477A - Juicer Zelmer - Free user manual and instructions

Product Type	Juice Extractor
Brand	Zelmer
Model	477A
Power Supply	230 V AC, 50 Hz
Motor Power	Approx. 500 W
Speed Settings	2 gears (I for soft, II for hard fruits)
Continuous Operation Time	15 minutes
Required Break Time	30 minutes between uses
Turbo Function	Yes, max 3 seconds, 10-second interval
Noise Level	75 dB(A)
Filter Type	Stainless steel micro-mesh with self-cleaning function
Safety Lock	Lid clamps must be secure; motor stops if improperly assembled
Pulp Container Capacity	Approx. 1.5 L
Juice Container Capacity	Approx. 1 L
Material	Food-grade plastic and stainless steel (filter)
Dishwasher Safe Parts	Juice container, lid, pusher, pulp container (max 60°C); filter and motor not dishwasher safe
Cord Length	Approx. 1.2 m
Weight	Approx. 4.5 kg
Dimensions	Approx. 30 x 20 x 30 cm
Accessories Included	Pulp container, juice container, pusher, cleaning brush

Frequently Asked Questions - 477A Zelmer

How do I assemble the juice extractor?

Place the motor body on a flat surface. Attach the juice collector body by turning it left (anticlockwise) until it locks. Insert the juice container, then the filter. Place the lid and secure with clamps. Insert the pusher into the feed tube. Attach the pulp container under the lid.

How should I clean the appliance?

Unplug the appliance. Disassemble all parts except the motor. Wash the juice container, lid, pusher, and pulp container in hot water with dish soap or in a dishwasher at max 60°C. Clean the filter with a hard brush only—never use metal brushes. Wipe the motor unit with a damp cloth. Dry all parts before reassembly.

Why does the juice extractor vibrate or produce little juice?

Excessive pulp buildup on the filter can cause vibration and reduced juice output. Use the turbo function (hold speed button for 3 seconds) to clean the filter. If the problem persists, turn off the appliance, unplug, and clean the filter. Also empty the pulp container if full.

Can I juice soft fruits like berries or peaches?

Yes, use speed I (low) for soft fruits. However, soft fruits may produce a spongy pulp that clogs the filter. Mix them with harder fruits or vegetables and clean the filter more frequently. Remove pits and seeds first.

What is the maximum continuous operating time?

The appliance can run continuously for up to 15 minutes. After that, allow a 30-minute break before next use. This prevents motor overheating.

How does the turbo function work?

Press and hold the speed button (b) for about 3 seconds. The motor runs at maximum speed for approximately 2 seconds to dislodge pulp from the filter. The function switches off automatically. Wait at least 10 seconds before using turbo again.

What should I do if the appliance stops working?

Check the power supply by testing another device in the same socket. Ensure the lid clamps are properly secured and the juice collector body is correctly locked. If the blue indicator light blinks red, reassemble correctly. If still not working, contact an authorized service center.

Can I put the parts in the dishwasher?

The juice container, lid, pusher, and pulp container are dishwasher safe at max 60°C. Do not put the filter or motor unit in the dishwasher. The filter should be cleaned only with a hard brush.

Which speed should I use for different fruits and vegetables?

Use speed I (low) for soft fruits like apples, pears, peaches, tomatoes, and cucumbers. Use speed II (high) for hard vegetables like carrots, beets, celery, and cabbage. Refer to the speed table in the manual for specific items.

Is it safe to leave the appliance unattended while in use?

No, never leave the appliance unattended when plugged in. Always turn off and unplug before cleaning, assembling, or disassembling. Keep children and pets away. Do not operate with damaged cord or parts.

USER MANUAL 477A Zelmer

Product photo of a green juiceizer with a glass of orange juice and a straw, no visible text or symbols.

477

Sokowirówka

Juice Extractor

B

D

Szanowny Kliencie!

Rice and fresh tomatoes produce juice of an excellent quality. Tomato juice may be mixed with all other vegetable juices. It contains a lot of vitamin A and C.

Two glasses of his juice covers a daily demand of vitamin C. Salt and pepper enhance the taste of the juice.

Seatrop/Juice

Bestmeal juice in combination with orange juice gives a chalk of an excellent mark. This juice in a pure form may be drunk, only upon a docker's recommendation

Cabbage Africa

This juice is applied in treatment of gastric ulcers, however only upon a doctor's recommendation. When mixed with canal juice, it may be drunk by those with sensitive stomach.

