Cobalt CO124DBX - Subwoofer ORION - Free user manual and instructions

Product Type	Dual 12-inch Vented Subwoofer Enclosure System
Model	Cobalt CO124DBX
Woofer Size	12 inches (each)
Number of Woofers	2
Enclosure Type	Slot Vented
Frequency Response	25 Hz – 250 Hz
Power Handling (RMS)	200 watts x 2 (400 watts total)
Power Handling (Peak)	400 watts x 2 (800 watts total)
Box Impedance	4 ohms x 2 (stereo or parallel)
Efficiency (1W/1M)	87 dB
Typical Output Level @ Full Power	120 dB – 129 dB
Depth x Width x Height	15.98" x 34" x 14.17" (406 mm x 864 mm x 360 mm)
Weight	55 lb (25 kg)
Recommended Amplifier Power	200 – 400 watts RMS per channel at 4 ohms
Mounting Brackets Included	Yes
Warranty (Authorized Dealer Install)	2 years limited
Warranty (Non-authorized Install)	1 year limited
Safety Note	Secure enclosure to prevent shifting; allow 3 inches clearance for port/woofer
Installation	Connect to amplifier observing polarity; do not exceed power specs
Maintenance	Keep dry and clean; avoid overdriving

Frequently Asked Questions - Cobalt CO124DBX ORION

What is the recommended amplifier power for the CO124DBX?

The CO124DBX handles 200 watts RMS per woofer (400 watts total RMS). Use an amplifier that delivers 200–400 watts RMS per channel at 4 ohms. Never exceed the peak power rating of 400 watts per channel.

Can I wire the dual enclosures in parallel or series?

Yes. The CO124DBX has two 4-ohm voice coils. You can wire them in parallel for a 2-ohm load, or in series for an 8-ohm load. Refer to your amplifier's owner manual for compatible loads.

What is the frequency response of the CO124DBX?

The frequency response is 25 Hz to 250 Hz, making it ideal for deep bass reproduction.

Do I need to break in the subwoofers?

While not strictly required, a gradual break-in period of 10–20 hours at moderate volume allows the suspension to loosen, improving low-frequency performance and longevity.

Where should I place the subwoofer enclosure for best bass?

Common placements include the trunk or rear seat. For most vehicles, orienting the woofers toward the rear enhances bass. Leave at least 3 inches of clearance in front of the ports and woofers.

How do I secure the enclosure to prevent movement?

Use the included mounting brackets to secure the enclosure to the vehicle floor or frame. This prevents shifting during sudden stops or turns, as loose objects can become projectiles.

What does the warranty cover?

The CO124DBX is covered by a limited warranty: 2 years if purchased and installed by an authorized Directed dealer, otherwise 1 year. It covers defects in workmanship and materials. Damage from abuse, improper installation, or thermal voice coil damage is not covered.

Can I use the CO124DBX in a home theater system?

Yes, but it is designed for car audio. For home use, you need a compatible amplifier and a 12V power supply. Ensure proper ventilation and avoid overdriving.

What is the impedance of each voice coil?

Each woofer has a 4-ohm voice coil. The dual enclosure allows flexible wiring configurations.

How do I clean and maintain the subwoofer enclosure?

Wipe the enclosure with a dry or slightly damp cloth. Avoid harsh chemicals. Keep the ports free of debris. Do not expose to moisture or extreme temperatures.

USER MANUAL Cobalt CO124DBX ORION

Single/Dual, 10"/12" Vented Subwoofer Enclosure System

MODEL

C0104SBX

C0124SBX

CO104DBX

C0124DBX

OWNER'S MANUAL

INTRODUCTION

Thank you for your purchase of the Orion vented subwoofer enclosure system from Directed Electronics. The Orion vented subwoofer enclosure system will excite and delight the auto sound enthusiast with years of high quality audio reproduction.

Orion vented subwoofer enclosure systems are covered by a limited warranty. Be sure to retain your original sales receipt, and refer to the warranty section on the back cover of this guide for full details about your coverage.

PRACTICE SAFE SOUND™

High-powered car audio systems may produce sound pressure levels that exceed the threshold at which hearing loss may result. They may also impair a driver's ability to hear traffic sounds or emergency vehicles. Use common sense and practice safe listening habits when listening to or adjusting your audio system. If your subwoofer enclosure is installed in the passenger compartment, make sure it is restrained from moving in case of an accident.

