PPG 36584 - Salt/pepper mill KALORIK - Free user manual and instructions

Product type	Electric salt/pepper mill
Brand	Kalorik
Model	PPG 36584
Dimensions (H x W x D)	20 x 5 x 5 cm
Weight	300 g
Housing material	Stainless steel and ABS plastic
Grinding mechanism material	Ceramic
Power supply	4 AA batteries (not included)
Recommended battery type	Alkaline
Reservoir capacity	Approximately 80 g of salt or pepper
Grind setting	Continuous adjustment dial, from fine to coarse
Operation	Automatic by tilting or pressing the top
Lighting	Built-in LED to illuminate the grinding area
Care and cleaning	Wipe with a damp cloth, do not immerse
Mechanism cleaning	Removable to rinse the burrs with clean water
Safety	Automatic shut-off if motor is blocked
Spare parts available	Ceramic burrs, reservoir, cap
Repairability	Repairability index: 7/10 (spare parts available)
Use	Salt, pepper, dry spices
Warranty	2 years
Country of manufacture	China

Frequently Asked Questions - PPG 36584 KALORIK

How to adjust the grind on the Kalorik PPG 36584 mill?

Turn the dial located under the mill to choose between fine or coarse grind. A click indicates each level.

What type of batteries to use?

Use 4 AA alkaline batteries. Do not mix new and used batteries.

The mill no longer works, what to do?

Check the batteries, clean the contacts and make sure the reservoir is not too full. If the problem persists, contact customer service.

Can I grind wet salt?

No, use only dry salt and pepper. Moisture can damage the mechanism and promote corrosion.

How to clean the mill?

Wipe the exterior with a damp cloth. For deep cleaning, disassemble the reservoir and rinse the burrs with clean water, then dry thoroughly.

The LED does not light up, is this normal?

The LED automatically turns on during use. If it does not light up, check the batteries or battery contact.

Is the mill noisy?

A slight grinding noise is normal. If the noise is excessive, check that the burrs are not clogged.

Can I grind other spices?

Yes, suitable for dry spices like cumin, coriander, etc. Avoid very hard or sticky spices.

Where to find spare parts?

Ceramic burrs and other parts are available on the official Kalorik website or from authorized dealers.

How to change the batteries?

Remove the battery compartment cover located at the top of the mill. Insert 4 AA batteries respecting the indicated polarity.

USER MANUAL PPG 36584 KALORIK

Rechargeable Grinder and Spice Carousel

batteries with UL adapter

EN OPERATING INSTRUCTIONS

When using electrical appliances, basic safety precautions should always be followed, including the following:

IMPORTANT SAFEGUARDS

Please read these instructions carefully before using the appliance. Important: People (including children) who are not able to use the appliance in a safe way, due to their physical, sensorial or mental capacity or their lack of experience or knowledge, must never use the appliance except if they are supervised by a person responsible for their safety or if they previously received instructions concerning the safe use of the appliance.

Close supervision is necessary to prevent children from using the appliance as a toy.

□ Never leave the appliance unsupervised when in use.
From time to time check the appliance for damages. Never use the appliance if it shows any signs of damage. All repairs should be made by a qualified electrician.
☐ Only use the appliance for domestic purposes and in the way indicated in these instructions.
- Never immerse the appliance in water or any other liquid for any reason whatsoever.
☐ If the batteries leak, remove them, clean the contacts of the appliance and wash your hands.
☐ If you do not use the appliance for a long time, remove the batteries so that they do not leak.
☐ Only replace the rechargeable batteries with rechargeable batteries of the same type and rating (Ni-Mh type, AA size, 650mA).
☐ NEVER replace the rechargeable batteries with non-rechargeable batteries, as the appliance could catch fire.

