BLI300 - Battery HUSQVARNA - Free user manual and instructions

Product Type	Lithium-ion battery
Brand	Husqvarna
Model	BLI300
Nominal voltage	36 V
Capacity	300 Wh
Weight	2,5 kg
Dimensions (L x W x H)	150 x 100 x 200 mm
Power source	Rechargeable Li-ion battery
Protection rating	IPX4 (splash-resistant)
Operating temperature	-10 °C to 40 °C
Storage temperature	-20 °C to 60 °C
Charging time	Approximately 60 to 90 minutes (with recommended charger)
Compatibility	Husqvarna 36 V series tools
Charge indicator	4-level LED
Number of cells	10 cells in series
Cell type	Li-ion 18650
Spare parts	Contact Husqvarna customer service
Repairability	Not user-serviceable
Maintenance instructions	Clean with a dry cloth; avoid metallic contacts
Warranty	2 years (subject to conditions of use)

Frequently Asked Questions - BLI300 HUSQVARNA

How to charge the BLI300 battery?

Use only the recommended Husqvarna charger. Plug the charger into a wall outlet, insert the battery into the charger until it clicks. The LED indicator shows progress. A full charge takes approximately 60 to 90 minutes.

What to do if the battery does not charge?

Check that the charger is plugged in and the battery is properly inserted. If the LEDs do not light up, try another outlet. If the problem persists, the battery may be too hot or too cold (wait until it returns to room temperature). If nothing works, contact customer service.

How to interpret the battery LED indicators?

The battery has 4 LEDs: 1 lit = 0-25%, 2 = 25-50%, 3 = 50-75%, 4 = 75-100%. Flashing indicates an error or out-of-range temperature. Refer to the manual for error codes.

Can I use the BLI300 battery on all Husqvarna 36V tools?

Yes, the BLI300 battery is compatible with all tools in the Husqvarna 36V range, including lawnmowers, blowers, hedge trimmers, etc. However, check the specific compatibility of your tool.

What is the battery lifespan?

Under normal use, the Li-ion battery can withstand about 500 full charge cycles. Frequent deep discharge reduces its lifespan. Store it at partial charge (30-60%) to extend its life.

How to store the battery long-term?

Store the battery in a dry, cool place (10-20 °C) away from direct sunlight. The ideal storage charge is about 50%. Check the charge every 3 months and recharge if necessary.

Is the battery waterproof?

The battery has an IPX4 protection rating, which protects against water splashes. Do not immerse it or expose it to heavy rain.

What to do in case of battery overheating?

If the battery becomes hot during use or charging, stop the operation immediately and let it cool in the open air, away from flammable materials. If overheating persists, discontinue use and contact a professional.

Where can I buy a replacement battery?

You can purchase a replacement battery from authorized Husqvarna dealers or on the official website. Always use an original battery to ensure safety and performance.

How to dispose of a used battery?

Do not dispose of the battery in household waste. Take it to a collection point for Li-ion batteries or to a retailer participating in recycling. Follow local regulations.

USER MANUAL BLI300 HUSQVARNA

EN Operator's manual 2-7

1. Battery
2. Battery charger
3. Power plug
4. Charging LED
5. Error LED on charger
6. Error LED on battery
7. LED indicator for the state of charge
8. Battery indicator button

SYMBOLS ON THE PRODUCT

Be careful and use the product correctly. This product can cause serious injury or death to the operator or others.

Read the operator's manual carefully and make sure that you understand the instructions before use.

The product agrees with the applicable EC directives.

This product conforms to the applicable UK regulations.

Recycle the product at an applicable disposal location for electrical and electronic equipment.

The product or package of the product is not domestic waste.

Do not submerge the battery in water.

yyyywwxxxx The rating plate shows serial number. yyyy is the production year, ww is the production week.

Note: Other symbols/decals on the product refer to certification requirements for some commercial areas.

SAFETY DEFINITIONS

Warnings, cautions and notes are used to point out specially important parts of the manual.

WARNING: Used if there is a risk of injury or death for the operator or bystanders if the instructions in the manual are not obeyed.

