DOKaTo NToeTc rOpINO OT pINITbpa.
3. 3aterhe Te np6kata 3a n3TOUbaHe.
4. CstapnpaIte DInrataIe. YBepTe ce, Ye npEynpEnTHeHaTa IaMaNa 3aracBa. PpoBepTe 3a TeOBe.

Kak ce npOBepBa/peryInpa pembka Ha

BeHTnlaTopa - Fmrgpa 9

PpOBepBaHe Ha pembka Ha BeHTnlaTopa

3a JIyHOn TbproBcKO non3BaHe

Двигаел Vanguard™ 3/LC

2roDHH

TapaHnIa 3a OCHOBn Yactn\*

3roDnHn

Pe3epBnH qactn n Bnlaran Tpyd

2roDnHn

* Otbenexete cneDnhte cneunHn rapanonHn nepnoi: 3a ceIHTe Ha Ta3n rapaHOnHn noJTNk, nOKpTmTe 3a pe3epBnTe aactn BnaRaHnT 3a zamHATA mtpd e 3a nepoD ot 2 roHN. Camo 3a ocHOBnTE pe3epBNu cactn rapaHOnHNOHOT oKpTnHE e p3wnpeHO n 3a tptata p60THa roHnA. rapanuHa 3a ochOBnHTe qactn (F.O.4) noKpBa, HO He CE orpaHnUaba eINHCTBeNo H CMO do cnInHDPBOBA 6LOK, cnInHDPBOBA T raNBA, KOENHATn BA, p3apEnJIteJIeHNBA J3bONHtpeJaBKn, 6ytaIATA, MOTOBUNKITE, MAXOBNA, KOGXya 3a MAXOBNA, MAcJeHATA NOMNa, BEHTnAToPA, pEmChNTe shoBm, MexAHnupeYrAtoPcMcyKaTeJHn N KOLEKTnpMACsEHHaNKeKAPert. F.O.4 He noKpBa HcHe orpaHnUaba eINHCTBeNo H CMO 3a 6yTAJIHnTE cerMeHTn, Cmehemite NaReepn, BoHDATA NOMNA, BCEKN ELEMENT OT eNEKTPueckata IHCTaLauZn, 3aDbNXBaUHTe ELEMENT 3a KNanAHNTe CNOMARATEJIHNTe QACTN, YyIbTHeHNAta, raphHTpynte, KApSbATopNPte, KOLEKTOPa 3a INROpEJIte rA0BE, FBkABITe npOBoDn, BCNUKn ELEMENTn Ha rOpBnHA TcNCTema, PA3npbCKBaHNTe IIO3n, HarHeTaTeHNAta NOMNA, Typ6okomnpecopa, yMoo3arlyuWentner, BCNUKnФInTPn, PAdnAtOPa, TepMOCTATA, ZanlanlNTe CBeuN, HArpeBaTeHNtE CBeuN N NOMNTE 3a NODaBae HA rOpBc. RapAHouOHnTepneoN H pAnOoB aT datata Na KyuBaHe OT IIpbBn Notpe6bntel Na Dpe6Ho NII ON To KynBauch 3a TpRoBcK N eI N npDoBxKabA 3a nepoOda ON BpeMe, fKncCpan B rOpHaT aTabNiua.

He e Heo6xOIMa pernctpaunHa rapaHuaT, 3a da ce npUynr rapauHIOHO o6cIyXBaHe 3a npodyknte Ha Briggs & Stratton. Pa3ete 3a dokaaateNCTBO KBTaHUNAOT OTOKyKnata. Ako He ocNpytne koka3atenCTBO 3a HauNATA Da T a KaynyBaHe, pni NocKBaHe a rapauHIOHO o6cIyXBaHe, daTata Ha npOnBODCTBO h npOyKTA ue 6bJe 3noP30BAHa 3a onpeJenHe h rapauHIOHH nePnoID.

OTHOCHOBaShaTa rapaHcHnA

Briggs & Stratton npHemAT c roTOBHOCT rapaHUNOHnI pMOHT n CE n3BnHBat 3a npHInHETO Bn HeyIO6CTBO. BCEKo TOpINiPAH cEBPn3EN ppeCTABITe H a Briggs & Stratton Moze da OcbSeCTBn rapaHUNOHnTE pMOHTn Ha DBrAteJIITE 3/LC. Nobecheto rapaHOnHH pMOHTn Ce npOBExdAT pyTHNO, HO NoHNKAOra e B3MOXHO nCKAHNTa 3a rapaHUnOHNo CEBM3HO o6cJyXBaHe a He ca ONpaBdAn. HanpIMep, rapaHnI HA da Ce npIN3Hae, aKO nobPeDA t B DVBAteJIe Ce bJLnKn Ha HEnpaBnIH a yOtnPEba, Na IINCA na PeDOBHO TEXMHNECKO o6cJyKBaHe, Ha HEnpaBnIH OtpHCnOPTtpanAE, MaHEBpINAe IN CKNaDIPAhe INN Ha HEkAYeCTBeH MOHTxK. CbIoTo Taka, rapaHUNTA ce rHyBu, aKO cepINiHNT HOMep HA DVBAteJIe oCTPaHEH INI Ca npaBeHn IpomEHn IO CAMn DVBAteJI.

Ako kynbvaht he e cbrnaceH cpeweHneTo ha Cepbn3Hn npdctTabnten, ue ce hnapabn pnooyBaHe, 3a da ce yctanOBn DaJI rapaHnTae TpeN3HbA. NsckBaIte OT Cepbn3Hn npdctTabTae H da pnoCTabn 3a pnerD BCNUKy DoNtBnTHeNPAkTN Ha cboa dncrbytOp INu HA 3aOda.AKO DnCrtn6BytOpbT INu 3a0oBt peuH, ye TOBA nCKaHa e OnpaDaHo, Kynbvaht 7e 6bJe HAnbIHO oBe3ueTeH 3a deFeekTHnTE qactn. 3a da ce n36eHHe HeOpa3yMeHNeTO, KOEt MOKe DA Bb3NHKe MEXJy KynbvaHa u npdctTabTHe, NO-dONy ca n36pOeHN HAKO ON tPnuHInTe 3a noBPeDA BDbiratela, KOITO rapaHnTHe TE NOKpMa.

HopmaHIO n3HocBaHe: DnBraTeJIte, KaKTO BCNUKm MEXaHUNH yCTPOCTBA, Ce HxJdaT O TEPNIOHNA 3aMHa Ha cactn N o6cNyKBaHe, 3a Da pa6oTt D0bpe. FapauHnIaTe He NOKPbA pEmOHTa, KORATO pnp HOPMaHO n3HOCBaHa dAeHa cAte H JIN DnBraTeATc Ca n3eepnAn JXWBToC t. FapauHnIaTe He ce pnpnaHa, Ako B DnBraTeAe CcNyH NOBPeDa, NpApdHnEHNpaBnHNO NOn3BaHe NNOTcBtne HpyTHNa NOpDpBkKa, TPAHCNPtIpaHe, MaHNyIpaHe, CbXpaHnBaHe INn HEnpabuIne MoTak. CbIo TaKa, rapaunHrTa Ce ry6n, Ako cepinHnRT Homep Ha DnBraTeJe O TcTpaHen INI no Hero ca npabeHn pomoeH.

