PC323 - Popcorn machine Coline - Free user manual and instructions

Product Type	Popcorn Popper
Brand	Coline
Model	PC323
Capacity	Approximately 3 liters
Power	750 W
Voltage	230 V AC, 50 Hz
Preparation Time	3–5 minutes
Maximum Popcorn Load	70 g
Bowl Material	Transparent plastic (polycarbonate)
Popping Surface	Non-stick coated
Stirring Rod	Removable, with rotating shaft
Control	On/off switch with indicator light
Safety Features	Overheat protection, automatic shut-off after 15 min continuous use; requires 20 min cool-down
Dimensions (Approx.)	25 cm diameter x 30 cm height (estimated)
Weight (Approx.)	1.5 kg (estimated)
Cord Length	Not specified (typical ~1 m)
Cleaning	Wipe with damp cloth; non-stick surface can be cleaned with mild detergent; never immerse in water
Repairability	Stirring rod replaceable; overheating protection non-resettable, requires service technician
Accessories Included	Plastic lid, stirring rod, bowl, base
Intended Use	Indoor household use only; not for commercial use
Waste Disposal	In accordance with local regulations

Frequently Asked Questions - PC323 Coline

How long does it take to pop popcorn?

It typically takes 3–5 minutes to pop a batch of popcorn. The exact time may vary depending on the quantity and type of popcorn used.

What is the maximum amount of popcorn I can use?

Do not exceed 70 grams of popcorn kernels per batch. Using more may cause burning or malfunction.

Can the appliance be used continuously?

No, the popcorn machine is not intended for continuous use. It should be operated for a maximum of 15 minutes in a row, then allowed to cool for about 20 minutes before the next use.

Why is there smoke coming from the appliance?

During first use or when oil heats up, slight smoke from the top is normal. However, if smoke comes from the handles, it may indicate that the lid (4) was not removed before use. Always remove the lid before starting.

How do I clean the non-stick popping surface?

Wipe the non-stick surface with a dry cloth. For stubborn grease, use a cloth slightly moistened with warm water and mild detergent. For discoloration, use a cloth with vinegar or weak citric acid, then rinse with clean water. Ensure the appliance is completely dry before storing.

Can I immerse the popcorn machine in water for cleaning?

No, never immerse the appliance in any fluids. Only wipe the exterior and popping surface with a damp cloth. The stirring rod can be removed and wiped separately.

What should I do if the stirring rod scrapes against the bottom?

Unplug the appliance, unscrew the center nut counter-clockwise, check the stirring rod for correct assembly or bending. Reassemble properly or gently bend the rod if necessary.

Why is the indicator light not on and the machine not heating?

First, ensure the appliance is plugged in and the socket works. If the light remains off, the overheat protection may have been triggered. This is non-resettable and requires a service technician to replace.

How much oil should I use?

Add about one teaspoonful of vegetable oil onto the popping surface before adding kernels. Do not exceed the recommended amount.

Is the popcorn machine safe for children to use?

Children should not use the appliance unless under adult supervision. The surface becomes very hot, and the base must be handled with care. Use an oven mitt when turning the appliance upside down to serve.

USER MANUAL PC323 Coline

Popcorn Popper coline®

Popcornmaskin • Popcornmaskin • Popcornkone

Black and white photo of a transparent dome-shaped container with a small pot, placed on a black surface (no text or symbols visible)

Art. No: Model. No:

18-4024 PC323-UK

34-7340 PC323

English 3

Svenska 7

Norsk 11

Suomi 15

Popcorn Popper

Art.no: 18-4024 Model: PC323-UK 34-7340 PC323

Please read the entire instruction manual before using and save it for future use. We apologise for any text or photo errors and any changes of technical data. If you have any questions concerning technical problems please contact our Customer Service Department (see address on reverse).

Warning! Please read through all the instructions. If the instructions below are not followed, it may lead to electric shock, fire and/or serious damages.

1. Safety

• Read through the manual and save it for future reference.
• Warning! Do not open the cover! There are dangerous, unprotected high-voltage components under the cover, contact with those components may cause electric chock.
• The Popcorn Popper may only be repaired by qualified service technicians.
• Unplug the mains cord after use. Pull the plug – do not pull on the cord.
• Never leave the appliance unattended while it is plugged into a socket.
• Never place the Popcorn Popper where it might fall into water or other fluids.
• If the Popcorn Popper falls into water after all, do not touch it without first unplugging it.
• Do not handle the appliance with wet hands.
• Do not let children use the Popcorn Popper unless supervised by an adult.
• Do not use the appliance if the plug, mains cord, or any other part is damaged.
• Do not carry the Popcorn Popper by the mains cord.
• Protect the mains cord from hot or sharp objects.
• The appliance is only intended for indoor use.
• Place the appliance on an even, heat-resistant surface; make sure that there are no inflammable materials nearby, such as curtains, furniture, beddings, paper, fabric, or wood.
• Do not place the Popcorn Popper on top of, or near, any source of heat, such as an electric cooker, an oven or a stove.
• Unplug the mains cord before assembling/dismantling or cleaning the appliance.
• Clean the Popcorn Popper regularly.
• The surface of the Popcorn Popper will become hot when the appliance is used – do not move the appliance when hot. Use an oven mit or similar to turn the appliance upside down after you finish popping.
• Do not use any other accessories than those that are enclosed with the Popcorn Popper.
• This Popcorn Popper is not intended for commercial use.
• Do not let the stirring rod engine run after you finish "popping".
• Make sure that there are no foreign objects in the container before you start "popping".