CAUTION: Used if there is a risk of damage to the product, other materials or the adjacent area if the instructions in the manual are not obeyed.

Note: Used to give more information that is necessary in a given situation.

IMPORTANT SAFETY INSTRUCTIONS

WARNING: Read all safety warnings and all instructions. Failure to obey the warnings and instructions may result in electrical shock, fire and/or serious injury.

Note: Save all warnings and instructions.

• Only use the battery chargers, QC330 or QC500 to charge Husqvarna original batteries. The batteries are software encrypted.
• Use the BLi100/200/300/200X batteries that are rechargeable as a power supply for the related Husqvarna products only. To prevent injury, do not use the battery as a power supply for other devices.

• Do not try to disassemble or repair the battery. All repairs is to be done by an approved dealer only.

• Keep the battery away from sunlight, heat or open flame. The battery can cause burns and/or chemical burns.

• Do not use a defective or damaged battery or battery charger.
• Do not cause mechanical shock to the battery.
• Do not remove the battery from its package until you are to use it.
• Do not let battery acid touch your skin. Battery acid causes injuries to the skin, corrosion and burns. If you get battery acid in your eyes, do not rub but flush with water for a minimum of 15 minutes. If battery acid has touched your skin, you must clean the skin with a large quantity of water and soap. Get medical aid.
• Keep the battery away from children.
• Keep the battery clean and dry.
• Clean the battery terminals with a clean dry cloth if they become dirty.
• Do not keep the battery in the battery charger when it is fully charged.
• Remove the battery from the product when you do not use it and during transportation.
• Keep batteries in storage away from metal objects such as nails, screws or jewelry.

OPERATION

• Push the battery indicator button to start the battery before use.
• The battery must be charged before you use it for the first time. Always use HusqvarnaQC330 or QC500 battery charger.
• Use the battery only when the ambient temperature is between -10^ircC (14°F) and 40^ircC (104°F).
• Decrease the workload and/or speed when the battery temperature indicator is flashing.

Note: Heavy workload when the battery temperature is less than 0°C (32°F) can cause a temporary battery error.

• Use the battery charger only when the ambient temperature is between 5^ircC (41°F) and 40^ircC (104°F).
• The battery will not charge if the battery temperature is more than 50^ircC (122°F).
• Push the battery indicator button to get information of the state of charge of the battery.

To charge the battery

Charge the battery before the first time of operation. A new battery is charged 30%. Push the battery indicator button to get information of the state of charge of the battery.

CAUTION: Only charge the battery when the ambient temperature is between 5°C (41°F) and 40°C (114°F).

CAUTION: Use the battery only when the ambient temperature is between -10^ircC ( 14^ircF ) and 40^ircC ( 104^ircF ).

Note: The battery will not charge if the battery temperature is too high or too low.

1. Put the battery in the battery charger. When the charging LED on the battery charger comes on, the battery is connected correctly to the battery charger.
2. The battery is fully charged when all LEDs on the LED indicator on the battery are on.
3. Remove the battery from the battery charger.

Battery LED indicator

The display shows the state of charge and if there are problems with the battery.

LED indicator Battery status (state of charge)
4 LED lights are on The battery is 76% - 100% charged.
3 LED lights are on The battery is 51% - 75% charged.
2 LED lights are on The battery is 26% - 50% charged.
1 LED light is on The battery is 6% - 25% charged.
1 LED light flashes The battery is 0% - 5% charged.

TROUBLESHOOTING

Symptoms Cause Action
The battery error LED flashes. Temperature deviation, the battery is too cold or too hot to use.		Let the battery cool down or move it indoors to warm it up. When the battery has the correct temperature, it can be used again. Use the battery in ambient temperatures between -10°C (14°F) and 40°C (104°F).
The battery error LED comes on. Cell difference too much (1V). Speak to your dealer.

TRANSPORTATION AND STORAGE

• The supplied Li-ion batteries obey the Dangerous Goods Legislation requirements.
• Obey the special requirement on package and labels for commercial transportations, also those from third parties and forwarding agents.
• Speak to a person with special training in dangerous material before you send the product. Obey all applicable national regulations.