YOUR PRODUCT INFORMATION

Model Number:

Date of Purchase:

INSTALLATION

Place the speaker assembly in your vehicle. Common placement will normally be 1. the trunk, back seat, or back of a van.

Connect each speaker to an amplifier output (not supplied), observing that the 2. polarity markings on the back of the speaker enclosure are connected to the corresponding polarities on the amplifier.

NOTES:

Do not use an amplifier that can drive the speakers beyond their specifications. Leave at least three inches of clear space in front of the port(s) and woofer(s) to allow for adequate air flow and woofer movement without obstruction. Orienting the woofers toward the rear of the vehicle will in most instances enhance the bass performance.

WARNING: Loose objects can become projectiles in the event of a rapid deceleration, abrupt turn or accident. Secure the enclosure in place with the mounting brackets provided to prevent it from shifting.

SINGLE ENCLOSURE WIRE CONNECTION GUIDE

The following diagram shows a standard connection to a mono amplifier or single channel of a multi-channel amplifier.

NOTE: Refer to your amplifier owner's manual before connecting the subwoofer enclosure system.

graph TD
    A["Amplifier"] --> B["4 ohm load"]
    B --> C["Subwoofer Enclosure System"]
    C --> D["+"]
    C --> E["-"]
    D --> F["Standard Amplifier Connection"]
    E --> F

SPECIFICATIONS

Feature CO104SBX CO124SBX
Frequency response 35 Hz – 250 Hz 25	Hz – 250 Hz
Power handling (rms) 200 watts x 1 20	0 watts x 1
Power handling peak 400 watts x 1 40	0 watts x 1
Box Impedance 4 ohms x 1 4 ohms x 1
Efficiency (1W/1M) 86 dB 87 dB
Woofer size (inches)	10"	12"
Number of woofers	1	1
Enclosure type	slot vented	slot vented
Typical output level @ full power	114 to 123 dB	117 to 126 dB
Depth x Width x Height (inches)	15.47" x 15" x 12.44"	15.98" x 17" x 14.17"
Weight	25 lb (11.5 kg)	27 lb (12.5 kg)

DUAL ENCLOSURE WIRE CONNECTION GUIDE

The following diagrams show a typical stereo and parallel setup with an amplifier.

NOTE: Refer to your amplifier owner's manual before connecting the subwoofer enclosure system, especially when employing bridge connections, as some amplifier models have different bridge output connections.

SPECIFICATIONS

Feature CO104DBX CO124DBX
Frequency response 35 Hz – 250 Hz 25	Hz – 250 Hz
Power handling (rms) 200 watts x 2 20	watts x 2
Power handling peak 400 watts x 2 40	watts x 2
Box Impedance 4 ohms x 2 4 ohms x 2
Efficiency (1W/1M) 86 dB 87 dB
Woofer size (inches) 10"	12"
Number of woofers	2	2
Enclosure type	slot vented	slot vented
Typical output level @ full power	117 to 126 dB	120 to 129 dB
Depth x Width x Height (inches)	15.47" x 30" x 12.44"	15.98" x 34" x 14.17"
Weight	48 lb (21.5 kg)	55 lb (25 kg)

LIMITED ONE-YEAR CONSUMER WARRANTY/*LIMITED TWO-YEAR CONSUMER WARRANTY FOR AUTHORIZED DIRECTED DEALER PURCHASE & INSTALLATION