Henpabnno noodbpxhae: XIBOTbHa na daen DVBATeI 3aBNCN OT yCNOBnTA, npn KONTO paobTn IOT prnKte, KOtO nOlyuYaba. HaKOn npInIOXeHnA, KaTO KUYTBAToPOn, NOMIN, INOTAUMHOHN KOCaQHn, MHOrO cTeO CE tN3oN3BaT B nPaShn a 3ambpceha CpeDa, KOEt MOxEJa da OOBeDo npDeBapNTeHOTo IM N3HOCBaHe. TaKoBA m3HOcBaHe NE CoNPKBa NT oRaHua, KORA To CE dJFkN HA MPbCOTn, npax, aba3nBa 3a NoCHCTBaHe Na CBeTaNa IIpyrN abpa3nBnMaTePnAIn, nonaHaJIbN B DvIRATeJI NOpaN HeKAeCTBEHO nOdBpxAe.

Ta3n rapaunna NOKPbBa cAmO yNtpe6eB V DBrataJIe DeEkeTeH MaepnA n/nn I3pa0bTka, a He 3aMnHaTa nn Bb3CTAHOBRAHETO Ha MauHHata, KbM KOrTo DnRatIeTn MOKe Da 6bJe MOHTnpaH. RapaunraTa He NOKPbBa n nonCKAnu pEmOnTHn nopArad:

1 IbIraTeJI, KOITHe Ca npaBnHIO MOHTnpaHI KbM 3aDbNkBaHaT a MaIHNa. HAcToIuHOb Ce npenOpBvBa npEdbApntNo da ce 6bPheTe KbM 3aBoDa, KORAto ige MoHTnpaTe 3-UNINHpOB DBaRtAeC BOHO OXlaJdane B&S 3/LC KbM MaIHNa, KOHTo HE n3non3Ba, no NaHano, DbIRatner B&S 3/LC.
2 Поблеми, пчинен OT части, кontо He ca opигиннч actи Ha Briggs & Stratton.

3 YcTPOIeCTBA 3a ynpabJIeHne Ha mAsunHATA nJn CbOpjKeHHn, KOtO npceHa T CTApTIPaHETo H aDnrtA, BOJrD NO He3aDOBONITENHATA m paBOTa nJN cKbCBATXJBOTMa Y. (KOHcyNTPiAPte Ce C npOn3BOINTEHa YcTPOIeCTBa.)
4 Kap6ypaTOpn c TeOHe, 3aIpbCTeHn IpoBoDN nIIN pa3npbCKBaun dIO3n 3a roPBOTO, 3JIENHAni KJanaHn, 3AmBpcEHn HArHeTATEHn NOMn INI INI npyra NOpeDa, pInuHHeNA ot 3aMbpceHO nIIN pIeTOAnIO rOpBNO. YIoTpe6RaBaiTe uNcTo, pIACHO rOpBNO (6eHN 6e3 cbIpxAHne Ha ONoBO, dN3eNoBO rOpBNO) n CTaBnIMaTOp HA rOpBnO Briggs & Stratton c KaTANOKeH No 5041.
5 7actn, KOIO tca HApaHn IIN ChyEnH, 3aOTo DBrAteIeT e pa60tn C HeIOCTaBtHNO IIN 3aMbPceHO MacNo, IIN c MaLo C HeNOdOAnIO KaueCTBO (PiPoBePABaIte EExEHeBNO HbTO HO MAcNtO IIN cCNE BCEK8 Uca Pa60ta. Korato e Heo6xOJIMO, DOInBaIte N CmEHnTe MacNTo I MAcENH O fIITbp Ha npenOpbYBaHnTE INTEpBaJIn OT BpeMe). ABAPHiNOTc yCTPOIcTB OIL GARD MOKe Da He CNPe pa60TeuIN DBrAten. Ako HbTO Ha MACIo To Ce nOblpka ToHNO, DBrAtenT MoKe Da ce NobpeDn. IpOcvTeTe PbKOBoCTBO T3pa60ta.
6 PEmOH NT nIpyrIynpaHe Na MOHTnpaHn qactn IIN arperatn KaTO cBeHNHTeN, npEdaBaTeENm MExaHn3Mn, DnCTaHNUOHH ynpabJeHn I npD, KOtTo He ca npOn3BeHn oT Briggs & Stratton.
7 NOBpeHa IINI IN3HOCBaHe Ha Yactn, npuHHeHOn OT HeNCTOTnI, nOaHnAla B DVBnFATeJI, NOpaIeHKeAueCTBeHO IOdIbPxaHe HA Bb3DyUHnIe FInTbp, HKeAueCTBEN IOBTOpeH MOHTAnIe ONI3IOJ3BaHe Ha NeOpunHnAHn EEmeHTn 3a FInTbpa. Ha npenOpYbaHnTE INHTepBaHn OT BpMe NoCtBaaTe WnIIM CmEHBAIte FInTbpa, KaKTo e NocOeHOb H PbKOBOcTBOTO 3a pa60Ta.
8 7actn, noBpeHn nopAdn HAdbuHsEHn MaKcMmaHn ObOpOTn IIN nopa,I nperrpaBaHe, dIbKaIoo ce Ha TpeBn,HACNoBaHn HIN 3aMbpcBaHe, KOITo 3aNyubat, 3aDp5CTBaT paAdnatoHa NtOBpOITE 3a DOCTbn Ha OXnJaDaunr Bb3dyx, INI NOBpeA, dIbKaIauaCe Ha pa60Ta B3aTbOpEO npocTpAnCTBO C HeDOCTaTHa BEHTInaUny. POpeBaHa HbViratEnn, DblKaIaua Ce Ha Hecna3BaHETo HA TOHOTo CbOTHOWeHne Ha aHTNΦpN3 INITeHn BOda IIN Ha npOnHKBaHETo H BAoDA B Hero NO HHKAKBA pRUnHa.
9 9actnHaDbirateJIINMaunHata,CyynenHOITpeKOMepHaB6paIaI, DbJXkaaCe HxlaabMOnTAX HaDbirateJIY,XnaBaNpeXeuiHOxOBe, XnaBaNPiactNIHxNbaBaNII3Je 6BaIahCupanHpaOToHKnOJIena,Ha HeNoDbo KpyInPraHe MaunHATA KbM KOJIeHATnBan Ha DbirateJIY,Ha CBpbXbncOKn Oobotn INI nprya3noynoTpe6a npn pa6ota.
10 PyTHHnHa HAcTpoKa n peryIuPobKa Ha DnBraTeJIa.
11 Поврета на дыгатял Ии на Heroь сementsТ.е. ropmba камера,Кларани, Кларанни Легл, Кларанни Воради, Илл Илгорели hamotkn Ha CTAPTeРа npordni nIIOJI3BaHTo He anItePehaTINbHM roPbA KaTo HaФтА,прюден ra3,бeнИисnpOMeHEn kauceCTba I.T.H.