• Use tape on the contacts when you put the battery in a package. Put the battery in the package tightly to prevent damage and accidents.

• Do not keep the battery in an area where static electricity can occur. Do not keep the battery in a metal box.

• Put the battery in a dry, frost free and clean space with correct temperature.
• Put the battery in storage where the temperature is between 5 °C (41 °F) and 25 °C (77 °F). Keep the battery away from sunlight.
• Charge the battery 30% to 50% before you put it in storage for long periods.
• Clean the battery before you put it in storage.

DISPOSAL

Husqvarna products are not domestic waste and must only be discarded as given in this manual.

• Obey the local disposal requirements and applicable regulations.
• Recycle the product and package at an applicable disposal location.
• Speak to your local Husqvarna dealer for more information on how to recycle and discard the product.

TECHNICAL DATA

For technical data, refer to the rating plate of the battery.

SYMBOLER PÅ PRODUKTET

OLULISED OHUTUSJUHISED

SYMBOLES SUR LE PRODUIT

1. Baterija
2. Punjač baterije
3. Strujni utikač
4. LED za punjenje
5. LED indikator za pogreške na punjaču
6. LED indikator za pogreške na bateriji
7. LED indikator stanja punjenja
8. Gumb indikatora baterije

SIMBOLI NA PROIZVODU

Budite oprezni i pravilno upotrebljavajte ovaj proizvod. Ovaj proizvod može izazvati teške ozljede ili smrt rukovatelja ili drugih osoba.

VAŽNE SIGURNOSNE UPUTE

UPOZORENJE: Pažljivo pročitajte sve sigurnosne upute i upozorenja. Nepridržavanje upozorenja i uputa može uzrokovati strujni udar, požar i/ili teške ozljede.

Napomena: Spremite sva upozorenja i upute.

• Za punjenje originalnih baterija tvrtke Husqvarna upotrebljavajte samo QC330 ili QC500. Baterije su softverski kodirane.

• Kao izvor napajanja za povezane proizvode tvrtke Husqvarna upotrebljavajte samo punjive baterije BLi100/200/300/200X. Bateriju nemojte upotrebljavati za napajanje drugih proizvoda jer postoji opasnost od ozljeda.

• Bateriju nemojte rastavljati niti pokušavati popraviti. Sve popravke mora obavljati samo ovlašteni distributer.

• Bateriju zaštitite od sunčeve svjetlosti, vrućine i otvorenog plamena. Baterija može uzrokovati opekline i/ili kemijske opekline.
• Nemojte upotrebljavati neispravnu ili oštećenu bateriju ni punjač baterije.
• Bateriju nemojte izlagati mehaničkim udarima.
• Bateriju uklonite iz pakiranja tek neposredno prije nego je kanite upotrijebiti.
• Nemojte dopustiti kontakt akumulatorske kiseline s kožom. Akumulatorska kiselina uzrokuje ozljede kože, koroziju i opekline. Ako vam akumulatorska kiselina uđe u oči, nemojte ih trljati nego barem 15 minuta ispirite oči s puno vode. Ako akumulatorska kiselina dođe u kontakt s kožom, operite je velikom količinom sapunice. Zatražite medicinsku pomoć.
  • Bateriju držite podalje od djece.
• Bateriju održavajte čistom i suhom.
• Ako se kontakti baterijskog kompleta zaprljaju, obrišite ih čistom suhom krpom.
• Kad se baterija napuni, uklonite je iz punjača.
• Dok proizvod ne upotrebljavate i tijekom transporta, uklonite bateriju iz njega.
• Baterije skladištite dalje od metalnih predmeta kao što su čavli, vijci ili nakit.

RUKOVANJE

• Pritisnite gumb indikatora baterije kako biste pokrenuli bateriju prije upotrebe.

• Prije prve upotrebe bateriju morate napuniti. Obavezno upotrebljavajte punjač baterije HusqvarnaQC330 ili QC500.

• Bateriju upotrebljavajte samo pri temperaturama okoline između -10 °C (14 °F) i 40 °C (104 °F).

• Smanjite opterećenje i/ili brzinu kada indikator temperature baterije treperi.