2. Product description

• Popcorn Popper with a capacity of about 3 litres. The popcorn is done in 3-5 minutes.
• Transparent bowl.
• Switch with indicator light.

• Power: 750W.

• Switch

• Stirring rod
• Non-stick surface container
• Plastic lid
• Bowl
• Rotating shaft for stirring rod
• Handle
• Base handle
• Base

3. Preparations before first use

1. Take out the Popcorn Popper from the box and remove all packaging.
2. Wipe off the inside of the Popcorn Popper, using a slightly moist cloth with a little bit of washing-up detergent, and then wipe off with a dry cloth.
3. Wipe off the non-stick coated popping surface (3), using a dry cloth.
4. Clean the stirring rod: Unscrew the centre nut counter-clockwise, remove the stirring rod (2) and wipe it off, replace the stirring rod (make sure that it is placed correctly in the groove on the rotating shaft) and tighten the centre nut.
5. The Popcorn Popper is now ready for use.
   Note: Remember that the handles of the Popcorn Popper will become hot; use an oven mit or some other form of heat protection when handling the Popcorn Popper.

4. Start using the Popcorn Popper

1. Place the Popcorn Popper on an even, heat-resistant surface.
2. Pour one teaspoonful of vegetable oil and a suitable amount of popcorn (max 70g) on the popping surface(3). Never use more popcorn or oil than what is recommended! Spread the popcorn evenly over the non-stick coated popping surface.
3. Place the bowl (5) on top, check that the handles (7) and (8) fit into each other.
4. Remove the lid (4).
5. Plug in the appliance to a socket and flip the switch (1). The indicator light will light up when the switch is switched on.
6. Turn off the Popcorn Popper by flipping the switch after 3 – 5 minutes, and unplug the mains cord once the “popping” has finished.
7. Put the lid (4) back on the bowl (5), hold the handles and turn the Popcorn Popper upside down, so that the content is collected in the bowl. Add salt according to taste, and serve.

Warning! Remember that the base of the Popcorn Popper can get very hot when the appliance is used. Be careful, you risk getting burned!

Note: The popcorn machine is not intended for continuous use. The machine may only be used for 15 minutes in a row; it must then be turned off for about 20 minutes, to allow it to cool off before the next period of use.

5. Cleaning

• Unplug the mains cord and let the Popcorn Popper cool off completely before cleaning.
• Wipe off the Popcorn Popper using a dry cloth. If there are grease spots on the non-stick coated popping surface (3), they can be wiped off using a cloth slightly moistened with warm water and washing-up detergent. Check that the Popcorn Popper is completely dry before putting it away.
• Never use strong cleaning agents or solvents!
• To clean the stirring rod: Unscrew the centre nut counter-clockwise, remove the stirring rod (2) and wipe it off, replace the stirring rod (make sure that it is placed correctly in the groove on the rotating shaft) and tighten the centre nut.
• Never immerse the appliance in any fluids.
• After long use, the non-stick coated popping surface (3) might get discoloured: Wipe the surface with a cloth slightly moistened with vinegar or a weak citric acid solution. Then wipe with a cloth only moistened with clean water. Check that the appliance is completely dry before putting it away.

6. Troubleshooting

Problem Cause Solution
Smoke formation when using the appliance.	Smoke coming from the top, from the oil heating up.	Completely normal, there is nothing wrong.
	Smoke from the handles, because the lid (4) is on.	Remember to remove the lid (4) in the bottom of the bowl (5) before use.
The popcorn is burnt. The popcorn was heated for too long.		Reduce the heating time, turn off the heat sooner.
The popcorn is not completely done.	The popcorn was not heated long enough.	Increase the heating time, turn off the heat later.
	The temperature regulator might have been activated. The indicator light will be on and the stirring rod will turn. The temperature regulator will be automatically reset when the Popcorn Popper has cooled off.	The Popcorn Popper is not intended for continuous use, it may only be used for 15 minutes in a row. Turn it off for about 20 minutes, so that it can cool off, before using it again.
	Protection against overheating might have been activated, the indicator light is not on and the stirring rod will not turn.	The Popcorn Popper is equipped with protection against overheating. In case of overheating, the power is turned off. This function can not be reset; a service technician must replace it.
The stirring rod scrapes against the bottom of the container.	The stirring rod is assembled wrong, or bent.	Unscrew the centre nut and check that the stirring rod is assembled right, bend the stirring rod if necessary.
The indicator light does not go on and the popcorn machine does not get hot.	The appliance might be unplugged.	Plug it in or try another socket.
The stirring rod is not moving, but the indicator light is on.	The stirring rod is assembled wrong, or bent.	Unscrew the centre nut and check that the stirring rod is assembled right, bend the stirring rod if necessary.

7. Waste disposal

Disposal of the used product should be carried out in accordance with local regulations. If you are unsure about what to do, contact your municipality.

8. Specifications

Rated voltage: 230VAC, 50 Hz Power: 750W

Popcornmaskin

Art.no: 18-4024 Model: PC323-UK 34-7340 PC323

For consumer contact, please visit

www.clasohlson.co.uk and click on

customer service.

INTERNET www.clasohlson.co.uk