Pries jjungiant varikli

Pries jjungiant varikli

CIMBOJII NO TEXHNIK E3OJACHOCTN I ONEPAZNM YNPABJEHNA

BocnJaMeHeHne

Dvnxuunea detanu

Macno

TOKCnUHbIe r3bl

MeDJIeHNO

BbICTpo

Cron

B3pbIB

3neKtpoWok

TOnnBO

Bo3duyunha 3acnohka

BkJI. BblKJI.

BbIKJIOUeHne nOdaunTOJINBa

OTdaua

HaedeBaIte 3aunTHbIe OcKn

OnaChbIe XMMUeCKNe BEECTBa

ykoBCTBO

TopyannobepxHOCTb

06mopoxeHne

Topnya KNDKoctb nnpap

IpeDynpTeIbHbI 3nak IcNoIb3yeTcI nIe 063Haehn HOpMaun 06 OAnCbHx CITyaUaHX, KOTOpB MOrY pNBeCTN K TpABMe. C 3TNM 3HaKOM IcNoIb3yeTcR CnHaJIbHOe CNOLO (O1ACHO, OCTOPOXHO nIN BHIMAHNE), yka3bIbaIOoee Ha BEPOrTHOCTb N NotEuaJIbHyTO XeCTb TpABMb. B DOnJIHeHne, CmBBoI OAnCHOCTN MOKeT IcNoIb3OBaTcBd nIyKa3aHn BnDa OAnCHOCTN

ONACHO yka3bIbaeT ha ONACHYIO CNTyaIIO, KOTOPaR, ECNI ee He n36exaTb, npBBeTeK cMeptelbHomy nCXoHy nn cepbeHOn TpaBMe.

PNEpyPExKHeHNe yKa3bIbaET Ha OnaChyIO CNTyaUIO, KOtOpAra, ecnne He n36eXaTb, MoXeT npNBecTN K CMeptEnbHomU NcXOy HIn CepBe3HO TpaBme.

BHHMAHNE yKa3bIbAeT Ha onaChyU cHTyaCmIO, KOTOPa eCJN ee He n36exatb, MoKET npNBcTeN K TpaBMe CpeDHe N TAAKeCTn IIN JERKO TpaBme.

BHIMAHNE, KOrda nCNoIb3yETc86e3 npEdupeDnTeIbHOro 3HaKa, yKa3bIbAet Ha cnTuayuNIO, KOtOpaM MoXeT npBBeCT N NOBpeJDeHInU n3denn.

OCTOPOXKHO

BbXONHbIe r3aIbIbIaTeRn CoepKxat XMMUeCKne npOdyKtbl, KOTOpBle, NO daHHbIM tTaTAt KaMfOpHnB, Bb3bIbaIOT paK, depeKtbl y HObOPoxdeHHbx iINn HbIte HapuShenr penPOdyKNBHO fYHKm.

OCTOPOXHO

KoMraHnIa Briggs & Stratton He OoO6pReT n He pa3peSaaet nCnoJIb3ObaHnne daHHbX DBVIRATEEN H TPEXKOJIeCHbIX Be3DExOJxA, MOTOcUKNλx, pOnyOrO'HbIX/pa3BNEKATEbIXbIX KAPrTHrAxx, B03dyuShbIX cydHnx IINI aBTOMoBnIax, npEHa3NaueHbNx DnI yNcNoJIb3OBAHnB CopeBHOBaHnx. VcNoJIb3OBAHne HauIMx DBVIRATEEN B DAHHbIX cEJIAX MOKeT npVBECTN K nopHe NmUyecCTBa, cepBe3hBM TpaBMM (BKJIOua JnapaIIH) IINI dJaKe K CMePTbHbOMY NCxOyD.

BHIMAHNE:Данньдвгагелпocstabлгетскомпанne� Briggs& Stratton 6e3 Macna.передз苹сckOMдвгагел,обзатelноЗалеMacno corgaCHO INCHtpkzmaHactoIgero pykoBODCTBa.EcIn Bby 3anyctnteDbvrgatelb 6e3 Macna,TO dbvrgatelb 6ydet HOBOCtahOBUMIO nobpexdeH,и3TOT cnuyaH he 6ydet nOKpbibatcbra rapahtnei.

OCTOPOXHO

BeH3nH ero napbI ype3BbUaHNo ORheONaChbl N B3pbIBOOnaChbl. BocPnAmHeHne Hnn B3pbIB MOrTy npNBecTN K CnJIbHbIM OXrOram nn CmeptelbHomY nCxOy.

Pn do6abJeHm TOnJIbBa

• PπeJxIe Yem OTKpbItb KpbIbUkTy TOnJIbHBOrO 6aKa, BbIKJIOUHTe DBrIaTeIb N daIte EMy OCTbITb B TeUeHHe, NO MEnIbSeM Mepe, 2 MmHyT.
  3aONHnIte TOJIINBbIb 6aOK, IIOHO HA OTKpblTom BO3dyXe, IIOBO Xopoio npOBetPnBaem0n 3oHe.
• He donnyckaTe nepenonHEnn TOnJIINBHO 6aKa. 3aONHnTe 6ak npimepHo Ha 1,5doMa (38 MM) HIXe BepxHne KpOMKn rOpIOBnHb, YTObI ToNlBO MOrIto pacuMPrTbC.
  B6N3n6eH3nHa n B 30He eTo NCnapeHn He DoJXHO 6bTb NCKpeHH, OTKpblTO Rn PnAmEHn, ropeNOK, HaraBeTaTeNe i DpyrNx IcTOHnKOBocPnAmEHn.
• Perynapno npobepnTe TOnnnBONpOBoD, 6aK, KpbIshky nΦHTnHn Ha HAnuHne Tpeunn uYteueK. Pn Heo6xOdmocTn, BblOpHnTe 3amEny.
  B cnyuae npoInBa tonnBa,doxndtebc ero noHoro nCnapenr,npexde yem 3anyctntb dbratelb.

Pp3zanyckeDbiratela

• Y6eNTecb, YTO CBEa 3aXnIaHINr, IYuINTeB, KpBIIka TOnPiBHO 6aKa N BO3dUshHbФJInTp (ecnYcTAHOBLeH) HAXOJrTaH cBOvIX MecTax N HaJeKHO 3aKpenJIeHb.
  He npOBepaIte NCKpy C BbHyTOB CBeuey 3axnFArHna.
  B cnlyae nepeninba tonniba B kap6kopaTope DbrarTeTBA, yctaHOBITE BO3dyuHyo 3acnoHKy (ecnn ToKOBANmEeTcB) B noLOXHeN EOPEN/RUN (OTkpBtA/Pa0Ta), nepemCteTne DpOceBEnHyo 3ACNOHKY (ecnn ToKOBANmEeTcB) B noLOXHeN EFAST (Bbictpo) n3aBOJNTeDnRAtBe, nOKa OH He 3anyCTnTCa.