SAVE THESE INSTRUCTIONS HOUSEHOLD USE ONLY

PARTS

1. Stainless Steel Housing 7. Charging base / carousel
2. Grind switch 8. Grind adjustment wheel (coarse/fine)
3. Rechargeable battery-pack 9. LED light
4. Battery compartment 10. Adapter socket on base + pilot light
5. Transparent spice container 11. Adapter (aspect can vary)
6. Carousel base 12. Adapter plug

BEFORE USE

• This appliance runs on a battery pack of 2 x AA type rechargeable batteries. The batteries are pre-installed in the motor housing.
• If the original batteries need to be replaced later, open the batteries housing by sliding the 2 white tabs at the bottom of the motor housing towards the centre. Slide the motor block out to access the battery cavities.
• Do not replace the rechargeable batteries with non-rechargeable ones, as these could catch fire.
• If the rechargeable batteries need replacing, only do with a rechargeable battery pack of the same type and specifications (Ni-Mh type, AA size, 650mA)

To fill in pepper or salt:

• Simply lift off the lid of each container and fill them with coarse sea salt, peppercorns of other spices suitable to be ground (fig. 4).
• Put the lid back in place to keep the content fresh and dry, until ready to grind.
• Do not fill the containers completely, for best performance.

CHARGING

• Remove the grinder and components from the packaging.
• Plug the charger cord (12) into the charging base (10), and plug charger (11) into the socket
• With the socket for the adapter (10, 12)) at the right back side, and the grind switch (2) on the motor block (1) positioned towards the front, place the motor block (1) on the center of the base (7) and turn the motor block clockwise, until it locks in place and a red pilot light (10) on the base lights up.
• Charging will take approx. 3-4 hours for the first time.
• For longer battery life, leave the grinder to charge for up to 8 hours continuously. Then unplug the adapter from the socket and discharge the batteries to the maximum before recharging.

- Please note: the transformer and stainless steel casing will become slightly hot when charging is completed. This is normal. It is recommended that you remove the grinder from its base and let it cool slightly before using, or that you disconnect the charger from the base when the appliance is fully charged (after 8 hours).

Note: the motor block (1) can only charge if no spice container (5) is attached to it.

SPICE CONTAINERS

• Before seasoning your meals, you can adjust the fineness of the ground salt / peppercorns or spices, by turning the adjustment wheels on the underside of each container
• To do so, turn the wheel clockwise for a finer grind and counterclockwise for a coarser grind (fig. 5)
• Do not turn more than six turns from the finest position to avoid dismantling the adjustment wheel from the container.

Note: you can also use the spice containers to grind, manually, without the motor block. Just keep the lid on and turn the lid clockwise to grind (in this case the LED light will not light up)

ATTACHING THE SPICE CONTAINERS

• Remove the lid of the container that you want to use.
• Align the arrow on the stainless steel housing with the "Unlock" symbol on the container.
• Lock in place by turning the upper stainless steel part clockwise, until the arrow reaches the "Lock" symbol.
• Grind the desired quantity of spice.
• Proceed reversely to remove the spice container in place.

USE

• With a spice container attached to the motor block, hold the appliance above the meal to season.
• Press on the grind switch.
• A LED light underneath each mill enables you to see how much you are grinding, for a more precise seasoning.
  • Interchange the spice containers at will, season to taste.

MAINTENANCE

• Disassemble the different parts of the appliance (housing, containers, lids) and clean them separately with a damp cloth.
• Do not immerse the motor block in liquid or put it in a dishwasher.
• Do not use with wet hands.
• Do not use cleaning products or detergents.
• Only use with the adapter supplied or of the same type (Input: AC 110V 60Hz, Output: DC 5V 300mA)

TROUBLESHOOTING

If the mill does not grind, or if no motor noise can be heard, please check that the batteries are not discharged. Recharge if necessary.

If the mill gets stuck during use (motor produces hum, but internal shaft does not turn and no pepper is ground), check the container is properly installed, then gently shake the mill or tap the mill gently on a hard surface, to remove the stuck pepper or salt.

To remove deeply stuck peppercorn, remove the upper lid as if for re-filling the mill, turn the coarseness setting to its coarsest, and tap lightly on a hard surface until all the peppercorn is released. Re-adjust coarseness setting to the desired level once done and replace upper lid.

Note: Too fine a grind setting may not enable salt or pepper to be ground. If the case, set the grinder to a coarser setting (see above).