Spinach juice

This juice is highly hematopoietic, however, due to a strong smell it is recommended to my truth came juice. Spinach juice, cancel juice and every juice mixed in equal amounts give a tasty drink.

Celery juice

Do not use salary leave because of their bitter taste. The juice from a root of a salary is very lazy. It can be mixed with other vegetable juices. It should be drunk in smaller amounts than cannot juice. Adding money increases the taolo-nit juice

Applicable use of Raman and other use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use of the Use

It is naturally blend and it should be mixed with apple, carrot or celery juice. Cucumber juice is used for skin care. It also there kidneys. It is recommended for slimming treatment.

Apple Juice

Juice made from fresh and rpe apps has a pleasant fragrance and taste and is rich in vitamins A and B and valuable mineral salts. A high content of seeds in the juice makes that it has properties supporting digestion. Fresh apple juice is used to treat podog's and bismustem. It is generally spacking an excellent nutrition.

Blackberry juice

Blackberry juice with a small amount of sugar and minimal water makes a very morning drink. Due to a big content of vitamins and micromolecules, it gives energy, especially to elderly people.

Black cider juice

The juice is rich in native elements, it has disappeared properties and is used to tear a cold. When preparing preserves, it may be mixed with other fruit juices.

Blackcurrent Juice

Blackcurrant juice has a specific fragrance, high acidity and noticeable texture. Due to its chemical composition and a content of vitamins, it is one of the best juices. It should be mixed with juices of low acidity or with water, honey or sugar.

Special health recipes

Energy drink	Body detox juice
6 cups	4 cups
2 capsules	1⁄2 of cucumber
1⁄2 of sweetroot	1 breastroot
"Strong breath" drink	"Timeless regulator" juice
1 handful of spinach	2 cups
1 handful of parsley	1 basket pair
2 capsules	1⁄2 of lemon or a handful of spinach
4 capsule	6 capsules
"Bunny" drink	"Live" drink
2 capsules	30g bromosides
8 strawberries	1⁄2 of cucumber
	1 oily
	1⁄2 of lemon

Ecology – Environment protection

Each user can protect the natural environment. It is neither difficult nor expensive.

In order to do it, put the cardboard packing into recycling paper container, put the polyethylene (PE) bags into container for plastic.

When worn out, disposes the appliance to particular disposal centre, because of the dangerous elements of this appliance, which can be hazardous for natural environment.

Do not dispose into the domestic waste disposal

INFORMACJE O OWOCACH I WARZYWACH

Please, read these instructions carefully. Special attention should be paid to the information concerning safety in order to avoid accidents and damages of the appliance. It is recommended to keep this manual for further use.

Characteristics of the juice extractor

The juice extractor is an electrical appliance for fast fruit and vegetable juice centrifuging with automatic separation of pulp. The raw material is first pulped and next the juice is centrifuged from the pulp. A simple and easy operation of the appliance enhance its utility advantages. An electronic speed stabilizer ensures a constant rotation speed irrespectively of loading, which guarantees obtaining of juice even consistency. The juice extractor is equipped with 2 centrifuging speeds (for hard and soft fruit) which were chosen to obtain the optimal quality parameters for squeezed juices. Keeping the maximal content of fruit pulp and fibre containing vitamins, pectin, enzymes and minerals in the juice results in its lower clarity. This is an intended effect since the Producer of the juice extractor decided that it is more important to keep the highest possible nutritious, health and dietetic values of the obtained fruit than its clarity. The juice extractor is additionally equipped with filter self-cleaning function. After pressing the turbo button, the engine works for about 3 seconds with high rotation. High rotation helps to clean the filter in the event of vibrations resulting from excessive pulp accumulation. The turbo function may be used in 10-second intervals only. The juice extractor may work for 15 minutes without any break. The quantity of juice obtained, e.g. from 1 kg of a raw material depends on its freshness as well as on filter cleanliness and the state of the pulping blade. The parts in contact with the processed raw materials are made of materials permitted for contact with food.

Safety operation instructions

• Do not disconnect the plug from the socket by pulling a cord.
  Before starting the appliance, uncoil appropriate amount of power supplying cord.
  Place the motor body near a socket on a flat, stable surface so that the vent holes of the appliance are not covered.
  The appliance must be plugged only to an alternating current 230 V grounded socket.
• Do not operate the appliance if the power supplying cord is damaged or the casing is visibly damaged.