Pn3Kcnnyataunm o6opydoBaHn

He haknohnyte Dniratelb nIn o6opyoBaHne Ha yron, npN KOtOpom MoKet npOnTbc8eH3nH.
He nepemeeaTe pIurar Bo3dyuHoi 3acnoHKn B 3akpyToe noLoXeHne dIro octahOba DnBraTeJI.
HmKorJa He 3aynckaIte Ne 3KcNpyATnpyTe DBnFateNB 6e3 yCTAHOBNEHHORO y3na BO3dyXOOHnCTnTEIe (ecnn yCTaHOBnE) nnn BO3dyuHORo FOINbTp a (ecnn yCTaHOBnEH).

Pn3aMeHeMacna

• Ecnbl CnBnaTe MaCNO Ype3 BepxHm MacNoHnBHOI npatpy6ok, TOnnBbIb 6akdoJXeH bIb OnopoxHne HnTOnnBO NaHcET BtEKeTa,TO npBBeTeK noXkapy nn B3pBy.

PtpTpaHcnpToPbOBe 6obOpDobAHNA

• TpahcnpTpyte Dnirateni C NyCTbIM TOnnBbIM 6akOM nIn C 3AKPbITbIM KpaHOM NoDauN ToTNIba.

PnXpaHHeHH 6eH3Ha HJIn o6OpyDobAHnC TOnJIbOM B 6aKe

Bo n36eJahne BOCIJIaMeHEHnI napOB 6eH3nHa xpaHHTe ERO BdAIN OT KOTIOB, neeH, BOHOHrpeBaTeHn I npOuH nPi6oBOPB, B KOtOpbIX NcONlb3yeTcR rOpEnKa INI INHOI NCTOCHIK BOCIJIaMeHEHnI.

OCTOPOXHO

Pn3zanycke DvraTeJI npOnCxOuNT o6pa3oBaHne nckpbI.

06pa3oBaHne NcKpbI MoKxET BbI3BaTb BOCJIaMeHeHne roIouHx ra3OB.

3To MoKTe npBecTu K B3pbIbY n noXkapy.

He 3anyckaTe DnBaTeIb B TOM MeCTe, rIe npOnCxOaNT yTeHka npnpOHO rIN CxNKeHHOro ra3a.
He nCnoJIb3yIte nycKOBblE XnIκOCTn B a3pO3OJbHOr ynaKOBKe, TAK KaK INx napbl OrHeONaChbl.

OCTOPOXHO

BbixlonHbIe ra3bI cOepKaT OKnc bYrIpepa - 6ecuBeTHbI n He IMeOuN 3anaXa IdoOBtBu r3.

Bbixhne OKncy yrnpoda (yraphoro ra3a) moKet Bbl3BaTb pBOTy, notepio co3HaHnI nn CmepTb.

3anyckaTe n 3kcnpyaTnpyTe Dnrgatelb BHe NOMEeHna.
He 3anyckai Te DbngateB NomueeHn DaKe npri OTKpbItbIX OKhax nDbepx.

OCTOPOXHO

BpaaiooieeaeTajn Moryt BOHTN B KOHTAK C pYKAM, HORAM, BONOCAM, Odekdo N ee Akceccyapamu NIN 3axBATNTb IX.

3TO MOXET PnBecTN K TpaBMaTHueCKoAMnyTaun NIN TReKeIbIM pBaHbIM paHAM.

He 3KcnpnyatpyuTe o6OpuyoBaHne 6e3 yctaHOBJIeHHbIX 3aunTHbIX npncnOco6NeHni.
He npibnkaite pykn n HOrn K Bpaauoummc TaTajm.
- PoiDBa3bIaIe TdINHHbIe BOIOcbl NCHMaJIte IOBEnIrpHbIe I3dJIInA.
He hocnte Cbo6oHyO OJky, 60TataUHneec HhyprKn nn npdeMeTbI, KOTOpBte MOrTy 6bItb 3axBaueHb I BnKyUmmCra DeTaJIaMn.

OCTOPOXHO

Bo BpempaobtIbBnraTeN BbIeJHOT TEnIO. DeTANI DnBaTeJIa, BOcObeHHoCTIgUwntEbn, CTahOBaTcA OueHb TropaMNI.

PpIKoCHOBHeHKe K Hm MoXeT PpNBecTn K CnJIbHbIM OXOrAM.

BocnnaMeHem MycOp, Hapmep JncTb, TpaBa, XBOPoCT N.T.I. MoryT 3arOpetbcra.

ДаиTe rIyshnteHIO, uINHHpy npe6pam uINHHpa OCTbITb, npexJde Yem dOtparNBatbCn DO HIX.
OuHCTIte 30Hy BOKpy rIyUHTeY I cIINHpa OT CKONIBWEROcBOCPnAmEHemoro MYcopa.
- UctahOBHTe NCKPOYNoBHTeN b NoDpeKxNBaTe ERO B pa6OcH coCToAHn B CnyaHe NCNoIb3OBaHNb O6OpUyDoBaNHa Ha He6NaRogCyTpoEHNHO TepnTOpIN, NOKpyToIeLcOM, TpaBOn IInu KycTaPnKHOM. 3TO tpe6yETcB C COOTbETCTBN C 3aKoHOaTeNbCTBOM Wtata KaINΦopHNr (Pa3dE1442 PpaBn Nl0b3OBaHNb 06UHMn pecypCAm). Dpyrue WtatbTu MOrT y MeTb HAnorHnHbIe 3aKoHb.I Ha ΦepeApbHOB TopePnTOpIM npImeHrOITc ΦepePAlbHbIe 3aKoHbI.

OCTOPOXHO

3To MoKTe IpnBecTn K Cepbe3HbIM TeIIOBbIM OXoRam B pe3yIbTaTe BbI6pOca napa nnrnpaey OxnaKaJIoUe KKnKOCTn DnuratEn.

HE chmmaTe KpbIuKy paIaTOpa uNn EMcKoCTn, ecn DbIrTaTeNb rOpRyHn uNn pa6Otaet.
- Pénéd CHATNEM KpbIuKN paIaIATOPa IIN KpbIuKN paCauPiTeNBHO 6aKa n nepeD 3aMeHOn IIN DOJIaIBKOJ OXIAJDaIOUe JIKKOCTN OCTaHOBITe DBIRaTeJB daIte EMY OCTbTb.

OCTOPOXHO

CnyaHoe 6bOBAHne NCKpbMOKET npBecT K noXapy nI npopaxHeHIO 3NeKtpnueckm TOKOM.
CnyaHbIy 3anyck MOKET npNBecTn K 3axBaTbIBaHNIO, TpaBMaTMcECKo amNYtauNi pa3NmNbHbIX cAteT eTaN K o6p3aOBaHNo pBAhBx paN.

