KH 3140 ACCUMULATOR AIR PUMP - Air pump TRONIC - Free user manual and instructions

Product Type	Battery-powered Air Pump
Brand	TRONIC
Model	KH 3140
Power Supply	Ni-Cd battery 9.6 V, 1200 mAh or mains 230 V / 50 Hz via adapter
Charging Time	5 to 8 hours
Inflation Pressure (battery)	3.2 kPa
Inflation Pressure (mains)	3.7 kPa
Inflation Flow Rate (battery)	103 L/min
Inflation Flow Rate (mains)	134 L/min
Suction Function	Yes, for deflating inflatable items
Included Accessories	3 nozzles, mains adapter, car charging cable, instruction manual
Intended Use	Occasional inflation of inflatable toys and camping equipment
Fuse	Model T5 H250 (in the car connector)
Battery Type	Nickel-Cadmium (Ni-Cd), 8 cells 1.2 V
Cleaning	Soft dry cloth only
Weight	Approx. 1.5 kg
Dimensions (L x W x H)	Approx. 25 x 15 x 20 cm
Warranty	According to accompanying leaflet

Frequently Asked Questions - KH 3140 ACCUMULATOR AIR PUMP TRONIC

How to charge the battery?

Connect the mains adapter or car cable to the left connector (battery symbol). A full cycle takes 5 to 8 hours. Avoid partial charging to limit the memory effect.

Can I use the pump on battery while charging?

No. While charging, the device cannot operate. Use the mains mode (switch I) via the right connector (turbine symbol) for operation without the battery.

What is the difference between switch positions I and II?

Position I: power via mains/car cable (without using the battery). Position II: operation on the built-in battery.

Can I inflate car tires with this pump?

No. This pump is designed for occasional inflation of toys and camping items. The maximum pressure of 3.7 kPa is insufficient for tires.

How to use the suction function?

Use the suction connector located on the top to suck air from inflatable items. Never suck liquids.

How to clean the device?

Clean only with a soft dry cloth. Never open the housing and do not let any liquid enter.

How to replace the fuse in the car connector?

Unscrew the cap of the car connector and replace the fuse with an identical model T5 H250 (available from an electrician). Never short-circuit.

How to know if the battery is charged?

The device does not have a charge indicator. A full charge cycle (5-8 h) guarantees a full charge. A drop in power indicates it is time to recharge.

What to do if the device does not turn on?

Check that the battery is charged or connect the mains adapter. Make sure the switch is in position II (battery) or I (mains). If the problem persists, contact customer service.

How to dispose of the device at the end of its life?

Remove the Ni-Cd battery (unscrew the bottom compartment) and dispose of it at a collection point. The device itself must not be thrown away with household waste: take it to a recycling center.

USER MANUAL KH 3140 ACCUMULATOR AIR PUMP TRONIC

Accumulator air pump

Operating Manual

Accumulator air pump

Tronic KH 3140

1. Intended purpose

This device is intended for the occasional inflating of objects, which were designed for inflating via respiratory air (e.g. inflatable toys, camping material) for domestic use. It is not intended for use in commercial or industrial environments, for continuous duty and it is not intended for use without adapter nozzles.

2. Technical Data

Device

Rated current : 3 A max

Accumulator rated voltage : 9.6 V

Accumulator rated capacity: 1200 mAh

Mains charging adapter

Input voltage 230 V / 50 Hz

Power consumption .. 53 W

Output voltage 12 V DC

Rated output current: 3 A

Accumulator block

... at 12 V direct operation via mains or motor vehicle charging cable

Inflation volume: 134 l/min

Deflation volume 117 l/min

Inflation pressure: 3.7 KpA

Deflation pressure.....-2.7 KpA

... at 9.6V accumulator operation

Inflation volume: 103 l/min

Deflation volume 941/min

Inflation pressure: 3.2 KpA

Deflation pressure.....-2.2 KpA

3. Scope of delivery

1 accumulator air pump Tronic KH 3140
1 Mains charging adapter
1 Motor vehicle charging cable
3 Adapter nozzles
1 Perverting instructions
1 Warranty card

Important Instructions for Your Safety!