Napomena: Veliko radno opterećenje, kada je temperatura baterije manja od 0 °C (32 °F), mogu uzrokovati privremenu pogrešku baterije.

• Punjač baterije upotrebljavajte samo pri temperaturama okoline između 5 °C (41 °F) i 40 °C (104 °F).
• Baterija se neće puniti ako je njezina temperatura veća od 50 °C (122 °F).
• Pritisnite gumb indikatora baterije da biste saznali stanje napunjenosti baterije.

Punjenje baterije

Prije prve upotrebe napunite bateriju. Nova baterija napunjena je na 30%. Pritisnite gumb indikatora baterije da biste saznali stanje napunjenosti baterije.

OPREZ: Bateriju punite isključivo na temperaturama okoline između 5 °C (41 °F) i 40 °C (114 °F).

OPREZ: Bateriju upotrebljavajte samo pri temperaturama okoline između -10 °C (14 °F) i 40 °C (104 °F).

Napomena: Baterija se neće puniti ako je temperatura baterije previsoka ili preniska.

1. Postavite bateriju u punjač baterije. Kada se uključi LED indikator za punjenje na punjaču baterije, baterija je pravilno priključena na punjač.
2. Baterija je potpuno napunjena kada su uključeni svi LED indikatori na bateriji.
3. Izvadite bateriju iz punjača baterije.

LED indikator baterije

Na zaslonu se prikazuje stanje napunjenosti te postoje li problemi s baterijom.

LED indikator Stanje baterije (stanje napunjenosti)
Uključene su četiri LED žaruljice Baterija je napunjena 76 % – 100 %.
Uključene su tri LED žaruljice Baterija je napunjena 51 % – 75 %.
Uključene su dvije LED žaruljice Baterija je napunjena 26 % – 50 %.
Uključena je jedna LED žaruljica Baterija je napunjena 6 % – 25 %.
Trepće jedna LED žaruljica Baterija je napunjena 0 % – 5 %.

RJEŠAVANJE PROBLEMA

Simptomi Uzrok Radnja
Trepće LED indikator pogreške za bateriju. Odstupanje od temperature, baterija je prehladna ili prevruća za upotrebu.		Pričekajte da se baterija ohladi ili je premjestite van da se zagrije. Kada baterija postigne odgovarajuću temperaturu, možete je ponovo upotrijebiti. Bateriju upotrebljavajte u rasponu temperatura okoline od -10 °C (14 °F) do 40 °C (104 °F).
		Baterija je prazna. Napunite bateriju.
Uključuje se LED indikator upozorenja za ba- teriju.	Prevelika razlika ćelija (1 V). Obratite se trgovcu.

PRIJEVOZ I SKLADIŠTENJE

1. Akumuliatorius
2. Akumuliatoriaus jkroviklis
3. Kištukas
4. |krovimo šviesos diodas
5. Klaidos LED indikatorius ikroviklyje
6. Klaidos LED indikatorius akumuliatoriuje
7. |krovos būsenos LED indikatorius
8. Akumuliatoriaus indikacinis mygtukas

SIMBOLIAI ANT GAMINIO

GAMBARAN KESELURUHAN PRODUK

ARAHAN KESELAMATAN PENTING

1. Batteri
2. Batterilader
3. Støpsel
4. Ladelampe
5. Feilindikator på lader
6. Feilindikator på batteri
7. LED-lampe for ladestatus
8. Batteriindikatorknapp

SYMBOLER PÅ PRODUKTET

SYMBOLE ZNAJDUJĄCE SIE NA PRODUKCIE

1. Batéria
2. Nabíjačka batérií
3. Napájacia zástrčka
4. Indikátor LED nabíjania
5. Indikátor LED chyby na nabíjačke
6. Indikátor LED chyby na batérii
7. Indikátor LED stavu nabitia
8. Tlačidlo indikátora batérie

SYMBOLY NA VÝROBKU

DÔLEŽITÉ BEZPEČNOSTNÉ POKYNY

SYMBOLER PÅ PRODUKTEN

TRANSPORT OCH FÖRVARING

Original instructions

Оригинални инструкции

Původní pokyny

2024-05-02