Puck Bo3HKnHOBeHn noXapa

Ipeep BbINOJIHHeHEm peryIINpOBOK nIpeMOHTa:

• OToeDInHnTe npoBOD cBeu3axirahanu ydaJIte erO ot cBeuN.
• OToeHNHtE OToIaTeIbHbI BbIOB aKKyMylTOpA (ToIbKO dIraDbIraTeJeC 3JIeKTPoCTapTePOM).
  IcnoIb3yIteToJIbKOIOxOJaIeHnCTpyMeHTbl.
  He MeHnTe HaCTpoKy npKnHbI, TAr nnn nHbIX DeTanei perYJrToPa dny yBeJIuHnHa cTObI BpaueHnBa IaBnTaTeJI.
  3aNaChbIe qactn DOnJXHbI 6bIT nDEHTNUHbIMn U yCTaHaBnBaTbcr Ha To Xe CaMOe MECTO, YTO INepBOHaUaNbHbIe DetAJI.
  He yadapIte no maxobky moJOTKOM nIN TBepdbm npEIMeTOM, T.K. maxobk MOKETno3Ke pa3OpBaTbCBO BVPemA 3KcPnyatauIN DBNfATEJIa.

Pn npOBepKe cnCTeMb 3aKunraHn:

• IcnoIb3yIte pa3peWHeHbI TeCTep CnCTeMbI 3aXnIraHna.
  He npOBePAnTe NCKpy C BbHyToT CBeChO 3axmraHnA.

y3JIbI DvIraTeIa I opraHbI ynpabJeHnA

CpaBNHTe pncyHOK CO CBOIM DnIraTeIeM, YTObI O3HaKOMITbcr C paacNOJIOXeHNEM pa3NJNCHbIX y3IOB DnIRaTeIeN I OpraHOB UnpaJIeHN.

A.ИdentnФнКаUMHNOE O6O3NaUeHne DBiRaTeJI MoDEnb TIn KOp
B. Μεθητιρήκαμηούνησε Εόβο3Ηγένηνε ένβυτατέλη Κόδιατό
C. Cbeca HakaJIiBaHnIa
D. lIyI npBnMaCna
E. MaclohaJINBHO naTpy60K
F. MacJHbI ΦnIbTp
G. Пюбka сиNBHOrO OTBepctnMaCna
H. ΦopcyHka
I. 3neKtpocTapTeP
J. TOnJIINBHyI HAcOC BbICOKO RaBHeHr
K. Tepmoctat
L. Typ6okomnpeccop
M. MacJHbI IOdoH
N. ΓeHepaTOp
0. Bnok OTnpaBkn DaHHbIX TempepaTybl OxlaJdaUoJe XnKIOCTN
P. BeHTNJATOp
Q. Pemehb BeHTnIaTopa
R. BbInyckHOJ KOJIeKTop
S. OxlaДиТь Macna (ecn yctahOBJIeH)

3Kcnpnyataza

KoJIuYeCTBO MaCna (CMOTpuTe pa3dEn TeXHnueckne daHhbie)

PeKOMeHndaцnnoNcNoJIb3OBaHHIO MacJa

Mby peKOMeHdyem nCnOJIb3OBAtB pa3peWSeHHbIe KOMmaHnei Briggs & Stratton Macna IaIy DOCTNXEHN HauNlyuHxIN 3KcNlpyATAUOnHHbIX XapakTePrcTnK. DpyrIne BbICOKOKaYeCTBeHHbIe DeTePreHTHbIe MaCNa DoNYcKaOTcB TOM Cnyae, ecNl OH NkAcssnupoBaHbI KaK CF NII CF-4. ZanpeuaetcN cNpIb3ObaHne CneuaJIbHbIX Do6abok.

Temnepatypa HApyXHoro B03Jya OnpeJeIeNt HAdJIeXaUIO B3KoCTb MOTOPHRMaca. BocnoIb3yIteB TabIeue IaBbOpa COOTBeTcByIOe B3KoCTn DOn OxNJaEMOr INHTpeBa TEmnpaTypbl HApyXHoro B03Jya.

• IcnoIb3OBAHne macna SAE 30 npn Tempepatypax Hnke 40^ (4^) npnbEeT K 3aTpynHeHHomy 3aIycky DInrataTeJ.
  ** IcnoIb3ObaHne macna 10W-30 npI TeMnepaTpyax BblIe 80^ (27^) npIbeTe K noBbIeHNOMy nOTpe6JIeHIO macna. YaIe npOBePraIte ypOBeHb macna.

Kak npOBepuMb yPOBeHb Macna/DoJntb MacNo -Pnc. ② ④пегдобавленим пьоверковуpoBNMaCna

• YctaHOBNTe DnIRatJIb B TROP3OHTaJIbHoe NONOKeHne.

OuHCTnTe 30Hy macIOn3aJIiNbHOro OTBepCTnO TJIIO6OrO Mycopa.

1. Bbytaunte uyn nla n3mepeHn ypoBn macna (A) n o6oTpnte ero YnctOu TpnoKo (Pnc. 2).

PeKOMeHdaunnoNcNoJb3OBaHnIO TOnJIbBa

TOnnBO DoJXHO COOTBcTCTBOBaTcJeDyUoIIM Tpe6OBaHm:

• DaaHbI dBnRaTeIb ceptnФuCnupoBaH IJr pa60tblc n3eJIbHbIM TOnIIbOM. PInr hNoJIb3OBAHm HEnpaBnJIbHO rTna TOnJIbBa MoXET BO3HKnKHTb CepHbI dIM, NOpTeR MOUHOCTN INOBpeXdEHNe DBrAraTeIa, KOTOpBie He 6yDyt NOKpbIbaTcraPahTne.
• IcnoIb3yIte YnCTOe, CBExee DnI3eIbHOe TOIINBO C UTeTAHOBbIM YNCLOM He MeHee 40. CBeexee TOIINBO HE O6pa3yeT CMJONHCTbIX OTIOXeHm B TOIINBHOn CNTeMe. NOKynaiTe TOIINBO B O6beMe, KOTOpby MOKeT 6bITb NCNoIb3oBAh B TeueHne 30 dHei. Cm. pa3dEn XpaHHeHne.

OCTOPOXHO: He nCnNoB3yTe KepocHn IINI 6eHNb BmecTo DN3eHbORo TOnNBA. HecO6JIaENHe 3tOrO pIeynpeKxHn INpBeDeT K NOBpeKxDEHIO DBrIaTeN I aHHyIpOBaHnI rapaHTn Ha dBrMaTeJb.

Kak do6abntb TOnJnBO - Pnc. 5

OCTOPOXHO

ToTnIBO I ero napbI ype3BbIaHIO orHeonacHbI N B3pbIBOONacHbI.
BoCnIaMeHenHe NII B3pbIB MOrY npNBecTN K CnJIbHbIM OXORAM NII
cMePeTeJbHOMy NCxOy.