To avoid danger for life via electric shock as well as fire danger via short circuit:

• Only use the mains charging adapter in dry rooms, do not use in moist environments.
• If the mains charging adapter or its mains cable is damaged, do not continue to use it. The mains charging adapter cannot be repaired, have it replaced by customer service or by specialised trade.
• Only use the supplied connection cable. Other models might not ensure your safety.
• Do not open the housing of the devices, it might not be possible to close them completely and safely.
• Do not subject devices to any head sources, e.g. solar radiation, heating...
• Do not let your children or invalid persons play with the device. They might not be able to realise potential dangers with respect to electrical energy.

To avoid the risk of accidents and injuries:

• Do not use the device as hairdrier – your hair could get caught by the device and be pulled into it!
• Do not direct the air jet in the direction of persons or animals. Particles which might be contained in the air jet could meet the object at high speed and cause injuries.

4. Charging

Charge the device completely prior to its initial use. The accumulator is only pre-charged to a minimum extent ex works.

Attention: The capacity (service life) of the accumulator decreases, if it is often charged or discharged only to half the extent possible (socalled "memory effect"). Therefore:

Always charge the device completely and not only to half the extent possible.
- Charge the device only if its capacity is noticeably low and not just in between.
- Avoid draining the accumulator - i.e. do not discharge it completely. This might destroy the accumulator.

a) Via a mains charging adapter

the complete charging process of the accumulator takes 5-8 hours:

Insert the low voltage plug of the mains adapter ...
in the left socket with the battery symbol ...
and then insert the mains plug in the socket. Now the device is being charged!

b) Via the motor vehicle charging cable ...

the complete charging process of the accumulator takes 5-8 hours:

3 Insert the low voltage plug of the motor vehicle charging cable...
in the left socket with the battery symbol ...
and only then insert the motor vehicle plug in the cigarette lighter of the car.

This sequence prevents a short circuit if the low voltage plug which is already live falls out of your hands.

5. Application

First place one of the supplied adapters on the discharge nozzle at the side.

a) Via the integrated accumulator:
5 If the latter is completely charged, you can switch on and off the device simply by means of the main switch.

To do this, switch the main switch to position II. The device turns on.

b) Via the mains charging adapter

If the accumulator is empty, insert the low voltage plug of the mains charging adapter...
in the right socket with the impeller symbol.
and then insert the mains plug in the socket. The integrated accumulator is not charged by this!
Switch the main switch to position I. The device turns on.

c) Via the motor vehicle charging cable

3 If the accumulator is empty insert the low voltage plug of the motor vehicle cable...
in the right socket with the impeller symbol.
and only then insert the motor vehicle plug in the cigarette lighter of the car. The integrated accumulator is not charged by this!
Switch the main switch to position I. The device turns on.

d) Suction instead of blowing

Warning: Not suited for suction of liquids, especially inflammable liquids! The device might explode!

Via the air intake at the top of the device you can also suck in air, e.g. if an inflatable object shall be deflated quicker.

6. Storage

Store the device in such a way that it will not be switched on accidentally. Otherwise the device could be damaged, if the draining of the accumulator is caused or if objects are sucked in accidentally.

7. Replacing of fuses

Attention: Do not bridge a fuse - and do not use any other value than specified. Otherwise your motor vehicle network is not protected sufficiently!

The motor vehicle plug features a miniature fuse to protect your motor vehicle's network from accidental short circuits. If the miniature fuse has blown ...

4 turn off the cap of the motor vehicle plug and replace the miniature plug by a new one with the identical value "T5 H250" purchased at a specialised electrical dealer.

8. Cleaning and Care

Should sand or dirt have accumulated in the device interior try to shake it out:

• Do not open the housing! It cannot be closed again.

• Do not let water run into the device! This would cause damage to the device.

• Do not use any detergents or solutions. This could damage the plastic surfaces.
  Only clean the devices with a soft dry cloth.

9. Disposal

The device features a nickel-cadmium accumulator as an energy source. It must not be disposed of in domestic waste:

• First remove the accumulator! For this open the accumulator compartment at the bottom of the device and take out the accumulator.
• Return the accumulator to your dealer or to a return center authorized for its disposal.

Tip: Protect the environment. Do not dispose of the rest of the device in your domestic waste. Return it to a disposal center authorized for electronic recycling.

10. Warranty & Service

The warranty conditions and the service address can be found on the enclosed sheet.

11. Importer

Batteridreven Luftpumper

Tronic KH 3140

1. Päregnet bruk

d) Sugging i stedet for blasing

Advarel: Aldri sug inn vaesker, spesielt不克 slike som er brennbare. Apparatet kan eksplodere!