If the non-detachable part of the cord is damaged, it should be replaced by the producer or at a proper service point or by a qualified person in order to avoid any hazards.

The appliance can only be repaired by qualified service personnel. Improper servicing may cause a serious hazard to the user. In case of defects please contact a qualified service center.

The appliance is intended for domestic use. In case it is used for food business purposes, the warranty conditions shall change.

Before the first use, wash thoroughly all elements of the equipment.
Turn off the device and unplug it from an outlet before replacing the equipment or approaching moving parts during use.
Before cleaning, assembling or disassembling the appliance, always unplug it first.
Immediately stop the operation and unplug the appliance if any liquid gets into the motor. Return the appliance to an authorised service facility for examination and servicing.
Do not expose the appliance to temperatures exceeding 60^ C.
Do not turn on the appliance if empty, without any products in.
De particularly cautions when the juice extractor is used in the presence of children.
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
●children should be supervised to ensure that they do not play with the appliance.
Do not leave the appliance unattended when it is plugged to a socket.
Do not put the appliance on wet surface.
Onplug the appliance after use.
Do not immerse the juice extractor's motor in water, nor rinse it with running water.
Do not use aggressive detergents for washing the casing, such as emulsion, cleaning milk or paste which may, among others, remove informative symbols and signs.
Do not use the juice extractor if the spinning strainer is damaged.
Make sure that the lid is clamped securely in place before motor is turned on.
Do not unfasten clamps when the juice extractor is in operation and the strainer is spinning because the safety system will cause the appliance to stop.
Use the pusher only to push food into the feeder opening.
Immediately turn off the juice extractor if you notice strong vibrations or the rotation speed is reduced. Clear the strainer and its cover.
Turn the motor off and unplug the appliance if food is blocked in the feeder opening or on the grinding blades. Remove the cause of blocking.
Use hard bristle brush for cleaning the strainer with sharp grinding blade.
Do not use the juice extractor without pulp collector.
Do not overload the appliance with extensive amount of product or do not push it to strong (with a pusher), because a sudden increase of juice amount in the bowl spout can cause the juice overflow out of the lid or into pulp collector.

INFORMATION ON FRUIT AND VEGETABLES

Fruit/vegetables	Centrifuging speed	Fruit/vegetables	Centrifuging speed
Pineapples	II	Carrots	II
Blueberries	I	Melons	I
Peaches	I	Apricots	I
Beetroots	I	Nectarines	I
Pears	I	Cucumbers	I
Apples	I	Kiwi	I
Cabbage	II	Tomatoes	I
Fennel	I	Celery	II
Raspberries	I	Grapes	I

Technical specifications

Technical parameters are indicated on the appliance's name plate.

Admissible continuous operating time of the motor with 15 minutes

A break between successive uses 30 minutes

A break between successive turbo uses 10 seconds

The appliance's noise level (LWA) 75 dB/A

Speed range I gear, II gear

The juice extractor type 477 is constructed in II class insulation ☐

It does not require connection to the grounded socket.

ZELMER appliances meet the requirements of effective standards.

The appliance meets the requirements of the following directives:

Low Voltage Device (LVD) - 2006/95/EC. -

Electro-Magnetic Compatibility (EMC) - 2004/108/EC.

The product is marked with CE symbol on the name plate.

Construction of the appliance (Fig. A)

1 Motor

a power on/off button

b gear 1 – gear 2 / turbo button

c indicator light

d pulse button (does not apply in case of juice extractor)

e skimmer

f sucker

g power supplying cord

2 Juice container

h spout

i cover

3 Body of the juice collector

4 Strainer

5 Lid
6 Clamps
7 Pusher
8 Pulp container

Preparation of the juice extractor for operation (disassembling) (Fig. B)

Before using the juice extractor for the first time, disassemble it and wash parts in contact with the processed product.

① Place the juice extractor near the socket on the firm, clean and dry surface.
② Pull down the clamps (6) so that the tracks moved out of grooves of the lid (5).
③ Take the pusher (7) and the lid (5) out.
④ Then remove the juice collector (2) including the body (3) and the filter (4). To this end, turn the body (3) right (clockwise) to the limit and raise the body with the juice collector and the filter.
⑤ Finally, disassemble the juice collector (2) from the body (3).

- Wash the disassembled parts (except the motor unit) carefully in hot water and wash-up liquid. You can also clean them in a dishwasher in max temp. 60°C (except for the strainer and the motor unit). After drying them carefully, start assembling the clean parts.