Pn do6ablen TOnJIbBa

• Ppéjde yem OTkpblb Kpbliuky TOnJIbHoro 6aKa, BbIKJIOUte DBrIaTeB n daIe emy octblb b TeueHne, mo MehseMpe, 2 MInHT.
  3aONHnIte TOJIINBbIb 6aOK, IIOHO HA OTKpblTom BO3dyXe, IIOBO XopoIo npOBetPnBaem0n 3oHe.
• He donyckaTe nepenonHEnHa TOnJIbHOrO 6ka.3aONnHrTe 6ak npImepHo Ha 1,5doMa (38 MM) HIXe BepxHcK KpOMKn rOpIOBnHbI, YTObI ToNlBO MOrIto pacuMPaTbCra.
  XpaHnTe TOnJIbMoB VdAaN OT NcKp,OTKpbITOrO PIIaMeHn,ROpeNoK, HArpeBaTeJbHbIX PrIb6OpOB IN PPOuNX IcTOUHNKO BOCIIaMeHeHn.
  Peynnpno npOBepnTe TOnnBONpOBoD,6ak, npO6ky nHHTnHnHa HnUne Tpeunn uYteek. Pn Heo6xOaMocTn, 3aMeHnTe Detan.
  B cnyuae npoInBa tonnBa,doxndtebc ero noHoro nCnapenr,npexde yem 3anyctntb Dbratelb.
• OuchTe KpbIbKy HAIINBHOI TOpIIOBInbI N 3OHy BOKpyr Hee OT IIO6oI rpr3n n OCTaTKOB MYcopa.CHIMNTE KpbIbKy TOIIINBO3anpABOCHoro NaTPy6ka (A, Pnc.5).
• 3aONHnTe TOJIINBbI b6ak (B) 6eHNOM. IJIa BO3MOxHOCtN paCUnpeHna 6eHNHa, He 3aONHnTe BbIe HIXHe YacTn RopIOBnbl ToJINBHOrO 6ka (C).
• YctahOBInTe Ha MeCTO KpbIuKy TOnPiBHorO 6aKa.

PekomeHdaunno nO nCnOJb3OBaHNIO OXnaJdaIoueJ XnDkoCTN

06bem oxnaaJdaIOuIe JxNIOKCTn (CM. pyKOBOCTBO I3rOBoTJIb OobpyoBaHn)
BHMAHne: 3TO DBVIRATEIb JxNIOKCTHO OXIAJDeHN.IIpaOxAJDeHN,
npEOITBpAaHEHnOBpa3OBAHnPjABHnI cMA3Kn BOJHORO HAcOcA Tpe6yETc
NCNOJIbOBAHnE 50/50% Cmecn aHTnFpN3a, He CoepJaaero foocpata, IN BODONPOBOHOI BObl.

PpOBepka/DolnBka oxlaXdaioe XnkocctN

OCTOPOXHO

3To MoKet IpnBecTn K Cepbe3HbIM TeNIOBbIM OXOKrAm B pe3yIbTaTe Bbl6poca napa nnI ropaye oxnaKaDaUoJe KxNkoCTn DbrgATEJ.

HE chImaIte KpbIuKy paIaNatOpa uNn EMcKoCTn, ecN nDbIrataTeIb rOpyuN npa60taT.
- Pénéd CHATNEM KpbIuKN paIaIATOPa IIN KpbIuKN paCauPiTeNBHO 6aKa n nepeD 3aMeHOn IIN DOJIaIBKOJ OXIAJDaIOUe JIKKOCTN OCTaHOBITe DBIRaTeJB daIte EMY OCTbTb.
1. Pered 3Kcnnnyatauem npobepbTe ypOBeHb oxJaXdaIOUeJxNdkOCTn. UpOBeHb oxJaXdaIOUeJxNdkOCTn DOJIbMekJy OTMeTkAmn FULL n LOW/ADD Ha EMKoCTn OXJaXdaIOUeJxNdkOCTn. Ecm npOBeHb oxJaXdaIOUeJxNdkOCTn HN3Kn,doJeTe B EMKoCT 50/50% CmEc oxJaXdaIOUeJxNdkOCTn COCTOSe N3 aHTINbp3a, he CoOpexaero focpaTa, n BOOpnpBODHOB OBObl.
2.ДЯСНТИКБКИ EMKOCTN NOCE OXNAJDEHURA DBINATEH NOLOKHTE TONCTYTO TKAHbHa KpbIky EMKOCTN.ДЯСНТИМEDJIENHO NOBOPaHBAte KpbIky pOTIMTB HACOBOIT CTEPNI.
3. EcniemKoCTb COBepseHNO ncyTAn, OobabTe OXnAaXdaIOUyO XnIKoCTb B emKoCTb N B paJnaTop.CM.pyKOBoDCTBO NO o6OpYDoBaHIno DnI

MECTONOLOXeHnI,3KcNpIyatauIN N O6CnyKmbaHnE MKOCTN OXnaJdaUoJe KNUKOCTN paHaTopa.
4.ДЯСНТЯКршкп радиаторя посе oxnaжденя DBINATENI NOONHTe TOnCTYU TkaHь Na Kpbshky pardniatape.MdJIeHNO nobopaunBaIte Kpbshky paadniatorpoTnBACOBN CTpeJKN DO nepBOrO OpranHHTeN.EcHn H3-nOD KpbshKy BbIXoNT Nap noD abJNeHmE OToNDte,TObIb N36ExaTb TpaMbI.Пocne TORO KAK BCE DAJIbJIeHMe 6yETC6pOSeHNo HAXMTE Kpbshky paadniatoparBHN3 IN NOBERHnTe eune npOTNV cAcoBOr CTpeJIke dIra ChTnIa.

Pn6opbI INHdkaTopbI

Ioka3aHHbIe np6Opby INHdkaTOpby ABNIAOTc TINHbIMn I NOka3bIBaIOT pa3NJHbIe BApnaHTbI, KOTOpbe MOrY INCNoB3OBaTbCra.ДЯ INHOPMaUmO paCNOJoxEHInФyHKcIqx np6Opob INHdkaTOpob ObaTNTecbK pykoBOdCTBy NO 3KcNlyatauIm.

Pnp6op temnepatypbO oxnaKaioe JxNkoctn

IokaBbAeT TempeAtpy OXnaxDaIOSeJ XnIKOCTN, KOrda BbIKIOHaTeB 3JIeKTPoCnTEMb 3aNyCz yCTaHOBJIe H bnoONKeHne BKNJ.

HopmaJIbHbI dHaIa3OH 80° - 90° C (175° - 195° F)

OnacbI dnaa30n Bbiue 105^ (220^)

Pn6op KOJImYeCTBa Yacob pa6oTbI

ПокаыBaetсуммарhoeКолиесъчacobКспл�атудим.

Yka3aTeNb TOnJnBa

IokaBbAeT KOJIaHcEBo TOnIbnBa B ToNIIbnHbOM 6aKe. JnA CNJxEHnA KOHNDeHbAeD PEXKHe TOnIbnBbHb 6aK3aONJIHeHbM.

HdkaTop temnepaotypb

CBeueHne HnDnkaTota TmepeatpybI CBnTeBteBCTByET O nepeRpeBE DnBaTaeJI. BbKIOUHTe DnBaTaeN I npOBeBte UPOBeH oxNaXdIoUe JxuKoCTn (secm. PAaDeI PnOBePKaOxNaXdIoUe JxuKoCTn).

Y6eIntecb B03dyxa.

B OTCYCTBm Mycopa Ha paIaIaTOpe, IpENATCTByIOUeI O NOTOKy

HdkaTop 3aXnraHna

Pn yctahokBbe kkiouateIe 3neKtpmeckO 3aNYcBa NIOLOXHEM BKL INHkntopat 3xKHHaHIN OJNOXeH cEBTNcR. pn pa6oTe DInrataTe

HnDnKATOp 3aXnRanH He nOJxEN CBETnTbC. EcnI npN yCTaHOBKe BbIKNoUcTeJIeKnTPnuCheKOro zanycka B noLoXeHne BKJI nHnDKaTOp H cbETntC, npOBepbTe npDeoxpAHntenB.