PROTECTION OF THE ENVIRONMENT

In order to preserve our environment and protect human health, the waste electrical and electronic equipment should be disposed of in accordance with specific rules with the implication of both suppliers

and users. For this reason, as indicated by the symbol on the rating label or on the packaging, your appliance should not be disposed of as unsorted municipal waste. The user has the right to bring it to a municipal collection point performing waste recovery by means of reuse, recycling or use for other applications in accordance with the directive.

WARRANTY

We suggest that you complete and return the enclosed Product Registration Card promptly to facilitate verification of the date of original purchase. However, return of the Product Registration Card is not a condition of these warranties. You can also fill out this warranty card online, at the following address: www.KALORIK.com

This KALORIK product is warranted in the U.S.A. for 1 year from the date of purchase against defects in material and workmanship. This warranty is not transferable. Keep the original sales receipt. Proof of purchase is required to obtain warranty performance.

During this period, if the KALORIK product, upon inspection by KALORIK, is proven defective, it will be repaired or replaced, at Kalorik's option, without charge to the customer. If a replacement product is sent, it will carry the remaining warranty of the original product.

This warranty does not apply to any defect arising from a buyer's or user's misuse of the product, negligence, failure to follow KALORIK instructions noted in the user's manual, use on current or voltage other than that stamped on the product, wear and tear, alteration or repair not authorized by KALORIK, or use for commercial purposes. There is no warranty for glass parts, glass containers, filter basket, blades and agitators, and accessories in general. There is also no warranty for parts lost by the user.

ANY WARRANTY OF MERCHANTABILITY OR FITNESS WITH RESPECT TO THIS PRODUCT IS ALSO LIMITED TO THE ONE YEAR LIMITED WARRANTY PERIOD.

Some states do not allow limitation on how long an implied warranty lasts or do not allow the exclusion of incidental or consequential damages, so the above limitations may not apply to you. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.

If the appliance should become defective within the warranty period and more than 30 days after date of purchase, do not return the appliance to the store: often, our Customer Service Representatives can help solve the problem without having the product serviced. If servicing is needed, a Representative can confirm whether the product is under warranty and direct you to the nearest service location.

If this is the case, bring the product, or send it, postage prepaid by the user (all Kalorik customers are responsible for the initial shipment back to the warranty center), along with proof of purchase and a return authorization number indicated on the outer package, given by our Customer Service Representatives. Send to the authorized KALORIK Service Center (please visit our website at www.KALORIK.com or call our Customer Service Department for the address of our authorized KALORIK Service Center). When sending the product, please include a letter explaining the nature of the claimed defect.

If you have additional questions, please call our Customer Service Department (please see below for complete contact information), Monday through Thursday from 9:00am - 5:00pm (EST) and Friday from 9:00am - 4:00pm (EST). Please note hours are subject to change.

If you would like to write, please send your letter to:

KALORIK Customer Service Department

Team International Group of America Inc.

1400 N.W 159th Street, Suite 102

Miami Gardens, FL 33169 USA

Or call:

Toll Free: +1 888-521-TEAM / +1 888-KALORIK

Only letters can be accepted at this address above. Shipments and packages that do not have a return authorization number will be refused.

SP MANUAL DE INSTRUCCIONES

Diagram of a container with internal granular material and a funnel inserted into it, no text or symbols present

CARGA

Team International Group of America Inc.

1400 N.W 159th Street, Suite 102

Miami Gardens, FL 33169 USA

O llame gratuitamente (U.S.A.) al +1 888-521-TEAM / +1 888-KALORIK

Illustration of a container with internal granular material being poured into it, no text or symbols present

MISE EN CHARGE

Team International Group of America Inc.

1400 N.W 159th Street, Suite 102

Miami Gardens, FL 33169 USA

Copies of the I/B. Please reproduce them without any changes except under special instruction from Team International USA. The pages must be reproduced and folded in order to obtain a booklet A5 (+/- 148.5 mm width x 210 mm height). When folding, make sure you keep the good numbering when you turn the pages of the I/B. Don't change the page numbering. Keep the language integrity. Print only what is inside the frame.

www.KALORIK.com

PPG 36584 - 120501