Preparation of the juice extractor for operation (assembling)

(Fig. C)

① Put the body of the juice collector (3) on the motor unit so that a clamp (6) is placed slightly on the left of the buttons on the motor and turn left to the limit (anticlockwise) so that a clamp is placed over the buttons.
② Put the juice container (2) on the body (3) so that the lip (h) was placed in the cutting of the body (3).
③ Put the filter (4) inside, press it slightly and check if it is well mounted and rotates easily.
④ Put the lid (5) and close the clamps (6).

⑤ Put the pusher (7) to the feeding tube.
⑥ Insert the pulp container (8) under the lid (5) in the following way: lean the pulp container and place it under a cover of the juice collector (3) and the lid (5), and next push it towards the motor (1).
⑦ Place the juice collector under the lip (h).

Place washed fruit and vegetables prepared for juice extraction near the appliance.

Start-up of the juice extractor and operation (Fig. E)

① Plug the juice extractor.

The appliance has an additional protection. If it is plugged and the button power (a) is on and if the switch is pulsating red, it means that either the body (3) or the clamps (6) were improperly placed on the lid. In such a situation the appliance cannot be started. Check again whether the assembly is proper until the lamp (c) turns blue.

② Press the button power (a) – the juice extractor will operate on gear 1 and the control lamp will turn blue. It is a gear recommended for fruit.
③ If you need operations on gear 2 (high rotation for hard fruit like carrots, celeries, beetroots, apples, etc.), press (for a short time, max. 2 sec.) the button (b) – the lamp (c) will shine red with a continuous light. If it is necessary to return to gear 1, press for a short time the button (b) and the juice extractor will return to gear 1, the control lamp will shine blue with a continuous light.

The juice extractor always start working on gear 1. An exemplar table containing detailed information about selecting a relevant gear for specific fruit and vegetables may be found on page 66.

But fruit or vegetables of relevant size into the feeding tube (if necessary, they should be cut into pieces of relevant size) and press them slightly with the pusher.

You must not push the products with your fingers or other objects.

④ In case of the necessity (in case of excessive accumulation of the pulp on the filter, which causes juice extractor vibrations) you can use turbo button. To this end, press the button (b) for a longer time (about 3 sec.). The engine operates in such a case on maximal rotation for approximately 2 seconds. After this time, the turbo function switches off automatically, and the engine returns to previous rotation.

ATTENTION! Repeated usage of turbo function can take place after min. 10 seconds.

Do not overload the appliance with extensive amount of product or do not push it to strong (with a pusher), because a sudden increase of juice amount in the bowl spout can cause the juice overflow out of the lid or into pulp collector.

After operation (centrifuging of juice) (Fig. D)

① Switch the juice extractor off, turning the button (a), the lamp (c) will go out.
② Unplug the appliance.

After the engine stops, start to disassemble the juice extractor in order to wash the parts (see „Preparation of the juice extractor for operation”).

Remove the accumulated pulp from the pulp container (8).

Prevent the excess of the pulp container (8). The excessive pulp can pour out while leaning the container during removing.

Juice extractor maintenance rules

• clean the juice extractor carefully after each usage, to prevent drying of juice and fruit remains.
  Remove the dirt from the corners with a bottle brush or tooth brush.
• clean the motor with a damped cloth sprinkled with washing up liquid. Then dry it.

When water or juice gets into the motor, stop operation and bring the appliance to the service centre for inspection.

The following elements of the equipment: the juice collector (2), the lid (5), the pusher (7) and the pulp container (8) should be washed in hot water with wash-up liquid.
You can also clean them in dishwashers in maximum temperature 60°C.
The exception is the filter (4). It should be washed with a hard brush only. Do not use any metal brushes to clean the filter!
As a result of a long use of the appliance, some plastic elements can change their colour. Do not treat it as a defect.
Colour from carrots can be removed by cleaning the surface with a cloth moistened with edible oil.
Dry carefully all parts after cleaning.
assemble the juice extractor according to the instructions described above (see "Preparation of the juice extractor for operation").
Roll the supplying cord inside the compartment located in the base of the juice extractor motor.

Pay special attention to transparent plastic parts. They are sensitive to hits and falls. They may easily be damaged then.

What to do when ...

The appliance does not work:

Plug another appliance into the socket and check whether – it works properly.

-Return the appliance to authorized service facility.