Инданкатор давлия macna DBurataЯ

Pn yctahOBBe kblIOUATEH 3neKTPmEeCKORO 3anyCKa B noIOxoHEMeBKL INHkIATOP daJIbNEHMA CnA bDINrATe DnoJcHEN CBETNbCt.Pn

paObe TbIraTeJI INHdNkaTOp DaJIbeHMa CnA B DbIraTeJI He DoJnxH CBETNbCt.
Ecnn pnpaBoTe DBIraTeJI NaHcAN CBETNbCt INHdNkaTOp DaJIbeHMa CnA,
HEMeJeHHO BkJIIOuHTe DblraTeJI. B nepByIO OHepeBb IpoBepbTe ypOBeHb Macna (cm. pa3JeN Ka NpObePbTb/DOJINaBb MaCNo). 3aTe m npObePbTe 3neKtpnueckyio CTsEMy.

Hdukatop 3apAdkn

Ipy cyaTahOBKe BbKIOHcAteN3eJIckrpeKOcRcO 3aOnyBa k noIoxHeJeB KBJI INHkATOp 3apRdKa dnOxHe CbeITbcBa. Pnp pa6oTe Dniratena

INHdkatop 3apJdkn He doJIkeh CBetntbC. Ecnin INHdkatop 3apJdkn haunHaET CBetntcb npi pa6ote DbrarTeJI, npOBepte 3neKtpueckyo CNTeMy.

HnDkaTOp HarpeBa HnHaKaJIbHaHn

KordaBbKlNoHaTeNb 3aXnRaHnY yCTaHabnBaTcB N noJoxeHne HarpeBa/HakaiNBaHn IN B noJoxeHne "BKn", INdNkATOp HArpeBa

CBNIDETeJIbCTByET O NOOrpeBE KAMEpbI CROPaHNA CBeaHNAHaKaJINBaHNA.

HnkaTop TOnJIbHOrO fNbTpTa

HnDnKaTOp TOnnBHO pNtpa HauHaHaET CBeTbCra, KOrDa B TOnNBHOM pNtpe Co6npaTeC rNShKOM MHOrO Bobl. HnDnKaTOp

dONJeHn ORaCHyTB NocNE CmBa A3NIMKOB BObI n3 TOnNIBHORO fINbTpa. EcnI INdIKaTOP TOnNIBHORO fINbTpa 3arOpaeTc BO BpEma pa6oTb DnBraTeNa, BByKIOuHTe DBrATeNB nCneTBe BOy n3 TOnNIBHORO fINbTpa.

Kak 3anyctntb DvraTeIb-Pnc. 6

OCTOPOXHO

TOnJIbO N er o npbl cype3BbIaHNo ORHeONaChbl B3pbIBOONaChbl.

BocnnaeHne Hn B3pbB MoryT npNBecTu K cnIbHbIM OXoRAM nIcMeptelbHomy NcxOy.

Pn3zanyckeDburatela

• Y6eIInTeCb,уTO rIyUnTeJIb, KpbIuKa TOIINBHorO 6aKa n BO3duHbI ΦnIbTp HaxOJaTcH a CBOUX MecTaX n HaJexKHO 3aKpeJIeHbI.
  B cnlyae nepenbBA tonnBa B kap6ipatope Dnirate, yctahOBnte Bo3dyuhyo 3acnoHky (ecmTAKOBAR NMeetc) B noLOXeHne open/run (OTKpbIra/paObaTa), a dpocceNHyO 3acNoHky B noLOXeHne fast (6bICtpo) n 3abOJnte DniratEn, noka OH He 3anYCTITcR.
  Дя уBERHENHа copka cny6bl CTapTepa, IcnoIb3yIte KOpOTKHe CTaPTOBIE 电KnIbI, He npBbIaOuIe 15 cKeYHd B MmHyTu. IpoJOnKInTeJIbHbI 3aNyCK MoKETcNcPONrTb MOTOP CTapTepa.

OCTOPOXHO

BbIOnHbIe ra3bI cOepKgAT Okncb yrIepoJa -6ecuBeTbI n He HMeIoU 3aIapa JdoBtBu Ra3.

BdIxHne OKnc yrIepoJa (yrapHoro ra3a) MoKet Bbl3BaTb pBOTy, nOtePio CO3HaHn IIN CMEptb.

3anyckaIte n 3KcnpyaTpyIte DnBraTeIb BHe NOMEueHna.
He 3anyckaite DnirateIb NomeeHn IdaKe np OTKpbIbIX OKhax IDBepx.

BHMHAHNE:ДанньдИгагелпocstabлentскOMmTaHnei Briggs & Stratton 6e3 macna.петадунбckOMдИгагелЯ,обзатelho 3azeTte macno cornaCHO nHTpykциM hactoIgero rykoBODCTBa.EcIn Bby 3anyctnte DBIratelb 6e3 macna, TO dIrgatelb 6ydet HOBOCtahOBIMNo nobpexden, n 3OT cnyaH he 6ydet nOKpbIbA TbCB rapaHTne.

OCTOPOXHO: PiepeIePbIbM 3aIyckOM dBiratEn, 3aprIte AkkyMnyTOp B COOTBETCTBN C peKoHemDaIaIIMn pno3BODIeN To OOBpyDobAHN. HEBINIOJIHeHNE 3TOFO yCIOBNA MOEJ tnpBECTN KOBpEJDeHIO dBirATEn.

Примочанe: HeKOTOpbIe DnBraTeNи OobopydObaHne Cha6xHeIb oprahAmnДиCTaunOnHOrO ynpabJIeHnA. KacateIbHo paCNoJoxEHHa n pa6ToI orpArHOBДиCTaHUNHOrO ynpabJIeHnCMOTpIte pyKOBoDcTBo NO 3KcNpyTaUmInДЯ KOHKPETHOrO OOBpyDoBaHnA.