Directed Electronics (herein "Directed") promises to the original purchaser of the subwoofer or amplifier, as applicable (herein "Unit" or "Product"), to repair or replace with a new or refurbished Unit (at Directed's sole and absolute discretion) should the Unit prove to be defective in workmanship or material under normal use, for a period of *two-years from the date of purchase from the authorized Directed dealer PROVIDED the Unit was purchased and installed by an authorized Directed dealer. During this *two-year period, there will be no charge for the repair or replacement PROVIDED the Unit is returned to Directed (DO NOT RETURN THE ENTIRE ENCLOSURE. PLEASE RETURN THE WARRANTIED UNIT ONLY.), shipping prepaid, along with the required proof of installation, the bill of sale or other dated proof of purchase, and the consumer's contact information. If the Unit is installed by anyone other than an authorized Directed dealer, the warranty period will be one-year from the date of purchase. This warranty is non-transferable and does not apply to any Unit that has been modified or used in a manner contrary to its intended purpose, and does not cover damage to the Unit caused by installation or removal of the Unit. During this one-year period, there will be no charge for the repair or replacement PROVIDED the Unit is returned to Directed, shipping pre-paid, along with the bill of sale or other dated proof of purchase and the consumer's contact information. This warranty is void if the product has been damaged by accident or unreasonable use, neglect, improper service or other causes not arising out of defects in materials or construction. This warranty does not cover the elimination of externally generated static or noise, or the correction of antenna problems or weak reception, damage to speakers, accessories, electrical systems, cosmetic damage or damage due to negligence, misuse, failure to follow operating instructions, accidental spills or customer applied cleaners, damage due to environmental causes such as floods, airborne fallout, chemicals, salt, hail, lightning or extreme temperatures, damage due to accidents, road hazards, fire, theft, loss or vandalism, damage due to improper connection to equipment of another manufacturer, modification of existing equipment, or Product which has been opened or tampered for any reason. Units which are found to be damaged by abuse resulting in thermally damaged voice coils are not covered by this warranty but may be replaced at the absolute and sole discretion of Directed. Unit must be returned to Directed (DO NOT RETURN THE ENTIRE ENCLOSURE. THE UNIT ENCLOSURE IS COVERED BY A SEPARATE 90-DAY LIMITED CONSUMER WARRANTY. PLEASE ONLY RETURN THE WARRANTIED UNIT UNLESS A WARRANTY CLAIM IS BEING MADE FOR THE ENCLOSURE.), postage pre-paid, with bill of sale or other dated proof of purchase bearing the following information: consumer's name, telephone number, and address, authorized dealer's name and address, and product description. Unit must be returned to the following address: ATTN: WARRANTY DEPARTMENT, Directed Electronics , 1 Viper Way, Vista, CA 92081. Note: This warranty does not cover labor costs for the removal and/or reinstallation of the Unit. IN ORDER FOR THE TWO-YEAR WARRANTY TO BE VALID, YOUR UNIT MUST BE SHIPPED WITH PROOF OF INSTALLATION BY AN AUTHORIZED DIRECTED DEALER. ALL UNITS RECEIVED BY DIRECTED FOR WARRANTY REPAIR WITHOUT PROOF OF DIRECTED DEALER INSTALLATION AND PURCHASE WILL BE COVERED BY THE LIMITED 1 YEAR WARRANTY.

BY PURCHASING THIS PRODUCT, ALL WARRANTIES INCLUDING BUT NOT LIMITED TO EXPRESS WARRANTY, IMPLIED WARRANTY, WARRANTY OF MERCHANTABILITY, FITNESS FOR PARTICULAR PURPOSE, AND WARRANTY OF NON-INFRINGEMENT OF INTELLECTUAL PROPERTY ARE EXPRESSLY EXCLUDED TO THE MAXIMUM EXTENT ALLOWED BY LAW, AND DIRECTED NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO ASSUME FOR IT ANY LIABILITY IN CONNECTION WITH THE SALE OF THE PRODUCT. DIRECTED HAS ABSOLUTELY NO LIABILITY FOR ANY AND ALL ACTS OF THIRD PARTIES INCLUDING ITS AUTHORIZED DEALERS OR INSTALLERS. IN NO EVENT WILL DIRECTED BE LIABLE FOR ANY INCIDENTAL, SPECIAL OR CONSEQUENTIAL DAMAGES (INCLUDING LOSS OF PROFITS). BY PURCHASING THIS PRODUCT, THE CONSUMER AGREES AND CONSENTS THAT ALL DISPUTES BETWEEN THE CONSUMER AND DIRECTED SHALL BE RESOLVED IN ACCORDANCE WITH CALIFORNIA LAWS IN SAN DIEGO COUNTY, CALIFORNIA. This warranty is only valid for sale of Product within the United States of America. Product sold outside of the United States of America is sold "AS-IS," and shall have NO WARRANTY, express or implied. Some states do not allow limitation on how long an implied warranty lasts. In such states, the limitation or exclusions of this Limited Warranty may not apply. Some states do not allow the exclusion or limitation of incidental or consequential damages. In such states, the exclusion or limitation of this Limited Warranty may not apply to you. This Limited Warranty gives you specific legal rights, and you may have other rights which vary from state to state. 920-0033 04-07

For more information on Orion products please visit www.orioncaraudio.com

Directed Electronics is an ISO 9001 registered company.

Directed Electronics is committed to delivering world class quality products and services that excite and delight our customers.

distributed by

Directed

ELECTRONICS

Vista, CA 92081

WWW.DIRECTED.COM