The juice extractor extracts little juice, wobbles and vibrates:

- Use turbo function. If the a/m problem still exists, turn off the appliance and clean the strainer of food remains.

Additionally, if the pulp container is full, empty it.

In case of any mechanical damages of the strainer, it is - necessary to replace it with a new one.

Vegetable and fruit juices preparation

Fruits and vegetables intended for juice extraction should be fresh and cleaned carefully. Vegetables should be cleaned from sand and soil with running water and peeled. Publications on making juices recommend to soak vegetables for 5 minutes in water with salt and citric acid.

Vegetables prepared in this way do not get darker during the process of grinding and juice made of them has a natural colour.

Derry fruits should be washed directly before using because they lose freshness quickly.

The selection of vegetables and fruit depends on the season of the year, taste preferences and health recommendations. Nutritive values of vegetable and fruit juices also depend on the way of preparation.

Juices should be prepared from juicy vegetables and fruits, which should be ripe and fresh to get the juice of an excellent taste and fragrance.

The following vegetables are suitable for juice preparation: tomatoes, carrots, celeries, beetroots, parsnips, onions, cabbage, cucumbers, black turnip, rhubarb, etc. For dietetic purposes juices may be prepared from lettuce, spinach, leek and other vegetables.

●uch vegetables as radish, chives, parsley, dill and cress are added to drinks in a finely cut form.

fruit juices may be obtained from almost all kinds of fruits.

apples, peaches, apricots and plums should be scalded in a colander after washing.

Remove pips, seeds or stones from fruits containing them because they could damage the juice extractor.

Extracting juice from plums, blueberries, raspberries, soft pears and apples and other fruits is inconvenient. The flesh of these fruits becomes a spongy pulp which blocks holes of the filter. You can use these fruits for extracting juice mixing a small amount of them with other fruit or vegetables and the filter should be cleaned more often in such a case.

Root vegetables and hard fruits should be cut into pieces which could fit in the feeding tube.

Fruits and vegetables are put into the feeding tube only after starting of the juice extractor.

the raw material gets stuck in the feeding tube or on the pulping blade of the filter, use the turbo function. If the above problem still exists, switch the appliance off, disassemble it and clean.

Nutritive values of fresh juices is similar to nutritive

values of fruit and vegetables, however a part of fibre is eliminated during the process of juice centrifuging. that is why juices may be drunk by persons who, due to complaints of their digestive tract cannot eat raw vegetables.

Drinks from fruits are specially recommended for children and elderly people nourishment.

is recommended to drink a small amount of water while drinking vegetable juices, which are very strong. If the juices are not diluted, a daily portion should not exceed a half of glass.

Fruit juices are easier to digest so they may be drunk in big amounts: from 3 to 4 glasses a day between meals.

- juices should be drunk immediately after extraction and drunk in sips. When drinking juice slowly, it mixes with saliva which helps to digest it. Drunk too fast and in excessive amounts, the juice is not absorbed properly.

Except apples, fruit should not be mixed with vegetables. Melons should not be mixed with other fruit.

- juices should not be stored for later consumption.

vegetable juices may be diluted with lukewarm boiled water, mineral water, milk or whey, you may add sugar or flavor them in a different way.

You may prepare low-alcoholic cocktails from juices.

Vegetable juices may be flavoured with fragrance spices such as pepper, dill, caraway, nutmeg, thyme, marjoram whereas fruit drinks may be flavoured with vanilla, cinnamon and clove. In order to get a full fragrance of spices, they should be finely ground before being added to a drink. They should be used in small amounts in order to keep a natural taste and fragrance of products from which a drink has been made. Due to a low caloric value of fruit and vegetable drinks are highly recommended for people on a diet.

Fruit and vegetable drinks should be served in room temperature or they should be cooled with ice cubes.

-alty sticks, crackers and croutons can be snacks to go with vegetable drinks and teacakes, cakes and biscuits to go with fruit drinks.

The juice obtained from certain fruit and vegetables has a tendency to self-condensing. Such phenomena results from the properties of used products and is irrespective of the application.

Fresh juice is healthy

Carrot juice

It accelerates metabolism since it contains microelements and vitamins necessary for the body to function properly.

Vitamin A, produced from carotene, improves sight. The ingredients of this juice eliminate

harmful effects of nicotine, restores the natural healthy colour of the skin. Half a glass of carrot juice and half a glass of milk is recommended for little children. Carrot juice in combination with apple juice is recommended as an energizing drink for elderly people.