1. PnOBePte yOBoHb MaCna. CMOTnPe pa3dEe KaK npOBepTb yOboHb MaCNa/DOJIbTb MaCNo.
2. Y6eIntecb, YTO pbyaru ynpabJeHn npBODom o6OpydoBaHn, ecJIn OHN yCTaHOBJIeHbl, OTKJIIOUHeHbl.
3. Повернше руку крана подачи толпamba (A), ecл.Tаковая Имeelс, в паложене On (Откры�) (Pucyhok 6).
4. Пелемостите рыаг уравлеслд розсел (В) в поожене slow (медленио)

3aMeHnTeMacNoBDbVrataTeIe*

Yepe3 kaxkbie 100 yacob pa6oTbi

• Поверпту haтжени peMHBAHTNJIrToPA
• Почисту радиатор
• PoiuCTnTe BOZdyuHbI ΦnIbTp
• PpOBepbTe rIywnTeJIb n noOuNCTnTe NCKporacnteJIb (ecJn yCTaHOBJIeH)

Yepe3 kaxkbie 150 cacob pa6oTbI

3aMeHInTeMacNoBDbVraTeIe*
3aMeHHTeMaCLHaBHyΦnJbTp

Kaxdbie 600 yacob pa6oTbI nn exeroqdo

3aMeHa Bo3DyUHOro 0nIbTpTa
- Поверп Te 3a3op KlaNaHa ■
3aMeHnTe TOIINBHybI qNJIbTp

Yepe3 kaxdbie 1500 yacob pa60tbI

• PpOeBpeΦopCyHKn BnPbIcKa

Exeroedno

3aMeHnTeMaCNoBDbnIraTeJe
3aMeHnteMacJHbIΦnIbTp
3aMeHnTe OXlaJdaHOuYU XnIKOCTb
- Поверп te haTЯженье pemнь BeHTnJIrToPA
- Почисту радиатор
- PpOBepeTe rJyWnteJIb nNouNCTnTe NCKporacnteJIb (ecJn yctaHOBJeH)
3aMeHa Bo3dyuHoro fNtpa
3aMeHnTe TOIINBHybI qNJIbTp
- Поверп Te 3a3op KlaanaHa ■

• 06cnykBaIte DnBraTeJIb YaIe npi pa6Ote C 6oJIbShIMN Harpy3kAMN IIN B yCIOBIAx BbICOKNX TempeAtyp.
  CobnoaTe rpaFmK 06cnykBaHnI n3rOToBnTeJI npI nCNoIb3OBaHnI DeTaJIe, n3rOToBHeHHx He KOMNaHnei Briggs & Stratton.
  06CnyxNBAHnE DOJnxHO BbIOnHrTcB aBTOpu3OBAHHbIM dIJIePOM DENSO.
  He tpe6yetcnaKa He 6ydyT 3aemeHb np6bnmb pa6oTb Dniratena.

PpOBepKa rIyUHTeJI n NCKpoYNoBHTeJI

OCTOPOXHO

Bo BpempaobtIbBnraTeIN BbIeJIaOT TEnIO. DeTANI dBnraTeJI, BOcObeHNOCTIgUwntEn, cTaHOBArTc OueHb rOpAIMN.

XpaHnTe 60pOyDOBaHne Ha paccToHmN OT KOtIOB,NeeH,BOHOHaRpeBaTeIeN I npOvHX npIbOpOB, B KOTOpbX mCNoJIb3yOTc RopeJIKn MIn HIIbe NCTOCHNI BOCINNAmeHEHnI, NCKoJIbKY OHN MOrYT BOCINNAmeHnTb Napbl TOnJIbNA.

Motophoe macno

3aMeHnTe MOTOPHOe MaCNo, KOrDa DvBraTeNb eUe TeNJIbI.

YcTaPaHeHne HEmCnpaBHOCTe

HyjdaetebcBcoeICTbIn?3auiTeHa web-caT BRIGGSandSTRATTON.COM nIINIO3BOHNTe 1-800-233-3723.

TexHnueckne daHHbIe

TexHnueckne daHbIe no DnurTaTeJIIO

JIuHoeI KOMMepueckoe IcNoJIb3ObaHne

2 roda

3 roda

2 roda

* Otmte cneu nie nea hie npnabhe npaHTnB: PAMKax daHoro rapaHTnHO rnoica deTALN B BYIOJIHe na paoT rapaHTnpETcB TceHne 2 net. TaPANTHa HOCOBHe Detan He npDeBaTeCn H TePTn Ro3KcIpyataum. RapantHa HCObHBle detan NOKpbBAeT, HO HE ORpAHnBaTeCn H HE ICKlOuaeT 6nok CUnInHApob, roONbky 6noka CUnInHApOB, KOJIeHATb BAN, paCnpDEJInTEbHb BAn, NOPHI, TOIkaTeiM, MAXOBIK, KOpNc maxOBiKA, MAcIaNbHb HACOC, BEHTNIATpO, SKNBb, MEXaHcNeckn PEGyIATpO, BNYCKHO KOnLEKToP, NOdON KapTepa. TaPANTHa HocOBHe Detan He npKpbBaet He ORpAHnBaTeCn KOJIbAmn NOpIHKe, ZAMEHEmbIM NODUINHkAMs, BOJHbIM HACOCOM, IIObIM 3JeKtpoOboOpdyoBaHNEM, KOMIOHENTamn PrnBOda KlanahanOB, YNLOTHENHmN, POKNaDkAMn, KAp6OpatopAMn, BByNUCKHbIM KOLNEKTOPOM, NATpy6kAmi, BCEMN KOMIOHENTAMN TOPIIBHOICCTEmbI, FOpCyHKAMn INXKEKTOHPBIM HACOCOM, Ty60kOMPpeCCOPOM, rnyuHTenEM, IIObIM fMbTPAMn, PAIDATOPOM, TepMOCTaTOM, CBeAMn 3aXJrAHHaN, CBeAMn HAKaJIbAHnH, HACOCAMn NOkKaChN ToTIINBa. RaPANTHbI PeNoID HAUYHAEcT C dAtb IOKyIKN PEPBbIM PO3NHyHM NOKyIaTEM N KOHeYhBM KOMMepeCEKM NIOI3ObaTeEM N 3akaHUNBaTeCn NO INCTeEHm NepNOda BVPemEnu, yka3aHHO B pinnBeDHHO Bblse TabIe.

IJa 10

B OTHOseHn BaSei rapaHTnn

Kopnpaun "B&S" c roTOBHOCTbIO npOn3BOUIT rapaHTnHbI peMOHT n npINOCHT
3NBHeHNe 3a npUnHHeHNoB BAM 6ecNOKOCTBO. IpObeDeHne rapaHTnHOro pEmOHt a
pa3peWHeNo IIObOMy YpONHomOeHHOMC CepBcHNOHM DInepy Briggs & Stratton 3/LC.
B 60bluHNCTBe cnuayBa rapaHTnHbI pEMOT npOn3BOUITc8 bICTPO n B 6ecCNOPHOM
nopJKe. Ondako IHORa Tpe6oBaHnHa rapaHTnHoe 6cnjXnbAHne He ABnIOTc
onPabDaHNbIMn. Hapmep, rapaHTn He paCnPoCTPAHETc H a Te cnyau, KOrda
deFeKTb IBVaTeArel ABnIcBpe3yNbTaTOM eHnpaBnHOrO NcOpJIb3OBaHnA,
OTcYCTbNnHaNDexKaUeO6cbNyXbAHnIN INN KOrDa NOBpeXdHeN pOn3OuIN B
npocce TpaHCnOpTnPOBKn, norpy3OCHo-pa3rpy3OHybIX pa6Ot, CKJaDnPoBAHn
DBVaTeReN INN IN3-3a INx HnpaBnHBoH yctAOBKn. FapAHTn TaKke anHynIpyeTcR,
ecNbIy Iy dAnEe HcpNbHbM OHEp DBVaTeJI INN ECNI DBVaTeJI bIy BIDOn3MeHEN
INm MoDNnFIOPOBaH.